Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
0238
15LD2550B 15LD2550EB
ATTENTION:
Avant d'effectuer l'entretien du chssis, le technicien doit lire les Prcautions de scurit et les Notices de scurit du produit prsents dans le prsent manuel.
VORSICHT:
Vor ffnen des Gehuses hat der Service-Ingenieur die Sicherheitshinweise und Hinweise zur Produktsicherheit in diesem Wartungshandbuch zu lesen.
TABLE OF CONTENTS
1.1. 1.2. 1.3.
1.
INTRODUCTION
3 3 3
2.1. Introduction 2.2. System Building Blocks 2.2.1. Analog Front End 2.2.2. Back End 2.2.3. General Block Diagram 2.2.4. Side Board(s) 2.3. Power Management
2.
GENERAL DESCRIPTION
6 6 6 6 7 8 11
3.
3.1. Definitions, Acronyms and Abbreviations 3.2. Basic Components 3.2.1. VCTI 3.2.2. TSU 3XAWL 3.2.3. 74HC4052 3.2.4. 74HC4053 3.2.5. TDA2822M 3.2.6. LM1117 3.2.7. KA78L08 3.2.8. IRF7314 3.2.9. NTGS 3446 3.2.10. FDC642P 3.3. Board Connectors, Headers & Jumpers 3.3.1. Scart Connector1 3.3.2. PC Connector3.3.3. DVB Connector 3.3.4. Side A/V Connector 3.3.5. IDTV_IF Connector 3.3.6. Led Connector without MECH SW 3.3.7. Led Connector with MECH SW 3.3.8. Keypad Connector 3.3.9. MSTAR Debug Connector 3.3.10. Flash Prog. And VCTI Debug Connector 3.3.11. LVDS Panel Connector 3.3.12. Speaker Right Audio Out 3.3.13. Speaker Left Audio Out 3.3.14. Side Headphone Connector
APPENDIX
13 17 17 20 22 23 23 24 24 25 25 26 26 27 27 28 28 29 29 29 29 29 30 30 30 30 31
13
The purpose of this document is to define the DHDS and the operation of 17MB21, 15XGA with LVDS input, 19 SXGA with double LVDS input. It is aimed to provide information to engineering staff to understand the operation and specs of the TV. The other related technical documents are as follows: Title: 17MB21 Schematics IR Receiver and Led Display Board Schematics Keypad Board Schematics VCTI49xy Datasheet ( Video-Controller-Text-IF-Audio IC) TSU33AWL for 15XGA TSU36AWL for SXGA Datasheet ( Controller with Analog Interface and Multi-Purpose Output Transmitter) Other ICs Datasheets (Please check the table in Appendix 3.2 for the complete component list.). Table : Related documents.
1 2 3 5 6 7
1.2. 1.3.
The document covers detailed descriptions of 17MB21 chassis system building blocks.
Scope
General product specifications and overview of the system will be introduced in this part. The system is a low end; 15 and 19 TFT LCD TV solution basically for EU market with VCTI49XYI and TSU33AWL or TSU36AWL Video Image Processor chip-set on single-layer PCB. As the first target market is EU, the first release of the TV will support PAL/SECAM B/G/D/K/I/L/L. The other general default features of the TV are as listed below: IR Control (RC5 and other customer specific protocols) OSD 100 Program Storage Locations Teletext No Ident Timer Screen Size (15, 19) Child Lock Sleep Timer 170/270V AC Plug ST-BY Power Consumption <1W 1 Scart input (1st Full) S-VHS Input , BAV input 75 ohms antenna input PC Input (VGA) 2H/4H Comb Filter
General Features
Sound Features Equalizer FM Radio Linear Stereo German-NICAM Stereo 5 Band Equalizer Control SRS TRU Surround (OPT) SRS TRU Bass (OPT) BBE, WOW (OPT) Stereo Audio Output Power (2x2W ) 16R speaker Volume Controlled HP Output, Stereo Audio line out, Stereo Audio line in Coaxial Audio Output (with IDTV or DVD Option) Detachable Headphone Output (OPT)
Picture 4:3 PANEL --- 4:3, 16:9, Auto Picture Modes (Bright, Standard, Soft) Media Window Enhancement (MWE) White balance settings (warm/normal/cool) for TV&PC Auto Shut down Multi System Reception : PAL-SECAM BG-DK-I/I-L/L NTSC Video Playback WSS (16:9 / 4:3 Aspect Ratio Auto Switch) Channel Type Sorting (Favorite/Sport/Music/News/Movie) Tuning FST Frequency Search (OPT) APS (Auto Search / Name / Sort) Auto Search CATV / HYPERBAND Keyboard Volume -/ +Button Program -/+ Button Menu Button TV / AV Button Teletext/OSD Simple Text 10 Pages Fastext & Top Text (OPT) Teletext Languages (ALL) Character Based OSD OSD Color & Transparency Selection
The general optional features of the system are as listed below: AV Input Y/Pb/Pr support via VGA connector Full Green Mode DPMS Support Plug & Play (DDC2Bi) For Windows 9X, ME, 2000, XP (OPT) Headphone {side || on board} (When the headphone is used, TV volume cut off automatically) IDTV With Single CI Connector (OPT) DVD (OPT) Comb Filter (OPT) LTI, CTI (OPT) IDTV OSD: 22 Menu Languages ENG, FRA, GER, ITA, SPA, POR, TUR, SWE, DEN, FIN, NOR, POL, HUN, CZE, BUL, ROM, RUS, DUTCH, CRO, SLOVAK, SLOVENIAN and GRE. 2x2W Speaker Output Power.
2.2.
17MB21 chassis main blocks are as follows: Analog Front End : VCTI (Microcontroller + Video Proccessor + Sound Proccessor + IF+ Keyboard/IR Interface+OSD), Audio Amp. Back End transmitter) Side Board(s) : TSU33AWL or TSU36AWL (Scaler, Deinterlacer, OSD generator, LVDS : Keyboards, IR/LED Boards, FAV Boards, Headphone Boards.
2.2.1.
17MB21 Main Board consists of two major blocks. The first block is analog front-end and this block is handled by VCTI chip that is highly multifunctional. This IC does demodulation of Video & Audio from Tuner IF, CVBS, Audio, RGB, SVHS input selection and processing. It has an audio processor that supports equalizer or tone control, volume control, AVL, surround effect etc and supplies amplifier, headphone and CVBS & audio line outputs. It handles video processing such as colour standard detection and demodulation, picture alignment (brightness, contrast, colour etc.). The IC also does teletext decoding with fastext memory. After video processing, the processed video is applied to TSU3XAWL chip in RGB format. The TV Tuner is an asymmetrical or a symmetrical IF output type and is PLL controlled. The IF signal is applied single saw filter. After the SAW filter block, IF signal is applied to VCTI IF inputs (Pin 16 and 17). As VCTI can handle all the audio processing, there is no need for additional audio processor solution on the board. VCTI supports three Audio outputs. These outputs are assigned to Line-out,Speaker and SC1 audio out. The board employs TDA2822M to drive speakers and headphone.
2.2.2.
Back End
The Back End section is handled by TSU chip. The RGB input can handle standard interlaced RGB output from VCTI, PC VGA RGB input and YPbPr. There are two set of ADC is present in TSU which are assigned to YPbPr/VGA and VCTI RGB output sources. TSU33AL chip have an integrated 6/8-bit LVDS transmitter. Backlight dimming and Panel power supply On/Off control is achieved via TSU chip. There are two pins to control inverter one of them is used for adjusting backlight the other one is used for backlight on/off control. Backlight on/off control is performed by VCTI.
2.2.3.
Figure 1
2.2.4. 2.2.4.1.
Front Audio Video board (17FAV20) for 17MB21 main board is detailed in the Table below.
Connector Name JK100 JK101 JK102 JK103 JK104 PL100 PL103 PL101
Type SVHS Jack 4P DIN Type RCA Jack Yellow RCA Jack Red RCA Jack White Headphone Jack Connector Header 8P Connector Male 5P Connector Male 5P
Function Side SVHS Input Side CVBS Input Side Audio Input Right Side Audio Input Left Side Headphone Connector 8P for SVHS Connector 5P for HP Connector 5P for CVBS, Audio R and L
2.2.4.2.
Keypads
The keypads button descriptions for 17MB21 main board are listed in the Table below. Key Name Power* Stand-by* TV/AV Menu ProgramProgram+ VolumeVolume+ Type Soft sw. Tact sw. Tact sw. Tact sw. Tact sw. Tact sw. Tact sw. Tact sw. Function Power shut-down and turn on Switch between stand-by and turn on modes. Input source select button. Display main menu on the screen. If any menu is active, display the upper menu. If main menu is active, turn menu off. Go to the lower program at any time in TV mode. (Scroll key function in menu mode) Go to the upper program at any time in TV mode. (Scroll key function in menu mode) Decrease the volume level in the volume. (Scroll key function in menu mode) Increase the volume level in the volume. (Scroll key function in menu mode)
Connector PL1 on keypads (connected to the connector PL303 on the main board): Pin No: 1 2 3 4 Name Gnd AV Tact SW Soft SW/Tact SW Program and Volume SW
2.2.4.3.
IR&Led Board
IR&LED board contains LED indicator(s) to show TVs status (For 1510/11 cabinet led colors are: Red for stand-by, green for normal operation) and one IR receiver to get remote control instructions. All the IR&LED boards have the same circuit and connector pinning but the different mechanical structure to fit different cabinets For 1510/11 cabinet 17LD12-3 boards are used.
17LD12-3 Schematics 10
2.3.
Power Management
All power requirements supplied from LIPS (Light Integrated Power Supply) Boards. IPS01 Lips Board used for 15 products and IPS02 for 19 products. (Please check the Table below for power management details.)
Table : Power management table. PL600 socket is used for power connections.
11
17IPS01 Outputs Voltage Current +33V 5mA +12V_Unregulated 1000mA +12V 700mA +5V 300mA +3V3 1600mA +1V8 400mA +560V_AC 15mA
12
3. 3.1.
2CS ACI ACL ADC AF AFC AGC AKB API ASD ASP ATS AV AVC AVL BBE BE BKS BTSC CC CCC CE CLUT COR CVBS DAC DBE DDEP DEMDEC DPL DPTR DRCS DSP DUB EPG FA FASTEXT FB FE FLOF FST
GTV HP HSH IF IIC IIS LibCoMa LS MIPS MPX MS NICAM NTSC NVM OSD OSRP OTP PAL PAT PB PIP PLL PMT PP PS-MTS PSW PWM RC-5 RCP RF RGB Round-robin RPMS RTC SAP SAW SCART SCI SCL SDA SDE SECAM Set-maker SFR SHLD SIF SRT SS SSS
Global TeleVision. Headphone Horizontal Shift Intermediate Frequency. Normally the output of the tuner. Inter Integrated Circuit Inter Integrated Sound Library Configuration Manager. Loudspeaker Million Instructions Per Second Japanese multiplexed sound standard Multi Standard Near Instantaneously Compacted Audio Multiplex National Television System Committee. Colour encoding system. Non-Volatile Memory On Screen Display Overall System Realization Process One Time Programmable Phase Alternating LineColour encoding system. Painter Authoring Tool. Development support tool to define Painter character sets (and UIMS data structures). Picture Booster Picture In Picture Phase Locked Loop Power ManagemenT Personal Preferences Mainstream Television Solutions Program Status Word Pulse Width Modulation Remote Control system Remote Control Preprocessor Radio Frequency TV signal broadcast. Red, Green Blue. The colour signals. A style of scheduling where each task is executed in turn, provided it is ready to run. Resource Persistent Memory Store Real Time Clock Second Audio Program; part of BTSC sound system. Surface Acoustic Wave External CVBS, S-VHS and Sound input/output, RGB and switching input. Software Configuration Item Serial Clock Serial Data Software Development Environment Sequentiel a Memoire Colour encoding system. The manufacturer/developer of the end product. Special Function Register. Software High Level Design Sound Intermediate Frequency Signal RouTing Source Switching Static Standard Selection
14
State Status Handler STB TOP(TEXT) TXT UHF UI UIMS UOC User VDS VG2 VHF VIF VOD VPS VS VSH VSP VST Y/C YprPb YUV Audio Preset:
The condition of a component that results in a particular observable behaviour. A step that handles a status change, by managing the response to the change. SetTop Box Table Of Pages, Special way of accessing teletext pages Teletext Ultra High Frequency User Interface User Interface Management System Ultimate One Chip See Set-maker Virtual Dolby Surround Voltage at Gate 2 Very High Frequency Video Intermediate Frequency Video On Demand Video Programming delivery control System Vertical Slope Vertical Shift Video Signal Processor (on Cosmic) Voltage Synthesis Tuning Luminance/Chroma signal, S-VHS Luminance Y and colour difference signals (Pr - red, Pb - blue, colour bar 100% saturation) Luminance (Y) and colour difference signals (U and V).
Pre-defined audio reproduction settings stored in NVM. The values of the items in a Preset can be set in service. SCAVEM: SCAn VElocity Modulation User 1: User defined setting for height of a 16:9 picture setting User 2: User defined setting for the zoom and the scroll of a 16:9 picture setting Indicator: An on screen object, giving textual or graphical information on user commands or system events NVM: Non Volatile Memory, used to store user and service/factory settings Program: A broadcasted TV signal received via the tuner. A program can be identified by the frequency by which it is transmitted. Source: The selected input of the TV receiver. This can either be a the front end (i.e. a program) or an external AV source Video Preset: Pre-defined video reproduction settings stored in NVM. The values of the items in a Preset can be set in service. White tone: Pre-defined values for the white point RED, GREEN and BLUE settings. The values of the white point settings for each white tine setting can be set in service. Hue: Tint First/last program: 0-99 for 100 programs available Available program: First available program is the lowest program number in NVM that is marked as not skipped. When all programs are skipped then the lowest program number is used. Last available program is the highest program number in NVM, which is marked as not skipped. When all program numbers are skipped then the highest program number is used.
15
Program number: A program number identifies a location in NVM. At this location all program information, like frequency, lock, AFC, etc., can be found. Selecting a program invokes activating the program information. Last status: A variable can be classified as last status' setting. Settings that are classified as last status are stored in NVM. The following settings are part of the last status: Program number Volume Audio Preset Video Preset Aspect ratio WSS: Wide Screen Signalling Letterbox: When a 14:9 or 16:9 format movie or picture on 4:3 transmission displayed on 4:3 set, black bars on top and the bottom of the screen are displayed. This is called letterbox or 4:3 letterbox.
16
3.2.
No
Basic Components
Title VCTI TSU33AWL or TSU36AWL 74HC4052 74HC4053 TDA2822M LM1117 KA78L08 IRF7314 NTGS3446 FDC642P Description Video-Controller-Text-IFAudio IC Family XGA LCD controller with analog interface and Single(TSU33AWL)/Double(TSU36AWL) LVDS Transmitter Dual 4- channel analog multiplexer/demultiplexer triple 2-channel multiplexer Dual Low Voltage Power Amplifier 800mA Low Dropout Linear Regulator 3-Terminal 0.1A Positive Voltage Regulator Dual P-Channel Mosfet Single N-Channel Mosfet Single P-Channel Mosfet Supplier Micronas Mstar Philips Philips ST National Semiconductor Fairchild IR On-Semi Fairchild
3.2.1.
VCTI49xy is composed of microcontroller, video proccessor, display and deflection processor, sound proccessor and IF blocks as shown in below Figure .
VCTI
VCTI49xyl family has two package types; PSSDIP88 and PMQFP144. PSSDIP88 package is chosen because of its compatibility for soldering in production. PSSDIP88 package has two
Fig
17
versions; 1 and 2. PSSDIP88-2 package is the pinning mirrorred version of PSSDIP88-1 and is preferred to be used for layout compatibility.
18
3.2.1.1.
3.2.1.2.
Pinout
3.2.1.3.
PIN NO 47 48 49 50 51 52 53 54 55 56 62 85 27 28
PORT NAME P10 P11 P12 P13 P14 P15 P16 P17 P20 P21 Safety Vert+ P22 P23
* Ths ports are used for different functionality according to IDTV support. In IDTV case Mute and Led functions are controlled by Digital Board.
3.2.2.
TSU3XAWL
The TSU33AL is total solution graphics processing IC for LCD displays with panel resolutions up to XGA. It is configured with a high-speed integrated triple-ADC/PLL, a high quality display processing engine, and an integrated multi-purpose output display interface that can support LVDS panel interface formats. To further reduce system costs, the TSU33AL also integrates intelligent power management control capability for green-mode requirements and spread-spectrum support for EMI management.
3.2.2.1.
Block Diagram
20
3.2.2.3.
PIN NO PORT NAME SIGNAL NAME TYPE 36 PWM0 A/A_DIM O 37 PWM1 PVCC_ON/OFF O
3.2.3.
DUAL 4-CHANNEL ANALOG MULTIPLEXER/DEMULTIPLEXER The 74HC4052 are dual 4-channel analog multiplexers or demultiplexers with common select logic. Each multiplexer has four independent inputs/outputs (pins nY0 to nY3) and a common input output (pin nZ). The common channel select logics include two digital select inputs (pins So and S1) and an active LOW enable input (pin ). When pin =LOW, one of the four switches is selected (lowimpedance ON-state) with pins S0 and S1. When pin =HIGH, all switches are in the highimpedance OFF-state, independent of pins S0 and S1.
74HC4052
Pin Configuration
22
3.2.4.
74HC4053
74HC4053 are triple 2-channel analog multiplexers/demultiplexers with a common enable input (). Each multiplexer /demultiplexer has two independent inputs/outputs (nYo and nY1), a common input/output (nZ) and three digital select inputs (S1 to S3). With LOW, one of the two switches is selected (low impedance ON-state) by S1 to S3. With HIGH, all switches are in the high impedance OFF-state, independent of S1 to S3.
Pin Configuration
Logic Symbols
3.2.5.
TDA2822M
Dual Low Voltage Power Amplifier TDA 2822M is a monolithic integrated circuit in 8 lead Minidip package. t is intended for use as dual audio power amplifier.
3.2.6.
The LM1117 is a series of low dropout voltage regulators with a dropout of 1.2V at 800mA of load current. The LM1117 is available in an adjustable version, which can set the output voltage from 1.25V to 13.8V with only two external resistors. In addition, it is also available in five fixed voltages, 1.8V, 2.5V, 2.85V, 3.3V, and 5V. The output voltage is adjusted according to the formula shown in Figure
LM1117
3.2.7.
KA78LXXA series of fixed voltage monolithic integrated circuit voltage regulators are suitable for application that required supply current up to 100mA.
KA78L08
24
3.2.8.
IRF7314
3.2.9
NTGS 3446
25
3.2 10
FDC642P
P-Channel Mosfet *Ultra Low RDS(ON) * Fast Switching Speed * Low Gate Charge
3.3.
26
SC1_L_IN SC1_B
3.3.3.
3.3.4.
28
Impedanc e 75ohms
3.3.5.
3.3.6.
3.3.7.
3.3.8.
3.3.9.
29
3.3.10.
3.3.11.
3.3.12.
3.3.13.
3.3.14.
31
Description
IF INPUT CON
I2C,UART,4 GPIO, IF AGC
ANALOG AV CON
SAW Filter
VIDEO AMP
AUDIO DAC
COFDM DEMOD
VCXO
EMMA2LL
CPU + MPEG DECODER
S/PDIF CON
16 MB DDRAM 2 MB FLASH
NEC
DIGITAL AV CON BUFFERS & GATES
PCMCIA CON
1.4 IF Connector:
Pin 1 2 3 Description IF + IF GND
RAM_VD
RAM_VDD
DADD8
DADD9
DADD11
RAM_VDD
DDR_RE
DCASB
DRASB
DADD0
DADD1
DADD2
DADD3
DADD4
DADD5
DADD6
DADD7
DWEB
3.3V_D
DCSB
DQ10
LDQS
DQ0
DQ1
DQ2
DQ3
DQ4
DQ5
DQ6
DQ7
DQ8
NOTLCLK
DQ9
DQ11
3.3V_D RDATA0
LCLK
C108 1.5V_D
C130
R137 100R
RAM_VDD
RAM_VDD
RAM_VDD
DADD10
3.3V_D
DQM1
DQM0
UDQS
DBA0
DBA1
R113 100R
R119 100R
R125 100R
R131 100R
R136 100R
R146 100R
R124 100R
S101
100n 10V
DCKE
100n 10V
2 3
R1
R2
R3
R4
RDATA1 TXD Q102 BC848B 22K R198 RDATA2 22K R199 R192 1K RDATA3 TP121 22K R200
1.5V_D
2 3
2 3
2 3
2 3
2 3
2 3
R126 100R
R129 100R
R130 100R
R132 100R
R139 100R
R140 100R
R142 330R
R144 330R
C116
C121
C128
C105
C106
C107
100n 10V
S102
R147 100R
16V 100n
10V 100n
10V 100n
10V 100n
10V 100n
R1
R2
R3
R4
R1
R2
R3
R4
R1
R2
R3
R4
R1
R2
R3
R4
R1
R1
R2
R3
R4
R2
R3
R4
216
215
214
213
212
211
210
209
208
207
206
205
204
203
202
201
200
DWEB 199
198
197
196
195
194
193
192
191
190
189
188
187
186
185
184
183
182
181
180
179
178
177
176
175
174
173
172
171
170
169
168
167
DQ8 166
165
164
163
1 2
RDATA4 22K R201 RDATA5 22K R219 RDATA6 22K R203 RDATA7 22K R221 RDATA8
DQM0
DADD0
DADD1
DADD2
DADD3
DADD4
DADD5
DADD6
DADD7
DADD8
DADD9
DCASB
DRASB
DQM1
DCLK
DCKE
DQ0
DQ1
DQ2
DQ3
DQ4
DQ5
DQ6
DQ7
DCSB
DBA0
DBA1
DADD10
DADD11
DADD12
VDD3-4
GND-22
GND-21
VDD2-6
VDD1-5
GND-20
VDD2-5
VDD2-4
GND-19
VDD2-3
GND-18
GND-17
VDD1-4
GND-16
VDD2-2
DQS1
DQ9
N/C
GND-15
GND-14
N/C-2
N/C-1
Q103 BC848B
3
TP122
PL102
1
TS_CLK TS_VAL TS_MERR TS_STRT 5 6 7 8 R4 R3 R2 R1 100R R110 4 3 2 1
GND-13 162
C137
3.3V_D
2 3 4 5
GND-12 161 VDD2-1 160 DQ10 159 DQ11 158 DQ12 157
RAM_VDD
PROGRAMMING CONNECTOR
R153 100R 1 8 DQ12 DQ13 DQ14 DQ15 2 3 4
RDATA10 22K R206 RDATA11 22K R207 RDATA12 22K R208 RDATA13 22K R209 RDATA14
5 6 7 8
R4 R3 R2 R1 100R R111
4 3 2 1
6 7 8 9
5 6 7 8
R4 R3 R2 R1 33R R109
6 5
JTMS 149 JTD0 148 JTDI 147 TXD1B 146 RXD1B 145 NMI 144 RSTSWB 143 RSTOUT 142 PWMOUT 141
100n
X1
X2
8
C155 2.2p 10V
3.3V_D
1.5V_D
JTCK 150
TP125
R212
19 RDATA3
R102 33R RDATA5 RDATA6 RDATA7 2 3 4 R1 RDATA4 1 R2 8 7 6 5
C157
100p
C159
GND
CLKOUT
27MHZ
R194 33R
10K
R161 10K
AAT3524
10n
UPD6111
16V
23 RDATA7
R103 33R RDATA9 RDATA10 RDATA11 2 3 4 R1 RDATA8 1 R2 8 7 6 5 C104 100n 16V
VDD3-3 140
VCXO CIRCUIT
S106
IC101
24 RDATA8
GND-10 139 GND-9 138 CLK27IN 137 PAVDD 136 PAGND 135 VDD1-3 134 PPORT44 133 PPORT43 132 PPORT42 131 PPORT41 130 PPORT40 129 PPORT39 128 PPORT38 127 PPORT37 126 PPORT36 125 PPORT35 124 PPORT34 123 PPORT33 122 PPORT32 121 PPORT31 120 PPORT30 119 SCL0 118 SDA0 117 PPORT29 116 PPORT28 115 PPORT27 114 PPORT26 113 PPORT25 112 PPORT24 111
C136 4.7K R171 100R R172 4.7K R179 4.2K R173 33R R174 33R R175 100R R180 100R 1n C144 C146 R181 1n SW_CNTRL GPIO_3 3.3V_D CI_POWER_CNTRL JTMS REG JTRST INPACKB 5V L113 FERRITE C151 1u Option For Optical Output S107 Q101 BC848B R191 150R R193 300R SPDIF_CONNECTOR JK101 TP130 JTDI TP129 R225 1K 1 2 3 4 1 R176 100R R177 100R 8 DVB_TX DVB_RX DVO_7 DVO_6 DVO_5 DVO_4 3.3V_D DVO_7 DVO_6 DVO_5 DVO_4 4.7K R186 4.7K R187 DVO_3 SCLK SDATA DVO_2 DVO_1 DVO_0 VCK L121 FERRITE L122 FERRITE L123 FERRITE L124 FERRITE L125 FERRITE L126 FERRITE L127 FERRITE L128 FERRITE L129 FERRITE TP112 L120 FERRITE TP111 R166 100R R167 100R R168 100R C139 C140 C143 VHS VVS VCK VVS VHS L118 FERRITE L119 FERRITE TP109 L117 FERRITE TP108 R165 100R 27MHZ C134 10V 100n L106 FERRITE L107 C142 100n 16V 1.5V_D ALRCK 1.5V_D IRQ ABCK ADO L114 FERRITE L115 FERRITE L116 FERRITE TP105
3.3V_D
PL101
FERRITE
1
TP106
2
TP107
3 4 5 6 7
TP110
3.3V_D
10K R226
IRQ
8 9 10 11 12
TP113 Q105 BC848B
DIGITAL AV CONNECTOR
4 6 8 10
3
TP131
16V 100n
100n 16V
3.3V_D
C102
53 VDD3-1 97 PPORT12 98 PPORT13 99 PPORT14 107 PPORT22 100 PPORT15 101 PPORT16 102 PPORT17 103 PPORT18 104 PPORT19 105 PPORT20 106 PPORT21 108 PPORT23 54 GND-5 69 VDD1-2 80 AGND-1 81 AVDD-1 87 AGND-2 88 AVDD-2 90 AGND-3 91 AVDD-3 94 DGND-1 95 DGND-2 96 DVDD-1 55 RADD16 56 RADD17 57 RADD18 58 RADD19 59 RADD20 60 RADD21 61 RADD22 79VACVBS 64 FCSB0 92 RSET1 67 GND-6 68 GND-7 65 GCSB0 73ALRCK 74GRDYB 83 REF0 93 REF1 75 TEST 82 RSET 62 FOEB 86 VAPR 89 VAPB 63 FWEB 70 ABCK 77AGND 78AVDD 84DGND 85DVDD 66 AMCK
3.3V_D
71 ATX
72 ADO
76 VAY
C152
470p 10V
SPDIF
12R R188
TP124 C153
910R R133
R114 33R
R115 33R
33R R116
33R R117
33R R118
33R R120
33R R127
10K R128
ENC_GREEN_S/Y
ENC_BLUE_S/C
910R R138
C129 R151 33R R141 R149 100R R143 10K 100R 100R R150 33R R152 33R 33R R145 R148
C154 470p
C117
C120
C122
C125
S103
100n 16V
1 3
FERRITE
1 2
PL103
L130
ENC_CVBS
ENC_RED
1.5V_D
100n 16V
100n 16V
100n 16V
100n 16V
R112 33R
R_CHIP_EN
R_OUTPUT_EN
R_WRITE_EN
GCSB0
10V 100p
S/PDIF
RADD20
RADD21
IREQ
1n 1n
C109 AMCK
100p
L101
10u
C127
RADD16
RADD17
RADD18
RADD19
L103
10u
C115
16V TP101 C118 R135 220R 150R R134 L102 10u 16V C123 C124 100n 10V 10u
16V
100n 10V
C119 10u
CARD_RESET
GPIO_1
GPIO_2
IOWR
IORD
C114
CARD_DETECT
GRDYB
3.3V_D
2 3
2 3
C126 1u
10p C110
SPDIF
R123 100R
3.3V
FERRITE
FERRITE
MPEG DECODER
3.3V_D
R4
R3
43 GND-4
R4
R3
R2
2 3
7 6 5 R169 100R
13
TP114 RSTOUT
14
TP115
Q104 BC848B
7 6 5
15
TP116
16
TP117
RESET CIRCUITS
17
TP118
18
TP119
19
TP120
20 PL104
TP126 JTCLK
C162
3.3V_D F_WE
5 7 9
JTAG
1u
R2
R1
R1
R4
RDATA3
18 RDATA2
RXD
1u 16V
R3
RDATA2
R2
RDATA1
2 3
R1
RDATA0
8 7 6
17 RDATA1
TXD PWMOUT
PI6CX100-27WE
3 VIN VDD 6
C156
L131
16 RDATA0
JTDI
3.3V_D
NC_1
NC_2
FERRITE
R158 33R
R1 R2 R3 R4
7 6 5
3.3V_D
27MHz
IC102
R1 R2 R3 R4
C163
R227 4.7K
5V
R3 R4 R3 R4 R3 R4 R3 R4 R3 R4 R3 R4 R3 R4
R1
R1
R2
R3
R4
R2
R3
R4
IC202
C213 C201 16V 47u C223 1u 16V 3.3V_D 100n 10V L201 FERRITE RAM_VDD
IC203
VSS3 54 1 2 3
DQ1
VDD1
VSS3 66 DQ15 65 VSSQ5 64 DQ14 63 DQ13 62 VDDQ5 61 DQ12 60 DQ11 59 VSSQ4 58 DQ10 57
DQ10 DQ9 C220 10V 100n DQ8 UDQS R255 15K DQ12 DQ11 DQ14 DQ13 C219 10V 100n DQ15
DQ0 DQ0
DQ0
DQ15 53
DQ15
4 5 6
VDDQ1
VSSQ4 52
DQ2
IC201
RADD16
A15
A16 48
RADD17
DQ1
DQ1
DQ14 51
DQ14
DQ3 DQ4
7 8 9
C202 RADD15
100n 16V
100n 10V
A14
BYTE 47
DQ2
DQ2
DQ13 50
C214 DQ13
DQ5
RADD14
A13
VSS2 46
VSSQ1
VDDQ4 49
DDRRAM_8MX16_333MHZ_LSI_REC
DQ6
DQ9 56 VDDQ4 55 DQ8 54 NC7 53 VSSQ3 52 UDQS 51 NC6 50 VREF 49 VSS2 48 UDM 47 CK1 46 CK 45 CKE 44 NC5 43 NC4 42 A11 41 A9 40 A8 39 A7 38 A6 37 A5 36 A4 35 VSS1 34
RADD13
A12
DQ15_A_1 45
RDATA15
DQ3
DQ3
DQ12 48
DQ12
DQ7
13 DQ7 14 NC1
A11
DQ7 44
RDATA7
DQ4
DQ4
DQ11 47
DQ11
15 VDDQ3
LDQS
16 LDQS 17 NC2
C222 C221
18 VDD2 19 NC
DQM0
RADD10
A9
DQ6 42
RDATA6
DQ5
10 DQ5
DQ10 45
DQ10
RADD9
A8
DQ13 41
RDATA13
DQ6
11 DQ6
DQ9 44
DQ9
DWEB DCASB
RADD20
A19
DQ5 40
RDATA5
12 VSSQ2
VDDQ3 43
DRASB DCSB
RADD21
10 NC1
DQ12 39
RDATA12
DQ7
13 DQ7
DQ8 42
DQ8 DBA0
FLASH_WE
11 W
DQ4 38
RDATA4
14 VDD2
VSS2 41
MT48LC4M16A2
C203 100n 16V RESET
12 RP
VCC 37
DQM0
15 DQML
NC2 40
M29W160B
S201
13 NC2
DQ11 36
RDATA11
DWEB
16 WE
DQMH 39
DQM1
14 NC3
DQ3 35
RDATA3
DCASB
17 CAS
CLK 38
LCLK
S203 RADD20
15 RB
DQ10 34
RDATA10
DRASB
18 RAS
CKE 37
DCKE
16 A18
DQ2 33
RDATA2
DCSB
19 CS
NC1 36
IC204
RADD18
17 A17
DQ9 32
RDATA9
DBA0
20 BA0
A11 35
DADD11
74V1G08
GND
RADD8
18 A7
DQ1 31
RDATA1
DBA1
21 BA1
A9 34
DADD9
1 A
1 Y
1 B
RADD7
19 A6
DQ8 30
RDATA8
DADD10
22 A10
A8 33
DADD8
RADD6
R_WRITE_EN
20 A5
DQ0 29
RDATA0
DADD0
23 A0
A7 32
RADD5
21 A4
G 28
R_OUTPUT_EN
DADD1
24 A1
A6 31
DADD6
RADD4
22 A3
VSS1 27
DADD2
25 A2
A5 30
DADD5
RADD3
23 A2
E 26
R_CHIP_EN
DADD3
26 A3
A4 29
DADD4
RADD2
24 A1
A0 25
RADD1
27 VDD3
VSS1 28
FLASH ROM
3.3V_D
VCC
R256 15K
DDR_REF
RADD11
A10
DQ14 43
RDATA14
VDDQ2
VSSQ3 46
MT46V16M16 IS OPT
C320 1n
PL301
TP327
R344 opt.
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
PL302
C321 1n 2 C342
3 GND IN2 OUT2 5 C326 X6966M 1 IN1 OUT1 4 L319 opt. opt.
C328 2.2n
TP307
TP317
R345 opt.
opt.
1
TP318 TP319
TP301
TP302
TP303
TP304
TP305
TP306
TP308
TP309
TP310
TP311
TP312
TP315
TP316
2 3
TP328
R346 opt.
3.3VA_DEMOD
FERRITE
FERRITE
FERRITE
FERRITE
FERRITE L307
FERRITE L308
FERRITE L309
FERRITE
FERRITE L313
FERRITE L314
FERRITE
FERRITE L316
FERRITE
DVB_GREEN_S/Y
DVB_CVBS
R334 4.7K
SMD_402 SDATA_TUNER AUDIO_R_OUT AUDIO_L_OUT DVB_TX DVB_RX RF_AGC SCLK_TUNER GPIO_1 GPIO_2 GPIO_3 C330 1.8VA_DEMOD C324 C327 100n 10V 100n R330 100R R331 100R C332 IRQ
1.8V_DEMOD
C323 1n
Z301
L306
L301
L302
L303
L304
L312
L315
TP325
C322 1n
C329 2.2n
DVB_BLUE_S/C
DVB_RED
100n
100n
ANALOG AV CONNECTOR
49 NC8
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34 SCL2
RES
PDN
PDP
INN
INP
SUBA
VSSAL
VSSAH
VDDAL
VDDAH
VSSL-2
VSSAL-1
VDDAL-1
VDDL-2
SDA2
33
IC302
100n 16V ENC_BLUE_S/C
50 NC9 OUT1 14
R311 75R C316 DVB_BLUE_S/C 1.8V_DEMOD
52 VSSL-3
ENC_RED
IN2
OUT2 13
R312 75R
DVB_RED
53 ASEL
TP324 TP326
54 UIO 55 VSSH-2
4MHz X301
FMS6145
100n 16V 5V C301
56 X0 57 XI 58 VDDH-2
10K R340
C339
VSSH-1 23
ENC_GREEN_S/Y
IN4
OUT4 10
R314 75R
DVB_GREEN_S/Y
TP320 TP321
16V
PMQFP64
R335 33R R336 33R C337 10K R341 10K R343 100n
10K R342
100n 16V
VCC
GND 11
IC303 DRXD3973D
MD_0 25
3.3V_DEMOD
VDDH-1 24
200R R301
200R R302
200R R303
200R R304
IN5
OUT5
TP322 TP323
NC1
NC2
5V_A
63 AGC1 64 AGC2
R327 1.5K
VDDL
RSTN
VSSH
VSSL
IRQN
RF_AGC C311
C313
5.6K R329
22n 16V
22n 16V
18K R324
10K R326
N C
VIDEO AMPLIFIER
R328 100R
10
11
12
13
14
15
16
SDA1
SCL1
NC1
NC2
NC3
NC4
NC5
NC6
NC7
SDATA RESET C331 L310 5V 100n 16V 16V 100n 5V_A C325 R315 10K L321 1.8V_DEMOD L317 FERRITE AUDIO_L_OUT R316 10K R319 220R 1.8V 100n 50V L318 FERRITE 50V 1n 50V 10p C312 1.8V_DEMOD FERRITE L320 3.3V 10u 100u 16V 100n 50V L322 FERRITE 1.8VA_DEMOD 10V 10p 1n C317 50V C319 C336 C340 3.3VA_DEMOD C333 C334 3.3V_DEMOD 3.3V_DEMOD SCLK
C303
C309
270K R305
1u 16V
IC301
ADO
SDATA
AOUTL
C305 ABCK
DEM/SCLK
VA
CS4334
ALRCK
TP314
LRCK
AGND
COFDM DEMODULATO
R317 10K Q302 BC848B AUDIO_R_OUT R318 10K R320 220R
C304 AMCK
MCLK
AOUTR
5
270K R306 10K R308 1u 16V
C310
AUDIO DAC
5.6n 16V
1u 16V
22p 50V
R4
ENC_CVBS
IN3
OUT3 12
DVB_CVBS
C314 33p
R3
R313 75R
IN1
51 VDDL-3
R3
MERR MSTRT
IC401
48 OE1 T/R1 1
SW_CNTRL_INV
IC402
48 OE1 T/R1 1
SW_CNTRL
IC403
48 OE1 T/R1 1
CI_POWER_CNTRL
IC404
48 OE1 T/R1 1 1
GCSB0
IC405
C422 100n 16V CI_DIR C423 100n 50V CI_PWR
1A
VCC 14
3.3V_BUF
MD0
47 A0
B0
MDI_0
MD0
47 A0
B0
TS0
MDO_0
47 A0
B0
TS0
RADD0
47 A0
B0
A0
1B
4B 13
MD1
46 A1
B1
MDI_1
MD1
46 A1
B1
TS1
MDO_1
46 A1
B1
TS1
RADD1
46 A1
B1
A1
1Y
4A 12
45 GND8
GND1
45 GND8
GND1
45 GND8
GND1
45 GND8
GND1
4
IORD
74LVC00A
4 2A 4Y 11
MD2
44 A2
B2
MDI_2
MD2
44 A2
B2
TS2
MDO_2
44 A2
B2
TS2
RADD2
44 A2
B2
A2 R_OUTPUT_EN
2B
3B 10
MD3
43 A3
B3
MDI_3
MD3
43 A3
B3
TS3
MDO_3
43 A3
B3
TS3
RADD3
43 A3
B3
A3
2Y
3A
C404
C409
C413
C415
100n 16V
100n 16V
100n 16V
16V 100n
3.3V_BUF
42 VCC4
VCC1
3.3V_BUF
3.3V_BUF
42 VCC4
VCC1
3.3V_BUF
3.3V_BUF
42 VCC4
VCC1
3.3V_BUF
3.3V_BUF
42 VCC4
VCC1
3.3V_BUF
GND
3Y
MD4
41 A4
B4
MDI_4
MD4
41 A4
B4
TS4
MDO_4
41 A4
B4
TS4
RADD4
41 A4
B4
A4
MD5
40 A5
B5
MDI_5
MD5
40 A5
B5
TS5
MDO_5
40 A5
B5
TS5
RADD5
40 A5
B5
A5
16V 100n
IC406
20 VCC 19 OE T_R A0 A1 A2 A3 1 2 3 4 5 6 7 8 9
CI_DIR RDATA8 RDATA9 RDATA10 RDATA11 RDATA12 RDATA13 RDATA14 RDATA15
C419 3.3V_BUF
39 GND7
GND2 10
39 GND7
GND2 10
39 GND7
GND2 10
39 GND7
GND2 10
D0 MD6
18 B0 17 B1 16 B2 15 B3 14 B4 13 B5 12 B6 11 B7
38 A6
B6 11
MDI_6
MD6
38 A6
B6 11
TS6
MDO_6
38 A6
B6 11
TS6
RADD6
38 A6
B6 11
A6 D1
74LVC16244
74LVC16244
74LVC16244
D2
MD7
37 A7
B7 12
MDI_7
MD7
37 A7
B7 12
TS7
MDO_7
37 A7
B7 12
TS7
RADD7
37 A7
B7 12
A7 D3 D4
74LVC16244
74LVX245
74LVT245 OLACAK
A4 A5 A6 A7
MCLK
36 A8
B8 13
MDI_CLK
MCLK
36 A8
B8 13
TS_CLK
MDO_CLK
36 A8
B8 13
TS_CLK
RADD8
36 A8
B8 13
A8 D5 D6
MVAL
35 A9
B9 14
MDI_VAL
MVAL
35 A9
B9 14
TS_VAL
MDO_VAL
35 A9
B9 14
TS_VAL
RADD9
35 A9
B9 14
A9 D7
GND 10
34 GND6
GND3 15
34 GND6
GND3 15
34 GND6
GND3 15
34 GND6
GND3 15
S401 S402 L402 BSH103 C421 100u 16V
33 A10
B10 16
MERR
33 A10
B10 16
TS_MERR
33 A10
B10 16
TS_MERR
RADD10
33 A10
B10 16
A10
5V
MSTRT
32 A11
B11 17
MDI_STRT
MSTRT
32 A11
B11 17
TS_STRT
MDO_STRT
32 A11
B11 17
TS_STRT
RADD11
32 A11
B11 17
R411 47k
C407
C412
C418
16V 100n
16V 100n
C402
16V 100n
30 A12
B12 19
R_WRITE_EN
30 A12
B12 19
WE_CI
IORD
30 A12
B12 19
IORD_CI
RADD12
30 A12
B12 19
100n 16V
3.3V_BUF
31 VCC3
VCC2 18
3.3V_BUF
3.3V_BUF
31 VCC3
VCC2 18
3.3V_BUF
3.3V_BUF
31 VCC3
VCC2 18
3.3V_BUF
3.3V_BUF
31 VCC3
VCC2 18
3.3V_BUF
CI_POWER_CNTRL
Q403 BC848B
A12
L401
29 A13
B13 20
GCSB0
29 A13
B13 20
CE_1_CI
IOWR
29 A13
B13 20
IOWR_CI
RADD13
29 A13
B13 20
A13
3.3V_D
3.3V_BUF
28 GND5
GND4 21
28 GND5
GND4 21
28 GND5
GND4 21
28 GND5
GND4 21
27 A14
B14 22
IREQ_CI
27 A14
B14 22
IREQ
CARD_RESET
27 A14
B14 22
RESET_CI
RADD14
27 A14
B14 22
INPACKB_CI
26 A15
B15 23
INPACKB
WAIT_CI
26 A15
B15 23
GRDYB
REG
26 A15
B15 23
REG_CI
R_OUTPUT_EN
26 A15
B15 23
OE_CI CARD_DETECT
25 OE2
T/R2 24
CI_POWER_CNTRL
25 OE2
T/R2 24
CI_POWER_CNTRL
25 OE2
T/R2 24
25 OE2
T/R2 24
CI_POWER_CNTRL CD_1_CI
R409 4.7K
CD_2_CI
Q404 BC848B
MDO_CLK
VS_CI
Q406 BC848B
MDO_STRT
CD_2_CI MDO_1
WAIT_CI
MDI_VAL
IOWR_CI
R401 10K
R402 10K
R404 10K
R407 10K
REG_CI
MDI_6
MDI_4
A13
CE_1_CI
MDI_2
MDI_0
MDO_7
MDO_5
MDO_3
10p C403
VS_CI
WE_CI
A9
OE_CI
A12
D1
A0
A2
A4
A6
D6
D4
67
65
63
61
59
57
55
53
51
49
47
45
43
41
39
37
35
33
31
29
27
25
23
21
19
17
15
13
11
PL401
R415 10K
4
D5
68
66
64
62
60
58
56
54
52
50
48
46
44
42
40
38
36
34
32
30
28
26
24
22
20
18
16
14
12
MDO_VAL
RESET_CI
MDO_6
INPACKB_CI
MDI_STRT
MDO_4
CD_1_CI
D2
D0
A1
A3
A5
A7
IREQ_CI
MDI_7
MDI_5
IORD_CI
MDO_2
MDO_0
MDI_3
MDI_1
A14
A8
A11
10
A10
D7
10K R403
10K R405
10K R406
CI_PWR 5V
MDI_CLK
10K R408
C408 15p
PCMCIA INTERFACE
D3
TP507
C507
C509
C506 100n
R502 2.2K
R504 opt.
10p
R503 6.8K
R505 opt.
COMP
C521 16V
MP1593-DC/DC
EN
FB
SS
47u
IC501
TP506
12/24V
4 GND
3 SW
1 B S
I N
PL501
1 2 3 4
TP505
FERRITE
POWER SUPPLY
63. B/ 5 63 . B/ 5
+ 3B/ 5B2 87
+ 3B/ 5 B2 8 7 3&B/ 5 B,1 ' 9% 6: 6$ 9B/ 5 B,1 3& ) $ 9B6: &2 1 75 2 / 32 5 7 6 $9B&9%6 %$ 9B/ 5 B,1 3&B/ 5 B,1 % 9B&9% $ 6 0 $ ,1 < & 6,' ( < & &9% 6 <* %& 5 ,54 8 $ 57 ' 9%B6: / ,1 ( B/ 5 B2 8 7 6&B/ 5 B,1 6&B9B,1 6&B9B2 8 7 6&B 5 B2 8 7 / 5* % )% $ 9B67$78 6 3& ) $ 9B6:
SCART
TUNER
Hitachi, Ltd. Tokyo, Japan International Sales Division THE HITACHI ATAGO BUILDING, No. 15 12 Nishi Shinbashi, 2 Chome, Minato Ku, Tokyo 105-8430, Japan. Tel: 03 35022111 HITACHI EUROPE LTD, Whitebrook Park Lower Cookham Road Maidenhead Berkshire SL6 8YA UNITED KINGDOM Tel: 01628 643000 Fax: 01628 643400 Email: consumer -service@hitachi-eu.com HITACHI EUROPE S.A. 364 Kifissias Ave. & 1, Delfon Str. 152 33 Chalandri Athens GREECE Tel: 1-6837200 Fax: 1-6835964 Email: service.hellas@hitachi-eu.com
HITACHI EUROPE GmbH Munich Office Dornacher Strasse 3 D-85622 Feldkirchen bei Mnchen GERMANY Tel: +49-89-991 80-0 Fax: +49- 89-991 80-224 Hotline: +49-180-551 25 51 (12ct/min) Email: HSE- DUS.service@hitachi-eu.com
HITACHI EUROPE S.A. Gran Via Carlos III, 86, planta 5 Edificios Trade - Torre Este 08028 Barcelona SPAIN Tel: +34 93 409 2550 Fax: +34 93 491 3513 Email: atencion.cliente@hitachi-eu.com
HITACHI EUROPE srl Via Tommaso Gulli N.39, 20147 Milano, Italia ITALY Tel: +39 02 487861 Tel: +39 02 38073415 Servizio Clienti Fax: +39 02 48786381/2 Email: customerservice.italy@hitachi-eu.com
HITACHI Europe AB Box 77 S-164 94 Kista SWEDEN Tel: +46 (0) 8 562 711 00 Fax: +46 (0) 8 562 711 13 Email: csgswe@hitachi-eu.com
HITACHI EUROPE S.A.S Lyon Office B.P. 45, 69671 BRON CEDEX FRANCE Tel: +33 04 72 14 29 70 Fax: +33 04 72 14 29 99 Email: france.consommateur@hitachi-eu.com
HITACHI EUROPE LTD (Norway) AB STRANDVEIEN 18 1366 Lysaker NORWAY Tel: 67 5190 30 Fax: 67 5190 32 Email: csgnor@hitachi-eu.com
HITACH EUROPE AB Egebkgrd Egebkvej 98 DK-2850 Nrum DENMARK Tel: +45 43 43 6050 Fax: +45 43 60 51 Email: csgnor@hitachi-eu.com
HITACHI EUROPE AB Neopoli / Niemenkatu 73 FIN-15140 Lahti FINLAND Tel : +358 3 8858 271 Fax: +358 3 8858 272 Email: csgnor@hitachi-eu.com
Hitachi Europe Ltd Bergensesteenweg 421 1600 Sint- Pieters-Leeuw BELGIUM Tel: +32 2 363 99 01 Fax: +32 2 363 99 00 Email: sofie.van.bom@hitachi-eu.com
HITACHI EUROPE LTD Na Sychrove 975/8 101 27 Pr aha 10 Bohdalec CZECH REPUBLIC Tel: +420 267 212 383 Fax: +420 267 212 385 Email: csgnor@hitachi-eu.com
www.hitachidigitalmedia.com