Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
6/11a
INSTALLATION INSTRUCTIONS
Original Issue Date:
Model:
Market:
Subject:
4/11
14RES, 14RESL, 20RES, and 20RESL
Residential/Commercial
OnCuet Ethernet Option Board Kit GM62465-KP1
Introduction
Customer-Supplied Equipment
Windowsr XP
d Kohlerr OnCuet software (version 2.0 or higher)
d 1 GB of RAM
d Up to 500 MB of available hard disk space may be
required
D Always-on Internet access (for example, cable or
firmware upgrade
OnCuet Software
2
GM62863
Figure 1
Firewalls
Safety Precautions
Observe the following safety precautions while installing
the kit.
WARNING
NOTICE
Electrostatic discharge damage. Electrostatic discharge
(ESD) damages electronic circuit boards.
Prevent
electrostatic discharge damage by wearing an approved
grounding wrist strap when handling electronic circuit boards
or integrated circuits. An approved grounding wrist strap
provides a high resistance (about 1 megohm), not a direct
short, to ground.
when handling
components.
circuit
boards
or
electronic
TT-1566
6/11
Installation Procedure
1. Open the enclosure roof. See Figure 2.
2. Update the controller firmware. Use a USB cable to
connect the controller directly to a computer and
use OnCue software to update the controller
firmware. See Figure 3. See Controller Firmware
Update in this document and TP-6796, OnCue
Software Operation Manual, provided with this kit,
for instructions.
TP6735
1.
2.
3.
4.
Roof
Controller
Intake panel screws (2 ea.)
Intake panel
Figure 2
RDC Controller
1. Down arrow button (RDC)
2. Exercise button (DC)
3. Service access (remove cover)
Figure 3
TT-1566
DC Controller
GM62860
6/11
Figure 4
1
1
Figure 5
GM66569
TT-1566
6/11
that were
2
3
GM62863
1.
2.
3.
4.
Figure 6
TT-1566
6/11
32. Set the exerciser on the day and time that the
generator set should run its weekly exercise. See
TP-6734, Operation Manual, for instructions.
Controller Password
The controller password is required for OnCuet
software operation. Follow the instructions in step 30 of
the installation procedure to find the controller
password. Record the password for entry into the
OnCue program later.
Note: The password changes each time the procedure
in step 30 is performed. If the controller is
connected to OnCue and the procedure is
performed again, the connection will be lost.
Pressing the down arrow or exercise button with the
controller OFF does not change the exercise setting.
1
1. Dot here indicates server connection
Figure 7
tt1566
TT-1566
6/11
Controller Firmware
Parts List
Kit: GM62465-KP1
Qty. Description
1
1
1
1
1
Part Number
GM23307
GM60385-1
GM60410
TT-1566
TP-6796
TT-1566
6/11
Notes
TT-1566
6/11