“WGA SERVICE SHEET No. 315
Printed, June, 1958
B GROUP MODELS
(with Engine Pretix Letters GB)
CLUTCH
Dismantling.
Remove the cliincase as deseribed im Service Short No. 814. Kemove the four
spring retaining units and withdraw the springs and spring enps. ‘The spring jtesute
atiention 10 these items:
phe and other chageh pkures cur chew be removed, and if only
is reqnired the chute need nut he dismantled further. ‘The steel pltes shook he smeatir,
and if badly scored: must be replaced, while the cork inserts nny require washing in petral
if the of on thepr is thick and gugany 2 (1 the inserts are burnt or glazed they should
he replaced
Vig. B27. Exploded View of Clutch,
‘To dismantle the remainder ef the clutch, (arn back the Gib washer ou the iain
shaft and take off the nut whieh has a right-hand thread, uate the position of thy pkio
washer, The complete clutch can now be withdrawn from the mainshaft, making sire
that the rollers de not fall oat from between the clutch centre and dhe chainwhee!
Lift the chainwhecl fron the chiteh centre and remove the 20 rollers. “The four
bolts, eight. screws and the two cover plates (rom the chitch centre can alse be removed
lo expose the vane and shock absorber rubbers, HE the rubbers require attention, th
must be pashead ont with the aid of a suitable deift
van
Re-assembly.
Before commencing re-assembly examine the roller tracks on the chainwheel Tatsh
and if the wear an either af these components execeds 0015 in it
and clutch centr
should be replacedBS.AL Se
ryice Sheet No, 315 (contd.)
11 the chainwheel teeth are wort loa book shape, the chainehcel ist be replaced
or rapid wear on the chain will result
To reassemble the vane into the clutch centre, first replace the vane and the four
eB).
and position the vane centre on it to prevent
andl slip the remainiuys
an hest be gripped with the :
thicker rubbers which should be on the left-hand side of each vane arm. (ig
Hold an old ge:
iUretaling. Rotate the clutch centre so as to compress (he rubber
four rabbers inio position. “The clutch centre
clutch plate, Replace the clutch centre cover plates and the four bolts and eight retain
ing, serews
box inainshaft in a vice
lof a pluie
The remainder of the clutch assembly is quite straightforward. Position the 20.
rollers carefully on the clutch centre before sliding the chainwheel over them. Re
position the remainder of the clutel on the shaft and replace the nut and washer, Make
sure that the nut is fully tightened before the tab washer is turned over.
Replace the elntch plates ensuring that the thick plain back plate is put in first.
assemblies have been replaced the tetaining wats should be tightened
down lirmly on to the distance pieces.
When the spr
Vig. B28. Vane Assembly.
KSA. MOTOR CYCLES LTD.
Service Dept. Birmingham, 1.
Vented an Bayglind.