Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Getting Started
Use the instructions in this guide to help you connect your Secure Services Gateway (SSG) 5 device to
your network. For additional configuration information, see the SSG 5 Hardware Installation and
Configuration Guide. (This guide uses a version of the SSG 5-WLAN device to illustrate basic network
connectivity.)
Callouts
Untrust
Callouts
Zone
DMZ
(ethernet0/1)
Wireless0/0
Console
SSG 5
TX/RX 0 LINK TX/RX 1 LINK TX/RX 2 LINK TX/RX 3 LINK TX/RX 4 LINK TX/RX 5 LINK TX/RX 6 LINK
TX/RX 0 LINK TX/RX 1 LINK TX/RX 2 LINK TX/RX 3 LINK TX/RX 4 LINK TX/RX 5 LINK TX/RX 6 LINK
STATUS B /G CD
10/100 10/100 10/100 10/100 10/100 10/100 10/100
WLAN V.92 V.9 2 CONSOL E
Console
Untrust
Trust (ethernet0/0) Trust
DMZ Zone (ethernet0/2 —
Zone AUX, V.92, or ethernet0/6)
ISDN
Step 1 b. After the device starts (about 2 minutes), ensure that the STATUS
Connect the workstation to the device using either of the following LED blinks green. This indicates that the device is operating
methods: normally.
• Connect an Ethernet cable from one of the Trusted ports labeled c. Ensure that the Link Activity LEDs glow green for the connected
0/2 — 0/6 to the Ethernet port on the workstation. Ethernet ports. This indicates that the device has network
(We recommend this connection method.) connectivity.
• Connect a straight-through serial cable from the console port to Step 3
the supplied DB-9 adapter which then connects to the serial port Configure the workstation to access the device through a browser:
on the workstation. a. Ensure that the workstation is properly connected to the device
Step 2 using one of the methods presented in step 1.
Connect the device to a power source using the supplied power
b. Change the TCP/IP settings of the workstation to automatically
cable. (We recommend using a surge protector.) Confirm that the
obtain its IP address from the device using DHCP. For help, see
following LEDs are working correctly:
the operating system documentation for the workstation.
Note: Ensure that your internal network does not already have a
DHCP server.
c. If necessary, restart the workstation to enable the changes to
take effect.
a. Ensure that the POWER LED glows green. This indicates that the You can use the Initial Configuration Wizard (ICW) to configure the
device is receiving power. SSG 5 device. Before starting the ICW, decide how you want to
deploy your device. (For additional information, see the
SSG 5 Hardware Installation and Configuration Guide.)
Getting Started Guide
Copyright © 2006 Juniper Networks, Inc. All rights reserved. Juniper Networks, the Juniper Networks logo, NetScreen, NetScreen Technologies, GigaScreen, NetScreen-Global PRO,
NetScreen-Remote, NetScreen ScreenOS and the NetScreen logo are trademarks and registered trademarks of Juniper Networks, Inc. in the United States and other countries. All other
trademarks and registered trademarks are the property of their respective companies. Information in this document is subject to change without notice. No part of this document may
be reproduced or transmitted in any form or by any means, electronic or mechanical, for any purpose, without receiving written permission from Juniper Networks, Inc.
P/N 530-015649-01Rev. A