Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Status LED
On button
Note: Installation should be performed only by a qualified electrician or a homeowner who is familiar and comfortable with electrical circuitry. If you have any questions regarding installation, consult an electrician or call the INSTEON Support Line at 800-762-7845. 1) Be sure to write down the INSTEON I.D. and location of the fixture you'll be controlling (e.g., 01.F7.G5, Upstairs Bathroom Fan) 2) Turn off circuit breaker supplying power to the fixture 3) Disconnect the wires from the fixture you will be controlling and ensure that you have of bare wire on the ends 4) See Figure 1 to identify and connect the line, load, neutral and ground wires on In-LineLinc. Be sure you have correctly identified the wires in the junction box before connecting them. 5) After you have connected all the wires, ensure that the wire connectors are firmly attached and that there is no exposed copper except for the ground wire 6) Prior to reinstalling the fixture, turn on circuit breaker supplying power to the fixture 7) Use the on/off buttons to test that the module is working and controlling the load 8) Add In-LineLinc to a scene as a responder: Use the On and Off button on In-LineLinc to set the load to the state you wish to activate from the controller (turn it on if you wish it to be on when the controller activates the scene, etc.). Press * and hold the scene controller button until it beeps. Controller LED will blink Press and hold In-LineLinc's Set button until it double-beeps In-LineLinc status LED will flash once and then turn on steady. Controller will double-beep** and its LED will stop blinking Confirm that scene addition was successful by tapping On then Off on the controller's scene button The load connected to the In-LineLinc will respond appropriately 9) Gently place In-LineLinc into the junction box, making sure that nothing could accidentally press any of the buttons on its face 10) Reinstall the fixture
Set button
Off button
Figure 1
*If the controller does not have a beeper, wait until its LED begins blinking **Most products
Rev. 7/16/2012 12:34 PM / See Owners Manual for Warranty Information, Patented Copyright 2012, INSTEON, 16542 Millikan Ave., Irvine, CA 92606, 800-762-7845