Sei sulla pagina 1di 80

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws.

f you acquired this


document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 1 of 80




Cadac Securty, Remote Start, Keyess Entry &
Navgaton Wre Coors Verson 4.2









PLEASE NOTE

The information contained is accurate to the best of our knowledge. 12 Volt Resource LLC
makes no representation or warranty with respect to the information contained in this
document including its accuracy or completeness. 12 Volt Resource LLC disclaims all
liability or responsibility for errors or omissions therein or any decision made by the
recipient in reliance thereon.

nstallations should be attempted by experienced installers only. Proper installation
remains the responsibility of the installer. t is the installer's responsibility to test and verify
all circuitry with the proper test equipment prior to installation.


Additional nformation:

This information is sorted alphabetically by vehicle model. f there are multiple
years for a particular vehicle model, then the oldest year comes first.

The installation notes referenced below and the full installation guide are located
in the nstall nstructions & Notes folder on this CD-ROM.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 2 of 80

Make: Model: Year:
CadiIIac AIIante 1988-1992


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3:
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: LT.BLUE AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT COL
Parking Lights: LEFT - BROWN RGHT - BROWN/WHTE (+) LGHT SWTCH
Headlights: N/A
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

CadiIIac AIIante 1988-1992

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: WHTE/GREEN (-) DRVER KCK PANEL
Dome
Lights/Superv:
GREEN/WHTE (-) AT COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: WHT/BLU OR YEL/BLU AT RELAYS TO LEFT
Power Unlock: BLK/WHT OR RED/WHT OF STEERNG COLUMN*
Trunk Release: BLACK/WHTE (+) AT RELEASE SWTCH
Alarm nput Wire: GREEN/WHTE (-) AT COURTESY LGHT

NOTES: * See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 3 of 80

Make: Model: Year:
CadiIIac AIIante 1993


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: VOLET/WHTE GNTON SWTCH HARNESS
gnition #3: ORANGE GNTON SWTCH HARNESS
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: LGHT BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT COL PACK
Parking Lights: LEFT - BROWN RGHT - BROWN (+) AT FUSE BOX
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

CadiIIac AIIante 1993

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: LGHT GREEN (-) N ETHER KCK PANEL
Dome
Lights/Superv:
BLUE/WHTE (-) AT COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: BLUE AT RELAYS TO LEFT OF
Power Unlock: BLACK STEERNG COLUMN*
Trunk Release: BLACK (+) AT RELEASE SWTCH
Alarm nput Wire: BLUE/WHTE (-) AT COURTESY LGHT

NOTES: * See Note #202 - Positive Pulse Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 4 of 80

Make: Model: Year:
CadiIIac Brougham 1985-1993


FUNCTON COLOR LOCATON
Start: PURPLE GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE OR LGHT BLUE AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN (+) AT HEALDGHT SWTCH
Headlights: YELLOW (+) HEADLGHT SWTCH OR BEAM SELECT
SW.
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Car s Throttle Body njection.

CadiIIac Brougham 1985-1993

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: LGHT GREEN (-) DRVER KCK PANEL
Dome
Lights/Superv:
WHTE (-) PN SWTCH OR AT COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL**
Power Unlock: BLACK DRVER'S KCK PANEL**
Trunk Release: BLACK (+) AT RELEASE SWTCH
Alarm nput Wire: WHTE (-) PN SWTCH OR AT COURTESY LGHT

NOTES: ** See Note #202 - Positive Pulse Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 5 of 80

BROUGHAM 1994 -1995



KEY
T-
HARNE
SS
MMOBLZER
N/A N/A
GM's VATS ANT-THEFT System (if Equipped, gnition Key has Chip) Requires Bypass
Module

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + ) GRAY/BLACK (+) BEHND FUSE BOX
POWER LOCK LGHT BLUE (TYPE A) N ETHER KCK PANEL
POWER UNLOCK WHTE (TYPE A) N ETHER KCK PANEL
DOOR TRGGER WHTE (-) or GRAY (-) N ETHER KCK PANEL
DOMELGHT SUPERVSON BLUE/WHTE (-) N DRVERS KCK PANEL
TRUNK RELEASE
BLACK (+) or BLACK/WHTE
(+)
@ TRUNK RELEASE SWTCH
SLDNG POWER DOOR N/A
HORN BLACK (-)
@ STEERNG COLUMN
HARNESS
TACH WHTE or WHTE/BLACK @ GNTON COL
WAT TO START LGHT N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 6 of 80
BRAKE YELLOW (+) or WHTE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM LGHT GREEN (-) N ETHER KCK PANEL
ANT-THEFT
2 WHTE wires or 1 WHTE and
1 PURPLE or PURPLE/WHTE
in an ORANGE or BLACK
TUBE in RUNNNG DOWN
STEERNG COLUMN
GM's VATS System @ gnition
Switch

EXTRA NFORMATON
SPECAL NOTE!!!! f vehicle is equipped with PASSKEY/VATS, gnition Key will have a little Chip on
the Steel Shaft of the Key that can be seen.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 7 of 80

Make: Model: Year:
CadiIIac Catera 1997-2002


FUNCTON COLOR LOCATON
Start: BLACK/RED GNTON SWTCH HARNESS
gnition #1: BROWN GNTON SWTCH HARNESS*
gnition #2: RED GNTON SWTCH HARNESS
gnition #3:
Accessory: WHTE GNTON SWTCH HARNESS
Brake Light: BLACK/YELLOW (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal:
Parking Lights: GRAY/GREEN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug: N/A
Clutch Bypass Wire:

NOTES: * Some vehicles equipped with anti theft system -

CadiIIac Catera 1997-2002

FUNCTON COLOR LOCATON
Constant +12 Volts:
OEM Alarm Disarm: BROWN/VOLET (-) AT BCM N PASSENGER KCK PANEL ***
Dome
Lights/Superv:
GRAY (-) DRVER KCK PANEL
OEM Horn: BROWN/WHTE (-) NSDE OF AR BAG HARNESS WRES
Power Lock: BLACK/BROWN (-) PASSENGER KCK PANEL
Power Unlock: BLACK/VOLET(-) PASSENGER KCK PANEL
Trunk Release:
Alarm nput Wire: GRAY (-) DRVER KCK PANEL

NOTES: ** See Note #201 - Negative Pulse Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 8 of 80

Make: Model: Year:
CadiIIac Cimarron 1982-1985


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: LGHT BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Throttle Body njected.

CadiIIac Cimarron 1982-1985

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
WHTE (-) DRVERS PN SWTCH
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL**
Power Unlock: BLACK DRVER'S KCK PANEL**
Trunk Release:
Alarm nput Wire: WHTE (-) DRVERS PN SWTCH

NOTES: ** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 9 of 80

Make: Model: Year:
CadiIIac Cimarron 1986-1988


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: LGHT BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * 4 Cylinder Engine s Throttle Body njected, Rest Are Electronic Fuel njected Engines.

CadiIIac Cimarron 1986-1988

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) PN SWTCH OR AT COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL**
Power Unlock: BLACK DRVER'S KCK PANEL**
Trunk Release: BLUE (+) AT RELEASE SWTCH
Alarm nput Wire: WHTE (-) PN SWTCH OR AT COURTESY LGHT

NOTES: ** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 10 of 80

Make: Model: Year:
CadiIIac Concours 1994


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS*
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: LGHT BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal:
WHTE OR
PURPLE/WHTE
AT GNTON MODULE
Parking Lights: BROWN (+) REAR BODY HARN'S N DRVER KCK
PANEL
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * This Vehicle s Equipped With GM's Anti-Theft System; See Note #237.

CadiIIac Concours 1994

FUNCTON COLOR LOCATON
Constant +12 Volts: RED/WHTE AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: LGHT GREEN (-) N ETHER KCK PANEL
Dome
Lights/Superv:
DARK BLUE (-) KCK PANEL OR HEADLGHT SWTCH **
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: RED/BLACK DRVER'S KCK PANEL ***
Power Unlock: WHTE DRVER'S KCK PANEL ***
Trunk Release: BLACK/WHTE (+) AT RELEASE RELAY
Alarm nput Wire: DARK BLUE (-) KCK PANEL OR HEADLGHT SWTCH **

NOTES: ** BLUE/WHTE (-) Wire At Courtesy Light Can Also Be Used For Door Trigger. ***
Without OEM Keyless Entry Door Locks Are- L BLUE (Lock) & WHTE (Unlock) n Driver Kick
Panel, See Note #202 - Positive Pulse Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 11 of 80
Make: Model: Year:
CadiIIac Concours 1995-1999


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS**
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: LGHT BLUE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS
Brake Light: L BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT POWERTRAN CONTROL MODULE *
Parking Lights: DK. BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Powertrain Control Module (PCM) Located On Driver Front Of Engine Under Air Filter.
** This Vehicle s Equipped With GM's VATS Anti-Theft System; See Note #237.

CadiIIac Concours 1995-1999

FUNCTON COLOR LOCATON
Constant +12 Volts: RED (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: L GREEN (-) DRVER KCK PANEL
Dome
Lights/Superv:
D BLUE/WHTE (-) AT COURTESY LGHT ***
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: RED/BLACK DRVER'S KCK PANEL****
Power Unlock: ORANGE/BLACK DRVER'S KCK PANEL****
Trunk Release: BLACK AT TRUNK RELEASE SWTCH
Alarm nput Wire: D BLUE/WHTE (-) AT COURTESY LGHT ***

NOTES: *** Optional Door Trigger At Body Control Module On Passenger Side Of Trunk, TAN
(Dr) (-), D BLUE/WHTE (Ps) (-) & ORANGE (Rear Doors) (-). Diode solation Needed Cathode
(Band Side) Of Diode Faces OEM Wires. **** See Note #201 - Negative Pulse Door Lock
Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 12 of 80

Make: Model: Year:
CadiIIac Coupe DeviIIe 1980-1984


FUNCTON COLOR LOCATON
Start: PURPLE GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN AT LGHT
SWTCH
OR DARK GREEN AT FUSE BOX (+)
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Throttle Body njected.

CadiIIac Coupe DeviIIe 1980-1984

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: LGHT GREEN (-) N ETHER KCK PANEL
Dome
Lights/Superv:
WHTE (-) PN SWTCH OR AT COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL**
Power Unlock: BLACK DRVER'S KCK PANEL**
Trunk Release: BLACK (+) AT RELEASE SWTCH #231
Alarm nput Wire: WHTE (-) PN SWTCH OR AT COURTESY LGHT

NOTES: ** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 13 of 80

Make: Model: Year:
CadiIIac Coupe DeviIIe 1985


FUNCTON COLOR LOCATON
Start: PURPLE GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN AT LGHT
SWTCH
OR DARK GREEN AT FUSE BOX (+)
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Throttle Body njection.

CadiIIac Coupe DeviIIe 1985

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: LGHT GREEN (-) N ETHER KCK PANEL
Dome
Lights/Superv:
WHTE (-) PN SWTCH OR AT COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL**
Power Unlock: BLACK DRVER'S KCK PANEL**
Trunk Release: BLACK (+) AT RELEASE SWTCH
Alarm nput Wire: WHTE (-) PN SWTCH OR AT COURTESY LGHT

NOTES: ** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 14 of 80

Make: Model: Year:
CadiIIac Coupe DeviIIe 1986-1989


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: LGHT BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN AT LGHT
SWTCH
OR DARK GREEN AT FUSE BOX (+)
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Throttle Body njected.

CadiIIac Coupe DeviIIe 1986-1989

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: LGHT GREEN (-) DRVER KCK PANEL
Dome
Lights/Superv:
WHTE (-) PN SWTCH OR AT COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL**
Power Unlock: BLACK DRVER'S KCK PANEL**
Trunk Release: BLACK (+) AT RELEASE SWTCH
Alarm nput Wire: WHTE (-) PN SWTCH OR AT COURTESY LGHT

NOTES: ** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 15 of 80

Make: Model: Year:
CadiIIac Coupe DeviIIe 1990-1991


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS**
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: LGHT BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) LGHT SWTCH OR DMMER SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Throttle Body njected Engine. **May be equipped with VATS - See Note #237

CadiIIac Coupe DeviIIe 1990-1991

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: LGHT GREEN (-) DRVER KCK PANEL
Dome
Lights/Superv:
WHTE (-) PN SWTCH OR AT COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL**
Power Unlock: BLACK DRVER'S KCK PANEL**
Trunk Release: BLACK (+) AT RELEASE SWTCH
Alarm nput Wire: WHTE (-) PN SWTCH OR AT COURTESY LGHT

NOTES: ** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 16 of 80

Make: Model: Year:
CadiIIac Coupe DeviIIe 1992-1993


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS*
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: LGHT BLUE (+) SWTCH ON BRAKE PEDAL BRACKET
Tach Signal: WHTE AT DSTRBUTOR
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) HEADLGHT SWTCH OR BEAM SELECT
SW.
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * This Vehicle s Equipped With GM's Anti-Theft System; See Note #237.

CadiIIac Coupe DeviIIe 1992-1993

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: LGHT GREEN (-)
ETHER
KCK PANEL (NEGATVE TRGGER
DSARMS)
Dome
Lights/Superv:
WHTE (-) DRVER KCK PANEL LT BLUE ALSO
WORKS
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: LGHT BLUE DRVER'S KCK PANEL**
Power Unlock: BLACK DRVER'S KCK PANEL**
Trunk Release: BLACK (+) RELEASE SW. OR REAR BODY HARNESS
#231
Alarm nput Wire: WHTE (-) DRVER KCK PANEL LT BLUE ALSO
WORKS

NOTES: ** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 17 of 80

Make: Model: Year:


CadiIIac CTS 2003


FUNCTON COLOR LOCATON
Start: Yellow (+) gnition switch harness*
gnition #1: Pink gnition switch harness
gnition #2: N/A
gnition #3: N/A
Accessory: Orange (+) gnition swith harness
Brake Light: Lt.Blue/White (+) Brake switch
Tach Signal: White (+) nstrument cluster
Parking Lights: Brown/White (-) Brown plug in module located under the glove
box.
Headlights: No info. available
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * This Vehicle s Equipped With GM's PASSKEY Anti-Theft System; See Note #144 -
Bypassing Transponder Type Theft System Diagram. To program additional keys for GM
PASSK-KEY please See Note #147.

CadiIIac CTS 2003

FUNCTON COLOR LOCATON
Constant +12 Volts: Red/White gnition switch harness
OEM Alarm Disarm: Lt.Green (-) Drivers door module in door
Dome
Lights/Superv:
Tan (-) Please see note below**
OEM Horn: Tan (-) Gray plug in module under the glove box.
Power Lock: Orange/Black (-) nside Drivers Door
Power Unlock: Orange/Gray (-) nside Driver Door
Trunk Release: Lt.Blue (-) Red plug in module on the passenger side
rear deck.
Alarm nput Wire: Tan (-) Please see note below**

NOTES: The vehicle is equipted with individual door triggers for each door. Driver's door is Tan.
The Right Rear door is Drk. Blue/White. The The Passengers side is Lt. Green. The door behind
the Drivers door is Yellow/Black, Diode isolate each door trigger.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 18 of 80

CadiIIac CTS 2004-2006



FUNCTION COLOR LOCATION
Start: YELLOW GNTON SWTCH HARNESS *
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: BROWN GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS
Brake Light: WHTE (+) UNDER REAR SEAT FUSE
BOX

Tach Signal: WHTE ECM **
Parking Lights: BROWN/WHTE (-) BROWN PLUG AT DM ***
Headlights:
OEM Alarm
Disarm:
LT. GREEN (-) NSDE DRVER'S DOOR
OEM Alarm Arm:
Diesel Glow Plug: N/A
Clutch Bypass
Wire:
N/A
Notes: * This Vehicle s Equipped With GM's PassKey Anti-
Theft System, Use a universal alarm bypass module. ** ECM
(Engine Control Module) is under the cover passenger side.
*** DM (Dash ntegration Module) is found under the glove
box.

CadiIIac CTS 2004-2005

FUNCTION COLOR LOCATION
Constant +12
Volts:
RED/WHTE GNTON SWTCH HARNESS
Starter Kill: YELLOW GNTON SWTCH HARNESS *
gnition +12 Volts: PNK GNTON SWTCH HARNESS
Dome
Lights/Superv:
GRAY (-) COURTESY LGHT
OEM Horn: TAN (-) GRAY PLUG AT DM ***
Power Lock: N/A
Power Unlock: N/A
Trunk Release:
Alarm nput Wire: GRAY (-) COURTESY LGHT
Notes:
*** DM (Dash ntegration Module) is found under the
glove box.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 19 of 80

DEVILLE 1987 -1989



KEY T-HARNESS MMOBLZER
N/A N/A N/A

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
BROWN (+) GNTON SWTCH HARNESS
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + ) BROWN (+) @ HEADLGHT SWTCH
POWER LOCK LGHT BLUE (TYPE A) N ETHER KCK PANEL
POWER UNLOCK
BLACK or BLACK/BLUE (TYPE
A)
N ETHER KCK PANEL
DOOR TRGGER LGHT BLUE (-) @ DOOR PN SWTCH
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE BLACK (+) @ TRUNK RELEASE SWTCH
SLDNG POWER DOOR N/A
HORN BLACK (-)
@ STEERNG COLUMN
HARNESS
TACH PURPLE/WHTE
@ GNTON COL or
DSTRBUTOR
WAT TO START LGHT N/A
BRAKE WHTE (+)
@ SWTCH ABOVE BRAKE

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 20 of 80
PEDAL
FACTORY ALARM DSARM LGHT GREEN (-) N DRVERS KCK PANEL
ANT-THEFT N/A

EXTRA NFORMATON




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 21 of 80

DEVILLE 1990 -1993



KEY
T-
HARNE
SS
MMOBLZER
N/A GM-2
GM's VATS ANT-THEFT System (if Equipped, gnition Key has Chip) Requires Bypass
Module

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + ) BROWN (+)
@ HEADLGHT SWTCH or in
DRVERS KCK PANEL
POWER LOCK LGHT BLUE (TYPE A) N ETHER KCK PANEL
POWER UNLOCK BLACK (TYPE A) N ETHER KCK PANEL
DOOR TRGGER LGHT BLUE (-)
@ ANT-THEFT MODULE, See
NOTE *1
DOMELGHT SUPERVSON WHTE (-) @ UNDER DASH LGHT
TRUNK RELEASE BLACK (+) @ TRUNK RELEASE SWTCH
SLDNG POWER DOOR N/A
HORN BLACK (-)
@ STEERNG COLUMN
HARNESS
TACH PURPLE/WHTE or WHTE
@ GNTON COL or
DSTRBUTOR

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 22 of 80
WAT TO START LGHT N/A
BRAKE LGHT BLUE (+) or WHTE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM LGHT GREEN (-) N DRVERS KCK PANEL
ANT-THEFT
2 WHTE wires or 1 WHTE and
1 PURPLE or PURPLE/WHTE
in an ORANGE or BLACK
TUBE in RUNNNG DOWN
STEERNG COLUMN
GM's VATS System @ gnition
Switch

EXTRA NFORMATON
SPECAL NOTE!!!! f vehicle is equipped with PASSKEY/VATS, gnition Key will have a little Chip on
the Steel Shaft of the Key that can be seen. NOTE *1 the ANT-THEFT Module is located to the LEFT
of the STEERNG COLUMN.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 23 of 80

CadiIIac DeviIIe 1994




FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS*
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: LGHT BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal:
WHTE OR
PURPLE/WHTE
AT GNTON MODULE
Parking Lights: BROWN (+) REAR BODY HARN'S N DRVER KCK
PANEL
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * This Vehicle s Equipped With GM's Anti-Theft System; See Note #237.

CadiIIac DeviIIe 1994

FUNCTON COLOR LOCATON
Constant +12 Volts: RED/WHTE AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: LGHT GREEN (-) N ETHER KCK PANEL
Dome
Lights/Superv:
DARK BLUE (-) KCK PANEL OR HEADLGHT SWTCH **
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: RED/BLACK DRVER'S KCK PANEL ***
Power Unlock: WHTE DRVER'S KCK PANEL ***
Trunk Release: BLACK/WHTE (+) AT RELEASE RELAY
Alarm nput Wire: DARK BLUE (-) KCK PANEL OR HEADLGHT SWTCH **

NOTES: ** BLUE/WHTE (-) Wire At Courtesy Light Can Also Be Used For Door Trigger. ***
Without OEM Keyless Entry Door Locks Are- L BLUE (Lock) & WHTE (Unlock) n Driver Kick
Panel, See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 24 of 80

Make: Model: Year:
CadiIIac DeviIIe 1995-1999


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS**
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: LGHT BLUE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS
Brake Light: L BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT POWERTRAN CONTROL MODULE *
Parking Lights: DK. BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Powertrain Control Module (PCM) Located On Driver Front Of Engine Under Air Filter.
** This Vehicle s Equipped With GM's VATS Anti-Theft System; See Note #237.

CadiIIac DeviIIe 1995-1999

FUNCTON COLOR LOCATON
Constant +12 Volts: RED (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: L GREEN (-) DRVER KCK PANEL
Dome
Lights/Superv:
D BLUE/WHTE (-) AT COURTESY LGHT ***
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: RED/BLACK DRVER'S KCK PANEL****
Power Unlock: ORANGE/BLACK DRVER'S KCK PANEL****
Trunk Release: BLACK AT TRUNK RELEASE SWTCH
Alarm nput Wire: D BLUE/WHTE (-) AT COURTESY LGHT ***

NOTES: *** Optional Door Trigger At Body Control Module On Passenger Side Of Trunk, TAN
(Dr) (-), D BLUE/WHTE (Ps) (-) & ORANGE (Rear Doors) (-). Diode solation Needed Cathode
(Band Side) Of Diode Faces OEM Wires. **** See Note #201 - Negative Pulse Door Lock
Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 25 of 80

Make: Model: Year:
CadiIIac DeViIIe 2000-2003


FUNCTON COLOR LOCATON
Start: YELLOW OR PURPLE GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS*
gnition #2: WHTE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: ORANGE & BROWN GNTON SWTCH HARNESS
Brake Light: WHTE LOW N DRVER'S KCK PANEL
Tach Signal: PURPLE/WHTE AT COL ON TOP OF MOTOR
Parking Lights: BROWN/WHTE (-) AT DM MODULE NEXT TO FAN MOTOR
NEAR PASS. KCK **
Headlights: WHTE (-) AT DM MODULE NEXT TO FAN MOTOR
NEAR PASS. KCK**
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A

NOTES: * This Vehicle s Equipped With GM's PassKey Anti-Theft System, a universal alarm
bypass module. *** Module s Located Above Speaker nside Of Driver's Door. To program
additional keys for GM PASSK-KEY please See Note #147.

CadiIIac DeViIIe 2000-2003

FUNCTON COLOR LOCATON
Constant +12 Volts: ORANGE OR
ORANGE/BLACK
GNTON SWTCH HARNESS
OEM Alarm Disarm: LT. GREEN (-) AT DRVER'S DOOR LOCK MODULE ***
Dome
Lights/Superv:
GRAY (-) AT COURTESY LGHT UNDERNEATH DASH
OEM Horn: BLACK (-) AT DM MODULE NEXT TO FAN MOTOR
NEAR PASS. KCK**
Power Lock: RED/BLACK (-) DRVER'S DOOR LOCK SWTCH***
Power Unlock: ORANGE/BLACK (-) DRVER'S DOOR LOCK SWTCH***
Trunk Release: BLACK/WHTE (-) UNDERNEATH REAR SEAT
Alarm nput Wire: GRAY (-) AT COURTESY LGHT UNDERNEATH DASH

NOTES: ** The DM Module Has Three Plugs Coming Out Of The Bottom Of The Module With
All Plugs Except The Horn Wire Coming Out Of The Middle Plug. Horn Wire s Located n Plug
Closest To Passenger Side Of Vehicle. *** Negative Trigger Door Locks - See Note #201



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 26 of 80

CadiIIac DeviIIe 2004-2005

FUNCTON COLOR LOCATON
Start: Yellow (+) gnition switch harness
gnition #1: Pink (+) gnition switch harness
gnition #2: White (+) gnition switch harness
gnition #3: Orange (+) gnition switch harness (must
use relay)

Accessory: Brown (+) gnition switch harness
Brake Light: White (+) Switch above pedal
Tach Signal:
White AC Behind instrument cluster in
green plug

Parking Lights: brown/white (-) Behind switch (must use relays)
Headlights: N/a
Diesel Glow Plug: N/a
Clutch Bypass
Wire:
N/a
Notes: This vehicle is equipped with a Passkey anti-
theft system. We recommend the use of a universal
alarm bypass module.

CadiIIac DeviIIe 2004-2005

FUNCTON COLOR LOCATON
Constant +12
Volts:
Orange (+) gnition switch harness
OEM Alarm
Disarm:
Lt.green (-) Drivers door module, gray plug
Dome
Lights/Superv:

OEM Horn: Black (-) Steering column harness
Power Lock: Red/black (-) Drivers door module
Power Unlock: Orange/black (-) Drivers door module
Trunk Release: Lt.blue (-) At trunk relay
Alarm nput Wire:
Notes:



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 27 of 80

DTS 2006

KEY T-HARNESS MMOBLZER
N/A N/A GM'S PASSKEY 3+

FUNCTON COLOR LOCATON
12 VOLT CONSTANT Connect to BATTERY ONLY
STARTER
YELLOW (Not for Remote
Starting)
@ ECM, BLUE Plug, Pin 26,
See NOTE *1
STARTER 2 N/A
GNTON 1 PNK (+)
@ GNTON SWTCH
HARNESS or BCM, Connector
C1, Pin 14, See NOTE *2
GNTON 2 See NOTE *3
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BROWN (+)
@ GNTON SWTCH
HARNESS or BCM, Connector
C1, Pin 21, See NOTE *2
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) LGHT BLUE (-)
@ HEADLGHT SWTCH or
BCM, Connector C2, Pin 8, See
NOTE *1
PARKNG LGHTS ( + )
PURPLE (+) LEFT and
BROWN/WHTE (+) RGHT,
USE BOTH wires, will require
(2) extra Relays,
N PASSENGER KCK PANEL,
Harness to REAR of vehicle.
POWER LOCK N/A
POWER UNLOCK N/A
DOOR TRGGER See NOTE *4
DOMELGHT SUPERVSON GRAY/BLACK (+)
N PASSENGER KCK PANEL
or BCM, Connector C6, Pin 1,
See NOTE *1
TRUNK RELEASE LGHT BLUE (-)
@ TRUNK RELEASE SWTCH
or BCM, Connector C2, Pin 10,

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 28 of 80
See NOTE *1
SLDNG POWER DOOR N/A
HORN YELLOW to TAN (-)
@ HORN SWTCH or BCM,
BROWN Plug, Pin 18, See
NOTE *1
TACH
NOT PNK/GRAY or
PNK/BLACK
@ Any FUEL-NJECTOR
WAT TO START LGHT N/A
BRAKE
LGHT BLUE (+) or
YELLOW/WHTE (+)
N PASSENGER KCK PANEL
or BCM, BROWN Plug, Pin 5,
See NOTE *1
FACTORY ALARM DSARM
LGHT GREEN (-) test while
turning the Key in the Drivers
Door
@ DRVERS DOOR MODULE
in DRVERS DOOR, BROWN
Plug
ANT-THEFT
GM's PASSKEY 3 (PK3 on
Steel Shaft of gnition Key)
TRANSPONDER SYSTEM
@ GNTON SWTCH
TUMBLER

EXTRA NFORMATON
NOTE *1 the ECM (Engine Control Module) is in the DRVERS SDE of the ENGNE Compartment, in
the Air Cleaner Assembly. NOTE *2 the BCM (Body Control Module) is located behind the Glove Box
and to the RGHT. NOTE *3 There is a WHTE wire and a WHTE/BLACK wire in the GNTON
HARNESS or the BCM, C1, Pins 2 and 4 that work as the Starter, and Second gnition, at this time
there is no information on if these wires will need to be wired in for the New Passlock system as
needed on the Chevy Cobalt. check back for more information in the near future!!! NOTE *4 The
DRVERS DOOR is a GRAY/BLACK (-) at the DRVERS DOOR MODULE in the DRVERS DOOR,
BROWN Plug, the PASSENGER DOOR is a TAN/WHTE (-) at the PASSENGER DOOR MODULE,
in the PASSENGER DOOR, BROWN Plug, the DRVERS REAR DOOR is a BLUE/BLACK (-) at the
BCM, C6, Pin 15 and the PASSENGER REAR DOOR is a LGHT GREEN/BLACK (-) at the BCM,
C6, Pin 14, when connecting to an Alarm System, use all (4) wires and Diode solate.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 29 of 80

Make: Model: Year:
CadiIIac EIdorado 1978-1985


FUNCTON COLOR LOCATON
Start: PURPLE GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE REDAL
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN AT LGHT
SWTCH
OR DARK GREEN AT FUSE BOX (+)
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Throttle Body njected Engine.

CadiIIac EIdorado 1978-1985

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: LGHT GREEN (-) STEERNG COLUMN HARNESS
Dome
Lights/Superv:
WHTE (-) PN SWTCH OR AT COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL**
Power Unlock: BLACK DRVER'S KCK PANEL**
Trunk Release: BLACK (+) AT RELEASE SWTCH
Alarm nput Wire: WHTE (-) PN SWTCH OR AT COURTESY LGHT

NOTES: * See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 30 of 80

Make: Model: Year:
CadiIIac EIdorado 1986-1989


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: DARK BLUE/WHTE GNTON SWTCH HARNESS (ECM)
gnition #3: PURPLE/WHTE GNTON SWTCH HARNEES (HEAT/AC)
Accessory: ORANGE GNTON HARNESS HARNESS
Brake Light: LGHT BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN AT LGHT
SWTCH
OR DARK GREEN AT FUSE BOX (+)
Headlights: YELLOW (+) GNTON SWTCH HARNESS
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Throttle Body njected Engine.

CadiIIac EIdorado 1986-1989

FUNCTON COLOR LOCATON
Constant +12 Volts: RED/WHTE AND RED
(3)
GNTON SWTCH HARNESS
OEM Alarm Disarm: LGHT GREEN (-) DRVER KCK PANEL
Dome
Lights/Superv:
WHTE (-) PN SWTCH OR AT COURTESY LGHT
OEM Horn: BLCK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL**
Power Unlock: BLACK DRVER'S KCK PANEL**
Trunk Release: BLACK (+) AT SWTCH
Alarm nput Wire: WHTE (-) PN SWTCH OR AT COURTESY LGHT

NOTES: ** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 31 of 80

Make: Model: Year:
CadiIIac EIdorado 1990-1991


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS*
gnition #2: DARK BLUE/WHTE GNTON SWTCH HARNESS *
gnition #3: ORANGE GNTON SWTCH HARNESS *
Accessory: BROWN GNTON HARNESS
Brake Light: LGHT BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * There Are 4 gnitions Total To Be Powered By Remote Start Unit. gnition #1- PNK
(Primary gnition). gnition #2- D BLUE/WHTE (Engine Control Module). ngition #3- ORANGE
(Heat/Ac). gnition #4- PURPLE/WHTE (Heat/Ac).

CadiIIac EIdorado 1990-1991

FUNCTON COLOR LOCATON
Constant +12 Volts: RED/WHTE AND RED
(3)
GNTON SWTCH HARNESS
OEM Alarm Disarm: LGHT GREEN (-) DRVER KCK PANEL
Dome
Lights/Superv:
WHTE (-) N SWTCH OR AT COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL*
Power Unlock: BLACK DRVER'S KCK PANEL*
Trunk Release: BLACK (-) AT RELEASE SWTCH
Alarm nput Wire: WHTE (-) N SWTCH OR AT COURTESY LGHT

NOTES: * See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 32 of 80

Make: Model: Year:
CadiIIac EIdorado 1992-1993


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: LGHT BLUE (+) AT SWTCH ON BRAKE PEDAL SUPPORT
Tach Signal: WHTE AT DSTRBUTOR
Parking Lights: BROWN (+) DRVER KCK PANEL
Headlights: YELLOW (+) BEAM SELECT SWTCH OR AT RELAY
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

CadiIIac EIdorado 1992-1993

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: LGHT GREEN (-) DRVER KCK PANEL
Dome
Lights/Superv:
GRAY/BLACK (-) DRVER KCK PANEL
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: LGHT BLUE DRVER'S KCK PANEL*
Power Unlock: BLACK DRVER'S KCK PANEL*
Trunk Release: BLACK (+) RELEASE SW. OR DRVER KCK PANEL
Alarm nput Wire: GRAY/BLACK (-) DRVER KCK PANEL

NOTES: * See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 33 of 80

Make: Model: Year:
CadiIIac EIdorado 1994


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS*
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: LGHT BLUE (+) SWTCH ON BRAKE PEDAL SUPPORT
Tach Signal:
WHTE OR
PURPLE/WHTE
AT GNTON MODULE
Parking Lights: BROWN (+) REAR BODY HARNESS N DRVER KCK
PAN.
Headlights: YELLOW (-) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * This Vehicle s Equipped With GM's Anti-Theft System; See Note #237.

CadiIIac EIdorado 1994

FUNCTON COLOR LOCATON
Constant +12 Volts: RED/WHTE AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: LGHT GREEN (-) N ETHER KCK PANEL
Dome
Lights/Superv:
DARK BLUE (-) DRVER KCK PANEL **
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: LT. BLUE DRVER'S KCK PANEL ***
Power Unlock: WHTE DRVER'S KCK PANEL ***
Trunk Release: BLACK/WHTE (+) RELEASE SW. OR REAR BODY HARNESS
Alarm nput Wire: DARK BLUE (-) DRVER KCK PANEL **

NOTES: ** BLUE/WHTE (-) Wire At Courtesy Light Can Also Be Used For Door Trigger. ***
Without OEM Keyless Entry Door Locks Are- L BLUE (Lock) & WHTE (Unlock) n Driver Kick
Panel, See Note #202 - Positive Pulse Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 34 of 80
Make: Model: Year:
CadiIIac EIdorado 1995-1996


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS**
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: LGHT BLUE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS
Brake Light: L BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT POWERTRAN CONTROL MODULE *
Parking Lights: GRAY/BLACK (-) AT HEADLGHT SWTCH ***
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Powertrain Control Module (PCM) Located On Driver Front Of Engine Under Air Filter.
** This Vehicle s Equipped With GM's Anti-Theft System; See Note #237.

CadiIIac EIdorado 1995-1996

FUNCTON COLOR LOCATON
Constant +12 Volts: RED (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: L GREEN (-) DRVER KCK PANEL
Dome
Lights/Superv:
D BLUE/WHTE (-) AT COURTESY LGHT ****
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LT. BLUE DRVER'S KCK PANEL*****
Power Unlock: WHTE DRVER'S KCK PANEL*****
Trunk Release: YELLOW (-) AT TRUNK RELEASE SWTCH
Alarm nput Wire: D BLUE/WHTE (-) AT COURTESY LGHT ****

NOTES: *** GRAY/BLACK (-) At Headlight Switch s Output From Switch To Parklight Relay.
PURPLE (+) s From Relay To Park Lights. **** Optional Door Trigger At Body Control Module
On Passenger Side Of Trunk, TAN (Dr) (-), D BLUE/WHTE (Ps) (-). Diode solation Needed
Cathode (Band) Side Of Diode Faces OEM Wires. ***** See Note #202 - Positive Pulse Door
Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 35 of 80

Make: Model: Year:
CadiIIac EIdorado 1997-1998


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS**
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: LGHT BLUE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS
Brake Light: L BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT POWERTRAN CONTROL MODULE *
Parking Lights: GRAY/BLACK (-) AT HEADLGHT SWTCH ***
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Powertrain Control Module (PCM) Located On Driver Front Of Engine Under Air Filter.
** This Vehicle s Equipped With GM's Anti-Theft System; See Note #237.

CadiIIac EIdorado 1997-1998

FUNCTON COLOR LOCATON
Constant +12 Volts: RED (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: L GREEN (-) DRVER KCK PANEL
Dome
Lights/Superv:
D BLUE/WHTE (-) AT COURTESY LGHT ****
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: RED/BLACK (-) DRVER'S KCK PANEL*****
Power Unlock: ORANGE/BLACK (-) DRVER'S KCK PANEL*****
Trunk Release: YELLOW (-) AT TRUNK RELEASE SWTCH
Alarm nput Wire: D BLUE/WHTE (-) AT COURTESY LGHT ****

NOTES: *** GRAY/BLACK (-) At Headlight Switch s Output From Switch To Parklight Relay.
PURPLE (+) s From Relay To Park Lights. **** Optional Door Trigger At Body Control Module
On Passenger Side Of Trunk, TAN (Dr) (-), D BLUE/WHTE (Ps) (-). Diode solation Needed
Cathode (Band) Side Of Diode Faces OEM Wires. ***** See Note #202.positive door lock
diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 36 of 80
Make: Model: Year:
CadiIIac EIdorado 1999-2002


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS**
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: LGHT BLUE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS
Brake Light: L BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT POWERTRAN CONTROL MODULE *
Parking Lights: GRAY/BLACK (-) AT HEADLGHT SWTCH ***
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: ** This Vehicle s Equipped With GM's PassKey Anti-Theft System, See nstallation
Note #144 - Bypassing Transponder Theft Systems. To program additional keys for GM PASSK-
KEY please See Note #147.

CadiIIac EIdorado 1999-2002

FUNCTON COLOR LOCATON
Constant +12 Volts: RED (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: L GREEN (-) DRVER KCK PANEL
Dome
Lights/Superv:
D BLUE/WHTE (-) AT COURTESY LGHT ****
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: RED/BLACK (-) DRVER'S KCK PANEL*****
Power Unlock: ORANGE/BLACK (-) DRVER'S KCK PANEL*****
Trunk Release: YELLOW (-) AT TRUNK RELEASE SWTCH
Alarm nput Wire: D BLUE/WHTE (-) AT COURTESY LGHT ****

NOTES: *** GRAY/BLACK (-) At Headlight Switch s Output From Switch To Parklight Relay.
PURPLE (+) s From Relay To Park Lights. **** Optional Door Trigger At Body Control Module
On Passenger Side Of Trunk, TAN (Dr) (-), D BLUE/WHTE (Ps) (-). Diode solation Needed
Cathode (Band) Side Of Diode Faces OEM Wires. ***** See Note #202.positive door lock
diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 37 of 80

Make: Model: Year:
CadiIIac EscaIade 1999


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS *
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: WHTE GNTON SWTCH HARNESS (ECM)
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS (HEAT/AC) **
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE
AT COL ON PASSENGER REAR OF
ENGNE
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * 1998+ Vehicles Are Equipped With GM's PASSLOCK Anti-Theft System; See Note
#113 - Bypassing GM's PASSLOCK Passive Theft System Diagram. ** See Note #233 - High
Current gnition Wires Diagram.

CadiIIac EscaIade 1999

FUNCTON COLOR LOCATON
Constant +12 Volts: RED (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A N SCHEMATCS
Dome
Lights/Superv:
PURPLE (-) 4 PN BLACK CONN. N DR. KCK PANEL***
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: L BLUE DRVER'S KCK PANEL ****
Power Unlock: WHTE DRVER'S KCK PANEL ****
Trunk Release: N/A
Alarm nput Wire: PURPLE (-) 4 PN BLACK CONN. N DR. KCK PANEL***

NOTES: *** PURPLE (-) Wire Also Located At Headlight Switch. See Tech Notes For Additional
nformation On Dome Light. **** 2 Door Without OEM Keyless Entry See Note #203 - Reverse
Polarity Door Lock Diagram. 2 Door With OEM Keyless Entry See Note #202 - Positive Pulse
Door Lock Diagram. 4 Door With Or Without OEM Keyless See Note #202 - Positive Pulse Door
Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 38 of 80

Make: Model: Year:
CadiIIac EscaIade 2000-2006


FUNCTON COLOR LOCATON
Start: YELLOW (+) GNTON SWTCH HARNESS
gnition #1: PNK (+) GNTON SWTCH HARNESS*
gnition #2: WHTE (+) GNTON SWTCH HARNESS(ECM)
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS (HEAT/AC)
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: VOLET/WHTE
AT PLUG ABOVE VALVE COVER ON DR.
SDE
Parking Lights: BROWN (+) AT HEADLGHT SWTCH OR 12 PN PLUG
AT FUSE PANEL
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A

NOTES: * This Vehicle s Equipped With GM's PASSLOCK Anti-Theft System. Use a universal
alarm bypass module or see Note #113

CadiIIac EscaIade 2000-2006

FUNCTON COLOR LOCATON
Constant +12 Volts: RED & RED/WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: LT.GREEN (-) N FLAT CONNECTOR N DR. KCK PANEL
OR DRVERS DOOR MODULE N DOOR
Dome
Lights/Superv:
WHTE AT PLUG N CONVENENCE CENTER **
OEM Horn: BLACK (-) OR
BLACK/YELLOW
STEERNG COLUMN HARNESS
Power Lock: See Note See Note***
Power Unlock: See Note See Note***
Trunk Release: N/A
Alarm nput Wire: WHTE AT PLUG N CONVENENCE CENTER **

NOTES: ** Convenience Center s Locate Under Driver's Dash Near Fire Wall (Listen for dome
light relay). *** See Note #202 - Positive Pulse Door Lock Diagram. For 2000-2002 use Lt.Blue
(lock) White (unlock)in brown plug of body control module. 2003 VEHCLE USE A MULTPLEX
WRNG SYSTEM.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 39 of 80
ESCALADE 2007

KEY
T-
HARNES
S
MMOBLZER
N/A N/A GM's PASSKEY 3 TRANSPONDER ANT-THEFT SYSTEM and gnition Key

FUNCTON COLOR LOCATON
12 VOLT CONSTANT (2) RED/BLACK (+) @ FUSE BOX
STARTER WHTE (+) See NOTE *1
@ GNTON SWTCH
HARNESS or BCM, LGHT
GREEN Plug, Pin 4 See NOTE
*2
STARTER 2 N/A
GNTON 1 PNK (+)
@ GNTON SWTCH
HARNESS or BCM, LGHT
GREEN Plug, Pin 14 See NOTE
*2
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BROWN (+)
@ GNTON SWTCH
HARNESS or BCM, LGHT
GREEN Plug, Pin 21 See NOTE
*2
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) LGHT BLUE (-)
@ HEAD LGHT Switch or
BCM, NATURAL Plug, Pin 8
See NOTE *2
PARKNG LGHTS ( + )
BROWN (+) Left and BROWN
(+) Right
@ UNDER HOOD FUSE BOX,
BLACK 30-Pin Plug
POWER LOCK No nformation at this time!!
POWER UNLOCK No nformation at this time!!
DOOR TRGGER See NOTE *3
DOMELGHT SUPERVSON GRAY (+)
@ BCM, NATURAL Plug, Pin 5
See NOTE *2

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 40 of 80
TRUNK RELEASE
PNK (-) Glass and GRAY (-)
Gate See NOTE *4
@ BCM, PNK Plug, Pins 24
and 13 See NOTE *2
SLDNG POWER DOOR N/A
HORN TAN (-)
@ HORN Switch or BCM,
BROWN Plug, Pin 18 See
NOTE *2
TACH NOT PNK, BROWN or BLACK
@ ANY FUEL-NJECTOR or
GNTON COL
WAT TO START LGHT N/A
BRAKE LGHT BLUE/WHTE (+)
@ SWTCH ABOVE BRAKE or
BCM, BROWN Plug, Pin 6, See
NOTE *2
FACTORY ALARM DSARM LGHT GREEN (-)
@ DRVERS DOOR MODULE,
BROWN 16-Pin Plug, Pin 4
ANT-THEFT
GM's PK3 TRANSPONDER
ANT-THEFT SYSTEM,
Requires Bypass Module and
Extra Programmed gnition Key
@ GNTON SWTCH
TUMBLER

EXTRA NFORMATON
NOTE *1 The STARTER 1 wire, requires a (+) POSTVE thru a 1300 OHM Resistor to Start . NOTE
*2 The BCM (Body Control Module) is located to the LEFT of the STEERNG COLUMN. NOTE *3
The DRVERS DOOR TRGGER is a GRAY/BLACK (-) at the DRVERS DOOR MODULE in the
DRVERS DOOR, BROWN 16-Pin Plug, Pin 13, the PASSENGER DOOR TRGER is a
BLACK/WHTE (-) at the PASSENGER DOOR MODULE in the PASSENGER DOOR, BROWN 16-
Pin Plug, Pin 13. The DRVERS REAR DOOR TRGGER is a LGHT BLUE/BLACK (-) PNK Plug, Pin
15 and the PASSENGER REAR DOOR TRGGER is a LGHT GREEN/BLACK (-) PNK Plug, Pin 14
both wires are located in the PNK Plug on the BCM, when connecting to an ALARM SYSTEM use all
(4) FOUR wires and DODE SOLATE, . NOTE *4 TEST these wires while OPENNG the LFTGLASS
and LFTGATE from the HANDLE on the REAR HATCH of the vehicle.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 41 of 80

ESCALADE ESV 2003 -2004

KEY
T-
HARNESS
MMOBLZER
N/A N/A GM's PASSLOCK 2 ANT-THEFT System, Requires Bypass Module

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) and RED/WHTE (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 WHTE (+) See NOTE *5 GNTON SWTCH HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) GRAY/BLACK (-)
@ BCM, BROWN Plug, Pin B2,
See NOTE *1
PARKNG LGHTS ( + ) BROWN (+) N DRVERS KCK PANEL
POWER LOCK See NOTE *2
POWER UNLOCK See NOTE *2
DOOR TRGGER See NOTE *3
DOMELGHT SUPERVSON GRAY/BLACK (+)
@ BCM, BLACK Plug, Pin E,
See NOTE *1
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN BLACK/YELLOW to BLACK (-)
@ BCM, GRAY Plug, Pin B9,
See NOTE *1
TACH WHTE @ PCM See NOTE *4
WAT TO START LGHT N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 42 of 80
BRAKE WHTE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM LGHT GREEN (-)
@ DRVERS DOOR MODULE
in DRVERS DOOR
ANT-THEFT
YELLOW (+), BLACK (-) and
RED/WHTE (Not Used)
GM's PASSLOCK 2 System,
these wires exit the gnition
Switch Tumbler together and
are in the Main gnition Switch
Harness in the Column.

EXTRA NFORMATON
NOTE *1 the BCM is located under the Drivers side of the dash, the unit has (6) plugs, with the
PURPLE Plug on the back. NOTE *2 this vehicle uses a Special Multi-plex Type Door Locking
System that will require extra Relays to do the Door Locks, or you can now get the New EZ-BUS
Module to do the Door Locks without the extra relays on this vehicle, to order contact 1-800-659-
0764. NOTE *3 the DRVERS DOOR wire is a GRAY/BLACK (-) at the DRVERS DOOR module in
the Drivers door, the PASSENGER DOOR wire is a BLACK/WHTE (-) at the PASSENGER DOOR
module in the Passenger door. The DRVERS REAR door is a LGHT BLUE/BLACK (-) Pin A3 and
the PASSENGERS REAR DOOR is a LGHT GREEN/BLACK (-) Pin A2, both wires are at the BCM
PURPLE plug. When connecting to an Alarm System, use all 4 wires and DODE SOLATE. NOTE
*4 the PCM is located at the LEFT front of the ENGNE COMFUNCTONMENT to the LEFT of the
FAN SHROUD. The TACH wire is in a GREEN Plug, Pin 10. NOTE *5 MPORTANT !!!!! this wire
MUST BE CONNECTED as GNTON #2 for REMOTE STARTNG!!!!!!




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 43 of 80

ESCALADE ESV 2005 - 2006



KEY
T-
HARNESS
MMOBLZER
N/A N/A GM's PASSLOCK 2 ANT-THEFT System, Requires Bypass Module

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 WHTE (+) See NOTE *5 GNTON SWTCH HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
BROWN (+) GNTON SWTCH HARNESS
KEYSENSE N/A
PARKNG LGHTS ( - ) GRAY/BLACK (-)
@ BCM, BROWN Plug, Pin B2,
See NOTE *1
PARKNG LGHTS ( + ) BROWN (+) N DRVERS KCK PANEL
POWER LOCK See NOTE *2
POWER UNLOCK See NOTE *2 See DAGRAM
DOOR TRGGER See NOTE *3 @ BCM, See NOTE *1
DOMELGHT SUPERVSON GRAY/BLACK (-) @ BCM, See NOTE *1
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN BLACK/YELLOW to BLACK (-)
@ BCM, GRAY Plug, Pin B9,
See NOTE *1
TACH WHTE @ PCM, See NOTE *4
WAT TO START LGHT N/A
BRAKE WHTE (+)
@ SWTCH ABOVE BRAKE

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 44 of 80
PEDAL
FACTORY ALARM DSARM LGHT GREEN (-)
@ DRVERS DOOR Module in
Drivers door
ANT-THEFT
YELLOW (+), BLACK (-) and
RED/WHTE (Not Used)
GM's PASSLOCK 2 System,
these wires exit the gnition
Switch Tumbler together and
are in the Main gnition Switch
Harness in the Column.

EXTRA NFORMATON
NOTE *1 the BCM is located under the Drivers side of the dash, the unit has (6) plugs, with the
PURPLE Plug on the back. NOTE *2 this vehicle uses a Special Multi-plex Type Door Locking
System that will require extra Relays to do the Door Locks, or you can now get the New EZ-BUS
Module to do the Door Locks without the extra relays on this vehicle, to order contact 1-800-659-
0764. NOTE *3 the DRVERS DOOR wire is a GRAY/BLACK (-) at the DRVERS DOOR module in
the Drivers door, the PASSENGER DOOR wire is a BLACK/WHTE (-) at the PASSENGER DOOR
module in the Passenger door. The DRVERS REAR door is a LGHT BLUE/BLACK (-) Pin A3 and
the PASSENGERS REAR DOOR is a LGHT GREEN/BLACK (-) Pin A2, both wires are at the BCM
PURPLE plug. When connecting to an Alarm System, use all 4 wires and DODE SOLATE. NOTE
*4 the PCM is located at the LEFT front of the ENGNE COMFUNCTONMENT to the LEFT of the
FAN SHROUD. The TACH wire is in a GREEN Plug, Pin 10. NOTE *5 MPORTANT !!!!! this wire
MUST BE CONNECTED as GNTON #2 for REMOTE STARTNG!!!!!!




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 45 of 80

ESCALADE EXT 2002 -



KEY
T-
HARNESS
MMOBLZER
N/A N/A GM's PASSLOCK 2 ANT-THEFT System, Requires Bypass Module

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 WHTE (+) See NOTE *4 GNTON SWTCH HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) WHTE (-)
@ BCM, LGHT BLUE Plug, Pin
A5, See NOTE *1
PARKNG LGHTS ( + ) BROWN (+)
@ BCM, LGHT BLUE Plug, Pin
B6, See NOTE *1
POWER LOCK LGHT BLUE (TYPE B)
@ BCM, BROWN PLug, Pin A4,
See NOTE *1
POWER UNLOCK WHTE (TYPE B)
@ BCM, BROWN Plug, Pin A3,
See NOTE *1
DOOR TRGGER See NOTE *2 @ BCM, See NOTE *1
DOMELGHT SUPERVSON TAN (-)
@ BCM, PURPLE Plug, Pin B4,
See NOTE *1
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN BLACK (-)
@ BCM, BROWN Plug, Pin A9,
See NOTE *1
TACH WHTE @ ECM See NOTE *3

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 46 of 80
WAT TO START LGHT N/A
BRAKE WHTE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM LGHT GREEN (-)
@ BCM, PURPLE Plug, Pin 3,
See NOTE *1
ANT-THEFT
YELLOW (+), ORANGE/BLACK
(-) and RED/WHTE (Not used)
GM's PASSLOCK 2 System,
these wires exit the gnition
Switch Tumbler together and
are in the Main gnition Switch
Harness in the Column.

EXTRA NFORMATON
NOTE *1 the BCM is located UNDER the DRVERS SDE of the dash with the plugs facing the rear of
the vehicle. NOTE *2 the DRVERS DOOR wire is a TAN (-) Pin B4, PURPLE plug at the BCM and
the PASSENGER DOORS are a BLUE/WHTE (-) Pin B11, LGHT BLUE Plug at the BCM. When
connecting to an ALALRM SYSTEM, use both wires and DODE SOLATE. NOTE *3 the ECM is
located near the battery down low between the fender and the fan under the BLACK plastic cover.
The tach wire on the 4.3L engine is in a 20 Pin plug labled RED. On all othe engines the TACH wire
is located at Pin 10 in the RED connector. NOTE *4 MPORTANT !!!!! this wire MUST BE
CONNECTED as GNTON #2 for REMOTE STARTNG!!!!!!




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 47 of 80

ESCALADE EXT 2003 -2004



KEY
T-
HARNESS
MMOBLZER
N/A N/A GM's PASSLOCK 2 ANT-THEFT System, Requires Bypass Module

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) and RED/WHTE (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 WHTE (+) See NOTE *4 GNTON SWTCH HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) GRAY/BLACK (-)
@ BCM, BROWN Plug, Pin B2,
See NOTE *1
PARKNG LGHTS ( + ) BROWN (+) N DRVERS KCK PANEL
POWER LOCK See NOTE *2
POWER UNLOCK See NOTE *2
DOOR TRGGER See NOTE *3 @ BCM, See NOTE *1
DOMELGHT SUPERVSON GRAY/BLACK (-)
@ DRVERS DOOR MODULE
in DOOR
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN BLACK/YELLOW to BLACK (-)
@ BCM, GREY Plug, Pin B9,
See NOTE *1
TACH WHTE @ PCM, See NOTE *4
WAT TO START LGHT N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 48 of 80
BRAKE WHTE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM LGHT GREEN (-)
@ DRVERS DOOR MODULE
in DRVERS DOOR
ANT-THEFT
YELLOW (+), BLACK (-) and
RED/WHTE (Not Used)
GM's PASSLOCK 2 System,
these wires exit the gnition
Switch Tumbler together and
are in the Main gnition Switch
Harness in the Column.

EXTRA NFORMATON
NOTE *1 the BCM is located UNDER the DRVERS SDE of the dash with (6) plugs, with the
PURPLE plug on the back. NOTE *2 this vehicle uses a Special Multi-plex Type Door Locking
System that will require extra Relays to do the Door Locks, or you can now get the New EZ-BUS
Module to do the Door Locks without the extra relays on this vehicle, to order contact 1-800-659-
0764. NOTE *3 the DRVERS DOOR wire is a GRAY/BLACK (-) at the DRVERS DOOR Module in
the DRVERS DOOR and the PASSENGER DOOR is a BLACK/WHTE (-) a the PASSENGER
DOOR Module in the PASSENGER DOOR. The DRVERS SDE REAR DOOR is a LGHT
BLUE/BLACK (-) Pin A3 and the PASSENGER SDE REAR DOOR is a LGHT GREEN/BLACK (-)
Pin A2, both are at the PURPLE plug at the BCM, When connecting to an Alarm System use ALL 4
wires and DODE SOLATE. NOTE *3 the PCM is located at the LEFT front of the ENGNE
COMFUNCTONMENT to the LEFT of the FAN SHROUD. The TACH wire is in a GREEN Plug, Pin
10. NOTE *4 MPORTANT !!!!! this wire MUST BE CONNECTED as GNTON #2 for REMOTE
STARTNG!!!!!!




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 49 of 80

ESCALADE EXT 2005 - 2006



KEY
T-
HARNESS
MMOBLZER
N/A N/A GM's PASSLOCK 2 ANT-THEFT System, Requires Bypass Module

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 WHTE (+) See NOTE *5 GNTON SWTCH HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
BROWN (+) GNTON SWTCH HARNESS
KEYSENSE N/A
PARKNG LGHTS ( - ) GRAY/BLACK (-)
@ BCM, BROWN Plug, Pin B2,
See NOTE *1
PARKNG LGHTS ( + ) BROWN (+) N DRVERS KCK PANEL
POWER LOCK See NOTE *2
POWER UNLOCK See NOTE *2 See DAGRAM
DOOR TRGGER See NOTE *3 @ BCM, See NOTE *1
DOMELGHT SUPERVSON GRAY/BLACK (-) @ BCM, See NOTE *1
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN BLACK/YELLOW to BLACK (-)
@ BCM, GRAY Plug, Pin B9,
See NOTE *1
TACH WHTE @ PCM, See NOTE *4
WAT TO START LGHT N/A
BRAKE WHTE (+)
@ SWTCH ABOVE BRAKE

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 50 of 80
PEDAL
FACTORY ALARM DSARM LGHT GREEN (-)
@ DRVERS DOOR Module in
Drivers door
ANT-THEFT
YELLOW (+), BLACK (-) and
RED/WHTE (Not Used)
GM's PASSLOCK 2 System,
these wires exit the gnition
Switch Tumbler together and
are in the Main gnition Switch
Harness in the Column.

EXTRA NFORMATON
NOTE *1 the BCM is located UNDER the DRVERS SDE of the dash with (6) plugs, with the
PURPLE plug on the back. NOTE *2 this vehicle uses a Special Multi-plex Type Door Locking
System that will require extra Relays to do the Door Locks, or you can now get the New EZ-BUS
Module to do the Door Locks without the extra relays on this vehicle, to order contact 1-800-659-
0764. NOTE *3 the DRVERS DOOR wire is a GRAY/BLACK (-) at the DRVERS DOOR Module in
the DRVERS DOOR and the PASSENGER DOOR is a BLACK/WHTE (-) a the PASSENGER
DOOR Module in the PASSENGER DOOR. The DRVERS SDE REAR DOOR is a LGHT
BLUE/BLACK (-) Pin A3 and the PASSENGER SDE REAR DOOR is a LGHT GREEN/BLACK (-)
Pin A2, both are at the PURPLE plug at the BCM, When connecting to an ALARM SYSTEM, use ALL
4 wires and DODE SOLATE. NOTE *4 the PCM is located at the LEFT front of the ENGNE
COMFUNCTONMENT to the LEFT of the FAN SHROUD. The TACH wire is in a GREEN Plug, Pin
10. NOTE *5 MPORTANT !!!!! this wire MUST BE CONNECTED as GNTON #2 for REMOTE
STARTNG!!!!!!


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 51 of 80

Make: Model: Year:
CadiIIac FIeetwood (RWD) 1980-1985


FUNCTON COLOR LOCATON
Start: PURPLE GNTON SWTCH HARNESS*
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR
Parking Lights: BROWN AT LGHT
SWTCH
OR DARK GREEN AT FUSE BOX (+)
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * See Note #300 - GM Rear Wheel Drive Vehicles

CadiIIac FIeetwood (RWD) 1980-1985

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: LGHT GREEN (-) N ETHER KCKPANEL
Dome
Lights/Superv:
WHTE (-) PN SWTCH OR AT COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL**
Power Unlock: BLACK DRVER'S KCK PANEL**
Trunk Release: BLACK (+) AT RELEASE SWTCH
Alarm nput Wire: WHTE (-) PN SWTCH OR AT COURTESY LGHT

NOTES: ** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 52 of 80

Make: Model: Year:
CadiIIac FIeetwood (RWD) 1986


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS**
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN AT LGHT
SWTCH
OR DARK GREEN AT FUSE BOX (+)
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Throttle Body njected Engine. ** See Note #300 - GM Rear Wheel Drive Vehicles

CadiIIac FIeetwood (RWD) 1986

FUNCTON COLOR LOCATON
Constant +12 Volts: RED OR RED GNTON SWTCH HARNESS
OEM Alarm Disarm: LGHT GREEN (-) N ETHER KCK PANEL
Dome
Lights/Superv:
WHTE (-) PN SWTCH OR AT COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL***
Power Unlock: BLACK DRVER'S KCK PANEL***
Trunk Release: BLACK (+) AT RELEASE SWTCH
Alarm nput Wire: WHTE (-) PN SWTCH OR AT COURTESY LGHT

NOTES: *** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 53 of 80

Make: Model: Year:
CadiIIac FIeetwood (FWD) 1986-1989


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: LGHT BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN AT LGHT
SWTCH
OR DARK GREEN AT FUSE BOX (+)
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Throttle Body njected Engine.

CadiIIac FIeetwood (FWD) 1986-1989

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: LGHT GREEN (-) DRVER KCK PANEL
Dome
Lights/Superv:
WHTE (-) PN SWTCH OR AT COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL**
Power Unlock: BLACK DRVER'S KCK PANEL**
Trunk Release: BLACK (+) AT SWTCH
Alarm nput Wire: WHTE (-) PN SWTCH OR AT COURTESY LGHT

NOTES: ** See Note #202 - Positive Pulse Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 54 of 80

Make: Model: Year:
CadiIIac FIeetwood 1990-1993


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: LGHT BLUE (+) AT SWTCH ON BRAKE PEDAL BRACKET
Tach Signal: WHTE AT DSTRBUTOR
Parking Lights: BROWN (+) HEADLGHT SWTCH OR DRVER KCK
PANEL
Headlights: YELLOW (+) HEADLGHT SWTCH OR BEAM SELECT
SW.
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

CadiIIac FIeetwood 1990-1993

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: LGHT GREEN (-)
ETHER
KCK PANEL (NEGATVE TRGGER
DSARMS)
Dome
Lights/Superv:
WHTE (-) DRVER KCK PANEL LT BLUE ALSO
WORKS
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: LGHT BLUE DRVER'S KCK PANEL*
Power Unlock: BLACK DRVER'S KCK PANEL*
Trunk Release: BLACK (+) RELEASE SW. OR REAR BODY HARNESS
Alarm nput Wire: WHTE (-) DRVER KCK PANEL LT BLUE ALSO
WORKS

NOTES: * See Note #202 - Positive Pulse Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 55 of 80
Make: Model: Year:
CadiIIac FIeetwood 1994-1995


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) SWTCH ON BRACKET ABOVE BRAKE
PEDAL
Tach Signal: PURPLE/WHTE AT DSTRBUTOR
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT RELAY TO LEFT OF
COLUMN
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

CadiIIac FIeetwood 1994-1995

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: LGHT GREEN (-) N ETHER KCK PANEL
Dome
Lights/Superv:
PURPLE (-) AT ""MN-WEDGE"" SWTCH OR
COURTESY LT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: LGHT BLUE AT RELAYS BEHND
Power Unlock: WHTE DRVER KCK PANEL*
Trunk Release: BLACK/WHTE (+) AT RELEASE SWTCH
Alarm nput Wire: PURPLE (-) AT ""MN-WEDGE"" SWTCH OR
COURTESY LT

NOTES: * See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 56 of 80

Make: Model: Year:
CadiIIac FIeetwood 1996


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS**
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT POWERTRAN CONTROL MODULE *
Parking Lights: PURPLE (+) AT CONVENENCE CENTER MODULE ***
Headlights: YELLOW (+) AT CONVENENCE CENTER MODULE***
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Powertrain Control Module (PCM) Located On Driver Front Of Engine Under Air Filter.
WHTE Wire Located At Pin #13 n 32 Pin Connector At PCM. ** This Vehicle s Equipped With
GM's VATS Anti-Theft System ; See Note #237.

CadiIIac FIeetwood 1996

FUNCTON COLOR LOCATON
Constant +12 Volts: RED (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: L GREEN (-) DRVER KCK PANEL
Dome
Lights/Superv:
PURPLE (-) 10 PN CONNECTOR N DR. KCK PANEL
OEM Horn:
Power Lock: L BLUE DRVER'S KCK PANEL****
Power Unlock: WHTE DRVER'S KCK PANEL****
Trunk Release: BLACK/WHTE (+) AT TRUNK RELEASE SWTCH
Alarm nput Wire: PURPLE (-) 10 PN CONNECTOR N DR. KCK PANEL

NOTES: *** Convenience Center Module Located Behind Driver Dash To Left Of Steering
Column.BROWN/BLACK (-) At Headlight Switch Can Also Be Used For Park Lights. **** See
Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 57 of 80

Make: Model: Year:
CadiIIac Sedan DeviIIe 1978-1985


FUNCTON COLOR LOCATON
Start: PURPLE GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN AT LGHT
SWTCH
OR DARK GREEN AT FUSE BOX (+)
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Throttle Body njected Engine.

CadiIIac Sedan DeviIIe 1978-1985

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: LGHT GREEN (-) N ETHER KCK PANEL
Dome
Lights/Superv:
WHTE (-) PN SWTCH OR AT COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL**
Power Unlock: BLACK DRVER'S KCK PANEL**
Trunk Release: BLACK (+) AT RELEASE SWTCH
Alarm nput Wire: WHTE (-) PN SWTCH OR AT COURTESY LGHT

NOTES: ** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 58 of 80

Make: Model: Year:
CadiIIac Sedan DeviIIe 1986-1989


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE OR LGHT BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRNUTOR *
Parking Lights: BROWN AT LGHT
SWTCH
OR DARK GREEN AT FUSE BOX (+)
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Throttle Body njected Engine.

CadiIIac Sedan DeviIIe 1986-1989

FUNCTON COLOR LOCATON
Constant +12 Volts: RED/WHTE AND RED
(3)
GNTON SWTCH HARNESS
OEM Alarm Disarm: LGHT GREEN (-) N ETHER KCK PANEL
Dome
Lights/Superv:
WHTE (-) PN SWTCH OR AT COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL**
Power Unlock: BLACK DRVER'S KCK PANEL**
Trunk Release: BLACK (+) AT RELEASE SWTCH
Alarm nput Wire: WHTE (-) PN SWTCH OR AT COURTESY LGHT

NOTES: ** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 59 of 80

Make: Model: Year:
CadiIIac Sedan DeviIIe 1990-1991


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: LT. BLUE(+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR
Parking Lights: BROWN (+) AT LGHT SWTCH
Headlights: YELLOW (+) LGHT SWTCH OR BEAM SELECT SW.
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

CadiIIac Sedan DeviIIe 1990-1991

FUNCTON COLOR LOCATON
Constant +12 Volts: RED/WHTE AND RED
(3)
GNTON SWTCH HARNESS
OEM Alarm Disarm: LGHT GREEN (-) DRVER KCK PANEL
Dome
Lights/Superv:
WHTE (-) PN SWTCH OR AT COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL*
Power Unlock: BLACK DRVER'S KCK PANEL*
Trunk Release: BLACK (+) AT SWTCH
Alarm nput Wire: WHTE (-) PN SWTCH OR AT COURTESY LGHT

NOTES: * See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 60 of 80

Make: Model: Year:
CadiIIac Sedan DeviIIe 1992-1993


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS*
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: LGHT BLUE (+) SWTCH ON BRAKE PEDAL BRACKET
Tach Signal: WHTE AT DSTRBUTOR
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) HEADLGHT SWTCH OR BEAM SELECT
SW.
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * This Vehicle s Equipped With GM's Anti-Theft System; See Note #237.

CadiIIac Sedan DeviIIe 1992-1993

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: LGHT GREEN (-)
ETHER
KCK PANEL (NEGATVE TRGGER
DSARMS)
Dome
Lights/Superv:
WHTE (-) DRVER KCK PANEL LT BLUE ALSO
WORKS
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: LGHT BLUE DRVER'S KCK PANEL**
Power Unlock: BLACK DRVER'S KCK PANEL**
Trunk Release: BLACK (+) RELEASE SW. OR REAR BODY HARNESS
#231
Alarm nput Wire: WHTE (-) DRVER KCK PANEL LT BLUE ALSO
WORKS

NOTES: ** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 61 of 80

Make: Model: Year:
CadiIIac SeviIIe 1984-1985


FUNCTON COLOR LOCATON
Start: PURPLE GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN AT LGHT
SWTCH
OR DARK GREEN AT FUSE BOX (+)
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Throttle Body njected Engine.

CadiIIac SeviIIe 1984-1985

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: LGHT GREEN (-) N ETHER KCK PANEL
Dome
Lights/Superv:
WHTE (-) PN SWTCH OR AT COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL**
Power Unlock: BLACK DRVER'S KCK PANEL**
Trunk Release: BLACK (+) AT RELEASE SWTCH
Alarm nput Wire: WHTE (-) PN SWTCH OR AT COURTESY LGHT

NOTES: ** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 62 of 80

Make: Model: Year:
CadiIIac SeviIIe 1986


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: DARK BLUE/WHTE GNTON SWTCH HARNESS (ECM)
gnition #3: PURPLE/WHTE GNTON SWTCH HARNESS (HEAT/AC)
Accessory: ORANGE GNTON HARNESS HARNESS(HEAT/AC)
Brake Light: LGHT BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN AT LGHT
SWTCH
OR DARK GREEN AT FUSE BOX (+)
Headlights: YELLOW (+) HEADLGHT SWTCH OR BEAM SELECT
SW.
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Throttle Body njected Engine.

CadiIIac SeviIIe 1986

FUNCTON COLOR LOCATON
Constant +12 Volts: RED/WHTE AND 3 RED GNTON SWTCH HARNESS
OEM Alarm Disarm: LGHT GREEN (-) DRVER KCK PANEL
Dome
Lights/Superv:
WHTE (-) PN SWTCH OR AT COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL**
Power Unlock: BLACK DRVER'S KCK PANEL**
Trunk Release: BLACK (+) AT SWTCH
Alarm nput Wire: WHTE (-) PN SWTCH OR AT COURTESY LGHT

NOTES: ** See Note #202 - Positive Pulse Door Lock Diagram.




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 63 of 80

SEVILLE 1987 -1988



KEY T-HARNESS MMOBLZER
N/A N/A N/A

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + ) BROWN (+)
@ HEADLGHT SWTCH or in
DRVERS KCK PANEL
POWER LOCK LGHT BLUE (TYPE A) N DRVERS KCK PANEL
POWER UNLOCK BLACK (TYPE A) N DRVERS KCK PANEL
DOOR TRGGER WHTE (-) N DRVERS KCK PANEL
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE BLACK (+) @ TRUNK RELEASE SWTCH
SLDNG POWER DOOR N/A
HORN BLACK (-)
@ STEERNG COLUMN
HARNESS
TACH PURPLE/WHTE or WHTE
@ GNTON COL or
DSTRBUTOR
WAT TO START LGHT N/A
BRAKE LGHT BLUE (+) or WHTE (+)
@ SWTCH ABOVE BRAKE

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 64 of 80
PEDAL
FACTORY ALARM DSARM LGHT GREEN (-) N ETHER KCK PANEL
ANT-THEFT N/A

EXTRA NFORMATON





This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 65 of 80

SEVILLE 1989 -1990



KEY
T-
HARNE
SS
MMOBLZER
N/A N/A
GM's VATS ANT-THEFT System (if Equipped, gnition Key has Chip) Requires Bypass
Module

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + ) BROWN (+) N PASSENGER KCK PANEL
POWER LOCK LGHT BLUE (TYPE A) N DRVERS KCK PANEL
POWER UNLOCK BLACK (TYPE A) N DRVERS KCK PANEL
DOOR TRGGER WHTE (-) @ DOOR PN SWTCH
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE BLACK (+) N PASSENGER KCK PANEL
SLDNG POWER DOOR N/A
HORN BLACK (-)
@ STEERNG COLUMN
HARNESS
TACH WHTE
@ GNTON COL or
DSTRBUTOR
WAT TO START LGHT N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 66 of 80
BRAKE LGHT BLUE (+) or WHTE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM LGHT GREEN (-) N ETHER KCK PANEL
ANT-THEFT
2 WHTE or 1 WHTE and 1
PURPLE, wires are in an
ORANGE tube
GM's VATS System @ gnition
Switch

EXTRA NFORMATON
SPECAL NOTE!!!! f vehicle is equipped with PASSKEY/VATS, gnition Key will have a little Chip on
the Steel Shaft of the Key that can be seen.




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 67 of 80

SEVILLE 1991 -1993



KEY
T-
HARNE
SS
MMOBLZER
N/A N/A
GM's VATS ANT-THEFT System (if Equipped, gnition Key has Chip) Requires Bypass
Module

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 DARK BLUE/WHTE (+) GNTON SWTCH HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) BLUE (-) @ HEADLGHT SWTCH
PARKNG LGHTS ( + ) BROWN (+) LOW in DRVERS KCK PANEL
POWER LOCK LGHT BLUE (TYPE A) N DRVERS KCK PANEL
POWER UNLOCK BLACK (TYPE A) N DRVERS KCK PANEL
DOOR TRGGER GRAY/BLACK (-)
LOW N DRVERS KCK
PANEL
DOMELGHT SUPERVSON DARK BLUE/WHTE (-) @ UNDER DASH LGHT
TRUNK RELEASE BLACK (+) @ TRUNK RELEASE SWTCH
SLDNG POWER DOOR N/A
HORN BLACK (-)
@ STEERNG COLUMN
HARNESS
TACH PURPLE/WHTE or WHTE @ GNTON COL
WAT TO START LGHT N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 68 of 80
BRAKE LGHT BLUE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM LGHT GREEN (-) N ETHER KCK PANEL
ANT-THEFT
2 WHTE or 1 WHTE and 1
PURPLE, wires are in an
ORANGE tube
GM's VATS System @ gnition
Switch

EXTRA NFORMATON
SPECAL NOTE!!!! f vehicle is equipped with PASSKEY/VATS, gnition Key will have a little Chip on
the Steel Shaft of the Key that can be seen.




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 69 of 80

SEVILLE 1994 -1995



KEY
T-
HARNESS
MMOBLZER
N/A N/A GM's VATS ANT-THEFT System (if Equipped) Requires Bypass Module

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) GRAY/BLACK (-) @ HEADLGHT SWTCH
PARKNG LGHTS ( + ) BROWN (+) LOW in DRVERS KCK PANEL
POWER LOCK RED/BLACK (TYPE A) N DRVERS KCK PANEL
POWER UNLOCK WHTE (TYPE A) N DRVERS KCK PANEL
DOOR TRGGER BLUE (-)
LOW N DRVERS KCK
PANEL
DOMELGHT SUPERVSON BLUE/WHTE (-) @ UNDER DASH LGHT
TRUNK RELEASE BLACK/WHTE (+) @ TRUNK RLEASE MOTOR
SLDNG POWER DOOR N/A
HORN BLACK (-)
@ STEERNG COLUMN
HARNESS
TACH PURPLE/WHTE or WHTE @ GNTON COL
WAT TO START LGHT N/A
BRAKE LGHT BLUE or WHTE (+)
@ SWTCH ABOVE BRAKE

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 70 of 80
PEDAL
FACTORY ALARM DSARM LGHT GREEN (-) N ETHER KCK PANEL
ANT-THEFT
2 WHTE or 1 WHTE and 1
PURPLE, wires are in an
ORANGE tube
GM's VATS System @ gnition
Switch

EXTRA NFORMATON





This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 71 of 80

SEVILLE 1996 -1997



KEY
T-
HARNES
S
MMOBLZER
N/A N/A GM's VATS ANT-THEFT System, gnition Key has Chip, Requires Bypass Module

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 LGHT BLUE (+) GNTON SWTCH HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) GRAY/BLACK (-) N DRVERS KCK PANEL
PARKNG LGHTS ( + ) PURPLE (+) See NOTE *1
@ the PARKNG LGHT
RELAY, See NOTE *1
POWER LOCK RED/BLACK (TYPE B) N DRVERS KCK PANEL
POWER UNLOCK ORANGE/BLACK (TYPE B) N DRVERS KCK PANEL
DOOR TRGGER See NOTE *3 @ BCM, See NOTE *2
DOMELGHT SUPERVSON TAN (-) @ BCM, C2, See NOTE *2
TRUNK RELEASE BLACK/WHTE (+)
@ TRUNK RELEASE RELAY,
See NOTE *4
SLDNG POWER DOOR N/A
HORN BLACK (-)
@ STEERNG COLUMN
HARNESS
TACH PURPLE/WHTE @ 5 Pin plug rear of engine
WAT TO START LGHT N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 72 of 80
BRAKE LGHT BLUE (+) or WHTE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM LGHT GREEN (-) N ETHER KCK PANEL
ANT-THEFT
2 WHTE or 1 WHTE and 1
PURPLE, wires are in an
ORANGE tube
GM's VATS System @ gnition
Switch

EXTRA NFORMATON
SPECAL NOTE!!!! f vehicle is equipped with PASSKEY/VATS, gnition Key will have a little Chip on
the Steel Shaft of the Key that can be seen. NOTE *1 the parking Light wire is located in the Trunk
Compartment #2 Micro Relay Center behind the Rear Seat DO NOT use any other wire that tests as
a (+) PARKNG LGHT wire in this vehicle. NOTE *2 the BCM is located behind the Drivers side of the
Rear Seat back, it has (2) plugs labled C1 and C2. NOTE *3 the DRVERS DOOR use the TAN (-)
Plug C2, the PASSENGER DOOR uses the DARK BLUE/WHTE (-) Plug C1 and both REAR
DOORS use (1) wire a ORANGE (-) Plug C1, when connecting to an Alarm System, use all (3) wires
and DODE SOLATE. NOTE *4 the Trunk Release Relay is located in the Trunk at the #1 Micro
Relay Center.




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 73 of 80

SEVILLE 1998 -2004



KEY
T-
HARNES
S
MMOBLZER
GM KEY-
1
N/A
GM's PK3 TRANSPONDER ANT-THEFT System, Requires Module and Extra
gnition Key

FUNCTON COLOR LOCATON
12 VOLT CONSTANT Connect to BATTERY ONLY
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 WHTE (+) GNTON SWTCH HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) BROWN/WHTE (-)
@ DM, BLUG Plug, Pin B3 See
NOTE *2
PARKNG LGHTS ( + )
PURPLE (+) and
BROWN/WHTE (+) Use both,
See NOTE *1
@ FUSE BLOCK UNDER
REAR SEAT
POWER LOCK RED/BLACK (TYPE B)
@ LOCK SWTCH in DRVERS
DOOR
POWER UNLOCK ORANGE/BLACK (TYPE B)
@ LOCK SWTCH in DRVERS
DOOR
DOOR TRGGER See NOTE *3 @ DOOR MODULES
DOMELGHT SUPERVSON GRAY (-) @ UNDER DASH LGHT
TRUNK RELEASE LGHT BLUE (-)
@ RM, GRAY Plug, Pin B4,
See NOTE *4
SLDNG POWER DOOR N/A
HORN BLACK (-)
@ STEERNG COLUMN

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 74 of 80
HARNESS
TACH WHTE
@ PCM, BLUE plug Pin 23 See
NOTE *5
WAT TO START LGHT N/A
BRAKE WHTE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM LGHT GREEN (-)
@ DRVERS DOOR MODULE
in DRVERS DOOR
ANT-THEFT
GM's PASSKEY 3 (PK3 on
Steel Shaft of gnition Key)
TRANSPONDER SYSTEM
TRANSPONDER @ GNTON
SWTCH TUMBLER

EXTRA NFORMATON
NOTE *1 this vehicle uses a 2-Wire PARKNG LGHT Circuit, that will require 2 extra Relays Part
#775, to connect, . NOTE *2 at DM Module located under the PASSENGER side of dash, near the
BLOWER MOTOR. NOTE *3 the DRVER DOOR wire is a TAN (-) at the DRVERS DOOR module in
the DRVERS DOOR and all other doors use a DARK BLUE (-) at the DOOR Module in each door.
When connecting to an Alarm System use all 4 wires and Diode solate. NOTE *4 the RM Module is
located behind the PASSENGER SDE REAR SEAT, in the lower corner. NOTE *5 the PCM is
located at the FRONT drivers side of engine compartment below the Air cleaner.




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 75 of 80

SRX 2004 -2006



KEY
T-
HARNES
S
MMOBLZER
GM KEY-
4
N/A
GM's PK3 TRANSPONDER ANT-THEFT System, Requires Module and Extra
gnition Key

FUNCTON COLOR LOCATON
12 VOLT CONSTANT Connect to BATTERY ONLY
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) BROWN/WHTE (-)
@ DM, BROWN Plug, Pin B3,
See NOTE *1
PARKNG LGHTS ( + ) DO NOT USE!
POWER LOCK ORANGE/BLACK (TYPE B)
@ LOCK SWTCH in DRVERS
DOOR
POWER UNLOCK RED/BLACK (TYPE B)
@ LOCK SWTCH in DRVERS
DOOR
DOOR TRGGER
USE DOME LGHT
SUPERVSON WRE

DOMELGHT SUPERVSON GRAY (-)
@ UNDER DASH LGHT or
RM Module, BROWN Plug, Pin
B10, See NOTE *3
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN TAN (-)
@ DM, GRAY Plug, Pin A6,

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 76 of 80
See NOTE *1
TACH WHTE @ ECM, See NOTE *2
WAT TO START LGHT N/A
BRAKE WHTE (+)
N DRVERS KCK PANEL,
HARNESS to REAR of
VEHCLE
FACTORY ALARM DSARM LGHT GREEN (-)
N DRVERS DOOR MODULE
in DOOR
ANT-THEFT
GM's PASSKEY 3 (PK3 on
Steel Shaft of gnition Key)
TRANSPONDER SYSTEM
TRANSPONDER @ GNTON
SWTCH TUMBLER

EXTRA NFORMATON
NOTE *1 the DM Module is located under the GLOVE BOX. NOTE *2 the ECM is located on the
PASSENGER SDE of the engine, under the cover on the 3.6L engine and on the 4.6L engine it is on
the LEFT FRAME rail below the Drivers side headlight. NOTE *3 the RM Module is located in the
RGHT REAR QUARTER PANEL.




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 77 of 80

STS 2005 - 2006



KEY T-HARNESS MMOBLZER
N/A N/A NO NFORMATON AT THS TME!

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) @ BATTERY UNDER HOOD
STARTER
YELLOW (-) Not for Remote
Start
@ ECM, C2, Pin 35 or BLUE
Plug, Pin 14 See NOTE *1
STARTER 2 N/A
GNTON 1
PNK (+) Not Required for
Remote Start
@ MP,26-Pin plug, Pin 6 See
NOTE *2
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) Not Required for
Remote Start
@ MP, 24-Pin plug, Pin 7 See
NOTE *2
ACCESSORY/HEATER
BLOWER 2
BROWN (+) Not Required for
Remote Start
@ MP, 24-Pin plug, Pin 1 See
NOTE *2
KEYSENSE N/A
PARKNG LGHTS ( - ) BROWN/WHTE (-)
@ MP, 26-Pin plug, Pin 14 See
NOTE *2
PARKNG LGHTS ( + )
PURPLE (+) and
BROWN/WHTE (+) Use both,
See NOTE *6
N EACH KCK PANEL in
harness going to rear of vehicle
POWER LOCK ORANGE/BLACK (TYPE B)
@ DRVER DOOR LOCK
SWTCH in DRVERS door
POWER UNLOCK ORANGE/BLACK (TYPE B)
@ DRVERS DOOR LOCK
SWTCH in DRVERS door
DOOR TRGGER See NOTE *3
@ EACH DOOR MODULE N
EACH DOOR
DOMELGHT SUPERVSON GRAY (-) @ UNDER DASH LGHT
TRUNK RELEASE LGHT BLUE (-)
@ RM, 16-Pin Plug Pin 11 See
NOTE *4
SLDNG POWER DOOR N/A
HORN TAN (-)
@ PM, 24-Pin plug, Pin 9 See

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 78 of 80
NOTE *2
TACH ANY wire NOT PNK/BLACK @ ANY FUEL NJECTOR
WAT TO START LGHT N/A
BRAKE WHTE (+)
@ MP, 26-Pin plug, Pin 5 See
NOTE *2
FACTORY ALARM DSARM LGHT GREEN (-)
@ DDM, 20-Pin plug, Pin 4 See
NOTE *5
ANT-THEFT
NO NFORMATON AT THS
TME!


EXTRA NFORMATON
NOTE *1 the ECM on the 3.6L engine is on the Passenger side valve cover, on the 4.6L engine the
ECM is located below the Drivers side Headlight. NOTE *2 the MP Module is located behind the
Glove Box. NOTE *3 the DRVERS DOOR is a GRAY/BLACK (-) 20-Pin plug, Pin 2, the
PASSENGER DOOR is a TAN/WHTE (-) 20-Pin plug, Pin 2, the DRVERS REAR DOOR is a LGHT
BLUE/BLACK (-) 20-Pin plug Pin 4 and the PASSENGER REAR DOOR is a LGHT GREEN/BLACK
(-) 20-Pin plug, Pin 4. When connecting to an Alarm System use all 4 wires and DODE SOLATE
NOTE *4 the RM Module is located below the Drivers side of the Rear Deck NOTE *5 the DDM is the
DRVERS DOOR MODULE in the Drivers door. NOTE *6 the PARKNG LGHTS on this vehicle use a
2-Wire System that will require 2 extra Relays part #775, to connect, .




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 79 of 80

XLR 2004 -2006



KEY T-HARNESS MMOBLZER
N/A N/A CHECK WTH DEALER

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED/BLACK (+)
@ BCM, C3, Pin D1, See NOTE
*1
STARTER
PURPLE (+) (Not for Remote
Start)
@ STARTER or FUSE BLOCK
under hood
STARTER 2 N/A
GNTON 1 PNK (+) (Not for Remote Start)
@ BCM, C4 Pin C8, See NOTE
*1
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
N/A
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) BROWN/WHTE (-)
@ BCM, C2, Pin 5, See NOTE
*1
PARKNG LGHTS ( + ) BROWN (+)
N HARNESS GONG TO
REAR OF VEHCLE
POWER LOCK ORANGE/BLACK (TYPE B)
@ LOCK SWTCH in DRVERS
DOOR
POWER UNLOCK ORANGE/BLACK (TYPE B)
@ LOCK SWTCH in DRVERS
DOOR
DOOR TRGGER
GRAY/BLACK (-) and
TAN/WHTE (-) Use both See
NOTE *2
@ BCM, C1, Pins 51 and 53,
See NOTE *1
DOMELGHT SUPERVSON WHTE (-)
@ BCM, C3, Pin A10, See
NOTE *1
TRUNK RELEASE BROWN/WHTE (-)
@ BCM, C1 Pin 71, See NOTE
*1

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Cadillac - Copyright 2004-2006 - 12 Volt Resource LLC Page 80 of 80
SLDNG POWER DOOR N/A
HORN TAN (-)
@ BCM, C2 Pin 14, See NOTE
*1
TACH WHTE @ ECM, See NOTE *3
WAT TO START LGHT N/A
BRAKE LGHT BLUE (+)
@ BCM, C4, Pin D4, See NOTE
*1
FACTORY ALARM DSARM
DSARMS with FACTORY
REMOTE ONLY

ANT-THEFT
YES , No nformation at this
time!!!


EXTRA NFORMATON
NOTE *1 the BCM is part of the FUSE/RELAY Block on the Passenger foor board under the carpet.
The BCM will have the following connectors: C1(72 Pin GRAY), C2(72 Pin GRAY), C3(41Pin RED)
and C4(68 Pin GRAY) Plugs. NOTE *2 the DRVERS DOOR is a GRAY/BLACK(-) and the
PASSENGER DOOR is a TAN/WHTE(-) located at the BCM. When connecting to an Alarm System
use both wires and DODE SOLATE NOTE *3 the ECM is located in the front Passenger fender,
must remove the wheel to access the panel behind the wheel. The TACH wire is in the BLUE Plug
Pin 26

Potrebbero piacerti anche