Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
www.huawei.com
Foreword
The commissioning is performed after the hardware installation The commissioning ensures the RNC works properly as designed RNC commissioning procedure
Commissioning RNC hardware Commissioning software loading Verifying all interfaces Verifying RNC services Integrating the RNC into M2000
Page2
References
Page3
Objectives
Describe the procedure of RNC commissioning Perform the steps in RNC commissioning
Page4
Contents
1. Introduction to RNC Commissioning 2. Procedure of RNC Commissioning
Page5
The commissioning of equipment, RNC loading, interfaces, and services after hardware installation To ensures that the RNC works as designed
Passing hardware installation acceptance and powering-on test At least one NodeB and one set of CN equipment available
Page6
BAM and LMT application software are ready License file is ready MML command script for initial configuration is ready
Page7
Contents
1. Introduction to RNC commissioning 2. Procedure of RNC commissioning
Page8
Contents
2.
2.2 Verifying interfaces (Iub, Iu-CS, Iu-PS, Iur) 2.3 Handling Alarms During RNC Commissioning 2.4 Verifying RNC Services 2.5 Integrating the RNC into the M2000 2.6 Creating RNC Scheduled Tasks 2.7 Checking RNC Commissioning Results
Page9
Install the BAM application in the active workspace Check the operation of the BAM application
Install LMT application Connect LMT to the BAM Start the local maintenance terminal
Page10
Format
DB
*.dat
FAM board
BAM
Copyright 2007 Huawei Technologies Co., Ltd. All rights reserved. Page11
Page12
Activate the license (ACT LICENSE) Check the license consistency between host and BAM (CMP LICENSE)
Step 5 Verifying Switchover Between Active and Standby Boards (SWP BRD)
Page13
User Data
Signaling Bearer
Signaling Bearer
Data Bearer
Physical Layer
Page14
Checking physical link (DSP E1T1, DSP ETHPORT) Checking control plane (DSP SAALLNK, DSP SCTPLNK, DSP IUBCP)
Page15
Verifying interfaces
The procedures and commands are similar with those in Iub interface
Page16
Basic services
Voice service, CS stream service, PS service, mobility management, and OM management
Feature services
Inter-system handover, HSDPA service, HSUPA service, MBMS service, and location service
Page17
Integrating the RNC into the M2000 Creating RNC Scheduled Tasks (back up tasks) Checking RNC Commissioning Results
iManagerTM M2000
DCN
Page18
Thank you
www.huawei.com