Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
December 2012
High-Performance Semiconductors
TABLE OF CONTENTS
Sensor IC Package Portfolio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3 Integrated Circuit Package Portfolio . . . . . . . . . . . . . . . . . . . . . . .4 Magnetic Linear and Angular Position Sensor ICs . . . . . . . . . . . .5
Customer Programmable, Medium to High Accuracy Solutions . . . . . . . . . . .5 Factory Programmed, Cost-Effective Solutions . . . . . . . . . . . . . . . . . . . . . . . .5 Factory Programmed, Micro Power 3 V Linears, Cost-Effective Solutions . . .5
Bipolar Stepper Motor Drivers - Step / Direction Interface . . . . . . . . . . . . .12 High Side Drivers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12 Low Side Drivers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13 Photoelectric Smoke Detector ICs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13 Ionization Smoke Detector ICs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13 Consumer Electronics Applications Overview . . . . . . . . . . . . . . . . . . . . . . . .13
Allegros products are not to be used in life support devices or systems, if a failure of an Allegro product can reasonably be expected to cause the failure of that life support device or system, or to affect the safety or effectiveness of that device or system.
UA (TO-92) Terminals: 3
SE Terminals: 4
SG Terminals: 4 SH Terminals: 4
KT Terminals: 4
KN Terminals: 4
SJ Terminals: 4
Without Leads
ES, EC, ET, EU, EV (QFN with exposed pad) Terminals: 16-48 Size: 3 x 3 mm body width to 7 x 7 mm body width EJ (TDFN with exposed pad) Terminals: 3-16 Size: 2 x 2 mm body to 3 x 3 mm body width
Chip Scale
CG (Chip Scale) Terminals: 4-12
With Leads
JP (QFP with exposed pad) Terminals: 48 Size: 7 x 7 mm body width LB (SOIC) Terminals: 16-28 Size: 7.5 mm body width LZ (MSOP with exposed pad) Terminals: 10 Size: 3 mm body width
LP (TSSOP with exposed pad) Terminals: 16-32 Size: 4.4 mm body width
Temperature range codes: S = -20C to 85C, E = -40C to 85C, K = -40C to 125C, L = -40C to 150C
Crankshaft Sensor ICs - Gear-Tooth Hall-Effect Speed Sensor ICs (Includes IC and Magnet)
Part Number ATS616 ATS627 Supply Voltage (V) 3.5 to 24 4 to 24 Output Type 3-wire 3-wire Power-On State High (off) High (off) Specified Air Gap Range (>20 Hz) 0.4 to 2.5 mm 0.5 to 3 mm Key Spec Timing accuracy Repeatability Minimum Speed 10 Hz Zero speed Packages SG SG
Temperature range codes: S = -20C to 85C, E = -40C to 85C, K = -40C to 125C, L = -40C to 150C
Micropower Switches-Latches
Part Number A1171 A1172 A1174 A3211 A3212 A3213 A3214 Operate Voltage (V) 1.65 to 3.5 1.65 to 3.5 1.65 to 3.5 2.5 to 3.5 2.5 to 3.5 2.4 to 5.5 2.4 to 5.5 Operating Point (G) 55 55 5 to 55 55 55 70 70 Release Point (G) 6 6 -55 to -5 10 10 10 10 Hysteresis (G) Typ 6 Typ 6 Typ 72 Typ 7.7 Typ 7.7 Typ 7.7 Typ 7.7 Temperature Ranges E E E E E, L E, L E, L Packages EW CG EW EL, EH, LH EL, EH, LH, UA LH, UA LH, UA Supply Current (A) 4 (typ) (VDD=1.8 V) 4 (typ) (VDD=1.8 V) 82 (VDD=3 V) 6 (typ) 6 (typ) 850 (max) 22 (max)
Temperature range codes: S = -20C to 85C, E = -40C to 85C, K = -40C to 125C, L = -40C to 150C For switch interface ICs, please see the "High Side Drivers" section on page 21.
We deliver robust, application-specific, magnetic sensor and power ICs for applications, including:
Engine speed sensing Electronic Power Steering (EPS) Fan and pump systems Infotainment Lighting systems Hybrid/Electric vehicles
For more than 20 years, Allegro has designed and manufactured highly innovative sensor and power integrated circuits (ICs) for demanding, safety critical automotive applications. In fact, Allegro has shipped well over 2.5 billion ICs into automotive applications. Allegros extensive experience in the automotive market motivates our entire organization to continually enhance and refine our broad foundation of high voltage automotive semiconductor and IC package technologies, our deep automotive applications knowledge, our global automotive market support infrastructure, and our commitment to automotive quality systems. As a result, Allegros core technologies are well aligned with emerging trends towards fuel efficiency and reduced vehicle emissions. Allegro is well positioned to deliver robust, applications specific ICs for a broad range of safety critical powertrain, electronic power steering, infotainment, and comfort and convenience applications for both internal combustion engine and hybrid or fully electric vehicles.
10
Packages WLCSP-6 1.47 x 0.97 mm DFN-6, WLCSP-6 Bare die e-TSSOP-16 eTSSOP-16 eLQFP-32 eLQFP-48
All devices above have a parallel interface. Note: "K" suffix denotes automotive grade product
11
12
We offer a range of Hall-effect sensor ICs, motor driver ICs and regulators to enable the operation of such products as:
Printers, copiers, scanners Satellite set-top boxes Servers Flat panel displays Appliances Mobile phones
Allegro offers a range of Hall-effect sensor ICs, motor driver ICs and regulators for a variety of consumer applications. Allegros portfolio serves a wide array of applications and enables the operation of such products as digital flat panel displays, satellite set-top boxes, mobile phones and appliances by providing power management, backlight display control, motor control, and position and current sensing functions. Allegros portfolio includes applications-specific products as well as a range of standard products designed for high-performance and a minimal footprint (or space).
13
14
A8601K
4 to 5.5
eTSSOP-28
Note: "K" suffix denotes automotive grade product *Typical voltage rails needed when powering LCD displays
We offer a growing portfolio of LED drivers used for the following applications:
Display backlighting Architectural lighting Automotive lighting Driving IR LEDs and HBLEDs
Allegro MicroSystems, Inc. offers a growing portfolio of LED drivers used for display backlighting, architectural lighting, signage, and automotive lighting applications. Allegros process technology and applications expertise has enabled the development of highly integrated LED driver ICs with on-chip FETs and diverse control options, providing flexibility and functionality in a small solution footprint. Allegros LED driver portfolio covers a wide variety of topologies, channel counts, output currents and feature sets to help customers optimize their solutions. Features within the portfolio of devices include: Buck, boost, charge pump, and linear topologies Series and parallel configurations Single and multiple (up to 16) channel outputs Output currents from 20 mA up to 3 A per channel Multiple intensity control methods including PWM control with high resolution per channel Current-control for color calibration (dot correction)
Open LED and shorted LED detection Thermal shutdown and undervoltage lockout Automotive voltage and temperature ratings available Excellent current matching and accuracy Low quiescent current Multiple package options
15
High-Performance Semiconductors
North America: 508-853-5000 sales@allegromicro.com Europe: +33-450-51-23-59 allegroeurope@allegromicro.com China: +86-21-51506818 allegrochina@allegromicro.com Japan: +03-3986-6166
japansales@allegromicro.com
Korea: +82-70-8852-8250
allegrokorea@allegromicro.com
Taiwan: +886-2-2757-7231
allegrotaiwan@allegromicro.com
www.allegromicro.com