Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
SmartEdge® Classic Ethernet modules provide service providers with a cost-effective and flexible range of carrier-class Ethernet-
based connectivity choices that enable the construction of efficient and highly-scalable next generation Smart Broadband Networks.
Leveraging the flexible modular design approach of the SmartEdge Multi-Service Edge Router, Classic Ethernet Modules are
supported in any SmartEdge chassis and are compatible with any generation module and route processor for complete trans-
generational interoperability. Service providers can mix modules in the same chassis to achieve a highly-flexible and cost-effective
configuration enabling tailored service delivery.
Module Specifications 41° to 104°F (5° to 40°C) - Safety of information technology equipment
Route/Switch Engine: PPA1 programmable Operating temperature, short term: ACA TS001 - Safety Requirement for
ASIC with 16 RISC core processor providing 23° to 131°F (-5° to 55°C) customer equipment
local routing and IP services in hardware 21CRF1040, EN60825-1, EN60825-2 –
Storage temperature:
Interface Types: Gigabit Interface Converters Laser Safety
-38° to 150°F (-40° to 70°C)
(GBICs) providing a SC-duplex connector
with support for the following fiber interfaces: Operating relative humidity: 5% to 90% RH Emissions Certification
1000BaseSX/LX/LH compliant with IEEE Storage relative humidity: 5% to 95% RH FCC CFR 47 Part 15 Class A
802.3z specifications Operating altitude: 60 to 4000 meters EN55022: Class A
1000Base-T connects a GBIC port to CISPR 22:Class A
Network Equipment Building Systems
Category 5 wiring via a standard RJ-45 VCCI V-3/97.04 Class A
interface SR-3580: Network Equipment Building
Systems (NEBS): Criteria Levels (Level 3- AS/NZS 3548: Class A
LEDs compliant) CNS-13438 Class A - BSMI in Taiwan
2 LEDs per module for module status GR-1089-Core: Electromagnetic
indication: ACTIVE (green or off) and FAIL Immunity
Compatibility and Electrical Safety – Generic
(red or off) Criteria for Network Telecommunications EN61000-4-2 ESD immunity
2 LEDs per port for port-level indications: Equipment EN61000-4-3 Radiated RF field immunity
LNK (green or off) indicates Ethernet link GR-63-Core: Network Equipment Building EN61000-4-4 Immunity to electrical fast
status System (NEBS) Requirements: Physical transients
Protection EN61000-4-5 Surge immunity
ACT (yellow or off) indicates whether link is
receiving/transmitting frames Regulatory Compliance EN61000-4-6 RF conducted immunity
Physical Specifications UL 60950-1: 2001 - Safety of information European Telecommunication Standards
technology equipment Institute
Dimensions (H x W x D): 16.0 x 1.12 x 9.97
in. CSA 22.2 No. 60950-1-03 1st Ed, April ETSI EN 300 386 : Electromagnetic
1, 2003 - Safety of information technology compatibility and radio spectrum Matters
(40.64 x 2.83 x 25.32 cm)
equipment (ERM); Telecommunication network
Environmental Specifications EN 60950-1: 2001 + IEC 60950-1: 2001 equipment; electromagnetic Compatibility
Operating temperature, nominal: (EMC) requirements
ORDERING INFORMATION
12-port 10/100Base-TX - Auto Sensing RJ-45 Interfaces EIM-SE8-L3-12FE-TX SE0S Version 2.5.0
4-port Gigabit Ethernet Module Base (GBICs required) EIM-SE8-L3-4GE SE0S Version 2.5.0
4-port Gigabit Ethernet Module - Enhanced (GBICs required) EIM2-SE8-L3-4GE SE0S Version 2.5.0
Short-Reach GBIC Optical Gigabit Ethernet – Multi-Mode fiber SC ASM-SE8-GBIC-SX SE0S Version 2.5.0
Long-Reach GBIC Optical Gigabit Ethernet – Single-Mode fiber SC ASM-SE8-GBIC-LX SE0S Version 2.5.0
Extended-Reach GBIC Optical Gigabit Ethernet - SIngle-Mode fiber SC ASM-SE8-GBIC-LX70 SEOS Version 2.5.0
1000Base-T GBIC Copper Gigabit Ethernet – Standard RJ-45 Interface ASM-SE8-GBIC-TX SEOS Version 2.6.3
Product Specifications are subject to change without notice. Redback Networks assumes no responsibility for any inaccuracies in this document and reserves the right to change, modify,
transfer, or otherwise revise this publication without notice.
REDBACK and SmartEdge are trademarks registered at the U.S. Patent & Trademark Office and in other countries. SMS and NetOp are trademarks or service marks of Redback Networks
Inc. All other products or services mentioned are the trademark, service marks, registered trademarks or registered service marks of their respective owners.
Copyright ©2006 Redback Networks Inc. All rights reserved. Doc # RB-CLAS-EM-08-06