Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
3.
Install the provided FCC/IC label (P/N 800-10342) on the controls case back (refer to Figure 1).
CONTAINS MODULE: FCC ID: CFS8DLZWM IC: 573F-ZWM IC MODEL: ZWM
800-10342 Label
L5100-ZWAVE
FCC / IC STATEMENT
This device complies with Part 15 of the FCC Rules, and RSS 210 of IC. Operation is subject to the following two conditions: (1) This Device may not cause harmful interference. (2) This device must accept any interference received, including interference that may cause undesired operation.
RECEPTACLE
800-10259 11/11 Rev A
EDGE CONNECTOR
LYNX TOUCH
5000-100-204-V0
Programming Notes
Programming associated with the L5100-ZWAVE module is accomplished as part of the control panel programming. Refer to the control panel installation and setup guide for additional information.
Specifications
Board Dimensions: Current Drain: Input Voltage: Temperature: 1.25 W x 2.875 L x 0.3125 D 40mA nominal ; 100mA max. 3.3 VDC 32F (0C) to 140F (60C)
REFER TO THE INSTALLATION AND SETUP GUIDE FOR THE CONTROL WITH WHICH THIS DEVICE IS USED FOR WARRANTY INFORMATION AND LIMITATIONS OF THE ENTIRE SYSTEM. FEDERAL COMMUNICATIONS COMMISSION (FCC) STATEMENTS
The user shall not make any changes or modifications to the equipment unless authorized by the Installation Instructions or User's Manual. Unauthorized changes or modifications could void the user's authority to operate the equipment.
ICES-003 Class B Notice - Avis NMB-003, Classe B This Class B digital apparatus complies with Canadian ICES-003. Cet appareil numrique de la classe B est conforme la norme NMB-003 du Canada.
FCC / IC STATEMENT
This device complies with Part 15 of the FCC Rules, and RSS 210 of IC. Operation is subject to the following two conditions: (1) This device may not cause harmful interference (2) This device must accept any interference received, including interference that may cause undesired operation. Cet appareil est conforme la partie 15 des rgles de la FCC & de RSS 210 des Industries Canada. Son fonctionnement est soumis aux conditions suivantes: (1) Cet appareil ne doit pas causer d' interferences nuisibles. (2) Cet appareil doit accepter toute interference reue y compris les interferences causant une reception indsirable.
WARNING: The L5100-ZWAVE must be installed to provide a separation distance of at least 20 cm from all persons except in accordance with FCC multi-transmitter product procedures.
RF Exposure
800-10226u
800-10226 10/11 Rev. A
2 Corporate Center Drive, Suite 100 P.O. Box 9040, Melville, NY 11747
Copyright 2012 Honeywell International Inc. www.honeywell.com/security