Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Pgina 1
Non-Economical LORA
The non-economic LORA is based upon a set of predefined questions, as given in the example Logic Chart below. This logic could be modified to take into consideration, other maintenance constraints, as dictated by a customer, or criteria such as operational environmental restriction. Using the Logic Tree, a response is made to each question (as given below), following the logic. This process will lead itself to establish the maintenance strategy and level of repair for each corrective maintenance task. The questions identify which of the failed units can be removed from their operational positions with a minimum amount of support resources. When determining if an item or sub-item should be replaced and/or repaired at 1st line, consideration must be given to all aspects of the maintenance task. These include fault diagnostic techniques, accessibility requirements, task verification, elapsed task times, disruption to the operational environment etc.
http://www.mtain.com/logistics/loglora.htm
02-09-2011 1:32:59
Pgina 2
Logic for the Level of Repair Analysis (CM Tasks - Non-Economical Criteria)
Questions
1. Is the design of the item such that repair is feasible? 2. Are the item's maintenance characteristics and installation such that a remove/replace strategy is feasible at first line? 3. Does the item have lower level subassemblies? 4. Does item's maintenance characteristics permit a replacement action of the sub-item? 5. Does the item's configuration consist of subassemblies from multiple vendors?
http://www.mtain.com/logistics/loglora.htm
02-09-2011 1:32:59
Pgina 3
MTain looks forward to receiving your comments about this Web Site. Send your comments to services@mtain.com
http://www.mtain.com/logistics/loglora.htm
02-09-2011 1:32:59