Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
For each bit of S1 and S2, status ON means 0, OFF means 1 S1 bits 18 are mapped ID_DOG logical bits 07; S2 bit 18 are mapped ID_DOG logical bits 815;
V3
FI GURE 1 - CABINET-TOP DIP SWI TCHES
15
14
13
12
11
10
BTS_TYPE
BTS_N O
SLAVE1_ POR T
ABIS_TS
BTS_NO
The number of the E1 port of the basic cabinet to connect the lower-level site cannot be the same as of SLAVE_PORT1 or SLAVE_PORT2. For example, suppose Port F of the basic cabinet connects with the lower-level site, then the values of SLAVE_PORT1
and SLAVE_PORT2 cannot be 01. For example,site1 and site2 are BTS B8018,site2 is the downsite of site1.Both sites use the common Abis,site1 E1 port A connect to BSC,site2 E1 port A connect to site1 port D. The O&M timeslot of site2 is TS31.Then the dip switches are Site1: S1(18) 00000000 S2(18) 00000011 Site2: S1(18) 10000000 S2(18) 00000011
V2
15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 0
INDO OR
SY N
CHAN EL_NO
BTS_NO
SLAV E1_PO RT
SLA VE2_PORT
SATE
ABIS_PORT
ABIS_TS
BTS_NO
The number of the E1 port of the basic cabinet to connect the lower-level site cannot be the same as of SLAVE_PORT1 or SLAVE_PORT2. For example, suppose Port D of the basic cabinet connects with the lower-level site, then the values of SLAVE_PORT1 and SLAVE_PORT2 cannot be 01.
For example,site1 and site2 are BTSV2,site2 is the downsite of site1.Both sites use the common Abis, site1 E1 port A connect to BSC,site2 E1 port A connect to site1 port D.The O&M timeslot of site2 is TS31.Then the dip switches are Site1: S1(18) 00000000 S2(18) 00000000 Site2: S1(18) 10000000 S2(18) 00000000 Note To check the DIP switch status in site by signal trace Site Power On Report (157)- last 4 they are in HEX change to BINARY this is for ibsc For V2 leaving last 2 next 4 (Reset site and find this message in signal tracing(OAM))
S1
S2
S3
1 OFF 2 OFF 3 ON 4 OFF