Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
7 5:10 PM 994
W13
W1HN(P)
Contact wiring
Application
DC24V
AC100V
DC24V
Load Current
5~40mA
5~20mA
40mA
None
Built-in
2.4V
1.5V
Indicator Lamp
How to Order
W1
Voltage
Output
Current Consumption
5mA
Current Leakage
None
100
Operation Time
1ms
2ms
Lead Wire
NPN(PNP)
Shock Resistance
30G
Insulation Resistance
100G
Voltage Resistance
Temperature
-10 ~ 60
Protection Structure
Internal Circuit
Protection Structure
(Slotted set screw)
Brown(+)
Indicator Lamp
Blue(-)
Blue(-)
Operating range
Black(S)
Blue(-)
Caution
Plase read and understand the
instructions before use. Refer to the auto
switch precautions before using auto
switches.
994
Operating Range
Section
W13
10mm
W1HN(P)
1 ~ 2mm
Operation range(L)
6 ~ 12mm
4 ~ 10mm
Series W2P
SPSA
SPSB
Auto
Swtch
How to Order
SPS
Part No.
W2P(L), (Z)
Application
Load Voltage
DC24V 015%
Load Current
2 ~ 40mA
Contact
Without contact
Wiring
5V 1.0mA
Current Leakage
0.6mA
Indicator Lamp
RED/GREEN/RED (ON)
W2P
Operation Time
40ms
Lead Wire
Shock Resistance
30G
Insulation Resistance
L : LEAD WIRE(3m)
Z : LEAD WIRE(5m)
Voltage Resistance
Internal Circuit
Temperature
10 ~ 80
Protection Structure
Protection Structure
Indicator Lamp
Brown(+)
(nonpola type)
Blue(-)
W2P circuit
Auto Switch
Operating Range
RED
GREEN
Mounting Hole
RED
Caution
Operating Range
Section
W2P
16mm
Operation range(L)
8~10mm
Do not fix the auto switch the existing screw installed on the auto switch body.
The auto switch may be damaged if a screw other than one supplied is used.
995
www.TPCpage.com
www.TPCpneumatics.com
W3
Application
Voltage
Load Current
DC24V
AC100V
AC200V
5~50mA
5~25mA
5~12.5mA
Built-in
2.4V
Indicator Lamp
Current Leakage
None
Response time - 1.2ms
Lead Wire - Oil proof vinyl. 4(0.3)mm2, 2 wire(red, black),
0.5m
Impact Resistance - 30G
Insulation Resistance - 100M or more under the test voltage 500VDC
(Between case and cable)
Withstand Voltage - 1500VAC 1min(between case and cable)
Ambient Temperature - 5~60
Protective Construction - IEC spec IP67, Water-proof(JISCO920), oil-proof.
If 3m lead wire is required, L is put at end of model numbers.
(Example) W3L
(mm)
14
Zener DIODE
(-)
Resistor
Choke coil
Red(Vcc)(+)
4.5
Reed
Switch
22
12 5
Black
(Gnd)
Indicator Lamp
12
16
11
4.2
33
Operating Range
S
Most Sensitive Position
Operating Range
996
Section
W3
8.5mm
Operation range(L)
9~11mm
SPSB
W4
Application
Voltage
Auto
Swtch
Load Current
AC100V
5~20mA
SPS
None
2.4V or less
Current Leakage
Response time
Lead Wire
Impact Resistance Insulation Resistance -
None
1.2 ms
Oil proof vinyl. 3.4, 0.2mm2, 2 wire(red, black), 0.5 m
30G
50M or more under the test voltage
500VDC (Between case and cable)
Withstand Voltage 1500VAC 1min(between case and cable)
Ambient Temperature - 5~60
Protective Construction - IEC spec IP67, Water-proof(JISCO920), oil-proof.
If 3m lead wire is required, L is put at end of model numbers.
(Example) W4L
(mm)
3.2
8
Red(Vcc)
Zener diode
3.4
14
Indicator Lamp
Reed switch
Light emitting
Black(Gnd)
11.7
6.2
22
Operating Range
Most Sensitive Position
Operating Range
Section
W4
8.5mm
Operation range(L)
6~12mm
997
www.TPCpage.com
www.TPCpneumatics.com
W5
Relay, Sequence Control
Voltage
DC24V
Load Current
AC100V
5~40mA
5~20mA
None
2.4V or less
ON:Red light emitting diode
(mm)
Red(Vcc)
Resistor
Zener Diode
Black(Gnd)
Indicator Lamp
L
S
Operating Range
998
Section
W5
9.5mm
Operation range(L)
6~8mm
Internal Circuit
SPSB
W6(L)(Z)
W7(L)(Z)
AC120V
DC24V
AC100V
20mA
0V
5~40mA
5~20mA
Auto
Swtch
SPS
Max 2.4V
1.2m/sec
30G
IEC Standard IP67
OFF Lighting(Red LED)
ON Lighting(Red LED)
MAX. 1.8mA
0
5~60
50M/500V DC
Relay, Sequence Controller
Dimension
Indicator Lamp
Brown(+)
Blue(-)
Mounting Hole
W6 Circuit
Operating Range(L)
Brown(+)
Blue(-)
W7 Circuit
Caution
Operating Range
Section
D-P70R
16mm
16mm
Operation range(L)
8 ~ 9mm
8 ~ 9mm
D-P74R
999
www.TPCpage.com
www.TPCpneumatics.com
How to Order
1
TPC Auto Switch Model
7 : TPC Auto Switch Model
8 : Mini existing plug point AUTO SWITCH
9 : Mini non plug point round AUTO SWITCH
10 : Mini non plug point round AUTO SWITCH(10mm)
H : LEAD WIRE HORIZONTAL TYPE
(W7 : Horizontal only)
V : LEAD WIRE VERTICAL TYPE
(W10 : Vertical only)
Specification
Item
W7
Size
Load Voltage
DC24V
Load Current
Contact (W8)
5~15mA
5~40mA (DC24V)
5~20mA(AC110V)
Non-Contact (W9)
5~30mA
W10
Solid State Switch
5~40
Vertical, Horizontal
Vertical, Horizontal
Vertical(V)
Lamp
Wiring
Double wiring
Output
NPN, PNP
Attachment
Screw-attachment on
Screw-attachment on Rail
Operation Time
Less than 12
W7
, W8
13
7~12
W9
6.5
4.3~4.7
W10
7
4~7
* Waming : When the amount of motion electric current loaded on the controllers such as PLC, is lower than
that of current leakage, it is called non-operative state (ON) and results in miss-operation.
When the number of parallel connection is n, the amount of current leakage multiplies n times.
1000
Dimension
W8*
M2.50.454L
Auto
Swtch
4
2.8
M2.50.454L
4
2
4.5
(8.5)
SPS
22
(15) (10)
5
9
0.8
4.5
4
2.8
2.5
(1m)
(1m)
2.5
24
0.8
4.5
4
4.5
(8.5)
(15) (10)
SPSB
W8H (Horizontal)
W8V (Vertical)
W9*
M2.50.454L
4
2.8
M2.50.454L
4
2
4.5
(11)
22
(15) (10)
(11)
5
9
0.8
4.5
4
2.8
0.8
2.5
(1m)
(1m)
2.5
24
4.5
4
4.5
(15) (10)
W9H (Horizontal)
W9V (Vertical)
10
W10*
2.5
4
(15)
19.5
15.5
4.5
M2.50.454L
0.5M
2.8
5.5
W9H ()
5
8
4
W10V (Vertical)
1001
www.TPCpage.com
www.TPCpneumatics.com