Sei sulla pagina 1di 45

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws.

f you acquired this


document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 1 of 45




Jeep Securty, Remote Start, Keyess Entry & Navgaton
Wre Coors Verson 4.2









PLEASE NOTE

The information contained is accurate to the best of our knowledge. 12 Volt Resource LLC
makes no representation or warranty with respect to the information contained in this
document including its accuracy or completeness. 12 Volt Resource LLC disclaims all
liability or responsibility for errors or omissions therein or any decision made by the
recipient in reliance thereon.

nstallations should be attempted by experienced installers only. Proper installation
remains the responsibility of the installer. t is the installer's responsibility to test and verify
all circuitry with the proper test equipment prior to installation.


Additional nformation:

This information is sorted alphabetically by vehicle model. f there are multiple
years for a particular vehicle model, then the oldest year comes first.

The installation notes referenced below and the full installation guide are located
in the nstall nstructions & Notes folder on this CD-ROM.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 2 of 45

Make: Model: Year:
Jeep Cherokee 1983


FUNCTON COLOR LOCATON
Start: LGHT BLUE GNTON SWTCH HARNESS
gnition #1: RED/TAN GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: YELLOW GNTON SWTCH HARNESS
Brake Light: L GREEN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: D GREEN GNTON COL *
Parking Lights: WHTE (+) AT LGHT SWTCH
Headlights: TAN (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Carburated Engine!!

Jeep Cherokee 1983

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK (-) AT PN SWTCH OR COURTESY LGHT
OEM Horn: GRAY/RED OR BLACK (-) STEERNG COLUMN HARNESS
Power Lock: ADD ACTUATORS N ALL DOORS **
Power Unlock: ADD ACTUATORS N ALL DOORS **
Trunk Release: N/A
Alarm nput Wire: BLACK (-) AT PN SWTCH OR COURTESY LGHT

NOTES: ** See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 3 of 45

Make: Model: Year:
Jeep Cherokee 1984-1987


FUNCTON COLOR LOCATON
Start: DARK GREEN GNTON SWTCH HARNESS
gnition #1: YELLOW GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: LGHT BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN/TAN AT GNTON MODULE *
Parking Lights: DARK BLUE (+) AT LGHT SWTCH
Headlights: TAN (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * 1987 4.0L Engine s Electronic Fuel njection, Rest Are Carburated Or Throttle Body
njection.

Jeep Cherokee 1984-1987

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK (-) AT PN SWTCH OR COURTESY LGHT
OEM Horn: GRAY/RED OR BLACK (-) STEERNG COLUMN HARNESS
Power Lock: WHTE LOCATED N DRVER'S KCK PANEL **
Power Unlock: DARK GREEN LOCATED N DRVER'S KCK PANEL **
Trunk Release: N/A
Alarm nput Wire: BLACK (-) AT PN SWTCH OR COURTESY LGHT

NOTES: ** Without OEM Keyless Entry See Note #203 - Reverse Polarity Door Lock Diagram.
With OEM Keyless Entry: Lock - L GREEN, Unlock - TAN, Find Wires At Relays Below
Passenger Dash And See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 4 of 45

Make: Model: Year:
Jeep Cherokee 1988-1990


FUNCTON COLOR LOCATON
Start: DARK GREEN GNTON SWTCH HARNESS
gnition #1: YELLOW GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: LGHT BLUE/BLACK OR LGHT BLUE (+) AT SWTCH
Tach Signal: GREEN/TAN OR GREEN AT GNTON MODULE OR DASH TACH *
Parking Lights: DARK BLUE (+) AT LGHT SWTCH
Headlights: TAN/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * 4.0L Engine Only s Electronic Fuel njection. Rest Are Carburated Or Throttle Body
njection.

Jeep Cherokee 1988-1990

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK/TAN OR BLACK/WHTE (-) AT PN SWTCH
OEM Horn: GRAY/RED OR BLACK (-) STEERNG COLUMN HARNESS
Power Lock: WHTE LOCATED N DRVER'S KCK PANEL **
Power Unlock: DARK GREEN LOCATED N DRVER'S KCK PANEL **
Trunk Release: N/A
Alarm nput Wire: BLACK/TAN OR BLACK/WHTE (-) AT PN SWTCH

NOTES: ** Without OEM Keyless Entry See Note #203 - Reverse Polarity Door Lock Diagram.
With OEM Keyless Entry: Lock - L GREEN, Unlock - TAN, Find Wires At Relays Below
Passenger Dash And See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 5 of 45

Make: Model: Year:
Jeep Cherokee 1991-1992


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: DARK BLUE GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: VOLET GNTON SWTCH HARNESS (BLOWER)
Brake Light: WHTE/TAN (+) SWTCH ON BRAKE PEDAL BRACKET
Tach Signal: GRAY AT COL OR PN 19 AT PCM *
Parking Lights: DARK BLUE/RED (+) AT HEADLGHT SWTCH
Headlights: TAN/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Powertrain Control Module (PCM) Located On Driver nner Fender Panel, Behind
Duct. GRAY Tach Wire At Pin #19, Second Tach Wire GRAY/L BLUE At Pin #43.

Jeep Cherokee 1991-1992

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: PURPLE/YELLOW (-) DRVER KCK PANEL
Dome
Lights/Superv:
YELLOW (-) AT ANY PN SWTCH OR COURTESY LGHT
OEM Horn: BLACK/RED (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: ORANGE/VOLET DRVER KCK PANEL OR AT RELAYS
Power Unlock: PNK/VOLET N PASSENGER KCK PANEL **
Trunk Release: N/A
Alarm nput Wire: YELLOW (-) AT ANY PN SWTCH OR COURTESY LGHT

NOTES: ** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 6 of 45

Make: Model: Year:
Jeep Cherokee 1993-1995


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: DARK BLUE GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HANNESS
gnition #3: N/A
Accessory: VOLET GNTON SWTCH HARNESS
Brake Light: WHTE/TAN (+) SWTCH ON BRAKE PEDAL BRACKET
Tach Signal: BLACK/GRAY AT COL OR PCM *
Parking Lights: DARK BLUE/RED (+) AT HEADLGHT SWTCH
Headlights: TAN/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Powertrain Control Module (PCM) Located On Driver nner Fender Panel, Behind
Duct. GRAY Tach Wire At Pin #19, Second Tach Wire GRAY/L BLUE At Pin #43.

Jeep Cherokee 1993-1995

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GN SWTCH HARNESS (BOTH 1 CRCUT)
OEM Alarm Disarm: PURPLE/YELLOW (-) DRVER KCK PANEL
Dome
Lights/Superv:
YELLOW (-) AT ANY PN SWTCH OR COURTESY LGHT
OEM Horn: BLACK/RED (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: ORANGE/VOLET LOCATED N DRVER'S KCK PANEL **
Power Unlock: PNK/VOLET LOCATED N DRVER'S KCK PANEL **
Trunk Release: N/A
Alarm nput Wire: YELLOW (-) AT ANY PN SWTCH OR COURTESY LGHT

NOTES: ** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 7 of 45

Make: Model: Year:
Jeep Cherokee 1996


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: D BLUE GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: VOLET GNTON SWTCH HARNESS
Brake Light: WHTE/TAN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLACK/GRAY AT COL *
Parking Lights: D BLUE/RED (+) AT HEADLGHT SWTCH
Headlights: TAN/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * GRAY Wire At Powertrain Control Module (PCM) Or GRAY/L BLUE Wire At PCM Can
Also Be Used For Tach Signal. PCM Located On Driver Fender Shield On Driver Side Of Engine
Comaprtment.

Jeep Cherokee 1996

FUNCTON COLOR LOCATON
Constant +12 Volts: RED (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
YELLOW (-) AT ANY PN SWTCH
OEM Horn: BLACK/RED (-) STEERNG COLUMN HARNESS
Power Lock: ORANGE/VOLET LOCATED N DRVER'S KCK PANEL **
Power Unlock: PNK/VOLET LOCATED N DRVER'S KCK PANEL **
Trunk Release: PNK/BLACK (+) (LFTGATE UNLOCK)
Alarm nput Wire: YELLOW (-) AT ANY PN SWTCH

NOTES: ** See Note #202 - Positive Pulse Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 8 of 45

CHEROKEE/CHEROKEE SPORT 1997 -1998



KEY T-HARNESS MMOBLZER
N/A CHR-2 N/A

FUNCTON COLOR LOCATON
12 VOLT CONSTANT PNK/BLACK (+) and RED (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 DARK BLUE (+) GNTON SWTCH HARNESS
GNTON 2 BLACK/ORANGE (+) GNTON SWTCH HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BLACK/WHTE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + ) BLACK/YELLOW (+) @ HEADLGHT SWTCH
POWER LOCK
ORANGE/VOLET (TYPE B)
See NOTE *1
N DRVERS KCK PANEL
POWER UNLOCK
PNK/VOLET (TYPE B) See
NOTE *1
N DRVERS KCK PANEL
DOOR TRGGER YELLOW (-) N DRVERS KCK PANEL
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN BLACK/RED (-)
@ STEERNG COLUMN
HARNESS

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 9 of 45

TACH GRAY
@ PCM, BLACK Plug, See
NOTE *2
WAT TO START LGHT N/A
BRAKE WHTE/TAN (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM N/A
ANT-THEFT N/A

EXTRA NFORMATON
NOTE *1 When testing the LOCK and UNLOCK wires, make sure the doors are closed. NOTE *2 the
PCM (Powertrain Control Module) is located on the DRVERS SDE nner Fender well near the
Radiator Support.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 10 of 45

CHEROKEE/CHEROKEE SPORT 1999 -2001



KEY
T-
HARN
ESS
MMOBLZER
CHR
KEY-1
CHR-2
CHRYSLER'S SENTRY ANT-THEFT TRANSPONDER System (GRAY GNTON
KEY ONLY), Requires Bypass Module and Extra gnition Key

FUNCTON COLOR LOCATON
12 VOLT CONSTANT PNK/BLACK (+) and RED (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 DARK BLUE (+) GNTON SWTCH HARNESS
GNTON 2 BLACK/ORANGE (+) GNTON SWTCH HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BLACK/WHTE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + ) BLACK/YELLOW (+) @ HEADLGHT SWTCH
POWER LOCK
ORANGE/PURPLE (TYPE B)
See NOTE *1
N DRVERS KCK PANEL
POWER UNLOCK
PNK/PURPLE (TYPE B) See
NOTE *1
N DRVERS KCK PANEL
DOOR TRGGER YELLOW (-)
N DRVERS KCK PANEL, See
NOTE *3
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 11 of 45

HORN BLACK/RED (-)


@ STEERNG COLUMN
HARNESS
TACH GRAY
@ PCM, BLACK Plug, See
NOTE *2
WAT TO START LGHT N/A
BRAKE WHTE/TAN (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM N/A
ANT-THEFT
CHRYSLER'S SENTRY KEY
(GRAY KEY ONLY) A
TRANSPONDER SYSTEM
TRANSPONDER @ GNTON
SWTCH TUMBLER

EXTRA NFORMATON
NOTE *1 When testing the LOCK and UNLOCK wires, make sure the doors are closed. NOTE *2 the
PCM (Powertrain Control Module) is located on the DRVERS SDE nner Fender well near the
Radiator Support NOTE *3 this wire will be in a GRAY 2-PN plug.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 12 of 45

Make: Model: Year:
Jeep CJ5 & CJ7 1983-1986


FUNCTON COLOR LOCATON
Start: LGHT BLUE GNTON SWTCH HARNESS
gnition #1: RED/TAN GNTON SWTCH HARNESS
gnition #2: RED/TAN GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: YELLOW GNTON SWTCH HARNESS
Brake Light: PNK (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN/TAN AT GNTON COL *
Parking Lights: WHTE (+) AT LGHT SWTCH
Headlights: RED/TAN (+) ATHEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Manual Transmission & Carburated!!

Jeep CJ5 & CJ7 1983-1986

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
DARK BLUE (-) AT PN SWTCH OR COURTESY LGHT
OEM Horn: BLACK/TAN (-) STEERNG COLUMN HARNESS
Power Lock: ADD ACTUATORS N BOTH DOORS **
Power Unlock: ADD ACTUATORS N BOTH DOORS **
Trunk Release: N/A
Alarm nput Wire: DARK BLUE (-) AT PN SWTCH OR COURTESY LGHT

NOTES: * See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 13 of 45

Make: Model: Year:
Jeep Comanche 1986-1989


FUNCTON COLOR LOCATON
Start: DARK GREEN GNTON SWTCH HARNESS
gnition #1: YELLOW GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: LGHT BLUE/TAN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal:
ORANGE/TAN OR
GREEN
AT GNTON MODULE *
Parking Lights: DARK BLUE (+) AT LGHT SWTCH
Headlights: TAN/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * 1987-90 4.0L Only s Electronic Fule njection, Rest Are Carburated Or Throttle Body
njection.

Jeep Comanche 1986-1989

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK (-) AT PN SWTCH **
OEM Horn: BLACK OR ORANGE (-) STEERNG COLUMN HARNESS
Power Lock: WHTE LOCATED N DRVER'S KCK PANEL ***
Power Unlock: DARK GREEN LOCATED N DRVER'S KCK PANEL ***
Trunk Release: N/A
Alarm nput Wire: BLACK (-) AT PN SWTCH **

NOTES: ** Door Pin Colors: 1986-88 - BLACK/TAN (-), 1989 - BLACK (-) At Pin Switch. ***
Without OEM Keyless Entry See Note #203 - Reverse Polarity Door Lock Diagram. With OEM
Keyless Entry: Lock - L GREEN, Unlock - TAN, Find Wires At Relays Below Passenger Dash
And See Note #202 - Positive Pulse Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 14 of 45
Make: Model: Year:
Jeep Comanche 1990


FUNCTON COLOR LOCATON
Start: DARK GREEN GNTON SWTCH HARNESS
gnition #1: YELLOW GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: LGHT BLUE/BLACK (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN AT GNTON MODULE *
Parking Lights: DARK BLUE (+) AT LGHT SWTCH
Headlights: TAN/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Tach Wire Also Found At Diagnostic Connector D1. 4.0L Only s Electronic Fuel
njection, 2.5L s Throttle Body njection.

Jeep Comanche 1990

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK/WHTE (-) AT PN SWTCH
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: WHTE LOCATED N DRVER'S KCK PANEL **
Power Unlock: DARK GREEN LOCATED N DRVER'S KCK PANEL **
Trunk Release: N/A
Alarm nput Wire: BLACK/WHTE (-) AT PN SWTCH

NOTES: ** Without OEM Keyless Entry See Note #203 - Reverse Polarity Door Lock Diagram.
With OEM Keyless Entry: Lock - L GREEN, Unlock - TAN, Find Wires At Relays Below
Passenger Dash And See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 15 of 45

Make: Model: Year:
Jeep Comanche 1991-1992


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: DARK BLUE GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: VOLET GNTON SWTCH HARNESS
Brake Light: WHTE/TAN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GRAY AT COL OR PCM *
Parking Lights: DARK BLUE/RED (+) AT LGHT SWTCH
Headlights: TAN/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Powertrain Control Module (PCM) Located On Driver nner Fender Panel Behind Duct.
GRAY TAch Wire At Pin #19, Second Tach Wire GRAY/L BLUE Located At Pin #43.

Jeep Comanche 1991-1992

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
YELLOW (-) AT PN SWTCH
OEM Horn: BLACK/RED (-) STEERNG COLUMN HARNESS
Power Lock: L GREEN DRVER KCK PANEL OR RELAYS
Power Unlock: TAN N PASSENGER KCK PANEL **
Trunk Release: N/A
Alarm nput Wire: YELLOW (-) AT PN SWTCH

NOTES: ** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 16 of 45

COMMANDER 2006

KE
Y
T-
HARNE
SS
MMOBLZER
N/A N/A
CHRYSLERS SENTRY TRANSPONDER ANT-THEFT SYSTEM, and Extra gnition
Key

FUNCTON COLOR LOCATON
12 VOLT CONSTANT LGHT BLUE/RED (+) @ GNTON HARNESS
STARTER PNK/ORANGE (+) @ GNTON HARNESS
STARTER 2
PURPLE/BROWN (-) See
NOTE *1
@ GNTON HARNESS,
GNTON 1 PNK/LGHT GREEN (+) @ GNTON HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
See NOTE *1 @ GNTON HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + ) N/A
POWER LOCK
PURPLE/DARK GREEN (1-
Wire Door Locking System) See
NOTE *2
@ DRVERS DOOR MODULE
in DRVERS DOOR
POWER UNLOCK Same Wire S
DOOR TRGGER See NOTE *3
N EACH KCK PANEL or
CLUSTER Connector 3
DOMELGHT SUPERVSON YELLOW/ORANGE (-)
@ UNDER DASH LGHT or
CLUSTER Connector 2, Pin 12

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 17 of 45

TRUNK RELEASE
ORANGE/PURPLE (-) See
NOTE *4
N DRVERS KCK PANEL or
CLUSTER, Connector 3, Pin 8
SLDNG POWER DOOR N/A
HORN DARK GREEN/ORANGE (+)
@ HORN or MP, Connector 2,
Pin 35, See NOTE *5
TACH
ANY wire NOT RED/TAN or
DARK GREEN/LGHT GREEN
@ ANY GNTON COL or
FUEL-NJECTOR
WAT TO START LGHT N/A
BRAKE WHTE/TAN (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM
DSARMS with FACTORY
REMOTE ONLY!!

ANT-THEFT
CHRYSLERS SENTRY
TRANSPONDER ANT-THEFT
SYSTEM
@ GNTON TUMBLER

EXTRA NFORMATON
NOTE *1 THE STARTER #2 AND ACCESSORY WRE are the same, The STARTER #2 wire
requires a (-) Negative thru a 180 Ohm resistor, and an extra Relay , the ACCESSORY wire requires
a (-) Negative thru a 560 Ohm resistor and an extra relay to connect NOTE *2 This vehicle uses a 1-
Wire Door Locking System, the LOCK requires a (-) Negative thru a 330 Ohm resistor the UNLOCK
requires a (-) Negative thru a 100 Ohm resistor. Some units will also require extra relays Part 778 to
connect S. NOTE *3 The DRVERS DOOR is a PURPLE (-) at Pin 6, the PASSENGER DOOR is a
PURPLE/WHTE (-) Pin 7, the DRVERS REAR DOOR is a PURPLE/GRAY (-) Pin 4 and the
PASSENGER REAR DOOR is a PURPLE/YELLOW Pin 5 when connecting to an ALARM SYSTEM
use all 4 wires ans DODE SOLATE NOTE *4 TEST this wire while opening the REAR GLASS from
the SWTCH on the REAR HATCH NOTE *5 The PM (ntegrated Power Module) is located on the
DRVERS FENDER, behind the BATTERY

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 18 of 45

Make: Model: Year:
Jeep Grand Cherokee 1993-1995


FUNCTON COLOR LOCATON
Start: YELLOW/DARK BLUE GNTON SWTCH HARNESS
gnition #1: DARK BLUE/GRAY GNTON SWTCH HARNESS
gnition #2: ORANGE/BLACK GNTON SWTCH HARNESS (HEAT-A/C)
gnition #3: N/A
Accessory: BLACK/WHTE GNTON SWTCH HARNESS
(RADO/WPER)
Brake Light: WHTE/TAN (+) SWTCH ON BRAKE PEDAL BRACKET
Tach Signal:
GRAY/WHT OR
GRAY/BLACK
AT COL OR PCM *
Parking Lights: DARK BLUE/RED (+) HEADLGHT SWTCH OR AT FUSE BOX
Headlights: TAN/BLACK (+) HEADLGHT SWTCH OR BEAM SELECT
SW.
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Powertrain Control Module (PCM) Located n Passenger Rear Corner Of Engine
Compartment Near A/C Receiver/Dryer. Tach Wire At Pin #19, GRAY/L BLUE At Pin #43 Can
Also Be Used For Tach.

Jeep Grand Cherokee 1993-1995

FUNCTON COLOR LOCATON
Constant +12 Volts: RED/WHTE FUSED AT
40
AMP AND PNK/BLACK FUSED AT 60 AMP
OEM Alarm Disarm: VOLET/YELLOW (-) DRVER KCK PANEL
Dome
Lights/Superv:
YELLOW (-) DRVER KCK PANEL OR COURTESY
LGHT
OEM Horn: GRAY/ORANGE (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: ORANGE/VOLET DRVER'S KCK PANEL **
Power Unlock: PNK/VOLET DRVER'S KCK PANEL **
Trunk Release: ORANGE/BROWN (+) LFT GLASS RELEASE (AT SWTCH)
Alarm nput Wire: YELLOW (-) DRVER KCK PANEL OR COURTESY
LGHT
NOTES: ** See Note #202 - Positive Pulse Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 19 of 45
Make: Model: Year:
Jeep Grand Cherokee 1996


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: D BLUE/GRAY GNTON SWTCH HARNESS
gnition #2: BLACK/ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: RED/BLACK GNTON SWTCH HARNESS
Brake Light: WHTE/TAN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GRAY/WHTE AT GNTON COL
Parking Lights: BLUE/RED (+) AT HEADLGHT SWTCH
Headlights: TAN/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Jeep Grand Cherokee 1996

FUNCTON COLOR LOCATON
Constant +12 Volts: RED/WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: VOLET/YELLOW (-) DRVER KCK PANEL
Dome
Lights/Superv:
YELLOW (-) BLACK 10 PN CONNECTOR AT FUSE
BLOCK
OEM Horn: GRAY/ORANGE (-) STEERNG COLUMN HARNESS
Power Lock: D\ ORANGE/VOLET P\ BLACK/WHTE *
Power Unlock: R/ PNK/BLACK S/ PNK/BLACK *
Trunk Release: N/A
Alarm nput Wire: YELLOW (-) BLACK 10 PN CONNECTOR AT FUSE
BLOCK

NOTES: * See Note #230 - Jeep Grand Cherokee Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 20 of 45

Make: Model: Year:
Jeep Grand Cherokee 1997-1998


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS *
gnition #1: D BLUE/GRAY GNTON SWTCH HARNESS
gnition #2: BLACK/ORANGE GNTON SWTCH HARNESS (HEAT/AC)
gnition #3: N/A
Accessory: RED/BLACK GNTON SWTCH HARNESS
Brake Light: WHTE/TAN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GRAY/WHTE AT GNTON COL OR PCM *
Parking Lights: D BLUE/RED (+) AT HEADLGHT SWTCH ***
Headlights: TAN/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Powertrain Control Module (PCM) Located On Passenger Rear Of Engine.

Jeep Grand Cherokee 1997-1998

FUNCTON COLOR LOCATON
Constant +12 Volts: RED/WHTE (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: VOLET/YELLOW (-) DRVER'S KCK PANEL
Dome
Lights/Superv:
YELLOW (-) AT COURTESY LGHT **
OEM Horn: GRAY/ORANGE (-) STEERNG COLUMN HARNESS
Power Lock: DRVER/
ORANGE/VOLET
PASSENGER/ BLACK/WHTE ****
Power Unlock: DRVER/ PNK/BLACK PASSENGER/ PNK/BLACK ****
Trunk Release: N/A
Alarm nput Wire: YELLOW (-) AT COURTESY LGHT **

NOTES: ** YELLOW (-) Wire Also Located n 12 Pin Yellow Connector At Fuse Block. *** Body
Control Module (BCM) Located Behind Driver Dash. **** See Note #230 - Jeep Grand Cherokee
Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 21 of 45

Make: Model: Year:
Jeep Grand Cherokee 1999-2002


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS *
gnition #1: DK. BLUE GNTON SWTCH HARNESS
gnition #2: BLACK/ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BLACK/WHTE GNTON SWTCH HARNESS
Brake Light: WHTE/TAN AT SWTCH ABOVE BRAKE PEDAL
Tach Signal:
Parking Lights: BLACK/YELLOW (-) N DRVER'S KCK PANEL ****
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * This vehicle may be equipped with Chrysler's Smart Key Transponder Theft System
Only f The gnition Key s Gray. Use a universal alarm bypass module. **** The Parking Lights
Are Activated By A Ground Pulse Through A 240 Ohm Resistor. See Note #145 for parking light
shortcut

Jeep Grand Cherokee 1999-2002

FUNCTON COLOR LOCATON
Constant +12 Volts:
OEM Alarm Disarm: LT.GREEN/ORANGE (-) AT SWTCH N DRVER'S DOOR **
Dome
Lights/Superv:
YELLOW (-) 3 PN PLUG N FUSE PANEL ON DR. SDE
OEM Horn: BLACK/RED (-) STEERNG COLUMN HARNESS
Power Lock: DRVER/
ORANGE/VOLET
PASSENGER/ BLACK/WHTE ***
Power Unlock: DRVER/ PNK/BLACK PASSENGER/ PNK/BLACK ***
Trunk Release:
Alarm nput Wire: YELLOW (-) 3 PN PLUG N FUSE PANEL ON DR. SDE

NOTES: **This wire requires a negative trigger through a 465 ohm resistor. *** See Note #230 -
Jeep Grand Cherokee Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 22 of 45
Make: Model: Year:
Jeep Grand Cherokee 2003


FUNCTON COLOR LOCATON
Start: Yellow (+) gnition switch harness
gnition #1: Dk.Blue (+) gnition switch harness*
gnition #2: gnition switch harness
gnition #3: gnition switch harness
Accessory: Red/Black (+) gnition switch harness
Brake Light: White/Tan (+) Drivers kick panel
Tach Signal:
Parking Lights: Yellow (-) Headlight switch
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * This vehicle may be equipped with Chrysler's Smart Key Transponder Theft System
only if the ignition key is gray. Use a universal alarm bypass module.

Jeep Grand Cherokee 2003

FUNCTON COLOR LOCATON
Constant +12 Volts: Red & Pink/Black (+) gnition switch harness
OEM Alarm Disarm: Lt.Green/Orange (-) Drivers door lock switch
Dome
Lights/Superv:

OEM Horn: Gray/Orange (-) Steering column harness
Power Lock: See Note **
Power Unlock: See Note **
Trunk Release:
Alarm nput Wire:

NOTES: **Use a vehicle specific doorlock module.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 23 of 45

Jeep Grand Cherokee 2003-2004

FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS *
gnition #1: DK. BLUE GNTON SWTCH HARNESS
gnition #2: RED/BLACK GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BLACK/ORANGE GNTON SWTCH HARNESS
Brake Light: WHTE/TAN AT SWTCH ABOVE BRAKE PEDAL
Tach Signal:
Parking
Lights:
YELLOW (-) HEADLGHT SWTCH****
Headlights:
Diesel Glow
Plug:

Clutch
Bypass Wire:

Notes: * This vehicle may be equipped with Chrysler's Smart Key Transponder Theft System Only f The
gnition Key s Gray. Use a universal alarm bypass module. **** The Parking Lights Are Activated By
A Ground Pulse Through A 1300 Ohm Resistor.

Jeep Grand Cherokee 2003-2004

FUNCTON COLOR LOCATON
Constant +12
Volts:

OEM Alarm
Disarm:
LT.GREEN/ORANGE (-) AT SWTCH N DRVER'S DOOR **
Dome
Lights/Superv:
YELLOW (-) 3 PN PLUG N FUSE PANEL ON DR. SDE
OEM Horn: BLACK/RED (-) STEERNG COLUMN HARNESS
Power Lock: DRVER/ ORANGE/VOLET PASSENGER/ BLACK/WHTE ***
Power Unlock: DRVER/ PNK/BLACK PASSENGER/ PNK/BLACK ***
Trunk Release:
Alarm nput
Wire:
YELLOW (-) 3 PN PLUG N FUSE PANEL ON DR. SDE
Notes:
**This wire requires a negative trigger through a 465 ohm resistor. *** See Note #230 - Jeep
Grand Cherokee Door Lock Diagram.




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 24 of 45

GRAND CHEROKEE 2005 - 2006



KEY
T-
HARNE
SS
MMOBLZER
CHRY
KEY-1
N/A
CHRYSLER'S SENTRY ANT-THEFT TRANSPONDER System, Requires Bypass
Module and Extra gnition Key

FUNCTON COLOR LOCATON
12 VOLT CONSTANT Connect to BATTERY ONLY
STARTER PNK/ORANGE (+) GNTON SWTCH HARNESS
STARTER 2
PURPLE/BROWN (-) See
NOTE *1
GNTON SWTCH HARNESS,
GNTON 1 PNK/LGHT GREEN (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
PURPLE/BROWN (-) Same wire
as STARTER #2, See NOTE *2
GNTON SWTCH HARNESS,
See STARTER #2 DAGRAM
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + ) DO NOT USE!
POWER LOCK
PURPLE/DARK GREEN (1-
Wire System) See NOTE *3
N DRVERS KCK PANEL or
Cluster Connector 3, pin 17
POWER UNLOCK Same wire, See NOTE *3, See DAGRAM
DOOR TRGGER See NOTE *4 N EACH KCK PANEL
DOMELGHT SUPERVSON YELLOW/ORANGE (-) @ ANY UNDERDASH LGHT
TRUNK RELEASE
ORANGE/PURPLE (-) See
NOTE *5
N DRVERS KCK PANEL
SLDNG POWER DOOR N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 25 of 45

HORN DARK GREEN/ORANGE (+)


@ HORN or PM, Connector,
C2 pin 35, See NOTE *6
TACH
ANY wire NOT RED/TAN or
DARK GREEN/LGHT GREEN
@ any FUEL-NJECTOR or
GNTON COL
WAT TO START LGHT N/A
BRAKE
WHTE/TAN (+) or
WHTE/LGHT GREEN (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM N/A
ANT-THEFT
CHRYSLER'S SENTRY KEY, A
TRANSPONDER SYSTEM
TRANSPONDER @ GNTON
SWTCH TUMBLER

EXTRA NFORMATON
NOTE *1 & *2 this vehicle requires a Special Circuit that requires (2) Relays and (2) Resistors, Starter
#2 requires a (-)Negative thru a 180 Ohm Resistor and an extra relay part #775 and Accessory
requires a (-)Negative thru a 610 Ohm Resistor and an extra relay part #775, to connect this circuit
up, NOTE *3 vehicles with MEMORY SEATS, have to go to the DRVERS MEMORY MRRO
MODULE in the door to get this wire. The LOCK wire requires a (-)Negative thru 330 Ohm resistor
and UNLOCK requires a (-)Negative thru a 100 Ohm resistor, some units require 2 extra relays part
#775, to connect. NOTE *4 the DRVERS DOOR is a PURPLE (-) PN 6, the PASSENGER DOOR is
a PURPLE/WHTE (-) PN 7, the DRVERS REAR DOOR is a PURPLE/GRAY (-) PN 4, and the
PASSENGER REAR DOOR is a PURPLE/YELLOW (-) PN 5, when connecting an ALARM
SYSTEM, use all 4 DOOR TRGGER wires and DODE SOLATE, to connect, . NOTE *5 when
testing the TRUNK/HATCH RELEASE wire, you must use the Key to open the REAR GLASS, this
wire should then show a (-) Negative during testing. NOTE *6 the PM (ntegrated Power Module) is
located on the DRVERS FENDER, BEHND THE BATTERY.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 26 of 45

Make: Model: Year:
Jeep Grand Wagoneer 1984-1985


FUNCTON COLOR LOCATON
Start: LGHT BLUE GNTON SWTCH HARNESS
gnition #1: RED/TAN GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: YELLOW GNTON SWTCH HARNESS
Brake Light: L GREEN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: D GREEN AT GNTON COL *
Parking Lights: WHTE (+) AT LGHT SWTCH
Headlights: RED/TAN (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: Carburated Engine!!.

Jeep Grand Wagoneer 1984-1985

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK (-) AT PN SWTCH
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: BLUE DRVER'S KCK PANEL **
Power Unlock: PNK DRVER'S KCK PANEL **
Trunk Release: N/A
Alarm nput Wire: BLACK (-) AT PN SWTCH

NOTES: ** See Note #203 - Reverse Polarity Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 27 of 45

Make: Model: Year:
Jeep Grand Wagoneer 1986-1991


FUNCTON COLOR LOCATON
Start: GREEN GNTON SWTCH HARNESS
gnition #1: YELLOW GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: L BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN/TAN GNTON CONTROL MODULE
Parking Lights: BLUE (+) AT LGHT SWTCH
Headlights: BROWN/WHTE (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Jeep Grand Wagoneer 1986-1991

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK (-) AT PN SWTCH *
OEM Horn: ORANGE (-) STEERNG COLUMN HARNESS
Power Lock: BLUE DRVER'S KCK PANEL **
Power Unlock: PNK DRVER'S KCK PANEL **
Trunk Release: N/A
Alarm nput Wire: BLACK (-) AT PN SWTCH *

NOTES: * Door Pin Colors: 1986-88 - BLACK/TAN, 1989-91 - BLACK/WHTE At Pin Switch. **
See Note #203 - Reverse Polarity Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 28 of 45

Make: Model: Year:
Jeep Grand Wagoneer 1993-1994


FUNCTON COLOR LOCATON
Start: YELLOW/DARK BLUE GNTON SWTCH HARNESS
gnition #1: DARK BLUE/GRAY GNTON HARNESS
gnition #2: ORANGE/BLACK GNTON SWTCH HARNESS (HEAT - A/C)
gnition #3: N/A
Accessory: BLACK/WHTE GNTON SWTCH HARNESS
Brake Light: WHTE/TAN AT SWTCH ON BRAKE PEDAL BRACKET
Tach Signal: GRAY/WHTE OR GRAY/BLACK - AT COL OR PCM
Parking Lights: DARK BLUE/RED (+) HEADLGHT SWTCH OR FUSE BOX
Headlights: TAN/BLACK (+) STEERNG COLUMN HARNESS
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Jeep Grand Wagoneer 1993-1994

FUNCTON COLOR LOCATON
Constant +12 Volts: RED/WHTE AND PNK/BLACK - GNTON SWTCH HARNESS
OEM Alarm Disarm: PURPLE/YELLOW (-) DRVER KCK PANEL
Dome
Lights/Superv:
YELLOW (-) DRVER KCK PANEL
OEM Horn: GRAY/ORANGE (-) STEERNG COLUMN HARNESS
Power Lock: ORANGE/VOLET DRVER'S KCK PANEL *
Power Unlock: PNK/VOLET DRVER'S KCK PANEL *
Trunk Release: N/A
Alarm nput Wire: YELLOW (-) DRVER KCK PANEL

NOTES: * See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 29 of 45

Make: Model: Year:
Jeep Liberty 2002-2003


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: RED/BLUE GNTON SWTCH HARNESS*
gnition #2: BLACK/ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BLACK/WHTE GNTON SWTCH HARNESS
Brake Light: WHTE/TAN AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: TAN/RED AT COL #1
Parking Lights: LT. GREEN/ORANGE (-) AT HEADLGHT SWTCH
Headlights: N/A
Diesel Glow Plug: N/A
Clutch Bypass Wire:

NOTES: * This vehicle may be equipped with Chrysler's Smart Key Transponder Theft System
Only f The gnition Key s Gray. Use a universal alarm bypass module. ** Single Wire System. A
Negative Pulse Through A 475 Ohm Resistor Will Disarm The Alarm. A Negative Pulse Through
A 2 K-Ohm Resistor Will Arm The Alarm.

Jeep Liberty 2002-2003

FUNCTON COLOR LOCATON
Constant +12 Volts: PNK/BLACK GNTON SWTCH HARNESS
OEM Alarm Disarm: LT. GREEN/ORANGE DRVER'S KCK PANEL **
Dome
Lights/Superv:
YELLOW AT COURTESY LGHT UNDER DASH ***
OEM Horn: BLACK/RED (-) STEERNG COLUMN HARNESS
Power Lock: PNK/VOLET DRVER'S KCK PANEL ****
Power Unlock: PNK/VOLET DRVER'S KCK PANEL ****
Trunk Release: ORANGE/BROWN (+) AT BCM THAT'S NTEGRATED NTO THE
FUSE PANEL
Alarm nput Wire: YELLOW AT COURTESY LGHT UNDER DASH ***

NOTES: *** Use For Alarm Pulse Only. For Domelight Supervision, Use Either A Tan (-) or
Tan/White (-) Wire Located n A Blue Plug To The Right Of The Steering Column. These Are The
Driver's And Passenger Door Pulses Respectively. **** Single Wire System. A Negative Pulse
Through A 1.4 K-Ohm Resistor Will Lock The Doors. A Negative Pulse Through A 425 Ohm
Resistor Will Unlock All The Doors. See Note #211 Single Wire Negative Trigger Door Locks.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 30 of 45

Jeep Liberty 2005-2006

FUNCTON COLOR LOCATON
Start: Lt.blue/red (+) GNTON SWTCH HARNESS *
gnition #1: Pink/lt.green (+) GNTON SWTCH HARNESS
gnition #2: Pink/yellow (+) GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: 2nd Pink/yellow (+) GNTON SWTCH HARNESS
Brake Light: WHTE/TAN AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: Not red/orange nor Pink/gray any coil
Parking
Lights:
Pink/red (-) AT HEADLGHT SWTCH** Through 910 ohm resistor
Headlights: N/A
Diesel Glow
Plug:
N/A
Clutch
Bypass Wire:

Notes: * This vehicle may be equipped with Chrysler's Smart Key Transponder Theft System Only f The
gnition Key s Gray. Use a universal alarm bypass module. ** Must use a relay to supply a ground
pulse through a 900 Ohm resistor. *** Single Wire System. A Negative Pulse Through A 475 Ohm
Resistor Will Disarm The Alarm. A Negative Pulse Through A 2 K-Ohm Resistor Will Arm The Alarm.

Jeep Liberty 2005-2006

FUNCTON COLOR LOCATON
Constant +12
Volts:
Red (+) GNTON SWTCH HARNESS
OEM Alarm
Disarm:
Factory remote only
Dome
Lights/Superv:
YELLOW/lt.blue or black/white back of fuse box
OEM Horn: dk.reen/purple STEERNG COLUMN HARNESS
Power Lock: Tan/dk.blue (-) DRVER'S KCK PANEL **** Through 1.4k ohm
Power Unlock: same as lock DRVER'S KCK PANEL ****Through 426 ohm
resistor

Trunk
Release:
lt.green/white (-) drivers kick
Alarm nput
Wire:
YELLOW/lt.blue or black/white back of fuse box
Notes:
*** Use For Alarm Pulse Only. For Domelight Supervision, Use Either A Tan (-) or Tan/White (-) Wire
Located n A Blue Plug To The Right Of The Steering Column. These Are The Driver's And
Passenger Door Pulses Respectively. **** Single Wire System. A Negative Pulse Through A 1.4 K-
Ohm Resistor Will Lock The Doors. A Negative Pulse Through A 425 Ohm Resistor Will Unlock All
The Doors. See Note #211 Single Wire Negative Trigger Door Locks.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 31 of 45

Make: Model: Year:
Jeep Pickup 1983


FUNCTON COLOR LOCATON
Start: LGHT BLUE GNTON SWTCH HARNESS
gnition #1: RED/TAN GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: YELLOW
Brake Light: L GREEN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: D GREEN AT GNTON COL *
Parking Lights: WHTE (+) AT LGHT SWTCH
Headlights: RED/TRACER (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Carburated Engine!!

Jeep Pickup 1983

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK (-) AT PN SWTCH
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: ADD ACTUATORS N BOTH DOORS **
Power Unlock: ADD ACTUATORS N BOTH DOORS **
Trunk Release: N/A
Alarm nput Wire: BLACK (-) AT PN SWTCH

NOTES: ** See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 32 of 45

Make: Model: Year:
Jeep Pickup 1984-1985


FUNCTON COLOR LOCATON
Start: GREEN GNTON SWTCH HARNESS
gnition #1: YELLOW GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: YELLOW GNTON SWTCH HARNESS
Brake Light: L GREEN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: D GREEN AT GNTON COL
Parking Lights: BLUE (+) AT LGHT SWTCH
Headlights: RED/TRACER (+) ATHEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: Carburated Engine!!

Jeep Pickup 1984-1985

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK/TAN (-) AT PN SWTCH
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: BLUE DRVER'S KCK PANEL **
Power Unlock: PNK DRVER'S KCK PANEL **
Trunk Release: N/A
Alarm nput Wire: BLACK/TAN (-) AT PN SWTCH

NOTES: ** See Note #203 - Reverse Polarity Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 33 of 45

Make: Model: Year:
Jeep Pickup 1986-1987


FUNCTON COLOR LOCATON
Start: GREEN GNTON SWTCH HARNESS
gnition #1: YELLOW GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: VOLET GNTON SWTCH HARNESS
Brake Light: L BLUE/TAN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN/TAN AT COL *
Parking Lights: BLUE (+) AT LGHT SWTCH
Headlights: BROWN/WHTE (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Carburated Engine.

Jeep Pickup 1986-1987

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK/TAN (-) AT PN SWTCH
OEM Horn: ORANGE (-) STEERNG COLUMN HARNESS
Power Lock: BLUE DRVER'S KCK PANEL **
Power Unlock: PNK DRVER'S KCK PANEL **
Trunk Release: N/A
Alarm nput Wire: BLACK/TAN (-) AT PN SWTCH

NOTES: ** See Note #203 - Reverse Polarity Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 34 of 45

Make: Model: Year:
Jeep ScrambIer 1983-1986


FUNCTON COLOR LOCATON
Start: LGHT BLUE GNTON SWTCH HARNESS
gnition #1: RED/TAN GNTON SWTCH HARNESS
gnition #2: RED/TAN GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: YELLOW GNTON SWTCH HARNESS
Brake Light: PNK (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN/TAN AT COL
Parking Lights: WHTE (+) AT LGHT SWTCH
Headlights: RED/TRACER (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Carburated Engine And Manual Transmission.

Jeep ScrambIer 1983-1986

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
DARK BLUE (-) AT PN SWTCH OR COURTESY LGHT
OEM Horn: BLACK/TAN (-) STEERNG COLUMN HARNESS
Power Lock: ADD ACTUATORS N BOTH DOORS **
Power Unlock: ADD ACTUATORS N BOTH DOORS **
Trunk Release: N/A
Alarm nput Wire: DARK BLUE (-) AT PN SWTCH OR COURTESY LGHT

NOTES: ** See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 35 of 45

Make: Model: Year:
Jeep Wagoneer 1983


FUNCTON COLOR LOCATON
Start: LGHT BLUE GNTON SWTCH HARNESS
gnition #1: RED/TAN GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: YELLOW GNTON SWTCH HARNESS
Brake Light: L GREEN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: D GREEN AT GNTON COL *
Parking Lights: WHTE (+) AT LGHT SWTCH
Headlights: TAN (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Carburated Engine!! .

Jeep Wagoneer 1983

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK (-) AT PN SWTCH
OEM Horn: GRAY/RED OR BLACK (-) STEERNG COLUMN HARNESS
Power Lock: ADD ACTUATORS N BOTH DOORS **
Power Unlock: ADD ACTUATORS N BOTH DOORS **
Trunk Release: N/A
Alarm nput Wire: BLACK (-) AT PN SWTCH

NOTES: ** See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 36 of 45

Make: Model: Year:
Jeep Wagoneer 1984-1987


FUNCTON COLOR LOCATON
Start: DARK GREEN GNTON SWTCH HARNESS
gnition #1: YELLOW GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: LGHT BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN/TAN AT GNTON MODULE *
Parking Lights: DARK BLUE (+) AT LGHT SWTCH
Headlights: TAN (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * 1987 4.0L Only s Electronic Fuel njection. Rest Are Carburated Or Throttle Body
njection.

Jeep Wagoneer 1984-1987

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK (-) AT PN SWTCH OR COURTESY LGHT
OEM Horn: GRAY/RED OR BLACK (-) STEERNG COLUMN HARNESS
Power Lock: WHTE DRVER'S KCK PANEL **
Power Unlock: DARK GREEN DRVER'S KCK PANEL **
Trunk Release: N/A
Alarm nput Wire: BLACK (-) AT PN SWTCH OR COURTESY LGHT

NOTES: ** Without OEM Keyless See Note #203 - Reverse Polarity Door Lock Diagram. With
OEM Keyless: Lock - L GREEN, Unlock - TAN, At OEM Relays n Passenger Kick Panel; See
Note #202 - Positive Pulse Door Lock Diagram.




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 37 of 45

WAGONEER 1988 -1990



KEY T-HARNESS MMOBLZER
N/A N/A N/A

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER DARK GREEN (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 YELLOW (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BROWN (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + ) BLUE/RED (+) N DRVERS KCK PANEL
POWER LOCK WHTE (TYPE C) See NOTE *1
@ HARNESS TOP RGHT of
STEERNG COLUMN
POWER UNLOCK
GREEN (TYPE C) See NOTE
*1
@ HARNESS TOP RGHT of
STEERNG COLUMN
DOOR TRGGER BLACK/WHTE (-) @ UNDERDASH LGHT
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN BLACK (-)
@ RBBON CABLE, N THE
STEERNG COLUMN
TACH GREEN @ GNTON COL

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 38 of 45

WAT TO START LGHT N/A


BRAKE WHTE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM N/A
ANT-THEFT N/A

EXTRA NFORMATON
NOTE *1 if vehicle is equipped with a FACTORY KEYLESS ENTRY the DOOR LOCKS are a TYPE
A System, the LOCK is a LGHT GREEN and the UNLOCK is a TAN located at the Relays in the
Passenger kick panel.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 39 of 45

Make: Model: Year:
Jeep WrangIer 1987-1990


FUNCTON COLOR LOCATON
Start: GREEN GNTON SWTCH HARNESS
gnition #1: YELLOW GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: VOLET GNTON SWTCH HARNESS
Brake Light: N/A
Tach Signal: GREEN/TAN AT GNTON MODULE *
Parking Lights: BLUE (+) AT LGHT SWTCH
Headlights: TAN (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Carburated Engine.

Jeep WrangIer 1987-1990

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK/TAN (-) AT PN SWTCH OR COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: ADD ACTUATORS N BOTH DOORS **
Power Unlock: ADD ACTUATORS N BOTH DOORS **
Trunk Release: N/A
Alarm nput Wire: BLACK/TAN (-) AT PN SWTCH OR COURTESY LGHT

NOTES: ** See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 40 of 45

Make: Model: Year:
Jeep WrangIer 1991-1992


FUNCTON COLOR LOCATON
Start: GREEN GNTON SWTCH HARNESS
gnition #1: YELLOW GNTON SWTCH HARNESS
gnition #2: VOLET GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS
Brake Light: LGHT BLUE (+) SWTCH ON BRAKE PEDAL BRACKET
Tach Signal: YELLOW/BLACK AT COL
Parking Lights: BLUE/RED (+) AT HEADLGHT SWTCH
Headlights: TAN/BLACK OR TAN (+) HEADLGHT SWTCH OR BEAM SELECT
SW.
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Jeep WrangIer 1991-1992

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK/WHTE OR
BLACK
(-) AT PN SWTCH OR COURTESY LGHT
OEM Horn: BLACK OR
ORANGE/WHTE
(-) STEERNG COLUMN HARNESS
Power Lock: ADD ACTUATORS N BOTH DOORS *
Power Unlock: ADD ACTUATORS N BOTH DOORS *
Trunk Release: N/A
Alarm nput Wire: BLACK/WHTE OR
BLACK
(-) AT PN SWTCH OR COURTESY LGHT

NOTES: * See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 41 of 45

Make: Model: Year:
Jeep WrangIer 1993-1996


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: DARK BLUE GNTON SWTCH HARNESS
gnition #2: BLACK/ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BLACK/WHTE GNTON SWTCH HARNESS
Brake Light: WHTE/TAN (+) SWTCH ON BRAKE PEDAL BRACKET
Tach Signal: GRAY AT COL OR GRAY/LGHT BLUE AT PN 43 ON PCM
Parking Lights: BLACK/YELLOW (+) AT HEADLGHT SWTCH
Headlights: LGHT GREEN (+) HEADLGHT SWTCH OR BEAM SELECT
SW.
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Jeep WrangIer 1993-1996

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
YELLOW (-) AT ETHER PN SWTCH
OEM Horn: BLACK/RED (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: ADD ACTUATORS N BOTH DOORS *
Power Unlock: ADD ACTUATORS N BOTH DOORS *
Trunk Release: N/A
Alarm nput Wire: YELLOW (-) AT ETHER PN SWTCH

NOTES: * See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 42 of 45

Make: Model: Year:
Jeep WrangIer 1997-2002


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS **
gnition #1: DK. BLUE GNTON SWTCH HARNESS
gnition #2: BLACK/ORANGE GNTON SW. HARNESS (HEAT/AC)
gnition #3: N/A
Accessory: BLACK/WHTE GNTON SWTCH HARNESS
Brake Light: WHTE/TAN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GRAY AT GNTON COL *
Parking Lights: BLACK/YELLOW (+) AT HEADLGHT SWTCH
Headlights: LT. GREEN (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Jeep WrangIer 1997-2002

FUNCTON COLOR LOCATON
Constant +12 Volts: PNK/BLUE & RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
YELLOW (-) 14 PN GREEN CONN. N DR. KCK PANEL
OEM Horn: RED/YELLOW (-) STEERNG COLUMN HARNESS
Power Lock: ORANGE/PURPLE (+) DRVER'S KCK PANEL ***
Power Unlock: PNK/PURPLE (+) DRVER'S KCK PANEL ***
Trunk Release: N/A
Alarm nput Wire: YELLOW (-) 14 PN GREEN CONN. N DR. KCK PANEL

NOTES: *** See Note #202 - Positive Door Locks. Vehicles without power door locks will require
the installation of door lock actuators - See Note #204 Adding Door Lock Actuators.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 43 of 45

Make: Model: Year:
Jeep WrangIer 2003-2004


FUNCTON COLOR LOCATON
Start: Yellow (+) gnition switch harness
gnition #1: Blue (+) gnition switch harness
gnition #2: N/A gnition switch harness
gnition #3: N/A gnition switch harness
Accessory: Black/Orange (+) gnition switch harness
Brake Light: White/Tan (+) Brake pedal switch
Tach Signal: Gray (AC) gnition coil
Parking Lights: Black/Yellow (+) Headlight switch
Headlights: N/A
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A

NOTES:

Jeep WrangIer 2003-2004

FUNCTON COLOR LOCATON
Constant +12 Volts: Pink/Black & Red (+) gnition switch harness
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
Yellow (-) Headlight switch
OEM Horn: Red/Yellow (-) Steering column harness
Power Lock: N/A **
Power Unlock: N/A
Trunk Release: N/A
Alarm nput Wire: Yellow (-) Headlight switch

NOTES: **Vehicles without power door locks See Note #204 Adding Door Lock Actuators.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 44 of 45

WRANGLER 2005 - 2006



KE
Y
T-
HARN
ESS
MMOBLZER
N/A N/A
CHRYSLER'S SENTRY ANT-THEFT TRANSPONDER System (GRAY GNTON KEY
ONLY), Requires Bypass Module and Extra gnition Key

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER PNK/ORANGE (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK/LGHT GREEN (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
PNK/YELLOW (+) (14 Gauge
wire)
GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + ) WHTE/YELLOW (+)
@ HEADLGHT SWTCH or in
DRVERS KCK PANEL
POWER LOCK ADD ACTUATORS TO BOTH DOORS,
POWER UNLOCK ADD ACTUATORS TO BOTH DOORS,
DOOR TRGGER
PURPLE (-) and
PURPLE/YELLOW (-) Use both,
See NOTE *1
N DRVERS KCK PANEL,
DOMELGHT SUPERVSON YELLOW/ORANGE (-) @ UNDER DASH LGHT
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 45 of 45

HORN RED/YELLOW (-) N DRVERS KCK PANEL


TACH
Any wire NOT BROWN or
PNK/GRAY
@ any FUEL-NJECTOR or
GNTON COL
WAT TO START LGHT N/A
BRAKE WHTE/TAN (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM N/A
ANT-THEFT
CHRYSLER'S SENTRY KEY
(GRAY KEY ONLY) A
TRANSPONDER SYSTEM
TRANSPONDER @ GNTON
SWTCH TUMBLER

EXTRA NFORMATON
NOTE *1 this vehicle has (2) DOOR TRGGER wires, a PURPLE (-) for the DRVERS door and a
PURPLE/YELLOW (-) for the PASSENGER door. When connecting to an ALARM SYSTEM, use both
DOOR TRGGER wires and DODE SOLATE, to connect,

Potrebbero piacerti anche