Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
1. Check which SP systems that are installed on the IOG. Make sure that the same
system and version is installed in both nodes.
Command: LASYP:SPG=0,VNODE=A;
Command: LASYP:SPG=0,VNODE=B;
Printout: SP SYSTEM LIST
--------------------------------------------------------------------------------
-------------
2. Make sure that both nodes are working normal.
Command: IMMCT:SPG=0;
Command: IMCSP;
Printout: NODE CONFIGURATION STATUS
Command: END;
--------------------------------------------------------------------------------
-------------
3. Insert optical disc (OD) into the optical drive in node A.
--------------------------------------------------------------------------------
-------------
4. Mount the OD.
Command: INMCT:SPG=0;
Command: INVOL:NODE=A,IO=OD-1;
Printout: VOLUME LOADED
Command: END;
--------------------------------------------------------------------------------
-------------
5. Start SP function change.
Command: FCSPI:SPG=0;
--------------------------------------------------------------------------------
-------------
6. Specify nodes to be updated.
Command: FCSLS:LNODE=A&B,RNODE=A&B,RSNODE=A&B;
--------------------------------------------------------------------------------
-------------
7. Load SP software from OD to HD.
Command: FCSSL:IONODE=A,IO=OD-1;
Printout: SP SOFTWARE LOAD
--------------------------------------------------------------------------------
-------------
8. Load SP system description from OD to HD.
Command: FCSDL:IONODE=A,IO=OD-1;
Printout: SP SYSTEM DESCRIPTION LOAD
--------------------------------------------------------------------------------
-------------
9. Install and switch in the new SP system.
Command: FCSSI:FCTYPE=1;
Printout: SP FUNCTION CHANGE
--------------------------------------------------------------------------------
-------------
10. End the SP function change.
Command: FCSPE;
Printout: SP FUNCTION CHANGE ENDED
--------------------------------------------------------------------------------
-------------
11. Make sure that the new SP system is active in both nodes.
Command: LASYP:SPG=0,VNODE=A;
Command: LASYP:SPG=0,VNODE=B;
Printout: SP SYSTEM LIST
--------------------------------------------------------------------------------
-------------
12. Make sure that both nodes are working normal.
Command: IMMCT:SPG=0;
Command: IMCSP;
Printout: NODE CONFIGURATION STATUS
Command: END;
--------------------------------------------------------------------------------
-------------
13. Unmount the and remove the OD.
Command: INMCT:SPG=0;
Command: INVOE:IO=OD-1, NODE=A;
Command: END;
Printout: VOLUME UNLOADED
--------------------------------------------------------------------------------
-------------