Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
BACHELOR OF TECHNOLOGY IN
computer science engineering
By
AVINASH KUMAR
09d01a0504
Ms. Radhika
Assistant Professor Department of computer science engineering
2012-13
CERTIFICATE
This is to certify that the dissertation work entitled " DESIGN AND ANALYSIS ON HAMMER OF A HAMMER MILL CRUSHER that is being submitted by AVINASH KUMAR bearing Roll No: 097W1A0305 in partial fulfillment of the requirement of the award of the degree BACHELOR OF TECHNOLOGY in the St Marys Integrated Campus, Deshmukhi Village, Pochampally (Mandal), Nalgonda is a record of student work carried out by her under my supervision and guidance during the year 2012. The results embodied in this dissertation have not been submitted to any other University or Institute for the award of any degree or Diploma.
Signature of the Head Mr. Malakondaiah (H.O.D) Associate Professor Head of Dept.M.E
DECLARATION
This is to certify that work reported in the present thesis titled DESIGN AND ANALYSIS ON HAMMER OF A HAMMER MILL CRUSHER is a record of work done by me in the Department of Mechanical Engineering, St. Marys Integrated Campus, Jawaharlal Nehru Technological University, Hyderabad. No part of the thesis is copied from books / journals / internet and wherever the portion is taken, the same has been duly referred in the text. The reported work is based on the project work done entirely by me and not copied from any other source.
*****
ACKNOWLEDGEMENT
I wish to express my deep sense of gratitude to my project guide Ms. RADHIKA, Assistant Professor, Department of Mechanical Engineering, St.Marys Integrated Campus, Jawaharlal Nehru Technological University, Hyderabad (JNTUH) for her extremely valuable guidance and hearted co-operation throughout the project. Her constant encouragement and advice gave me the inspiration for the completion of thesis work. My Special thanks to Mr.MALAKONDAIAH ,Head of the Department, Mechanical Engineering, St. Marys Integrated Campus, Jawaharlal Nehru Technological University. Finally, my sincere thanks to all the staff members and friends of Department of Mechanical Engineering, St.Marys Integrated Campus, Jawaharlal Nehru Technological University and employees who contributed directly or indirectly to make this project a success.