Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Wm. Greco
ENGINEERING Boom Truck Aerial Platform
Operation Inspection
APPROVED BY:
SAFETY GUIDE
DATE 04/10/09
1.0 PURPOSE
This Guide sets forth the provisions of Aerial Platform Inspections at facilities with the specific
objective of minimizing the potential for injuries and fatalities resulting from Boom Truck Aerial
Platform accidents involving employees and contractors during construction, and maintenance
activities.
2.0 SCOPE
The provisions of this Guide are applicable to all Divisions, Subsidiaries and Majority Interest
facilities. Should local, state, federal or government regulations exceed the requirements stipulated
in this Guide, then those regulations shall apply. Aerial Platform Inspection measures are to be
used by all parties involved in construction, and maintenance at facilities.
3.0 RESPONSIBILITY
3.1 Division, site and departmental policies, procedures and practices at all worldwide
locations should be in accordance with the intent of this Guide as well as any applicable
local regulations.
3.3 Site Safety and/or Industrial Hygiene Departments will provide technical support to
engineers/supervisors for Aerial Platform Inspection standards and methods.
3.4 Engineering personnel in charge of construction and maintenance along with Site Safety
personnel’s participation, shall periodically audit the Aerial Platform methods employed to
assure that the requirements of this Guide are met.
4.0 POLICY
Aerial Platforms on construction sites and during maintenance procedures at are recognized to
require consideration in order to protect against deaths and injuries.
Wm. Greco
ENGINEERING Boom Truck Aerial Platform
Operation Inspection
APPROVED BY:
SAFETY GUIDE
DATE 04/10/09
Aerial platforms are used under the same operating rules as any piece of mobile hoisting equipment. This
includes:
I .Operator knowledge of the unit and its load capacity charts, and his/her ability
2. Pre-operation inspection
(See Section 6.0 of this guide)
Personnel in the basket are always under the control of the ground operator (even in platform
controlled units). Ground operator is always required while boom is being operated.
Aerial platforms normally have insulated booms and fiberglass baskets. OSHA regulations require a yearly
inspection. The boom must have a dielectric test, the fiberglass basket is ultrasound tested, and the
structural components are magnetic particle inspected.
6 Pre-Operation Inspection
Wm. Greco
ENGINEERING Boom Truck Aerial Platform
Operation Inspection
APPROVED BY:
SAFETY GUIDE
DATE 04/10/09
2. Platform
Upper controls all controls free in movement
with no binding _____
Wm. Greco
ENGINEERING Boom Truck Aerial Platform
Operation Inspection
APPROVED BY:
SAFETY GUIDE
DATE 04/10/09
5. Vehicle
7. Jib boom
Wm. Greco
ENGINEERING Boom Truck Aerial Platform
Operation Inspection
APPROVED BY:
SAFETY GUIDE
DATE 04/10/09
Wm. Greco
ENGINEERING Boom Truck Aerial Platform
Operation Inspection
APPROVED BY:
SAFETY GUIDE
DATE 04/10/09