Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Page 1 of 14
Hydrogen vehicle
From Wikipedia, the free encyclopedia
A hydrogen vehicle is a vehicle that uses hydrogen as its onboard fuel for motive power. Hydrogen vehicles include hydrogen fueled space rockets, as well as automobiles and other transportation vehicles. The power plants of such vehicles convert the chemical energy of hydrogen to mechanical energy either by burning hydrogen in an internal combustion engine, or by reacting hydrogen with oxygen in a fuel cell to run electric motors. Widespread use of hydrogen for fueling transportation is a key element of a proposed hydrogen economy.
Honda FCX Clarity, a hydrogen fuel cell demonstration vehicle introduced in 2008
Hydrogen fuel does not occur naturally on Earth and thus is not an energy source, but is an energy carrier. Currently it is most frequently made from methane or other fossil fuels. However, it can be produced from a wide range of sources (such as wind, solar, or nuclear) that are intermittent, too diffuse or too cumbersome to directly propel vehicles. Integrated wind-to-hydrogen plants, using electrolysis of water, are exploring technologies to deliver costs low enough, and quantities great enough, to compete with traditional energy sources.[1] Many companies are working to develop technologies that might efficiently exploit the potential of hydrogen energy for mobile uses. The attraction of using hydrogen as an energy currency is that, if hydrogen is prepared without using fossil fuel inputs, vehicle propulsion would not contribute to carbon dioxide emissions. The drawbacks of hydrogen use are low energy content per unit volume, high tankage weights, very high storage vessel pressures, the storage, transportation and filling of gaseous or liquid hydrogen in vehicles, the large investment in infrastructure that would be required to fuel vehicles, and the inefficiency of production processes.
Contents
1 Vehicles 1.1 Automobiles 1.2 Buses 1.3 Bicycles 1.4 Motorcycles and scooters 1.5 Quads and tractors 1.6 Airplanes 1.7 Fork trucks 1.8 Rockets 2 Internal combustion vehicle 3 Fuel cell 3.1 Fuel cell cost 3.2 Freezing conditions 3.3 Service life 4 Hydrogen 4.1 Production 4.2 Storage 4.3 Infrastructure 4.4 Codes and standards 5 Criticism 6 Comparison with other types of alternative fuel vehicle 6.1 Plug-in hybrids 6.2 Natural gas 6.3 Battery electric vehicles 7 See also 8 References
http://en.wikipedia.org/wiki/Hydrogen_vehicle
01-10-2011
Page 2 of 14
9 External links
Vehicles
Further information: Fuel cell vehicle Buses, trains, PHB bicycles, canal boats, cargo bikes, golf carts, motorcycles, wheelchairs, ships, airplanes, submarines, and rockets can already run on hydrogen, in various forms. NASA uses hydrogen to launch Space Shuttles into space. There is even a working toy model car that runs on solar power, using a regenerative fuel cell to store energy in the form of hydrogen and oxygen gas. It can then convert the fuel back into water to release the solar energy.[2] The current land speed record for a hydrogen-powered vehicle is 286.476 mph (461.038 km/h) set by Ohio State University's Buckeye Bullet 2, which achieved a "flying-mile" speed of 280.007 mph (450.628 km/h) at the Bonneville Salt Flats in August 2008. For production-style vehicles, the current record for a hydrogen-powered vehicle is 333.38 km/h (207.2 mph) set by a prototype Ford Fusion Hydrogen 999 Fuel Cell Race Car at Bonneville Salt Flats in Wendover, Utah in August 2007. It was accompanied by a large compressed oxygen tank to increase power. Honda has also created a concept called the FC Sport that it hopes will challenge that record.[3]
Automobiles
Main articles: List of fuel cell vehicles and List of hydrogen internal combustion engine vehicles Many companies are currently researching the feasibility of building hydrogen cars, and some automobile manufacturers have begun developing hydrogen cars (see list of fuel cell vehicles). Funding has come from both private and government sources. However, the Ford Motor Company has dropped its plans to develop hydrogen cars, stating that "The next major step in Ford s plan is to increase over time the volume of electrified vehicles".[4] Similarly, French Renault-Nissan announced in 2009 that it is cancelling its hydrogen car R& D efforts.[5] As of October 2009, General Motors CEO Fritz Henderson noted that GM had reduced its hydrogen program because the cost of building hydrogen cars was too high. "It's still a ways away from commercialization", he said. The "Volt will likely cost around $40,000 while a hydrogen vehicle would cost around $400,000.[6] Most hydrogen cars are currently only available as demonstration models for lease in limited numbers and are not yet ready for general public use. The estimated number of hydrogen-powered cars in the United States was 200 as of October 2009, mostly in California.[7]
Honda introduced its first fuel cell vehicle in 1999 called the FCX and has since then introduced the second generation FCX Clarity. In 2007 at the Greater Los Angeles Auto Show, Honda unveiled the first production model of the FCX Clarity. Limited marketing of the FCX Clarity began in June 2008 Ford Edge hydrogen-electric plugin the United States, and it was introduced in Japan in November 2008.[8] The in hybrid concept FCX Clarity is available in the U.S. only in Los Angeles Area, where 16 hydrogen filling stations are available, and as of July 2009, ten drivers had leased the Clarity for US$600 a month.[9] Honda stated that it could start mass producing vehicles based on the FCX concept by the year 2020[9] and reaffirmed, in 2009, that it continues to put resources into hydrogen fuel cell development, which it saw as "a better long term bet than batteries and plug-in vehicles".[10] In December 2010, however, it introduced a BEV version of the Honda Fit, using elements of its hydrogen engine design, stating that the "industry trend seems to be focused on the battery electric vehicle".[11]
http://en.wikipedia.org/wiki/Hydrogen_vehicle
01-10-2011
Page 3 of 14
In 2008, Hyundai announced its intention to produce 500 FC vehicles by 2010 and to start mass production of its FC vehicles in 2012.[12] In early 2009, Daimler announced plans to begin its FC vehicle production in 2009 with the aim of 100,000 vehicles in 20122013.[13][14] In 2009, Nissan started testing a new FC vehicle in Japan.[15] In September 2009, Daimler, Ford, General Motors, Honda, Hyundai, Kia, Renault, Nissan and Toyota issued a joint statement about their undertaking to further develop and launch fuel-cell electric vehicles as early as 2015.[16] In February 2010 Lotus Cars announced that it was developing a fleet of hydrogen taxis in London. London's deputy mayor, Kit Malthouse, said he hoped six filling stations would be available and that around 20 to 50 taxis would be in operation by the time of the 2012 Olympic Games, as well as 150 hydrogen-powered buses.[17] In March 2010, General Motors said it had not abandoned fuel-cell technology and is still targeted to introduce hydrogen vehicles to retail customers by 2015. Charles Freese, GM s executive director of global powertrain engineering, stated that the company believes that both fuel-cell vehicles and battery electric vehicles are needed for reduction of greenhouse gases and reliance on oil, and the U.S. should follow Germany and Japan in adopting a more uniform strategy on advanced technology options. Both countries have announced plans to open 1,000 hydrogen fuel stations.[18]
Buses
Main article: fuel cell bus Fuel cell buses (as opposed to hydrogen fueled buses) are being trialed by several manufacturers in different locations. The Fuel Cell Bus Club is a global fuel cell bus testing collaboration. Hydrogen was first stored in roof mounted tanks, although models are now incorporating onboard tanks. Some double deck models use between floor tanks.
Bicycles
Main article: PHB (bicycle) Pearl Hydrogen Power Sources of Shanghai, China, unveiled a hydrogen bicycle at the 9th China International Exhibition on Gas Technology, Equipment and Applications in 2007.
Airplanes
For more details on this topic, see Hydrogen planes. Companies such as Boeing, Lange Aviation, and the German Aerospace Center pursue hydrogen as fuel for manned and unmanned airplanes. In February 2008 Boeing tested a manned flight of a small aircraft powered by a hydrogen fuel cell. Unmanned hydrogen planes have also been tested. [24] For large passenger airplanes however, The Times reported that "Boeing said that hydrogen fuel cells were unlikely to power the engines of large passenger jet airplanes but could be used as backup or auxiliary power units onboard." [25]
http://en.wikipedia.org/wiki/Hydrogen_vehicle
01-10-2011
Page 4 of 14
In July 2010 Boeing unveiled its hydrogen powered Phantom Eye UAV, powered by two Ford internal combustion engines that have been converted to run on hydrogen.[26] In Europe, the Reaction Engines A2 has been proposed to use the thermodynamic properties of liquid hydrogen to achieve very high speed, long distance (antipodal) flight by burning it in a precooled jet engine.
Fork trucks
A HI CE forklift or HI CE lift truck is a hydrogen fueled, internal combustion engine powered industrial forklift truck used for lifting and transporting materials. The first production HICE forklift truck based on the Linde X39 Diesel was presented at an exposition in Hannover on May 27, 2008. It used a 2.0 litre, 43 kW diesel internal combustion engine converted to use hydrogen as a fuel with the use of a compressor and direct injection.[27][28] The hydrogen tank is filled with 26 liters of hydrogen at 350 bar pressure.
Rockets
Many large rockets use liquified cryogenic hydrogen as a propellant. In addition they use liquified cryogenic oxygen, and liquified cryogenic hydrogen in the space shuttle, to charge the fuel cells that power the electrical systems.[ citation needed] The biproduct of the fuel cell is water, and is used for drinking, and any other application that requires water in space. The oxygen is also used to provide the rocket engines with oxygen for better thrust in space, due to the lack of oxygen in space.[ citation needed] Just prior to a launch, the rocket fuel tanks are filled and chilled. The hydrogen fuel used in the rocket engine is directly ignited. The main advantage of hydrogen is that the velocity change of a stage employing it is little different from a stage using denser fuel, while the lift-off weight of the stage is less. Particularly when used for upper stages this permits a lighter rocket for any given payload. [ citation needed] The main disadvantage of hydrogen in this application is the low density and deeply cryogenic nature, requiring insulation; this makes the hydrogen tanks relatively heavy, which offsets the advantages for this application, but these disadvantages could be overcome through the advent of better on board hydrogen refrigeration, and liquifier technology to produce fuel needed for long distance space travel to a destination where salt water is available, such as possibly comets, moons, and planets.[ citation needed] But another advantage of using cryogenic fuel is that the fuel system is able to be routed in specific paths to act as a cooling system for the rocket, which is crucial for temperature regulation in extended use of rocket propulsion.[29]
http://en.wikipedia.org/wiki/Hydrogen_vehicle
01-10-2011
Page 5 of 14
Fuel cell
While fuel cells themselves are potentially highly energy efficient, and working prototypes were made by Francis Thomas Bacon in 1959[32] and Roger E. Billings in the 1960s, at least four technical obstacles and other political considerations exist regarding the development and use of a fuel cell-powered hydrogen car: the cost, reliability and durability of the fuel cells; storage of hydrogen for use in fuel cells; production of hydrogen; and delivery of hydrogen to vehicles.[33]
Freezing conditions
Temperatures below freezing are a concern with fuel cells operations. Operational fuel cells have an internal vaporous water environment that could solidify if the fuel cell and contents are not kept above 0 Celsius (32F). Most fuel cell designs are not as yet robust enough to survive in below-freezing environments. Frozen solid, especially before start up, they would not be able to begin working. Once running though, heat is a byproduct of the fuel cell process, which would keep the fuel cell at an adequate operational temperature to function correctly. This makes startup of the fuel cell a concern in cold weather operation. Places such as Alaska where temperatures can reach 40 C (40 F) at startup would not be able to use early model fuel cells. Ballard announced in 2006 that it had already hit the U.S. DoE's 2010 target for cold weather starting which was 50% power achieved in 30 seconds at -20 C.[38] Fuel cells have startup and long term reliability problems. Early gasoline engines had the characteristic of higher heat dissipation once running, whereas fuels cells emit less heat, making the warm up process somewhat less quick.[39]
Service life
Although service life is coupled to cost, fuel cells have to be compared to existing machines with a service life in excess of 5000 hours[40] for stationary and light-duty. Marine PEM fuel cells reached the target in 2004.[41] Current service life is 7,300 hours under cycling conditions.[42] Research is going on especially for heavy duty like in the bus trials which are targeted up to a service life of 30,000 hours. For more details on this topic, see Fuel cell.
Hydrogen
Hydrogen does not come as a pre-existing source of energy like fossil fuels, but is first produced and then stored as a carrier, much like a battery. Hydrogen for vehicle uses needs to be produced using either renewable or nonrenewable energy sources. A suggested benefit of large-scale deployment of hydrogen vehicles is that it could lead to decreased emissions of greenhouse gases and ozone precursors.[43]
http://en.wikipedia.org/wiki/Hydrogen_vehicle
01-10-2011
Page 6 of 14
According to the United States Department of Energy "Producing hydrogen from natural gas does result in some greenhouse gas emissions. When compared to ICE vehicles using gasoline, however, fuel cell vehicles using hydrogen produced from natural gas reduce greenhouse gas emissions by 60%.[44] While methods of hydrogen production that do not use fossil fuel would be more sustainable,[45] currently renewable energy represents only a small percentage of energy generated, and power produced from renewable sources can be used in electric vehicles and for non-vehicle applications.[46] The challenges facing the use of hydrogen in vehicles include production, storage, transport and distribution. Because of all these challenges, the well-to-wheel efficiency for hydrogen is less than 25%.[47][48][49]
Production
For more details on this topic, see Hydrogen production. The molecular hydrogen needed as an on-board fuel for hydrogen vehicles can be obtained through many thermochemical methods utilizing natural gas, coal (by a process known as coal gasification), liquefied petroleum gas, biomass (biomass gasification), by a process called thermolysis, or as a microbial waste product called biohydrogen or Biological hydrogen production. 95% of hydrogen is produced using natural gas,[50] and 85% of hydrogen produced is used to remove sulfur from gasoline. Hydrogen can also be produced from water by electrolysis or by chemical reduction using chemical hydrides or aluminum.[51] Current technologies for manufacturing hydrogen use energy in various forms, totaling between 25 and 50 percent of the higher heating value of the hydrogen fuel, used to produce, compress or liquefy, and transmit the hydrogen by pipeline or truck.
[52]
Environmental consequences of the production of hydrogen from fossil energy resources include the emission of greenhouse gases, a consequence that would also result from the on-board reforming of methanol into hydrogen. [47] Studies comparing the environmental consequences of hydrogen production and use in fuel-cell vehicles to the refining of petroleum and combustion in conventional automobile engines find a net reduction of ozone and greenhouse gases in favor of hydrogen.[43] Hydrogen production using renewable energy resources would not create such emissions or, in the case of biomass, would create near-zero net emissions assuming new biomass is grown in place of that converted to hydrogen. However the same land could be used to create Biodiesel, usable with (at most) minor alterations to existing well developed and relatively efficient diesel engines. In either case, the scale of renewable energy production today is small and would need to be greatly expanded to be used in producing hydrogen for a significant part of transportation needs.[53] As of December 2008, less than 3 percent of U.S. electricity was produced from renewable sources, not including dams.[54] In a few countries, renewable sources are being used more widely to produce energy and hydrogen. For example, Iceland is using geothermal power to produce hydrogen,[55] and Denmark is using wind.[56]
Storage
For more details on this topic, see Hydrogen storage. Hydrogen has a very low volumetric energy density at ambient conditions, equal to about one-third that of methane. Even when the fuel is stored as liquid hydrogen in a cryogenic tank or in a compressed hydrogen storage tank, the volumetric energy density (megajoules per liter) is small relative to that of gasoline. Hydrogen has a three times higher energy density by mass compared to gasoline (143 MJ/kg versus 46.9 MJ/kg). Some research has been done into using special crystalline materials to store hydrogen at greater densities and at lower pressures. A recent study by Dutch researcher Robin Gremaud has shown that metal hydride hydrogen tanks are actually 40 to 60-percent lighter than an equivalent energy battery pack on an electric vehicle permitting greater range for H2 cars.[57] In 2011, scientists at Los Alamos National Laboratory and University of Alabama, working with the U.S. Department of Energy, found a new single-stage method for recharging ammonia borane, a hydrogen storage compound.[58][59]
http://en.wikipedia.org/wiki/Hydrogen_vehicle
01-10-2011
Page 7 of 14
I nfrastructure
For more details on this topic, see Hydrogen infrastructure. For more details on this topic, see Hydrogen highway. The hydrogen infrastructure consists mainly of industrial hydrogen pipeline transport and hydrogen-equipped filling stations like those found on a hydrogen highway. Hydrogen stations which are not situated near a hydrogen pipeline can obtain supply via hydrogen tanks, compressed hydrogen tube trailers, liquid hydrogen tank trucks or dedicated onsite production. Hydrogen use would require the alteration of industry and transport on a scale never seen before in history. For example, according to GM, 70% of the U.S. population lives near a hydrogen-generating facility but has little access to hydrogen, despite its wide availability for commercial use.[60] The distribution of hydrogen fuel for vehicles throughout the U.S. would require new hydrogen stations costing, by some estimates, 20 billion dollars.[61] and 4.6 billion in the EU.[62] Other estimates place the cost as high as half trillion dollars in the United States alone.[63]
Hydrogen car fueling
The California Hydrogen Highway is an initiative to build a series of hydrogen refueling stations along that state. These stations are used to Hydrogen fueling refuel hydrogen vehicles such as fuel cell vehicles and hydrogen combustion vehicles. As of March 2011, the California Fuel Cell Partnership showed 20 stations in operation, with eight more planned. These are located mostly in and around Los Angeles, with a few in the Bay area[64][65] South Carolina also has a hydrogen freeway project, and the first two hydrogen fueling stations opened in 2009 in Aiken and Columbia, South Carolina. According to the South Carolina Hydrogen & Fuel Cell Alliance, the Columbia station has a current capacity of 120 kg a day, with future plans to develop on-site hydrogen production from electrolysis and reformation. The Aiken station has a current capacity of 80 kg. There are several funding projects for Hydrogen fuel cell research and infrastructure in South Carolina. The University of South Carolina, a founding member of the South Carolina Hydrogen & Fuel Cell Alliance, received 12.5 million dollars from the Department of Energy for its Future Fuels Program.[66]
Criticism
Critics claim the time frame for overcoming the technical and economic challenges to implementing wide-scale use of hydrogen vehicles is likely to last for at least several decades, and hydrogen vehicles may never become broadly available.[46][68] They claim that the focus on the use of the hydrogen car is a dangerous detour from more readily available solutions to reducing the use of fossil fuels in vehicles.[69] In May 2008, Wired News reported that "experts say it will be 40 years or more before hydrogen has any meaningful impact on gasoline consumption or global warming, and we can't afford to wait that long. In the meantime, fuel cells are diverting resources from more immediate solutions." [70] K. G. Duleep speculates that "a strong case exists for continuing fuel-efficiency improvements from conventional technology at relatively low cost." [71] Critiques of hydrogen vehicles are presented in the 2006 documentary, Who Killed the Electric Car?. According to former U.S. Department of Energy official Joseph Romm, "A hydrogen car is one of the least efficient, most expensive ways to reduce greenhouse gases." Asked when hydrogen cars will be broadly available, Romm replied: "Not in our lifetime, and very possibly never." [71] The Los Angeles Times wrote, in February 2009, "Hydrogen fuel-cell technology won't work in cars. ... Any way you look at it, hydrogen is a
http://en.wikipedia.org/wiki/Hydrogen_vehicle
01-10-2011
Page 8 of 14
lousy way to move cars." [72] A 2007 article in Technology Review stated, "In the context of the overall energy economy, a car like the BMW Hydrogen 7 would probably produce far more carbon dioxide emissions than gasoline-powered cars available today. And changing this calculation would take multiple breakthroughs which study after study has predicted will take decades, if they arrive at all. In fact, the Hydrogen 7 and its hydrogen-fuel -cell cousins are, in many ways, simply flashy distractions produced by automakers who should be taking stronger immediate action to reduce the greenhouse-gas emissions of their cars." [46][73] The Wall Street Journal reported in 2008 that "Top executives from General Motors Corp. and Toyota Motor Corp. Tuesday expressed doubts about the viability of hydrogen fuel cells for mass-market production in the near term and suggested their companies are now betting that electric cars will prove to be a better way to reduce fuel consumption and cut tailpipe emissions on a large scale." [6][74] The Economist magazine, in September 2008, quoted Robert Zubrin, the author of Energy Victory, as saying: "Hydrogen is 'just about the worst possible vehicle fuel'".[75] The magazine noted the withdrawal of California from earlier goals: "In March [2008] the California Air Resources Board, an agency of California's state government and a bellwether for state governments across America, changed its requirement for the number of zero-emission vehicles (ZEVs) to be built and sold in California between 2012 and 2014. The revised mandate allows manufacturers to comply with the rules by building more battery-electric cars instead of fuel-cell vehicles." [75] The magazine also noted that most hydrogen is produced through steam reformation, which creates at least as much emission of carbon per mile as some of today's gasoline cars. On the other hand, if the hydrogen could be produced using renewable energy, "it would surely be easier simply to use this energy to charge the batteries of all-electric or plug-in hybrid vehicles." [75] The Washington Post asked in November 2009, "But why would you want to store energy in the form of hydrogen and then use that hydrogen to produce electricity for a motor, when electrical energy is already waiting to be sucked out of sockets all over America and stored in auto batteries"? The paper concluded that commercializing hydrogen cars is "stupendously difficult and probably pointless. That's why, for the foreseeable future, the hydrogen car will remain a tailpipe dream".[50] A December 2009 study at UC Davis, published in the Journal of Power Sources, found that, over their lifetimes, hydrogen vehicles will emit more carbon than gasoline vehicles.
[76]
In 2009 the U.S. Secretary of Energy, Stephen Chu, stated that fuel cell hydrogen vehicles "will not be practical over the next 10 to 20 years". He cited difficulties in the development of the required infrastructure to distribute hydrogen as a justification for cutting research funds.[77] The National Hydrogen Association and other hydrogen groups criticized the decision.[78] Secretary Chu told MIT's Technology Review that he is skeptical about hydrogen's use in transportation because "the way we get hydrogen primarily is from reforming [natural] gas. ... You're giving away some of the energy content of natural gas. ... So that's one problem. ... [For] transportation, we don't have a good storage mechanism yet. ... The fuel cells aren't there yet, and the distribution infrastructure isn't there yet. ... In order to get significant deployment, you need four significant technological breakthroughs. ... If you need four miracles, that's unlikely: saints only need three miracles".[33] Congress reversed the funding cuts in its appropriations bill for 2010,[7] but the Department of Energy plans to decrease funding for Fuel Cell Vehicle development in its 2012 budget.[79] In July 2011, the Chairman and CEO of General Motors, Daniel Akerson, stated that while the cost of hydrogen fuel cell cars is decreasing: "The car is still too expensive and probably won't be practical until the 2020-plus period, I don't know." [80][68]
Plug-in hybrids
Plug-in hybrid electric vehicles, or PHEVs, are hybrid vehicles that can be plugged into the electric grid and contain an electric motor and also an ICE or other engine. The Chevrolet Volt, the first commerciallymanufactured PHEV, became commercially available in some U.S. states in 2010 and in more locations in 2011. The PHEV concept augments standard hybrid electric vehicles with the ability to recharge their batteries from an external source while parked, enabling increased use of the vehicle's electric motors while reducing their reliance on internal combustion engines. The infrastructure required to charge PHEVs is already in place,[81] and
http://en.wikipedia.org/wiki/Hydrogen_vehicle
01-10-2011
Page 9 of 14
transmission of power from grid to car is about 93% efficient.[82] This, however, is not the only energy loss in transferring power from grid to wheels. AC/DC conversion must take place from the grids AC supply to the PHEV's DC. This is roughly 98% efficient.[83] The battery then must be charged. As of 2007, the Lithium iron phosphate battery was between 80-90% efficient in charging/discharging.[84] The battery needs to be cooled; the GM Volt's battery has 4 coolers and two radiators.[85] As of 2009, "the total well-to-wheels efficiency with which a hydrogen fuel cell vehicle might utilize renewable electricity is roughly 20% (although that number could rise to 25% or a little higher with the kind of multiple technology breakthroughs required to enable a hydrogen economy). The well-to-wheels efficiency of charging an onboard battery and then discharging it to run an electric motor in a PHEV or EV, however, is 80% (and could be higher in the future)four times more efficient than current hydrogen fuel cell vehicle pathways." [49] A 2006 article in Scientific American argued that PHEVs, rather than hydrogen vehicles, would become standard in the automobile industry.[86][87] A December 2009 study at UC Davis found that, over their lifetimes, PHEVs will emit less carbon than current vehicles, while hydrogen cars will emit more carbon than gasoline vehicles.[76]
Natural gas
ICE-based CNG or LNG vehicles (Natural gas vehicles or NGVs) use Natural gas or Biogas as a fuel source. Natural gas has a higher energy density than hydrogen gas. Natural gas powered vehicles have a lower carbon dioxide footprint than ICE vehicles. When using Biogas, NGVs become carbon neutral vehicles that run on animal waste.[88] CNG vehicles have been available for several years, and there is sufficient infrastructure to provide both commercial and home refueling stations. In 2008, the ACEEE (http://www.aceee.org/) rated the Honda Civic GX, which uses compressed natural gas, as the greenest vehicle available.[89][90][91]
See also
Alternative fuel car Bivalent engine Electric vehicle Future of the car Hell and High Water The Hype about Hydrogen Tribrid vehicle World Green Car
References
1. ^ "Wind-to-Hydrogen Project" (http://www.nrel.gov/hydrogen/proj_wind_hydrogen.html) . Hydrogen and Fuel Cells Research. Golden, CO: National Renewable Energy Laboratory, U.S. Department of Energy. September 2009. http://www.nrel.gov/hydrogen/proj_wind_hydrogen.html. Retrieved 7 January 2010. 2. ^ Thames & Kosmos kit (http://www.thamesandkosmos.com/products/fc/fc2.html) , Other educational materials (http://www.bpa.gov/Energy/N/projects/fuel_cell/education/fuelcellcar/index.cfm) , and many more demonstration car kits (http://www.fuelcellstore.com/cgi-bin/fuelweb/view=NavPage/cat=14) .
http://en.wikipedia.org/wiki/Hydrogen_vehicle
01-10-2011
Page 10 of 14
3. ^ "New Hydrogen-Powered Land Speed Record from Ford" (http://www.motorsportsjournal.com/archives/fuel_saving_vehicles_hybrids/) . Motorsportsjournal.com. http://www.motorsportsjournal.com/archives/fuel_saving_vehicles_hybrids/. Retrieved 2010-12-12. 4. ^ "Ford Motor Company Business Plan" (http://online.wsj.com/public/resources/documents/Ford_Motor_Company_Business_Plan122008.pdf) , December 2, 2008 5. ^ Dennis, Lyle. "Nissan Swears Off Hydrogen and Will Only Build Electric Cars" (http://www.allcarselectric.com/blog/1019079_nissan-swears-off-hydrogen-and-will-only-build-electric-cars) , All Cars Electric, February 26, 2009 6. ^ a b Blanco, Sebastian. "GM CEO: electric cars require teamwork; hydrogen cars 10x more expensive than Volt" (http://green.autoblog.com/2009/10/30/gm-ceo-electric-cars-require-teamwork-hydrogen-cars-10x-more-e/) , green.autoblog.com, October 30, 2009 7. ^ a b Whoriskey, Peter. "The Hydrogen Car Gets Its Fuel Back", (http://www.washingtonpost.com/wpdyn/content/article/2009/10/16/AR2009101601002.html) Washington Post, October 17, 2009 8. ^ Honda Motor Company (16 June 2008). "Honda Announces First FCX Clarity Customers and World s First Fuel Cell Vehicle Dealership Network as Clarity Production Begins" (http://world.honda.com/news/2008/4080616First-FCXClarity/) . http://world.honda.com/news/2008/4080616First-FCX-Clarity/. Retrieved 1 June 2009. 9. ^ a b Bloomberg News (24 August 2009). "Hydrogen-powered vehicles on horizon" (http://www.washingtontimes.com/news/2009/aug/24/hydrogen-powered-vehicles-on-horizon/?page=2) . Washington Times. http://www.washingtontimes.com/news/2009/aug/24/hydrogen-powered-vehicles-on-horizon/? page=2. Retrieved 5 September 2009. 10. ^ Abuelsamid, Sam. "Honda pulls out of Frankfurt to save costs, starts testing FCX in Germany" (http://www.autobloggreen.com/2009/04/02/honda-pulls-out-of-frankfurt-to-save-costs-starts-testing-fcx-i/) , AutoBloggreen, April 2, 2009 11. ^ Ohnsman, Alan. "Honda Says Hydrogen Auto Fuel Cell Know-How Helped Speed Battery-Car Plan" (http://www.bloomberg.com/news/2010-12-16/honda-says-hydrogen-auto-know-how-helped-speed-plan-forbattery-run-fit.html) . Bloomberg.com, December 16, 2010 12. ^ "Hyundai Will Have Hybrids Next Year - And Fuel Cells in 2012?" (http://blog.wired.com/cars/2008/03/hyundai-willha.html) Wired.com, March 2008 13. ^ "Produktion der Brennstoffzelle beginnt schon im Sommer (German)" (http://www.auto-motor-undsport.de/eco/daimler-produktion-der-brennstoffzelle-beginnt-schon-im-sommer-953613.html) . Auto-motor-undsport.de. 2009-01-29. http://www.auto-motor-und-sport.de/eco/daimler-produktion-der-brennstoffzelle-beginnt-schonim-sommer-953613.html. Retrieved 2010-12-12. 14. ^ Daimler starts small series production of (http://www.h2euro.org/2009/01/725) fuel cell vehicles in summer 2009 15. ^ "Nissan Starts Vehicle Testing of New Fuel-cell Technology" (http://www.japanesesportcars.com/nissan-testingvehicle-new-fuel-cell-technology_5298.html) . Japanesesportcars.com. 2009-02-25. http://www.japanesesportcars.com/nissan-testing-vehicle-new-fuel-cell-technology_5298.html. Retrieved 2010-12-12. 16. ^ Scott Doggett. "9 Major Automakers Sign Letter Agreeing to Develop and Launch Fuel-Cell Vehicles" (http://blogs.edmunds.com/greencaradvisor/2009/09/9-major-automakers-sign-letter-agreeing-to-develop-andlaunch-fuel-cell-vehicles.html/) Green car advisor-Edmunds, Sep 9, 2009 17. ^ Jha Alok. "Hydrogen taxi cabs to serve London by 2012 Olympics" (http://www.guardian.co.uk/environment/2010/feb/22/hydrogen-taxi-cabs-london-2012-olympics) . The Guardian, 22 February 2010 18. ^ Alan Ohnsman. "GM to Maintain Hydrogen Push as Plug-In Volt Readied for Sale" (http://www.businessweek.com/news/2010-03-17/gm-to-maintain-hydrogen-push-as-plug-in-volt-readied-forsale.html/) . BusinessWeek, March 17, 2010 19. ^ "Hydrogen scooter by vectrix" (http://jalopnik.com/cars/lighter_than_air-scooting/the-graf-scooter-278441.php) . Jalopnik.com. 2007-07-13. http://jalopnik.com/cars/lighter_than_air-scooting/the-graf-scooter-278441.php. Retrieved 2010-12-12. 20. ^ "Suzuki Burgman fuel-cell scooter" (http://www.hydrogencarsnow.com/blog2/index.php/hydrogen-vehicles/suzukiburgman-fuel-cell-scooter-to-rollout-within-months/) . Hydrogencarsnow.com. 2009-10-27. http://www.hydrogencarsnow.com/blog2/index.php/hydrogen-vehicles/suzuki-burgman-fuel-cell-scooter-to-rolloutwithin-months/. Retrieved 2010-12-12. 21. ^ "Fhybrid fuel cell-electric hybrid scooter" (http://www.io.tudelft.nl/live/pagina.jsp?id=b679efb4-ec62-4a49-96c8eaf3839d6480& lang=en) . Io.tudelft.nl. http://www.io.tudelft.nl/live/pagina.jsp?id=b679efb4-ec62-4a49-96c8eaf3839d6480& lang=en. Retrieved 2010-12-12. 22. ^ "Autostudi S.r.l. H-Due" (http://www.ecofriend.org/entry/smallest-of-em-rides-piemonte-h-due-concept/) . Ecofriend.org. 2008-04-15. http://www.ecofriend.org/entry/smallest-of-em-rides-piemonte-h-due-concept/. Retrieved 2010-12-12. 23. ^ New Holland Wins Gold for Energy Independent Farm Concept (http://www.efarming.com.au/NewProducts/machinery/08/01/2009/1358/new-holland-wins-gold-for-energyindependent-farm-concept.html) or Hydrogen-powered tractor in an Energy Independent Farm (http://www.terrenet.fr/materiel-agricole/tracteur-quad/article-new-holland-hydrogene-pile-a-combustible-nh2-harris-ihrig-tracteurhydrogene-prototype-hydrogen-fuel-cell-powered-tractor-207-53740.html) 24. ^ "Ion tiger hydrogen UAV" (http://www.sciencedaily.com/releases/2009/10/091013123350.htm) . Sciencedaily.com. 2009-10-15. http://www.sciencedaily.com/releases/2009/10/091013123350.htm. Retrieved 2010-12-12.
http://en.wikipedia.org/wiki/Hydrogen_vehicle
01-10-2011
Page 11 of 14
25. ^ David Robertson (3 April 2008). "Boeing tests first hydrogen powered plane" (http://business.timesonline.co.uk/tol/business/industry_sectors/transport/article3675188.ece) . London: The Times. http://business.timesonline.co.uk/tol/business/industry_sectors/transport/article3675188.ece. 26. ^ "oeing's 'Phantom Eye' Ford Fusion powered stratocraft" (http://www.theregister.co.uk/2010/07/13/phantom_eye_rollout/) . The Register. 13-07-2010. http://www.theregister.co.uk/2010/07/13/phantom_eye_rollout/. Retrieved 2010-07-143. 27. ^ "Hydrogen engines get a lift" (http://www.accessmylibrary.com/coms2/summary_0286-35668015_ITM) . Accessmylibrary.com. 2008-10-01. http://www.accessmylibrary.com/coms2/summary_0286-35668015_ITM. Retrieved 2010-12-12. 28. ^ a b HyICE (https://www.hfpeurope.org/uploads/700/836/2005_HFP_Brussels_HyICE.pdf) 29. ^ "Rocket stage article" (http://www.braeunig.us/space/propuls.htm#stage) . Braeunig.us. http://www.braeunig.us/space/propuls.htm#stage. Retrieved 2010-12-12. 30. ^ 1807 Francois Isaac de Rivaz - internal combustion engine (http://www.h2cars.de/1_cardata/c214.htm) 31. ^ Linde X39 (http://www.linde-mh.com/news/detail/news080526_29.php) 32. ^ Online biography of Francis Thomas Bacon (http://chem.ch.huji.ac.il/history/bacon.html) 33. ^ a b Bullis, Kevin. "Q & A: Steven Chu", (http://www.technologyreview.com/business/22651/page2/) Technology Review, May 14, 2009 34. ^ Copeland, Michael V. "The hydrogen car fights back", (http://money.cnn.com/2009/10/13/technology/hydrogen_car.fortune/index.htm) Fortune magazine, October 14, 2009 35. ^ "COE researchers engineer low-cost catalyst for hydrogen production" (http://www.engr.wisc.edu/alumni/perspective/30.1/Article08_hydrogen.html) . Engr.wisc.edu. http://www.engr.wisc.edu/alumni/perspective/30.1/Article08_hydrogen.html. Retrieved 2010-12-12. 36. ^ "Accomplishments and Progress" (http://www1.eere.energy.gov/hydrogenandfuelcells/accomplishments.html) . Fuel Cell Technology Program, U.S. Dept. of Energy, June 24, 2011 37. ^ Ballard "2006 achievements" press release (http://www.ballard.com/be_informed/fuel_cell_technology/roadmap) 38. ^ From the Ballard website (http://www.ballard.com/images/image_gallery/roadmap/2006%20Freeze%20Start% 20Graph.gif) 39. ^ United States Department of Energy, http://www1.eere.energy.gov/hydrogenandfuelcells/ 40. ^ "EERE Service life 5000 hours" (http://www.hydrogen.energy.gov/pdfs/progress07/v_0_introduction.pdf) (PDF). http://www.hydrogen.energy.gov/pdfs/progress07/v_0_introduction.pdf. Retrieved 2010-12-12. 41. ^ "Marine PEM fuel cell service life" (http://www.industry.siemens.com/broschueren/pdf/Marine/Sinavy/en/SINAVY_FuelCells_e_Fr_SMM2809.pdf) . Industry.siemens.com. http://www.industry.siemens.com/broschueren/pdf/Marine/Sinavy/en/SINAVY_FuelCells_e_Fr_SMM2809.pdf. Retrieved 2010-12-12. 42. ^ "Fuel Cell School Buses: Report to Congress" (http://www.hydrogen.energy.gov/pdfs/epact_743_fuel_cell_school_bus.pdf) (PDF). http://www.hydrogen.energy.gov/pdfs/epact_743_fuel_cell_school_bus.pdf. Retrieved 2010-12-12. 43. ^ a b Schultz, M.G., Thomas Diehl, Guy P. Brasseur, and Werner Zittel. "Air Pollution and Climate-Forcing Impacts of a Global Hydrogen Economy", (http://www.sciencemag.org/cgi/content/full/302/5645/624) Science, October 24, 2003 302: 624-627 44. ^ "FCT Hydrogen Production: Natural Gas Reforming" (http://www1.eere.energy.gov/hydrogenandfuelcells/production/natural_gas.html) . .eere.energy.gov. 15 December 2008. http://www1.eere.energy.gov/hydrogenandfuelcells/production/natural_gas.html. Retrieved 19 October 2009. 45. ^ F. Kreith, "Fallacies of a Hydrogen Economy: A Critical Analysis of Hydrogen Production and Utilization" in Journal of Energy Resources Technology (2004), 126: 249257. 46. ^ a b c "From TechnologyReview.com "Hell and Hydrogen", March 2007" (http://www.technologyreview.com/Energy/18301/) . Technologyreview.com. http://www.technologyreview.com/Energy/18301/. Retrieved 2011-01-31. 47. ^ a b Bossel, Ulf. "Does a Hydrogen Economy Make Sense?" (http://www.efcf.com/reports/E21.pdf) Proceedings of the IEEE, Vol. 94, No. 10, October 2006 48. ^ Heetebrij, Jan. "A vision on a sustainable electric society supported by Electric Vehicles" (http://www.olino.org/us/articles/2009/06/05/a-vision-on-a-sustainable-electric-society-supported-by-electricvehicles-and-solar-energy) , Olino Renewable Energy, June 5, 2009 49. ^ a b c d Romm, Joseph. "Climate and hydrogen car advocate gets almost everything wrong about plug-in cars", (http://climateprogress.org/2009/10/06/climate-and-hydrogen-car-advocate-gets-almost-everything-wrong-about-plug-in -cars) The Energy Collective, October 6, 2009 50. ^ a b Suplee, Curt. "Don't bet on a hydrogen car anytime soon" (http://www.washingtonpost.com/wpdyn/content/article/2009/11/16/AR2009111602668.html) . Washington Post, November 17, 2009 51. ^ L. Soler, J. Macans, M. Muoz, J. Casado. Journal of Power Sources 169 (2007) 144-149 52. ^ F. Kreith (2004). "Fallacies of a Hydrogen Economy: A Critical Analysis of Hydrogen Production and Utilization". Journal of Energy Resources Technology 126: 249257. 53. ^ "US Energy Information Administration, "World Primary Energy Production by Source, 19702004"" (http://www.eia.doe.gov/aer/txt/ptb1101.html) . Eia.doe.gov. http://www.eia.doe.gov/aer/txt/ptb1101.html. Retrieved 2010-12-12.
http://en.wikipedia.org/wiki/Hydrogen_vehicle
01-10-2011
Page 12 of 14
54. ^ Galbraith, Kate and Matthew L. Wald. "Energy Goals a Moving Target for States", (http://www.nytimes.com/2008/12/05/business/05power.html) The New York Times, December 4, 2008 55. ^ Iceland's hydrogen buses zip toward oil-free economy (http://www.detnews.com/2005/autosinsider/0501/14/autos60181.htm) . Retrieved 17-July-2007. 56. ^ First Danish Hydrogen Energy Plant Is Operational (http://www.renewableenergyaccess.com/rea/news/story? id=48873) . Retrieved 17-July-2007. 57. ^ "Light Weight Hydrogen 'Tank' Could Fuel Hydrogen Economy" (http://www.sciencedaily.com/releases/2008/11/081104084215.htm) . Sciencedaily.com. 2008-11-05. http://www.sciencedaily.com/releases/2008/11/081104084215.htm. Retrieved 2010-12-12. 58. ^ Hydrazine fuels hydrogen power hopes. (http://www.rsc.org/chemistryworld/News/2011/March/17031104.asp) ChemistryWorld.com, March 2011. 59. ^ The Drive Toward Hydrogen Vehicles Just Got Shorter (http://www.chem.info/News/Feeds/2011/03/topics-softwarethe-drive-toward-hydrogen-vehicles-just-got-shorte/) . ChemNews.com, March 2011. 60. ^ Henry, Jim (October 29, 2007). "GM's Fuel-Cell Hedge" (http://www.businessweek.com/autos/content/oct2007/bw20071026_550384.htm? chan=autos_hybrids+index+page_news+%3Cspan+style%3D%22font-family%3Aarial%3B%22%3E%2B%3C% 2Fspan%3E+features) . BusinessWeek. http://www.businessweek.com/autos/content/oct2007/bw20071026_550384.htm? chan=autos_hybrids+index+page_news+%3Cspan+style%3D%22font-family%3Aarial%3B%22%3E%2B%3C% 2Fspan%3E+features. Retrieved 9 May 2008. 61. ^ Gardner, Michael (November 22, 2004). "Is 'hydrogen highway' the answer?" (http://www.signonsandiego.com/news/science/20041122-9999-1n22hydrogen.html) . San Diego UnionTribune. http://www.signonsandiego.com/news/science/20041122-9999-1n22hydrogen.html. Retrieved 9 May 2008. 62. ^ Stanley, Dean. "Shell Takes Flexible Approach to Fueling the Future" (http://web.archive.org/web/20080121004423/http://www.hydrogenforecast.com/ArticleDetails.php? articleID=250) . hydrogenforecast.com. Archived from the original (http://www.hydrogenforecast.com/ArticleDetails.php?articleID=250) on January 21, 2008. http://web.archive.org/web/20080121004423/http://www.hydrogenforecast.com/ArticleDetails.php?articleID=250. Retrieved 9 May 2008. 63. ^ Romm, Joseph (2004). The Hype about Hydrogen, Fact and Fiction in the Race to Save the Climate. New York: Island Press. ISBN 155963703X. (ISBN 1-55963-703-X), Chapter 5 64. ^ "California Fuel Cell Partnership" (http://www.cafcp.org/stationmap) . http://www.cafcp.org/stationmap. 65. ^ "Filling the Tank with Hydrogen" (http://its.berkeley.edu/btl/2011/winter/hydrogen) . Berkely Transportation Letter . University of California at Berkeley. Winter 2011. http://its.berkeley.edu/btl/2011/winter/hydrogen. Retrieved January 21, 2011. 66. ^ "Cluster Successes in South Carolina" (http://www.schydrogen.org/documents/Reports/Cluster_Successes.pdf) (PDF). http://www.schydrogen.org/documents/Reports/Cluster_Successes.pdf. Retrieved 2011-01-31. 67. ^ "DOE codes and standards" (http://www.hydrogen.energy.gov/codes_standards.html) . Hydrogen.energy.gov. http://www.hydrogen.energy.gov/codes_standards.html. Retrieved 2011-01-31. 68. ^ a b Meyers, Jeremy P. "Getting Back Into Gear: Fuel Cell Development After the Hype" (http://www.electrochem.org/dl/interface/wtr/wtr08/wtr08_p36-39.pdf) . The Electrochemical Society Interface, Winter 2008, pp. 3639, accessed August 7, 2011 69. ^ White, Charlie. "Hydrogen fuel cell vehicles are a fraud" (http://dvice.com/archives/2008/07/shift_hydrogen.php) Dvice TV, July 31, 2008 70. ^ Squatriglia, Chuck. "Hydrogen Cars Won't Make a Difference for 40 Years", (http://www.wired.com/cars/energy/news/2008/05/hydrogen?currentPage=1) Wired, May 12, 2008 71. ^ a b Boyd, Robert S. (May 15, 2007). "Hydrogen cars may be a long time coming" (http://www.mcclatchydc.com/staff/robert_boyd/story/16179.html) . McClatchy Newspapers. http://www.mcclatchydc.com/staff/robert_boyd/story/16179.html. Retrieved 9 May 2008. 72. ^ Neil, Dan (February 13, 2009). "Honda FCX Clarity: Beauty for beauty's sake" (http://www.latimes.com/classified/automotive/highway1/la-fi-neil13-2009feb13,0,6636491.story) . Los Angeles Times. http://www.latimes.com/classified/automotive/highway1/la-fi-neil13-2009feb13,0,6636491.story. Retrieved 11 March 2009. 73. ^ Winfrey, Graham. "BMW Bets Against the Hydrogen Car", The Business Insider , December 21, 2009 (http://www.businessinsider.com/bmw-bets-against-the-hydrogen-car-2009-12) 74. ^ GM, Edward Taylor and Mike Spector. "Toyota Doubtful on Fuel Cells' Mass Use", The Wall Street Journal (http://online.wsj.com/article/SB120468405514712501.html) , March 5, 2008 75. ^ a b c Wrigglesworth, Phil. "The car of the perpetual future"' (http://www.economist.com/science/tq/displaystory.cfm? story_id=11999229) September 4, 2008, retrieved on September 15, 2008 76. ^ a b "Hydrogen Cars' Lifecycle Emits More Carbon Than Gas Cars, Study Says", (http://www.digitaltrends.com/lifestyle/cars-lifestyle/hydrogen-cars-lifecycle-emits-more-carbon-than-gas-cars-studysays/) Digital Trends, January 1, 2010 77. ^ Matthew L. Wald (7 May 2009), U.S. Drops Research Into Fuel Cells for Cars (http://www.nytimes.com/2009/05/08/science/earth/08energy.html) , New York Times, http://www.nytimes.com/2009/05/08/science/earth/08energy.html, retrieved 9 May 2009
http://en.wikipedia.org/wiki/Hydrogen_vehicle
01-10-2011
Page 13 of 14
78. ^ "Hydrogen and Fuel Cell Associations Criticize DOE Program Cuts" (http://www.renewableenergyworld.com/rea/partner/national-hydrogen-association1881/news/article/2009/05/hydrogen-and-fuel-cell-associations-criticize-doe-program-cut) . National Hydrogen Association Press Release. 7 May 2009. http://www.renewableenergyworld.com/rea/partner/national-hydrogenassociation-1881/news/article/2009/05/hydrogen-and-fuel-cell-associations-criticize-doe-program-cut. Retrieved 9 May 2009. 79. ^ Chu, Steven. "Winning the Future with a Responsible Budget" (http://blog.energy.gov/blog/2011/02/11/winningfuture-responsible-budget) . U.S. Dept. of Energy, February 11, 2011 80. ^ Shepardson, David. "GM CEO: Fuel cell vehicles not yet practical" (http://detnews.com/article/20110730/AUTO01/107300380/GM-CEO--Fuel-cell-vehicles-not-yetpractical#ixzz1U0rgmbIh) . The Detroit News, July 30, 2011 81. ^ "US government news release" (http://www.pnl.gov/news/release.asp?id=204) . Pnl.gov. 2006-12-11. http://www.pnl.gov/news/release.asp?id=204. Retrieved 2011-01-31. 82. ^ "Domestic Energy use in the UK" (http://www.powerwatch.org.uk/energy/graham.asp) . Powerwatch. http://www.powerwatch.org.uk/energy/graham.asp. Retrieved 2011-01-31. 83. ^ "CR4 - Blog Entry: Transformer Efficiency Standards Proposed" (http://www.google.co.uk/url? sa=t& source=web& ct=res& cd=7& url=http%3A%2F%2Fcr4.globalspec.com%2Fblogentry%2F434%2FTransformerEfficiency-Standards-Proposed& ei=uMG0SpjHIcL4Aa4pNl8& usg=AFQjCNGEiscm6FsMHUGDIcZKlA20v3jCWQ) . Google.co.uk. 6 November 2006. http://www.google.co.uk/url?sa=t& source=web& ct=res& cd=7& url=http%3A%2F%2Fcr4.globalspec.com% 2Fblogentry%2F434%2FTransformer-Efficiency-Standards-Proposed& ei=uMG0SpjHIcL4Aa4pNl8& usg=AFQjCNGEiscm6FsMHUGDIcZKlA20v3jCWQ. Retrieved 19 September 2009. 84. ^ http://www.pluginhighway.ca/PHEV2007/proceedings/PluginHwy_PHEV2007_PaperReviewed_Valoen.pdf 85. ^ Stewart, Ben (4 April 2008). "Chevy Volt Plug-in Car Batteries Ready for 2010 - GM Technical Center" (http://www.popularmechanics.com/automotive/new_cars/4257460.html) . Popular Mechanics. http://www.popularmechanics.com/automotive/new_cars/4257460.html. Retrieved 19 September 2009. 86. ^ Romm, Joseph and Prof. Andrew A. Frank. "Hybrid Vehicles Gain Traction", Scientific American (April 2006) (http://www.calcars.org/calcars-news/329.html) 87. ^ "Plug-in Hybrid Advocacy Group" (http://www.pluginpartners.org) . Pluginpartners.org. http://www.pluginpartners.org. Retrieved 2011-01-31. 88. ^ "Car Fueled With Biogas From Cow Manure: WWU Students Convert Methane Into Natural Gas" (http://es.epa.gov/ncer/p3/press/04_22_07.html) 89. ^ "ACEEE Greenest Vehicles of 2008" (http://greenercars.org/highlights_greenest.htm) . Greenercars.org. http://greenercars.org/highlights_greenest.htm. Retrieved 2011-01-31. 90. ^ "The Cleanest Cars on Earth?: Honda Civic GX and Other Natural Gas Vehicles (NGVs)" (http://gas2.org/2008/05/05/the-cleanest-cars-on-earth-honda-civic-gx-and-other-natural-gas-vehicles-ngvs/) 91. ^ ""Honda Civic GX Natural Gas Car Earns Top Spot on ACEEE's "Greenest Vehicles of 2008" List for the Fifth Straight Year"" (http://world.honda.com/news/2008/4080219Civic-GX-Natural-Gas-Car/) . World.honda.com. 2008-0219. http://world.honda.com/news/2008/4080219Civic-GX-Natural-Gas-Car/. Retrieved 2011-01-31. 92. ^ "The Last Car You Would Ever Buy Literally: Why we shouldn't get excited by the latest hydrogen cars" (http://www.technologyreview.com/blog/guest/22087/) , Technology Review, June 18, 2008 93. ^ "Efficiency of Hydrogen PEFC, Diesel-SOFC-Hybrid and Battery Electric Vehicles" (http://www.efcf.com/reports/E04.pdf) (PDF). 15 July 2003. http://www.efcf.com/reports/E04.pdf. Retrieved January 7, 2009. 94. ^ "Information from" (http://cta.ornl.gov/data/index.shtml) . cta.ornl.gov. http://cta.ornl.gov/data/index.shtml. Retrieved 2011-01-31. See also the cost comparison tables here: Buchmann, Isidor. "Batteries against fossil fuel" (http://batteryuniversity.com/learn/article/batteries_against_fossil_fuel) , accessed March 15, 2011. Excerpted from Buchman, Isidor. Batteries in a Portable World A Handbook on Rechargeable Batteries for Non-Engineers (3rd edition), 2011, Cadex Electronics Inc. ISBN 0968211828 95. ^ "MINI E" (http://www.miniusa.com/minie-usa/) . MINIUSA.com. http://www.miniusa.com/minie-usa/. Retrieved 19 September 2009.
External links
California Fuel Cell Partnership homepage (http://www.fuelcellpartnership.net/) Clean Energy Partnership (http://www.cleanenergypartnership.de/index.php?id=13& L=1) C-Net Hydrogen: More Polluting than Petroleum? (http://news.com.com/8301-10784_3-61729507.html) Cnet news 2007 U.S. Dept. of Energy hydrogen pages (http://www1.eere.energy.gov/hydrogenandfuelcells/) Toronto Star article on hydrogen trains dated October 21, 2007 (http://www.thestar.com/columnists/article/268851) NOVA Video on Fuel Cell Cars (http://www.pbs.org/wgbh/nova/sciencenow/3210/01.html) (aired on PBS, July 26, 2005)
http://en.wikipedia.org/wiki/Hydrogen_vehicle
01-10-2011
Page 14 of 14
Sandia Corporation Hydrogen internal combustion engine description (http://www.ca.sandia.gov/crf/research/combustionEngines/PFI.php) UK Low Carbon and Fuel Cell Knowledge Transfer Network (http://www.low-carbon-fuel-cellktn.org.uk/) Inside world's first hydrogen-powered production car (http://www.bbc.co.uk/news/business-11297410) BBC News, 14 September 2010 Retrieved from "http://en.wikipedia.org/wiki/Hydrogen_vehicle" Categories: Hydrogen vehicles | Automotive technologies | Sustainable technologies | Green vehicles | Hydrogen technologies | Hydrogen economy | Emerging technologies This page was last modified on 26 September 2011 at 20:17. Text is available under the Creative Commons Attribution-ShareAlike License; additional terms may apply. See Terms of use for details. Wikipedia is a registered trademark of the Wikimedia Foundation, Inc., a non-profit organization.
http://en.wikipedia.org/wiki/Hydrogen_vehicle
01-10-2011