Sei sulla pagina 1di 3

Udostępnij Zgłoś nadużycie Następny blog» Utwórz bloga Zaloguj się

Renewable Energy for the Poor Man


Come on..step outside that box. The weather is fine out here.

1
THURSDAY , MAY 14, 2009 About Me

Updated Charger/Desulfator Richard


With amp and volt readout

by Richard Lewis
American living in Canada.
Today, I'll be showing you how to make an updated model Always working on new
of my desulfator and charger that you see in my windmill "outside the box" concepts.
book. This version is nice because it has a pluggin for a
View my complete profile
simple digital meter and with a flip of a switch you can
read the current to the battery, or battery voltage. It also Blog Archive
has another switch for a high or low charge current
▼ 2009 (86)
setting. In the below design I used a standard spring
loaded speaker wire quick connect box. I used light ► November (1)
switches for the on/off and the hi/lo switches. I used a ► October (1)
spdt light switch for amps/volts switch. I used a GFCI ► September (3)
socket inside instead of an isolation transformer for safety.
► August (15)
I also show a pair of 80 MFD capacitors for my high section
► July (24)
charging. Actually, it parallels those along with the 24,
giving me 184 MFD. That would be about 7.6 amps of ► June (26)
charging and about 1 amp at the low setting. You can use ▼ May (16)
some more capacitors in parallel, but remember to make Solar Air Heaters
sure your switches, wires, fuse and rectifier can handle
windmill ebook cover
the current. The fuse should be just under what the
testing
rectifier can handle. If you hook the battery up backwards,
Hooking up the other
this fuse will blow instantly. I used 25 amps for my fuse
stuff
because I had a 30 amp full wave bridge rectifier.
Conservation
Solar Powered Spotlight
24 Volt Battery? But I
have a 12 volt
inverter.
Solar Panels and battery
bank
Tiny Little House
DIY solar panels
Candle Heater
Updated
Charger/Desulfator
Homemade battery
Notice the 1/4 inch stainless steel bolt (about 2 inches
charger - desulfator
long). It has to be stainless, not plated or galvanized. And
the wire connections must be exactly 1 inch apart. Low Voltage Heating
Element (4,000 Watts)
for $10

2 homemade tachometer
3

Potrebbero piacerti anche