Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Your Answer: 10 to 1 k
Correct Answer: 1 M to several hundred M
4. Which of the following transistor(s) has (have) depletion and enhancement types?
9. At which of the following is the level of VDS equal to the pinch-off voltage?
11. Refer to the following characteristic curve. Calculate the resistance of the FET at VGS = –0.25
V if ro = 10 k .
12. What is the level of drain current ID for gate-to-source voltages VGS less than (more negative
than) the pinch-off level?
13. The three terminals of the JFET are the _____, _____, and _____.
15. The region to the left of the pinch-off locus is referred to as the _____ region.
16. Which of the following represent(s) the cutoff region for an FET?
Your Answer: ID = 0 mA
Correct Answer: All of the above
17. Referring to this transfer curve. Calculate (using Shockley's equation) VGS at ID = 4mA.
20. The drain current will always be one-fourth of IDSS as long as the gate-to-source voltage is
_____ the pinch-off value.
21. Which of the following ratings appear(s) in the specification sheet for an FET?
22. Refer to this portion of a specification sheet. Determine the values of reverse-gate-source
voltage and gate current if the FET was forced to accept it.
23. Hand-held instruments are available to measure _____ for the BJT.
Your Answer: dc
Your Answer: 2
Correct Answer: 3 or 4
Your Answer: No direct electrical connection between the gate terminal and the channel
Correct Answer: All of the above
26. Referring to the following transfer curve, determine the level of VGS when the drain current is
20 mA.
28. It is the insulating layer of _____ in the MOSFET construction that accounts for the very
desirable high input impedance of the device.
29. Refer to the following figure. Calculate VGS at ID = 8 mA for k = 0.278 × 10 –2 A/V2 .
Your Answer: 3.70 V
30. The transfer curve is not defined by Shockley's equation for the _____.
32. What is the purpose of adding two Zener diodes to the MOSFET in this figure?
33. Which of the following is (are) the advantage(s) of VMOS over MOSFETs?
34. Which of the following FETs has the lowest input impedance?
Your Answer: 10 10
Correct Answer: 10 8
Me Te x t
Instructor Te x t
TA Te x t
O the r Te x t
Copyright © 1995 - 2010 Pearson Education . A ll rights reserved. Pearson Prentice Hall is an imprint of Pearson .
Legal Notice | Privacy Policy | Permissions