Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
1-
2-
3-
4-
5-
Before using a fixed co2 system to fight an engine room fire, you must ............
- Call Master to engine room.
- Wait for shore support.
- Evacuate all engine room personnel.
- Close Quick Close Valves.
- Inform shore authorities.
6-
7-
The most modern kind of lifeboat, dropping or falling into the sea and which is covered, is a/an :
Inflatable life raft
- Freefall
- Lifebelt
- Liferaft
- Water proof life boat
8-
9-
During surveys, ship is sometimes ..... for visual hull inspection below the water line, anchor
equipment, and thickness measurement.
- Anchored
- Docked
- at Sea
- Dry Docked
- Sea Locked
11-
12-
Safety communications must be concerned with two subjects. They are ............
A) meteorology and first aid
B) channels and publications
C) navigation and communication
D) grounding and lowing
E) navigation and meteorology
13-
Dredging operations by the vessel M/V Gate from 10 October 13.00 hours to 11 october 03.00
hours in position 15 degrees 34 minutes North, 61 degrees 29 minutes. Wide ____
A) channel needed
B) berth request
C) assistance required
D) distances indicated
E) cases covered
14-
15-
16-
On 25 August 1994, SALLY STAR, a Bhamian Registered Ro-Ro passenger ferry was enroute to
Ramsgate from Dunkirk and in a position about 6.5 miles east of Ramsgate when fire broke out in
the main engine room. The fire was caused by the failure of a bolted flange joint on the low
pressure fuel system to No 4 main engine, allowing flammable fuel oil vapour to come into contact
with part of the engine exhaust system. Initial attempts to extinguish the fire were unsuccessful,
mainly due to failure of the auxiliary generators and the emergency fire pump and despite the
injection of Kalongs into the space. However, the closure of the engine room ventilation and fuel
oil system effectively started the fire of fuel and oxygen. The fire was finally reported as
extinguished about three hours from the onset of the emergency. The incident required the coordinating role of HM Coastguard Dover, off-shore fire fighting teams from Kent Fire Brigade, RAF
and HM Coastguard helicopters. A total of 85 non-essential crew and 17 passengers were
transferred ashore by RNLI lifeboats based at Ramsgate and Margate. Tugs and other vessels
stood by the SALLY STAR which was finally towed to Dunkirk for repairs. One crew member
suffered and injury during fire fighting operations and was evacuated ashore by helicopter.
The passage does not explain;
A) The reason why the fire broke out.
B) The reason why the initial fire fighting attempts were unsuccessful.
C) The place where fire occured.
2
17-
18-
An abandon ship drill and a/an ........... must be hold within 24 hours of leaving port f more than
%25 of the crew have taken past drills on board in previous month.
Fire drill
19-
20-
21-
22-
23-
Lifeboats should be taken ashore,nspected and tested.All the damage,if any should be
repaired.Lifeboat winches sould be dismanted,overhauled and worn parts renewed.Hand brakes
and mechanical brake should be checked and adjusted.After completng the work,they should be
tested under Chief officer's supervision. this passage is part of.........
deck department orders
24-
There shall be clear nstructons relatng to the operatng of the system.(Trkcesi nedir?)
Sistemin calsmasna ilikin ak talmatlar bulunacaktr
25-
Accordng to colreg 1972 and ts supplement,the master is not oblgated to be on the bridge
hmself;
while checkng whstles daily
26-
'In cold water the skn and perpleral tissues become cooled and then the deep body temperature
falls' Ths s called as ...............
hypotherma
27-
28-
29-
30-
31-
For Shps good condton demonstration ........... and fitted resposble person and charge of men
workng.
maintenance
32-
33-
34-
35-
36-
37-
38-
39-
40-
It is required to use the capstan (irgat) to haul (cekmek) a line. The order given is .....
a) To take line to capstan to heave vessel alongside
b) To take line to capstan and heave away
c) To weigh anchor
d) To take the head line and turn it around
e) To hold the line and wait near the capstan
41-
42-
The M/V Yldz got loaded at Port of Izmir with dried fruits and left for Lsbon. When arrived at the
Port of Lisbon, she was detained because the Masters Certificate was Master Certificate not
Unlimited Master Certificate. The detention was attributed to the incompliance with the
requirements of
a) SOLAS
b) STCW
c) LOADLINE
d) MARPOL
e) ISM
43-
44-
45-
46-
47-
48-
49-
50-
51-
The ship's safety comittee should include;.............., safety officer and all respresetetive personnel
for safety ...
a-all crewmember
b-the master
c-the chief engineer
d-all ratings
52-
53-
54-
55-
Draft marks and astern ( trkesi draft markalar geminin banda ve knda her iki
bordada bulunur)
bow
56-
57-
Many types of bulk cargo are liable to shftng and therefore special precautions
must be taken wth such cargoes as grain some kind of ores, certain kinds of coal,
broken granite etc. t s necessary to see that the bulk cargo is well trimmed. A load
of barrels should be stowed blge free and well blocked off to avoid it.
This passage is about................
A) handling damage
B) crushing
C) dust damage
D) leakage
E) shifting
58-
59-
60-
61-
62-
Bill of lading is a ............... document and implies the owner ship of the cargo
a) nternational
b) Customary
c) Negotiable
d) Certified
e) Secure
63-
............ meteorlogy deals air and wind forecast for shps at sea
maritime
64-
Dear sirs,
I regret to inform you that due to the stoppage of the separating valve of the bilge manifold some
water from the ballast tank on port side was pumped overboard together with the oil
contaminared bilge water from the shaft tunnel.
The cause of this contamination is purely technical and totally accidental.
The CHIEF ENGINEER OF THE M/V..........
This correspondence is an example of
A) bunkering order
B) notification
C) damage to the ship
D) statement of sea protest
E) resume
65-
Which of the following statements about finding a ships position is not true?
A) A ships position can be calculeted by a technques known as dead reckoning
B) When n sght of land, the navigator uses the technques of coastal navgation to find position.
C) To fnd the exact position of the ship, a compass bearing can be used.
D) When out of sght of land,a ships position can be found out by using the technques of celestial navigation.
E) It s not possible finding the position of a ship by means of satellite.
66-
67-
68-
Nautical chart based.......by issued national hydrographic office of more national country.
a-)land survey
b-)hydrographic survey
c-)deep tide water
69-
70-
Tender Ship: The ship with a small Metacentric height has a small righting lever at any angle & will roll easily
is said to be tender ship. In tender ship, in it the centre of gravity lies below the transverse metacentre. The
GM is more than GZ. & these kinds of ships are more stable. GM KCK!!!
71-
Stiff Ship: The ship with a large Metacentric height has a large righting lever at any angle & has considerable
resistance to rolling. A stiff ship is very uncomfortable. In it the Centre of Gravity lies above the transverse
metacentre. GM is larger than the GM that belongs to tender vessel. GM BYK!!! Stiff gemi GMi byk
olarak tanmlanabilir.Bu da GZ in yani dorultucu kuvvet kolunun byk olmas demek olur.Byle
bir gemi bir d etkenin etkisiyle bir yana baylrsa, gemiyi dorultmaya alacak olan dorultucu
moment byk olur.nk dorultucu kuvvetlerin kolu byktr.Byle olduu iin de gemi hzla
dorulur.Bu yzden diri gemilerin yalpas sert ve yalpa peryodu kktr.
7
The mechanical barrel around which lines and wires are turned is a .............
A) buoy
B) barrel
C) capstan
D) captain
E) waist
73-
74-
75-
76-
77-
78-
Port state control officer said to the Master of the M/ V Rose that the ship got detained because of
the absence of the lifeboat inventory.
Which of the following conventions didnt the M/V Rose comply with?
A) SOLAS
B) STCW
C) LOADLINE
D) MARPOL
E) ISM
79-
If an object blocks the airway of a person, what first aid method is used to remove that object?
A) Cardiopulmonary Resuscitation(CPR)
B) Artificial Respiration
C) Heimlich Manoeuvre
D) Splinting
E) Rescue Breathing
80-
Line may have either a left........or a right.......depending up on how the strand are twisted to
gether.
a-)Lay b-)twist c-)side d-)way e-)hand
81-
83-
84-
85-
86-
Btn yangn tiplerinde kullanlabilen cooling (soutucu) etkisi olmayan yangn sndrc
hangisi?
a) water
b) foam
c) halon 1211
d) dry powder
e) halon mixcur
87-
Deniz dibi derinlii gibi baz bilgilerve uyarlar haritalarda gsterilir aadakilerden hangisi
uyarlardan biridir ..
a) light house
b) buoy
c) ship wreck
88-
89-
The radio log book should be kept clear to the radio for ...... by any authorized person.
a) filling in
b) an easy access
c) inspection
d) drills
e) maintenance
90-
Alterations or.................. in an official logbook must be initialled by the authorised keeper of the
logbook and the original data entries which have been cancelled or corrected must remain legible.
corrections
91-
93-
94-
95-
96-
................... barometer doesn't including liquid inside, without - unlike mercury barometer
a) Aneroid
b) Mercury
97-
Solas 74 convention has different evalution levels for different passages which of the following is
nor an evalution
a) Length of the ship
b) Purpose of usage
c) Number of the passengers
d) Tonnage of the ships
e) Owner of the ship
98-
A ships size capasity can be described two ways linear dimensions or ...........
a) Tonnage
b) Length
c) Length overall
d) Draft
e) Width
99-
.............. is to elliminate the heat side of the fire by applying something that will absurb the heat
a) Smothering
b) Cooling
c) Smouldering
d) Prevating
e) Diluting
100-
101-
For the carriage of the goods firstly the shipper or agent sends a ................... to the carrier to
book his cargo. The document includes full explanations and facts of all the cargo
a) Booking note
b) Charter party
c) Sea report
d) Dock receipt
e) Boat note
102-
103-
105-
An instrument used for measuring the .................. of the air is called a hygrometer
a) Pressure b) Heat c) Air pressure d) Speed e) Humidity
106-
107-
108-
During the survey, the vessel's structure support systems, equipment and electronics are
inspected and ...............
a) Examined
b) Repaired
c) Replaced
d) Tested
e) Fixed
109-
........... is an official record book which is used to keep information about a journey such as the
ship's speed heading, port of call, crew complement, and events on board ship
a) A noon position report
b) A letter of confirmation
c) A log book
d) A draft survey
e) A letter of protes
110-
Is published weekly informing marines of important effecting navigational safety including new
hydrographic information changes in aids to navigation
a) The notice to marines
b) The nautical almanac
c) Planning guide
d) The pilot book
e) The sailing directions planning
111-
The main reasons to coot the underwater full is for ...... and fouling prevention.
a) Corrosion
112-
113-
114-
During navigation, navigator shall be refer to both texts and ....... example of text sailing
directions list of lights example of table sight reduction.
a) Books
b) Directions
c) Tables
115-
Notice of readiness are given to charteres agent that when the ship ........ at the port
a) Pilotage
11
116-
117-
After using co2 potable extinguisher it should ........ put back in the service.
a) If 50m co2 remaining
118-
According to COLREG vessels should be deeled to be in sight of one another when one is
observed............. from to other.
a) by radar
b) in range
c) visually
d) on course
e) and heard
119-
The success of emergency response depend on............ by voce and by radio handset between
team leaders and command area..
a) Cooperaton
b) Cordination
c) Chech lst
d) the quality of communication
120-
..... survey is a unique one and a complete inspection of all the items relating to the particular
certificate before the ship
a- initial
b- intermediate
c- annual
d- periodical
e- renewal
121-
What peepens the channels and clears the muddy bottom of ports, canals rivers?
a) Pipe layers
b) Icebreakers
c) Dredgers tarayici
d) Reefers
e) Bulkers
122-
123-
124-
125-
For ship's good condition demostration................................ and fitted, responsible person and
charge of men working - keeping
a) Maintenance
12
127-
aadakilerden hangisi kiisel can kurtarma aleti deildir diye bir soru vard?
liferaft
128-
129-
130-
Because Log books are vital documents,in the event of ........... or shipwrecks; they should be well
protected documents for this events.
a)an accident
b)drills
c)berthing operation
d)routine jobs
e)fire drills
131-
132-
133-
During navigation, shall be refer to both texts and ......... example of text sailing directions, list of
lights. Example of table sight reduction.
a) books
b) directions
c) tables
134-
135-
136-
137-
138-
139-
141-
Deadweight displacement net tonnage gross tonnage ve stowage factor tanmlam yanl
tanmlanan hangisidir diyor.
gross tonnage
142-
Haritalar aklam iki tr harita olduunu 1.si chart ve dierinde boluk var.
Electronic chart
143-
Gmdss vessel diye balayp devam ediyor ve cmlenin devamnda should be kept .
gmdss log book
144-
muster station a gelmeden nce tm ventilation larn kapal olduunu, kaplarn kapal
olduunu, emergency fire pump n altn vs. kontrol eder demi.
a) chief officer
b) second engineer
c) safety officer
d) first mate
e) 3rd officer or 2nd officer
145-
146-
147-
Vessel's lenght over all (LOA) is measured as .......... and inch diye devam ediyor.
FEET
148-
............ meteorlogy deals air and wind forecast for ships at sea
a) general
e) maritime
149-
150-
A coaster was on a journey in a fjord. Early in the morning, when the ship was to change course,
she collided with a small lighthouse. The reason why the collision took place is unknown. The
foundation of the lighthouse was circular with a flat top just underneath the water surface. Its
diameter was bigger than the diameter of the lighthouse itself, situated right on top of the
foundation. This construction causes a rather sharp outer edge, which could easily rip a ship's hull.
This was what happened - the ship's hull was ripped open and she sank within minutes. Two
persons on the bridge died. Two other crew members survived although they could not reach the
survival suits which were kept under port bridge wing as the ship immediately listed to port and
put them out of reach. One of the survivors managed to launch the starboard life raft. Another
crew member was down in the mess room and threw out a couple of life jackets. He did not
manage to get out of the mess room. The investigation found that the hydrostatic releases to the
rafts had not been properly mounted. If the starboard side raft had not been launched manually,
no raft would have been released.
We can not understand from the passage ..
a) why the vessel collided with a lighthouse
b) why the vessel sank
c) why the vessels hull was ripped
d) why the crew member in the mess room died
e) why the two other crew members survived
151-
The fixed aids to navigation located ashore or attached to the bottom of shallow waterways are;
a) buoys
b) lighthouse
c) lightships
d) beacons
e) flags
153-
meteorology report
athens meteology center
part 1 : no gale
part 2 : baleras sw1-3, w2-4, nw4-6 later strom and strong wind , moderate thunderstrom .....
which could be the weather case of baleras state?
veering saat yn dns (clockwise)
Backing saat yn tersi dns (counterclockwise)
154-
usually paper printed chart used by mariners and different type of chart entegred ..........
electronics used.
computer-based
155-
156-
157-
Bulundugunuz blge zerinde alcak basnc var. bir yksek basnca dogru ilerliyosunuz karslaslan
hava hareketi nedir?
a) low
b) hgh
c) lb
d) tayfun
e) siklon (alcak basinc)
158-
159-
160-
which can be taken if owner does not comply with class requirements
a) renewal survey carried out
b) annual survey carried out
c) need a new class
161-
162-
163-
15
164-
165-
kirli yaktlar sepere edildiinde sepere edilen kirli meteryal nereye gnderilir gibi bir soru
sludge
166-
According to the International Code of Signal, the statement I must abandon my vessel is
symbolized by means of the code letters ?
a) AE
b) BF
c) DX
d) HW
e) ED
167-
The content of any letter of protest prepared and signed by the master is to be .
a) kept in a locked drawer on board the ship
b) taken to the court by the master himself
c) passed to the owner / charterer or their agent
d) published in any regional newspaper related with the topic
e) checked and corrected by the chief officer.
168-
Geminin tekne kaplamasnn neden yapld ile ilgili bir soru vard.Sorunun iinde "coating"
geiyordu "Corrosion"
169-
A cloud of great width and an altitude of between 2000 and 7000 feet is called ..
a) nimbus
b) nimbostratus
c) stratus
d) cumulus
e) stratocumulus
170-
171-
A male passenger, Seluk Gne, aged 35, has been ill for three days. His temperature is 39 and
his pulse rate is 85. This is a description of a .................................................. ...
a) doctors state
b) nurses state
c) patients state
d) pupils state
e) customers state
172-
A receipt of goods shipped on board a ship signed by the person (or his agent) who contracts to
carry them, and stating the terms on which the goods are carried is known as . .
a) Bill of Health
b) Bill of Lading
c) Bill of Bulkhead
d) Bill of Sale
e) Notice of Readiness
173-
174-
175-
176-
177-
A vessel which is not made fast to the shore, at anchor or aground and not moving through the
water is ............
a) A vessel underway and making way
b) A vessel underway and misled
c) A vessel underway but not making way over the ground
d) A vessel underway and stopped
e) A vessel which is disabled
178-
A vessel which is used for pulling or pushing a disabled vessel is known as a/an .
a) Tug
b) OBO
c) Reefer
d) Dredger
e) Icebreaker
179-
180-
A wind which first blows from South, then changes direction to blow from the South East, then
changes direction to blow from the East is said to be ..............
a) veering
b) backing
c) clockwise
d) freezing
e) funnelling
181-
A wind which first blows from South, then changes direction to blow from the South West, then
changes direction to blow from the West is said to be ..............
a) anti-clockwise
b) deliberate
c) swelling
d) veering
e) backing
182-
183-
184-
An oil derrick is ..
a) a platform where all the needed machinery for drilling is mounted
b) all the equipment needed on the ground
c) where brokers and captains live
d) a machine used to dive into the sea bottom
e) an experienced greaser
185-
186-
At its 20 th session in November 1997, 1MOs Assembly adopted resolution A. 850 (20) on The
Human Element: Vision, Principles and Goals and, at the 21 st Assembly in November 1999, IMO
passed a resolution whereby the prime emphasis in the Organizations work was shifted away
from developing technical standards and towards the human factor. Resolution A. 900 (21)
Objectives of the Organization in the 2000s pays particularly close attention to the importance
of fostering a culture of maritime safety. This was deemed to be the Organizations prime mission
in the early years of the new millennium.
According to the above paragraph, the resolution adopted at the 21 st assembly focused more on
than.
a) developing technical standards / the human factor
b) the human factor / developing technical standards
c) the organizations work / maritime safety
d) maritime safety / the human factor
e) the previous resolution / the one of the new millennium
187-
188-
Bir teknenin dier bir tekne zerine veya rhtma, iskeleye yanamas;
a) Alongside
b) Berthing
c) Portside
d) Starboard
e) Afloading
189-
By means of radio, the captain of a ship can talk with men in other ships or with men ashore.
......., or if bad weather is ahead, he can be told of it in time to change his course.
a) TV is a means of entertainment
b) Because of it, captains keep the radio under their pillows
c) Phone too, makes communication possible
d) Whatever, the captain should maintain his course
e) He can learn if it is safe for him to go on his destination
190-
Careless and improper handling of cargo during loading and discharging operations, improper
stowage, fastening and lashing, improperly laid dunnage or lack of dunnage altogether,
insufficient ventilation or lack of it and poor separation of cargo may be considered as the main
ones.
The passage is related with ..
a) crushing
b) pilferage
c) leakage
d) damage to cargo
e) ventilation
191-
Cargo gear .
a) provides ventilation in the holds
18
192-
193-
194-
Complete the following message with a proper message marker: .................... Obstruction in the
fairway
a) Warning
b) Request
c) Information
d) Advice
e) Instruction
195-
196-
197-
Dnya scaklndaki son deiimlerin nedenlerinden biri de ozon tabakasndaki deliktir. The
English version would be ............
a) The late hole in the ozone layer is partly the result of changes in the worlds temperature
b) Due to global temperature change, you can expect a hole in the ozone layer
c) One of the reasons for the recent changes in the world temperature is the hole in the ozone
layer
d) One reason for the hole in the ozone layer is nationwide change in temperature
e) The hole in the ozone layer was the result of a sudden change in the global temperature
198-
Fire-fighting equipment ..
a) should be regularly checked.
b) might be driven
c) must be drawn
d) is loaded
e) is used for keeping liquid for foods
199-
200-
Going through water by force of wind with the help of the sails is known as :
a) Navigation
b) Steering
c) Propulsion
19
201-
202-
203-
204-
205-
206-
207-
208-
209-
If collision is imminent, which one of the two power-driven vessels has to keep out of the way?
a) The one which has the other on her starboard side
b) The one which has the other on her port side
c) The one which is faster
d) The one which is slower
e) The one which is newly bought
20
211-
If the weight of a floating ship is greater than the weight of equal volume of water displaced by
the ship, the ship will ...........
a) float
b) tilt
c) list
d) sink
e) capsize
212-
In certain fairways you must maintain a speed of ten knots exactly. The name given to this speed
is
a) quick speed
b) heart attack
c) fast speed
d) increased speed
e) fairway speed
213-
In cold water the skin and peripheral tissues become cooled and then the deep body temperature
falls
This is called as ..............................
a) drowning
b) hypothermia
c) hyperthermia
d) shock
e) immersion
214-
In these circumstances it is difficult to assess the damage caused by the collision. In Turkish you
would say .................................................. ......
a) Bu koullarda atmann hasara yol ap amayacan tahmin etmek zor
b) atmann ne gibi hasara yol atn bu koullarda aklamak zor gelebilir
c) atmann yol at zarar karlamak, bu koullar altnda ok zor
d) Farkl durumlarda atmann zararn karlamak ve karlatrmak ok zor
e) Bu koullar altnda atmann neden olduu hasar saptamak zor
215-
It usually occurs off the ship, but as stolen cargo can be unwittingly accepted by the vessel and as
sound cargo may be subject to theft after discharge, it is usually the vessel which is blamed.
Losses due to it are very serious, especially when foodstuffs, liquors and soft drinks, expensive
clothes, tools and spare parts for cars, electronic equipment and precious stones are being carried
on board ship.
The passage is about . . . . . . . . . .
a) chafing
b) collapsing
c) pilferage (hirsizlik - asirma)
d) moisture and sweating
e) rain damage
216-
Last night, being the third of the month May, Mr.Selim Yavuz, the pumper, went ashore without
leave and came back this morning. He did not turn out for work when ordered at 7 oclock. For this
reason he is fined a sum of days pay. This is a report of ............
a) offence
b) penalty
c) defense
d) accusation
e) acceptance
217-
218-
Master transmitted a distress alert ............. Inm-C which was quickly acknowledged.
a) for
b) through
c) via
d) beneath
e) beyond
219-
220-
221-
222-
Navigators sea map with coast outlines, rocks, shoals, etc.is known as .
a) Charter party b) Chart c) Charge d) Charter e) Clearance
223-
No matter how sophisticated navigational aids and safety devices become, no matter how
automated, computerized and mathematically planned become the voyages of vessels, the
element of human fallibility will always exist and will remain the prime cause of collisions in
navigable waters.
The above quotation emphasizes the importance of .. in collisions.
a) sophisticated navigational aids
b) automated vayages
c) human factor
d) computerization
e) mathematically planned voyages of vessels
224-
225-
226-
Portable rechargeable battery operated lamps shall be available in some important points.
Correct translation of this sentence into Turkish is;
a) Baz nemli noktalarda arjedilebilir, portatif bataryal lambalar bulunacaktr.
b) Baz nemli noktalarda arjedilebilen bataryayla alan, portatif lambalar bulunacaktr.
c) Portatif arjedilebilen pilli lambalar nemli noktalarda bulunacaktr.
d) Bir ka nemli noktada arjl portatif lambalar bulunacaktr.
e) arjl bataryalar tanabilir olmaldr ve baz nemli noktalarda istiflenmelidir.
228-
Port to Port Shipment: The responsibility of the Carrier is limited to that part of the Carriage from
and during loading onto the vessel up to and during discharge from the vessel and the Carrier shall
not be liable for any loss or damage what so ever in respect of the Goods or for any other matter
arising during any other part of the Carriage even though charges for the whole Carriage have
been charged by the carrier.
According to this clause of a bill of lading, the carrier shall not be held responsible for any damage
to the goods
a) after they are loaded on board the ship.
b) while they are loaded on board the ship.
c) while they were taken to the port on trucks.
d) which occured during any part of the sea voyage.
e) likely to appear following the discharging operation.
229-
Received by the Carrier the Goods specified below in apparent good order and condition unless
otherwise stated, to be transported to such place as agreed, authorized or permitted herein and
subject to all the terms and conditions appearing on the front and reverse
The above part is taken from a
a) bill of lading
b) notice of readiness
c) passenger list
d) noon position report
e) ship ullage report
230-
231-
Routine details of the voyage, any loss or damage to the ship or cargo or any related events are
kept in the .. by the mates during their watches.
a) The official Log Book
b) The Scrap Log Book
c) The Engine Room Log Book
d) The Ships Log Book
e) Manuals
232-
233-
234-
23
236-
237-
238-
The following four stages in a VHF exchange are in the wrong order. Write down the letters of the
correct sequences.
I-Agree on a working VHF channel
II-Exchange messages
III-Terminate
IV-Make contact
a) BACD
b) ABCD
c) DABC
d) CDBA
e) DBAC
239-
240-
241-
242-
243-
24
244-
The maintenance on board is the responsibility of the and the men in his charge.
a) Captain
b) Chief officer
c) Second officer
d) Third officer
e) Chief engineer
245-
The master of every ship carrying hazardous cargo other than in bulk- whether it is, or may be,
explosive, flammable, toxic, health- threatening, or environment polluting- shall in organizing safe
watch keeping arrangements take full account of the nature, quantity, packing and stowage of the
hazardous cargo and of any special conditions on board, afloat and ashore.
Considering this rule, complete the following statement in case the cargo is . , the
master must consider . while arranging
a) hazardous/ the nature, quantity, packing and stowage of the cargo/ watch keeping
b) bulk / explosive, flammable, toxic, health- threatening/ the stowage
c) special/ health- threatening or environment polluting/ the full account
d) on board/ watch keeping arrangements/ any special conditions
e) carried in bulk / any special conditions on board / watch keeping
246-
247-
The opening to the hold from the upper deck is called a/an ..
a) hatch
b) boom
c) derrick
d) upper peak
e) iner bottom
248-
249-
250-
251-
The space between the holds and the bottom of the hull contains .. used for ballast water and
fuel.
a) tweendecks
b) double bottom tanks
c) cargo-carrying compartments
d) fore peak tank
e) aft peak tank
252-
The term vessel is different from the term ship in that the term vessel is used for
a) floating craft smaller than ships.
25
253-
The weather was supposed to be nice today, but we were almost frozen to death while doing the
ships maintenance. can be expressed as .....................................
a) The weather was expected to be cold today but it is not
b) The weather was not very cold today as it was before
c) Although everyone hoped for a cold day it turned out to be nice
d) The weather was terribly cold although it had been expected to be good
e) The day was so nice and warm just as we had expected before
254-
There are certain medicines on board which you can only use when:
a) Captain orders you to do so,
b) You think it is necessary,
c) You have medical advice by radio,
d) The ill/injured person wants you to do so ,
e) The shipowner gives you instructions to do so .
255-
256-
There is no doubt that the scope of a pilots duties have over the years been clearly defined. That
he has exclusive control and conduct of the ship is seldom disputed, but this is very different from
having command of the ship. It is implied in the above mentioned quotation that
a) the scope of a pilots duties has ever been doubtful.
b) no rule has ever clearly defined as pilots duties.
c) a pilot has the conduct of the ship he is in charge of navigating.
d) a pilot has both conduct and command of the ship he is in charge of.
e) a pilots exclusive control and conduct of a ship has been a point of dispute
257-
This is to certify that before/after loading/discharging, all cargo tanks were inspected and found
empty and dry. This is an example of
a) Notice of Readiness
b) Letter of Protest
c) Dry-Tank Certificate
d) Job Application
e) Deratting Certificate-Deratting Exemption Certificate
258-
259-
260-
26
262-
When a message has been received but the information requested can not be obtained, say
________
a) No information
b) Say again
c) Message not understood
d) Message not requested
e) Message not received
263-
264-
When steel is in contact with water, air or salt solutions, it undergoes a chemical change known as
.. .
a) Coating
b) Bitumen
c) Rusting
d) Cement
e) Deteriration
265-
When the engine refuses to start, which of the following situations cannot be a reason?
a) No fuel
b) Starting air pressure to low
c) Air in fuel line or pump
d) Injection nozzles not working
e) Overloading
266-
267-
When you are going to request Radio Medical Advice, you must have some information ready.
These information are:
a) Routine particulars about the ship and the patient,
b) Particulars of the illness and the results of the examination of the ill person,
c) Diagnosis and Treatment,
d) Problems and other comments,
e) All the above.
268-
269-
27
271-
272-
273-
274-
275-
276-
277-
278-
Yangn nlemek iin tedbirler alnacaktr. Correct translation of this sentence into English is;
a) Precautions must be done to avoid fire.
b) Precautions shall be taken to prevent fire.
c) There shall be prevented with caution.
d) To prevent fire, some cautions shall be taken.
e) Fire is prevented by some precautions.
279-
280-
281-
You must shorten your cable to three shackles is an order given by a pilot station .....
a) when the pilot boards the vessel to take her from waiting anchorage into harbour
b) after the pilot boards the vessel to take her from waiting anchorage into harbour
c) immediately before the pilot boards her to take her from waiting anchorage into harbour
d) immediately after the pilot boards her to take her from waiting anchorage into harbour
e) it has nothing to do with the pilot whatsoever
282-
283-
284-
285-
A: Do not follow me B: . . . . . . . . . . . . . .
a) I am stopping
b) I will not follow you
c) What is your course?
d) Full ahead immediately
e) Must I take tugs?
286-
287-
288-
290-
If an object blocks the airway of a person, what first aid method is used to remove that object?
A) Cardiopulmonary Resuscitation(CPR)
B) Artificial Respiration
C) Heimlich Manoeuvre
D) Splinting
E) Rescue Breathing
291-
As the heat increases, hurricane begins to swirl in a counter clockwise motion. The average life of
a hurricane is only about 9 days. Water, not wind, is the main source of death and destruction in a
hurricane. A typical hurricane brings 6 to 12 inch downpours resulting in sudden floods. Worst is
the powerful movement of the sea-the mountains of water moving toward the low-pressure
hurricane center. The water level rises as much as 15 feet above normal as it moves toward shore.
ANSWER THE QUESTIONS
The counter-clockwise swirling of the hurricane is brought about by ..........
A) the low-pressure area in the center of the storm
B) the increasing heat
C) the trade winds
D) the power of water waves
E) the high-pressure area with the storm
292-
All ships which you meet at sea or in the approaches to a harbour are collectively called ..........
A) jam
B) fleet
C) power-driven lifeboats
D) tug
E) traffic
293-
294-
The masters of all merchant vessels must hold fire-fighting drills in the framework of ..............
A) World Health Organization
B) The Merchant Shipping (Musters and Training regulations)
C) Prevention of Collision at Sea (The International Regulation)
D) Maritime Judges Resolutions
E) Merchant Marine Cadets Achievement
295-
Laytime for loading and discharging shall commence at 13.00 hrs, if notice of readiness is given up
to and including 12.00 hrs, and at 06.00 hrs next working day if notice given during office hours
after 12.00 hours.
According to this clause of charter party, if the notice of readiness is given at 13.00 hours on
Friday, lay time for loading and/or discharging shall commence ..............
a) On Friday at 13.00 hours
b) On Monday at 06.00 hours
c) On Saturday at 06.00 hours
d) On Friday at 06.00 hours
296-
30
The document prepared by the vessel or by his agents separately at loading and unloading ports
stating all the operations performed by the vessel, from tendering of the notice readiness up to
sailing from port is called .
A) Statement of Facts
B) Notice of Readiness
C) Cargo Manifest
D) Mates Receipt
E) Charter Party
298-
299-
300-
301-
In which case does each of the two power-driven vessels have to alter course to starboard so as to
passone another on the port side?
A) When standing on
B) When giving way
C) When meeting end-on
D) When overtaking
E) When offering way
302-
303-
304-
Any ............. of course and/or speed to avoid collision shall, if the circumstances of the case admit
be large enough to be readily apparent to another vessel observing visually or by radar.
A) depletion
B) declaration
C) transmission
D) alteration
E) measurement
305-
307-
.............. is to elliminate the heata side of the fire by applying something that will absurb the heat
a) Smothering
b) Cooling
c) Smouldering
d) Prevating
e) Diluting
308-
309-
For the carriage of the goods firstly the shipper or agent sends a ................... to the carrier to
book his cargo. The document includes full explanations and facts of all the cargo
a) Booking note
b) Charter party
c) Sea report
d) Dock receipt
e) Boat note
310-
311-
312-
313-
314-
315-
317-
318-
319-
The ship's safety comittee should include;..............,safety officer and all respresetetive personnel
for safety...
a-all crewmember
b-the master
c-the chief engineer
d-all ratings
e-hatrlayamadm.
320-
Personel ............... or in survival craft being lowered should remain seated, keep their hands
inside to avoid them being crashed against ship side.
a) On board
b) Standing By
c) Monitoring
d) Taking part in
e) In a rescue boat
321-
Depth are measured from chart ....... which is related to the local sea level.
a) Datum
b) Information
c) Line
d) Scale
e) Symbol
322-
323-
The emergency ............. consist of seven short blast followed by prolonged blast
a) Drill
b) Alarm
c) Ring
d) Procedure
e) Response Plan
324-
When received a message from a VTS station "Instruction. Alter Course" the recipient
a) Has to alter course
b) Musnt alter course
c) Keep clear
325-
The main reasons to cool the underwater full is for ...... and fouling prevention.
a) Corrosion
326-
After using co2 potable extinguisher it should ........ put back in the service.
a) If 50m co2 remaing
33
............ meteorlogy deals air and wind forecast for shps at sea
a) General
e) maritime
328-
Weather ............... is chart that displays various meteorology features across a particular area of a
particular
Map
329-
meteorology report
athens meteology center
part 1 : no gale
part 2 : baleras sw1-3, w2-4, nw4-6 later strom and strong wind , moderate thunderstrom .....
which could be the weather case of baleras state?
veering
330-
A vessel would be referred to as "tender" when the weight of the cargo is __________.
a. evenly distributed vertically and the double bottoms are full
b. concentrated low and the double bottoms are empty
c. concentrated low and the double bottoms are full
d. concentrated high and the double bottoms are empty
331-
332-
333-
.......show full details of all cargo on board the ship and ssued for customs declaration
a-mate receipt
b-nor
c-sof
d-manifesto
e-time sheet
334-
335-
336-
337-
gemi ve irket arasnda her trl emniyet konularnda irketin en st dzey grevlileriyle irtibata
geebilen kii kimdir? (karada atanm gibi cevrilmis bariz dpa yani designated kelimesi
kullanlms emnm dpa)
designated person
338-
incase ship has headway ..avoid cumping on liferaft canopy or ..... liferaft....
starboard
port
astern
on top of
in front of
340-
If a centrifugal pump is noisy with excessive vibration during its operation, the cause would most
likely be due to_____________
a) Bent shaft
b) Worn wearing rings
c) Reverse rotation
d) Excessive sealing water pressure
e) B and C
341-
342-
343-
344-
A propeller turning clockwise when viewed from aft is considered rihgt handed and most single
screw ships have_____________propellers. A twin screw ship usually has
a___________________________propeller and a___________________________propeller.
a) Right handed/right handed starboard/left handed port
b) Right handed/right handed port/left handed starboard
c) Left handed/right handed starboard/left handed port
d) Left handed/right handed port/left handed starboard
e) Right handed/left handed starboard/right handed port
345-
_____________the fire pumps are at work. What word can be used instead of underlined part?
a) inoperable
b) operable
c) in operation
d) arranged
e) out of order
346-
347-
In case of burning of radio equipments on the bridge the extinguishers should be the same as the
ones to be used in_____________fires, keeping in mind that the fire will turn out to be
a_____________fire when starting firefighting takes long.
a) Class E/Class A
b) Class E/Class B
c) Class B/Class A
35
348-
349-
While making your rounds, you notice the main lube oil temperature is higher than normal. To
remedy (care olmasi adina) this situation, you should:
a) Speed up the main lube oil pump
b) Open the lube oil cooler seawater inlet valve wider
c) Throttle in on the lube oil cooler seawater discharge valve
d) Close the lube oil cooler seawater discharge valve wider
e) Open the lube oil cooler seawater discharge valve wider daha genis
350-
Radar alm; radio detecting and ranging (saptayan ve mesafe tayin eden)
351-
Haritalar aklam iki tr harita olduunu 1.si chart ve dierinde boluk var.
Electronic chart
352-
353-
After loading cargo, cargo manifest is prepared based on the ............. it describes the ship cargo in
terms of packing weight, quantities, shipper name, consignee name.
a) Bill of Lading
b) Damage Report
c) Notice of Readiness
d) Statement of Facts
e) Protest
354-
For classification survey, the following is to be kept on board and made available to the surveyor
on request
a) Class certificates and other documentation of significance,
b) Reports on previous surveys performed,
c) Approved drawings,
d) All the above,
e) None of the above
355-
I have herewith the pleasure in informing you that my vessel is in all respects ready to
commence working as per above in accordance with terms of mentioned charter party. Yours
faithfully. Master
The above mentioned remark takes place in a/ an
a) Notice of readiness.
b) Bill of lading.
c) Letter of credit.
d) Negotiable bill of lading.
e) Time charter party.
356-
This is to notify you officially that vessel . under my command has arrived in your port on ...
at . hours and is ready to discharge/load cargo of kilos of .. as per clauses and
conditions of the covering charter-party. Master. This is an example of a . .
a) Notice of Readiness
b) Letter of Protect
c) Bill of Lading
d) Bill of Health
e) Bill of Sale
357-
Going through water by force of wind with the help of the sails is known as :
a) Navigation
36
358-
basn tablosu veriyorlar seceneklerden hangsnde daha sddetl rzgar olur gb b soru vard
-tablodak en alcak basnc olan nokta
359-
360-
all ship which you meet at sea or in the approaches to a harbour are collectively called....
traffic
361-
362-
363-
364-
365-
366-
The Cargo Securing Manual is required on all types of ships engaged in the carriage of all cargoes
other than solid and liquid bulk cargoes.
cargo securing manual
367-
368-
369-
370-
371-
Kaptan 1 gemisi singapur limanna yanam ve gemi kaptan protesto notu hazrlam ve
gndermi bu notu ne iin hazrlam olabilir?
a) Geminin kt havaya girip kargoya hasar gelmi olabileceinden phelenmi
b) Tayfann kargodan aldndan phelenmi
37
372-
Geminizde bilinsiz yatan ve ...... eklinde hastalar var bunlarn aciliyet sras kanamal, solunum
yetmezlii , bilin kayb eklinde olmaldr.
a) bleeding
b) freezing
c) uncondinuous
373-
Grafiklerle hazrlanms olup denizciler iin faydal bir aratr. (pheli klara sahip bir soruydu)
a)nautical chart
b)Notice to mariners
c)Tide tables
d)Norries tables
374-
During Port State Control Procedures, there are certain definitions, to limit or authorize the port
state control officer (PSCO), executing his/her responsibility. Choose the correct answer: A Port
State control officer is :
a) The Administration representative of the flag state
b) The senior command authority of the coast guard of the port state
c) A person duly authorized by the competent authority of a party to a relevant convention, to
carry out port state control inspections, and responsible exclusively to that party
d) A person who meets the relevant conditions set forth by resolution A. 739 (18) and has been delegated by
the flag state administration
e) The captain of the coast guard boat
375-
The quantity of oil in separated water is controlled by a control unit. What sentence below has the
same meaning?
a) Control unit controls the oil quantity and separate it.
b) The quantity of oil is separated and controlled by control unit
c) The oil quantity in water is separated by control unit
d) Control unit controls the oil quantity in separated water.
e) Separated water in oil is controlled by control unit.
376-
377-
There are some Certificates/documents which are internationally recognized and have to be
carried on board. These are checked/inspected by the port state control officer (PSCO) when
he/she/they come on board. One of the following certificates does not have to be carried on board
on tanker. Choose that certificate and mark it :
a) Document of compliance, Solas 74, Regulation II-2/54,
b) Oil record book, Parts I and II
c) Cargo record book
d) Document of Authorization for the carriage of grain
e) Minimum safe manning document
378-
During the inspection of the machinery spaces on board for oil and oily mixtures, the port state
control officer ( PSCO) may determine and takes into account:
a) If reception facilities have been used
b) If there is any inadequacy of such facilities
c) The quantity of oil residues generated
d) The capacity of sludge and bilge water tank and the capacity of the oily-water separator
379-
380-
38
The success of emergency response depend on............ by voce and by radio handset between
team leaders and command area..
a) Cooperation
b) Cordination
c) Chech lst
d) the quality of communication
382-
383-
Immersion suits help reduce the .......... of body heat and shock on entering cold water,
immersion suits are critically important life saving appliances.
a)temperature
b)loss
384-
385-
Maintenance of the ship is the responsibility of the chief officer and his men in his charge.they
must protect the ship from the damaging effects of ... changes in temperature and the action of
waves.
a)oil
b)bunker
c)any liquid
d)salt water
e)fresh water
386-
Which sentences is true for Inspections of the outside of the ship's bottom of cargo ships.
Inspections of the outside of the ship's bottom of cargo ships being carried out with both ship is in
drydock and afloat.
387-
When checking of the lighting of the muster and embarkation stations and the alleyways,
stairways and exits giving access to the muster and embarkation stations, including when
supplied from the emergency source of power which survey being carried out.
Safety construction certificate survey
Safety electrical installation survey
Safety Equipment certificate survey
388-
Before apply first layer of paint, last particles on bare metal removed with .....
Line Brush
Flat Brush
Wire Brush
Chipping hammer
389-
390-
391-
392-
emergency stop valve, ve diger yag kacrablecek systemlerle ilgili hangi surveyde kontrol eder
hangsne grer
iopp
393-
394-
395-
You are treating a shipmate with a compound fracture of the lower arm. Which action should you
take?
A) Apply a tourniquet to control bleeding then align the bones and splint.
B) Apply traction to the hand to keep the bones in line, splint, and apply a pressure dressing.
C) Force the ends of the bones back into line, treat the bleeding, and splint.
D) Apply a bulky, sterile, pressure dressing to control bleeding, then apply a temporary splint, and
obtain medical advice
396-
The beam of a ship is its width at the ....widest.... point as measured at the ship's nominal
waterline.
397-
398-
399-
DUNNAGE NEDR?
Yk paralarnn skp ezilmemesini, slak yerlere dememesini, havalanmasn salamak ve baz
yklerde de fork lift kullanlmasna olanak vermek amacyla ykler arasna ve altna konan ou
kez tahtadan- malzemeye verilen isim.
400-
401-
A vessel cannot comply with all of the SOLAS requirements due to its construction. Where will this
be indicated?
A) Nowhere; the vessel must comply to engage in international trade.
B) On the reverse of the SOLAS certificate
c) On the Exemption Certificate
D) On the Certificate of Inspection
402-
403-
Glen surat sagging hizli ezber!!! geminin ortasnda droop olursa ne olur
hag
sag
404-
405-
406-
407-
408-
409-
410-
411-
412-
The most effective first aid treatment for chemical burns is to immediately __________.
A) apply ointment to the burned area
B) flood the affected area with water
C) wrap the burn with sterile dressing
D) apply an ice pack to the burned area
413-
The fore and aft run of deck plating which strengthens the connection between the beams and
the frames and keeps the beams square to the shell is called the __________.
A) garboard strake
B) limber strake
C) sheer strake
D) stringer strake uzunlamasina borda kaplamasi
414-
Bir konuma paragraf vermi 4.kaptan ve 2.kaptan arasnda geciyor 2.kaptan drop the life boay
talimatn bosuna bildir diye sylyor 4.kaptan da sylediini onaylyor
-what did the chief off ask the third off to do after informaning the bosun?
a) organise recovery action
b)transmit the distress call
c)plot the ships pos
d)drop the lifeboat
e)call the roll
415-
According to this clause of a charter party, if loading operation is performed on holidays, time
spent for loading ............................ ; otherwise, these days ...........................
41
416-
417-
The vertical joint formed when two steel plates are ent to end is called a.............
a)butt
b)butress
c)bond
d)seam
e)bevel
418-
419-
420-
421-
422-
423-
424-
If is there more thab one unconscious and _____ casualt. You must start first aid in order of dont
have pulse,Have severe bleeding, conscious
a) Bleeding
b) Breathing
c) Vomitting
d) Asphyx
425-
................... use many credentials, letters, and terms such as "accredited", "certified", "qualified",
"AMS", "CMS", etc. fill in the blangs
a)inspector
b)class
c)marine survey
d)psco
e)harbour master
426-
427-
428-
When chipping rust on a vessel, the MOST important piece of safety gear is __________.
A) goggles
B) gloves
C) ahard hat
D) helmet
E) googles (oltaya gelmeyin)
429-
A vessel loads 100 tons of glass jars. The mate on watch discovers that some of the cartons have
been damaged and has an exception made on the Bill of Lading. What is this document called?
a)Damage Bill of Lading
b)Letter of Indemnity
c)Non-negotiable Bill of Lading
d)Unclean Bill of Lading
430-
431-
usually paper printed chart used by mariners and different type of chart entegred .......... electronics
used
computer-based
432-
433-
434-
(forumlarda bu soru tam tersi verilmi) uygun tama yaplabilmesi iin solas a gre liferaft arl
ne kadardan fazla olmamaldr.
a-185 kg
b 50 kg
c- 110 kg
d- 155 kg
435-
436-
gemi class denetimi geirmi ve class dan atlm. aadakilerden doru olan seiniz
a- geminin tekne ve makinesi class yeterliliklerini karlamad iin
b- gemi sagibinin class yeterliliklerini bakm tutum ile karlamad iin
c- gemi 12 yandan byk olduu iin
d- a+b
e hibiri
437-
To sound the tanks and bilges in order to check the depths of liquit in them is the regular job of a
.. on board
43
438-
Although you had been informed about the bad weather conditions,you ignored it and had an
accident.You say as a regret..
A)I feel dizzy when I have a few drinks
B)I should have the ship overhauled before setting out for the voyage
C)What if the shipowner gets worried!
D)Why on earth did not I pay attention to the warning on the radio?
E)It is useless to listen to the weather reports.
439-
Immersion suits help reduce the .......... of body heat and shock on entering cold water,
immersion suits are critically important life saving appliances.
b)loss
440-
441-
442-
443-
444-
445-
446-
gemi yukunu yuklemeye baslamadan once yapilmasi gereken AMBAR ilaclamasindan kim
sorumludur?
a) charterer's survey
b) dpa
c) harbor master
d) bayrak devleti
447-
denizde kotu hava sartlarina maruz kaldiginiz zaman bazen yuku denize atma gibi bir durumla
karsilasabilirsiniz. boyle bir durumda gerekli rapor hazilanip ve yakindaki gemilere bu durum seyir
emniyeti icin bildirilmeli.
Bu paragraph verilmis ve bosluk birakilarak ; yukun denize atilmasi nasil ifade edildigini sormus/
jettison/jettisoning agirlik bosaltmak
448-
449-
450-
451-
452-
453-
which factor below s not the cause of vbraton and nose n turbness
d) unbalans
e) dstorton of casngs
f) loose couplings
g) tight (siki) couplings
h) any above
454-
455-
Flood current?
A) Horizontal Current, after low tide from land
B) Horizontal Current, after high tide from land
C) Horizontal Current, high water from sea
D) Horizontal Current, low water from sea
E) Horizontal Current, neap tide from land
As the tide rises, water moves toward the shore. This is called a flood current. As the tide recedes (geri
cekilmek), the water moves away from the shore. This is called an ebb current. The movement of water
toward and away from the shore is illustrated by the movement of the green seaweed. Tidal currents that ebb
and flood in opposite directions are called rectilinear or reversing currents.
456-
Klozu tam hatrlayamadm iin, Vardiya zabiti seyir fenerlerinin pozisyonunu amacn ve grn
alarn iyi bilmelidir diye balayan bir soru. Devamnda seyir fenerleri diye balayan bir
cmle .................. and standings into danger... Bolua ne gelecek?
A) En Route
B) On The Way
C) Off Course
D) Safe
E) On the Described Route
457-
458-
459-
460-
45
462-
cargo havalandirmasinda 3kuralinda, should a.... ventilation if out of air below 3 gibi deiik bir
soru vardi.
hygrostatic cargo
463-
464-
radio operatr is able to carry out the receving and.... ,distress,urgency safety ?
transmiting
465-
If you are bunkering and you close off one tank in the line of tanks being filled, the rate of flow to
other open tanks on the same line will __________.
a. increase
b. decrease
c. stop
d. remain constant
466-
467-
Battery Room larn havalandrlmas gerektiini sylemi , hemen aklma Hidrojen gaznn
birikmemesi iindir diye dndm ama klarda yoktu; klar da unlar vard:
a) flammable gases larn birikmesi olasll olduu iin
b) Co2 build up demi
c) battary lerin oksijenli ortamda daha iyi arj olduklarn sylemi
d) oksijen ile elektrolit lerin daha iyi olduunu sylemi (alakas yok)
e) yine sama bir neden vermiti
468-
469-
470-
Bir pararaf vermi ve paragrafa gre Pilot kalk manevras iin gemiye geliyor ve Pilot card
exchange yaplyor ancak buradaki baz bilgiler yanl ve hem pilot hemde gemi kaptan bunun
farkna varmyor ve buradaki hatay soruyor.
Pilot sorusu kolay ama dikkatli okumak gerekiyor, sorunun cevab iskele krlang ykseliinin
hesabnn yanl yaplmas olacak
471-
472-
gemide ship safety officer, supervisor olmal ancak bunun olmadn belirtmi ve ayrca supervisor
n bir officer olabileceini sylemi ve dier paragrafta ise supervisor n baz flag state lere gre
zorunlu olduu ve bu kiinin de ratingler arasndan seleceini belirtmi ve 3.
paragraftada boluk brakarak bu durumda supervisor n kim olabileceini sormu
46
473-
the day to day state of atmosphere and its short term variation's is:
a) climantology
b) meteorology
c) weather
d) atmosphere
e) synoptic meteorology
474-
Ky ile yaplan bir telsiz muhaberesinde sizden bir bilgi istiyorlar, fakat o bilgi sizde yok 10 dk
sonra elinize geecek vb., bu durumda ky istasyonuna ne demeniz gerekir.
-imdi msait deil
-daha onra bilgi aktarrrm
-10 dakika sonra bilgi veririm
475-
Procedures and technics beyond the .......... ability should not be attemts since more harm than
good might result.
a) victim's
b) patient's
c) rescuer's
d) casualty's
e) first aid receiver's
476-
a certificate issued to a company or responsible person that complies with the requirements of
the ISM code
a) DOC
b) objective evidence
c) SMC
d) NOR
e) complemantary issue of certificate
477-
commercial ship often keep .......... a preliminary draft of the ship cours, speed, and other
data which is the writen as the official log the final version of the ship record.
a) scrap log
b) proper log
c) unofficial log
d) officer's log
e) clean log
478-
liferaftlar can simitleri vs. ile ilgili gemide nerede ve ka adet bulundugunu gsteren bilgi iin neye
bakmak gerekir diye
safety equip.
479-
480-
481-
class srvey ile ilgili bir soru geldi .....no unapproved modification and construction ...diye gidiyor
soru. bu ne srveyidir diye soruyor.
a-)annual (Annual Survey; it should also include a visual examination to confirm that no
unapproved modifications have been made to the ship and its equipment)
b-) intermediate
c-)renewal
d-)inital
482-
483-
.... suspect of cargo damage when wheather is foul ... which document Master prepares?
Sea protest
47
485-
486-
deniz haritalarnda landmarks, lights, ... ilave olarak hangi bilgi bulunur?
seabed information
487-
488-
489-
490-
491-
The maximum distance at which a light may be seen under existing visibility conditions is called
__________.
a. nominal range
b. luminous range
c. charted range
d. geographic range
492-
493-
to reduce the number of strakes at the bow, to strakes are tapered and joined at their ends
stealer plate
494-
timber la ilgili bir soru; upright fixture that provides support for some other object.Minumum 3 m
distance between them...
Stanchions (Babadalya)
495-
496-
Examining the location of the lighting (muster station, emberkation ladders, emergency exits...),
including.... emergency source of power.... is part of?
a)Ship safety certificate
b)Ship safety construction certificate
c)Emergency lighting certificate
Safety equipment survey
48
498-
499-
500-
501-
Soru da Gemi ykleme yapmadan nce ambarlar surveyor tarafndan kontrol ediliyor ve ambarlar
satisfied olarak bulunuyor. Surveyor hangi evrak gemiye verir.
a: Accept
b: Fit
c: Satisfield
502-
503504505506507-
508-
509-
Adamin bas parmagina (thumb) balikci oltasi ignesi(fishhook) takiliyor. Nasil mudahale edersin
diyor
a)-Push the barb(cengel), cut it off then remove the hook
510-
Guvertede araba tasiyan gemiler icin araba en etkin nerede tasinmalidir diyordu
a)One of the hatch immedialty backward of midship
b)-No 1 hatch
c)-Forward hatch
d)-One of the hatch immedialty forward of midship
e)-On the deckhouse
49
checking the provision of means of embarkation and disembarkation from ships for use in port and
in port-related operations, such as gangways and accommodation ladders-which certificate
..
a)-safety equipment cert
b)-LL cert
c)-Safety contruction cert
d)-Deck department cert
512-
Cargo gear annual srvey tamamlandktan sonra uygulanacak prosedr nedir diyordu?
attaced to cargo gear certificate
513-
Kaptan bir yazi yazmis c/p ye gore yukleme yaptim,. tarihi ve saatinde bilmem ne limaninda
shifting yaptim diyor. Butun olaylarin sorumlulugu aliyorum diyor. Bu yazilan nedir diyordu.
a)-Nor
b)-Letter of protest
c)-Bill of lading
d)-Time .
514-
515-
516-
genel kural geregi toplanma istasyonunda herkes can yelegini giymis sekilde toplanir.ancak bazi
durumlarda bu yapilmaz, yelekler ellerde hazir tutulur .. Buna kim karar verir
a)-owner
b)-safety officer
c)-master
d)-chief officer
e)-chief engineer
517-
518-
Seabed old day sounding pipe, this times (eski zamanlarda dip olcumu yapilamiyordu.suan
ise bilmem ne sayesinde olcumler daha kolay vs diyordu.
echosounding
519-
Gemi jurnalinden bahsetmi... jurnale hava raporu, rota sicaklik vs -en az hangi sklklarda jurnal
doldurulmaldr?
a)weekly
b)daily
c)monthly
d)hourly
e)nemli bir olay sonrasnda hemen
520-
The upward slope of a vessels bottom from the keel to the bilge is called __________.
A rake
B sheer
C camber
D rise of bottom
50
If an electric cargo winch is being used to lift a draft of cargo and the engine room loses all power,
which will occur?
A The load will fall rapidly to the deck unless the foot brake is engaged.
B An electromagnetic brake will hold the load where it is suspended.
C A pawl, forced by a spring mechanism, will engage the teeth of the bull gear and hold the load.
D The load will slowly lower to the deck under control of the drag of the winch motor.
522-
Which type of vessel shall be required to have an emergency towing arrangement fitted at both
ends?
A An 18,000 dwt ton tanker constructed in 1998
B A 22,000 dwt ton tanker operated after Jan. 1, 1999
C A 30,000 dwt ton oil barge
D A 5,000 dwt ton coastal tanker
SOLAS 1974 Chapter V, regulation 15-1 requires all tankers of 20,000 tonnes deadweight and
above, including oil, chemical and gas tankers, to be provided with an emergency towing
arrangement at both ends of the ship
523-
Vertical structural members attached to the floors that add strength to the floors are called
__________.
A stiffeners kizak
B boss plates
C buckler Plates
D breast hooks
524-
Gemi operasyon srasnda shifting yapmak zorunda kalms ama c/p de shifting olmadg icin metin
asagdakilerden hangisine aittir.
notice of readiness
bill of lading
protest of letter
testimonial
525-
526-
527-
528-
529-
Gemi ambar temizliinden dolay off hire oluyorsa bu ambara survey satisfied olmad iin .
belgesi verir
Unfit
530-
531-
Which device is designed to automatically hold the load if power should fail to an electric winch?
Electromagnetic brake.
532-
Diesel engines obtain combustion air through turbo chargers, blowers, or __________.
A natural aspiration soluma
B air starters
C air receivers
D carburettors
533-
534-
The joint formed when two steel shell plates are placed longitudinally side to side is called a
__________.
A bevel
B bond
51
535-
536-
"North Harbour, this is Amphora, this is Amphora, on channel 14, over" is an example of...
First contact
537-
What is the difference in height between MHW (high water) and MLW (Low water)?
Range
538-
539-
Which sentence is true for inspections of the ship's bottom of cargo ships.
Inspections of the outside of cargo ships bottom bottom of cargo ships being carried out with both
ship is in drydock and afloat
540-
Bill of Lading ile ilgili bir paragraf vermi, bu durumda yklenme durumu nedir gibi bir soru
sormu. Cmlede ykn yklenmi olduu anlatlyor. Bu nedenle;
carrier received the goods
541-
542-
Sesli ve grsel alarm (ballast and dry space gibi ifadeleri de ieren bir cmle vard) SOLAS' a gre
hangi tr gemiler iin zorunluluktur eklinde sormu.
Bulk Cariers
543-
544-
545-
---- what does not disbursement account (masraf hesaplari) includes an expense?
a) fuel
b) store
c) port due
d) custom fee
e) freigth
546-
52
547-
548-
549-
Securing cargo by running timbers from an upper support down to the cargo, either vertically or at
an angle, is called __________.
A shores
B Toms
C braces
D dunnage
550-
What is the period of validity of the SOLAS required Cargo Ship safety construction Certificate?
A 12 months
B 24 months
C 48 months
D 60 months
551-
552-
Which variable factor affects the initial lashing requirements aboard Ro-Ro vessels?
A Size and weight of vehicle/cargo unit
B Air pressure in the vehicles tires
C Age of vehicle or cargo unit
D Reputation of shipper concerning condition of cargo
553-
Which variable factor affects the initial lashing requirements aboard Ro-Ro vessels?
A Port of origin
B Vessel's draft
C ABS requirements
D Number, position and angle of lashings
554-
Your load line certificate expires on 27 May 1988. The vessel is surveyed on that date and is found
satisfactory. You are sailing foreign the same day. Which statement is TRUE?
A A new certificate must be issued before you sail.
B The existing certificate is extended for a period of up to 150 days.
53
555-
556-
557-
558-
What term indicates the outward curvature of the hull above the waterline?
A sheer
B tumble home
C Flare
D deadrise
559-
What term indicates an inward curvature of the ship's hull above the waterline?
A Deadrise
B Tumble home
C Camber
D Flare
560-
561-
562-
documented vessel operating over 50 miles offshore must carry an inflatable liferaft with a
__________.
A solas B pack
B coastal pack
C solas A pack
D small vessel pack
563-
564-
565-
566-
What may NOT be used when securing heavy vehicles aboard Ro-Ro vessels?
A Chain lever
B Chain
C Webbing
D Turnbuckle
567-
568-
Damage to cargo caused by fumes or vapors from liquids, gases, or solids is known as __________.
A oxidation
B vaporization
C Tainting
D contamination
569-
570-
571-
For an upright vessel, draft is the vertical distance between the keel and the __________.
A amidships section
B Waterline
C Plimsoll mark
D freeboard deck
572-
To ensure receipt of all relevant MSI, a NAVTEX receiver should be turned on at least how many
hours prior to departure from port?
A6
B8
C2
D4
573-
Cargo that is highly susceptible to damage by tainting from odorous cargo is called __________.
A dry cargo
B delicate hassas cargo
C immune cargo
D clean cargo
574-
Cargo that gives off fumes that may contaminate other cargo is known as a(n) __________.
A dirty cargo
B toxic cargo
C delicate cargo
D odorous cargo
575-
576-
Your vessel is required to have a slop chest. Which of the following articles is NOT required by law
to be carried in the slop chest?
A Blankets
B Candy
55
577-
578-
What is the major limitation in using the sight reduction Tables for Air Navigation Volume I (Pub.
No. 249) for star sights?
A More accuracy is needed for celestial observations on board ship than what is tabulated.
B Only first magnitude stars are tabulated.
C Sights must be made at even time increments to benefit from the tables.
D Only certain stars are included and sights must be limited to those stars.
579-
When determining compass error by an azimuth of Polaris, you enter the Nautical Almanac with
the __________.
A GHA Aries
B LHA Polaris
C lha aries
D GHA Polaris
580-
581-
Aqueous Film Forming Foam (afff), commonly known as 'light water', is especially suitable for
fighting __________.
A any class D fire
B oil fires in the engine room bilges
C class C fires in paint lockers
D all of the above
582-
583-
The distance between the bottom of the hull and the waterline is called __________.
A freeboard
B reserve buoyancy
C draft
D tonnage
584-
the fore and aft run of deck plating which strengthens the connection between the beams and the
frames and keeps the beams square to the shell is called the __________.
A stringer (uzunlamasina kiris) strake
B garboard strake
C sheer strake
D limber strake
585-
You are in a tropical port. The refrigeration machinery on a container loaded with air- cooled fruit
fails. It cannot be repaired for 18 to 24 hours. Which step should you take to reduce the
temperature rise and spoilage of the fruit?
A Discharge a cylinder of nitrogen into the container
B Spread ice over the top layer and in any voids within the container
C Seal any ventilation openings and add dry ice
D Shade the container and periodically hose it down (sulamak)
586-
587-
The complete details of a crude oil washing system aboard your vessel, including the operating
sequences and procedures, design characteristics, a description of the system, and required
personnel will be found in the __________.
A crude oil washing Operations and Equipment Manual
B Code of Federal Regulations
C Oil Transfer Procedures Manual
D crude oil washing addendum to the Certificate of Inspection
588-
589-
590-
Before a tank is to be crude oil washed, what position must the oxygen content in the tank must
be measured at?
A in the vent riser
B immediately above the level of the oil
C at the top of the tank
D one meter from the deck
591-
592-
593-
594-
595-
The IMO requires cargo securing manuals on certain vessels. Which of the following are required
to maintain this manual onboard?
A RoRo Carriers
B Liquid Bulk Carriers
C LNG Carriers
D Solid Bulk Carriers
596-
597-
598-
599-
Which variable factor affects the initial lashing requirements aboard Ro-Ro vessels?
A Vessel's draft
B Center of gravity of vehicle or cargo unit
C Changes in humidity
D Age of vehicle or cargo unit
600-
601-
602-
603-
You are docking a ship with a single-screw tug assisting on your starboard bow. How should the
tug be tied up if you are anticipating (nce davranmak )that she will have to hold your bow off
while you stem the current?
A The tug should put a stern line up, leading ahead on the ship.
B One head line would be sufficient.
C The tug would need at least two head lines.
D The tug should put a spring line up, leading astern on the ship.
604-
When instructing a crew member concerning the right way to lift a weight, you would instruct him
to __________.
A arch the back to add strength to the muscles
B bend his back and stoop
C bend (bkmek) his knees and lift with his legs
D bend his back and stoop with arms straight
605-
What does it mean to "shore up" (payanda vurmak) the main deck for the stowage of deck cargo?
A strengthen the main deck by placing pillars underneath it in the tween-decks
B package the cargo in wooden crates so it will not damage the deck
C distribute the weight of the cargo by placing fore-and-aft planks on the main deck
D weld pad eyes on deck in proper position to secure the cargo
606-
58
A periodic thorough examination of the cargo gear proves satisfactory. What percentage of the
total gear must be dismantled (cikarmak) to determine actual internal condition?
A None
B 10%
C 25%
D 100%
608-
The water in which a vessel floats provides vertical upward support. The point through which this
support is assumed to act is known as the center of __________.
A effort
B buoyancy
C gravity
D flotation
609-
Onboard a Ro-Ro vessel many decks are used for the carriage of both rolling and container
cargoes, as such it is most useful if a deck socket accepts both __________.
A container locks and bridge fittings
B twist-Locks and lashing hooks
C bridge fittings and lashing hooks
D twist-locks and container locks
610-
The biggest problem you generally encounter while towing a single tow astern is __________.
A yaw rotadan cikis dmeni ktye saptirma
B swamping of the tow
C the tow tending to dive
D the catenary dragging on the bottom
611-
Your chart indicates that there is an isolated rock and names the rock using vertical letters. This
indicates the __________.
A rock is dry at high water
B exact position of the rock is doubtful
C rock is a hazard to deep draft vessels only
D rock is visible at low water springs only
612-
The only portable electrical equipment permitted in a compartment which is not gas free is a lamp
that is __________.
A self-contained
B approved explosion proof
C battery fed
D All of the above
613-
Which danger exists to people when co2 is discharged into a small enclosed space?
A Respiratory arrest (solunum durmasi)
B Damaged eardrums
C Frostbite
D Electric shock
614-
615-
When using a pneumatic chipping tool all of the following are TRUE except?
A The equipment is not required to be grounded to prevent shock hazard.
B The equipment shall be secured to the hose by a quick-disconnect coupling to prevent the tool from
becoming accidentally disconnected.
C It is not intended to be used in an explosive atmosphere.
D The needles of the needle-type chipping gun must be replaced when they have been blunted
more than ½ of their diameter.
616-
59
Combustible gas indicators operate by drawing an air sample into the instrument __________.
A where it is mixed with nitrogen
B where its specific gravity is measured
C over an electrically heated platinum filament
D where it is ignited by a sparking device
618-
619-
Normally It is desirable to have screens on the vents of potable water tanks to __________.
A prevent explosions
B filter the incoming air
C stop insects from entering
D prevent backups
620-
621-
622-
Normally Your vessel is on a voyage of three months duration. The number of sanitary inspections
required is __________.
A one
B three
C six
D twelve
623-
624-
625-
You are berthed at a cargo facility where you have just completed discharging a dangerous cargo.
You must complete topside repairs involving hot work before sailing. Which of the following
statements is TRUE?
A The repair area must be inspected by a marine surveyor to ensure that it can be done safely.
B The Captain of the Port may give specific approval to make hot work repairs.
C You can make repairs with permission of the facility owner since you are empty and the cargo is on the
facility.
D Hot work repairs at such a facility are prohibited.
626-
627-
628-
Your vessel has gone aground in waters where the tide is falling. The BEST action you can take is
to __________.
A shift the vessel's load forward and wait until the next high tide
B shift the vessel's load aft and repeatedly surge the engine(s) astern
C set out a kedge anchor (tonoz demiri)
D slowly bring the engine(s) to full speed astern
629-
The best information on the location of the blocks when dry docking a vessel is contained in the
__________.
A ship's docking plan
B general arrangement plan
C docking diagram
D shell expansion plan
630-
631-
The Sailing Directions (Enroute) contain information on all of the following EXCEPT __________.
A ocean currents
B tidal currents
C outer dangers to navigation
D major port anchorages
632-
The maritime radio system consisting of a series of coast stations transmitting coastal warnings is
called __________.
A NAVAREA
B HYDROLANT/HYDROPAC
C NAVTEX
D SAFESEA
633-
634-
Water ballast placed in a tank that has been crude oil washed, but not water rinsed, shall be
regarded as __________.
A segregated ballast
B dirty ballast
C crude oil
D clean ballast
635-
The agency which assigns Load lines and issues Load line Certificates is the __________.
A American Bureau of Shipping
B U.S. Coast Guard
C U.S. Customs
D Secretary of Commerce
636-
When referring to dry bulk cargoes, the term "flow state"(akim hali) __________.
A relates to the suitability of loading a cargo by flowing down inclined chutes
B designates the state of a commodity when the ship is heeled past the angle of repose
C refers to the saturation of a dry bulk product with water to the point where it acts as a liquid
D relates to the minimum granule size of a particular product where it will flow like a liquid at an angle of
30°
637-
the official logbook is filed with the Officer in Charge, Marine Inspection (OCMI) __________.
A at the end of the year with all other official logbooks
61
638-
If the vertical center of gravity (vcg) of a ship rises, the righting arm (GZ) for the various angles
of inclination will __________.
A increase
B be changed by the amount of GG' x cosine of the angle
C decrease
D remain unchanged
(Gm is decreased)
639-
640-
The Boom stops on a pedestal crane prevent the boom from __________.
A swinging at sea
B being lowered too low
C being raised too high
D overloading when not in use
641-
642-
643-
The original Bill of lading, once signed by the Master, is NOT __________.
A surrendered to the customs agency of the country where the cargo is discharged
B a receipt and proof that goods have been received on board
C proof of title or ownership of the cargo
D used to transfer ownership of the cargo while the ship is enroute
644-
Cargo pump rooms on tank vessels, constructed in 1965, handling grade C liquid cargo shall have
power ventilation systems. What is time requirement for these ventilation systems to completely
change the air?
A 1 minute
B 3 minutes
C 5 minutes
D 10 minutes
645-
Your vessel has completed an inspection for certification and is issued a temporary certificate.
This __________.
A must be posted in the vicinity of the officers' licenses
B expires six months after it is issued
C has the full force of a regular Certificate of Inspection
D must be exchanged for a regular Certificate of Inspection before going foreign or out of state
646-
62
One advantage of Chain over wire rope for a tow bridle is that chain __________.
A is better suited for inland towing
B handles more easily
C resists damage from chafing (asinma)
D equalizes towing forces better
648-
The instrument most commonly used to gather the data for determining the relative humidity is
the __________.
A psychrometer
B hydrometer
C barometer
D anemometer
649-
The total weight of cargo, fuel, water, stores, passengers and crew, and their effects, that a ship
can carry, is the __________.
A bale cubic
B loaded displacement
C gross tonnage
D deadweight
650-
For vessels fitted with cargo gear, an initial test of the units under a proof load shall be conducted.
Subsequent tests and exams of the same nature shall be carried out at what time interval?
A 1 year
B 3 years
C 4 years
D 5 years
651-
652-
653-
cribbing" is __________.
A cardboard separation pieces placed between deck loads to prevent chafing
B a crate in which a deck cargo is packaged
C the chains and shackles used to secure a deck cargo
D wooden blocks or dunnage placed between a deck load and the deck
654-
Fires which occur in energized electrical equipment, such as switchboard insulation, are class
__________.
AA
BB
CC
DD
655-
A major advantage of the Navtex system when compared to other systems is that __________.
A broadcasts are at scheduled times
B warnings are printed out for reading when convenient
C the information can be received on an ordinary FM radio
D a low frequency band is used for long distance transmission
656-
63
658-
659-
The usual method of arranging a line on deck so that it will run out easily without kinking or
fouling is __________.
A flemishing the line
B faking down the line
C racking the line
D coiling the line
660-
661-
Which factor is MOST important in preventing Sweat damage within a cargo hold?
A Outside air temperature
B Dew point of the outside atmosphere
C Dew point of the cargo hold
D Temperature of the cargo
662-
663-
664-
When fruit is carried as refrigerated cargo, the most frequent cause of its being infected at the
discharge port is __________.
A improper pre-cooling of the cargo spaces
B leaks in the ship's refrigeration system
C carriage at the wrong temperature
D improper cleaning of the cargo spaces
665-
666-
667-
668-
You have abandoned ship and are in an inflatable raft that has just inflated. You hear a continuous
hissing (islik sesi) coming from a fitting in a buoyancy tube. What is the cause of this?
A The inflation pump is in automatic operation to keep the tubes fully inflated.
B Excess inflation pressure is bleeding off and should soon stop.
C A deflation plug is partially open allowing the escape of CO2.
D The saltwater is activating the batteries of the marker lights on the canopy.
669-
670-
671-
672-
673-
The internal volume of a cargo hold measured from the inside faces of the cargo battens, the lower
side of the deck beams, and the top of the tank top ceiling is known as the __________.
A bale cubic
B stowage area
C deadweight space
D gross tonnage
674-
Which can be prevented only by segregating two lots of cargo into separate holds?
A Contamination of a clean cargo by a dirty cargo
B Contamination of a food cargo by an odorous cargo
C Overcarriage, overstowage, and short landing
D Contamination of dry cargo by a wet cargo
675-
676-
677-
678-
Distance along a track line is measured on a Mercator chart by using the __________.
A longitude scale near the middle of the track line
B latitude scale near the middle of the track line
C latitude or longitude scale at the middle of the scale
D latitude scale at the mid-latitude of the chart
679-
680-
681-
A major advantage of the NAVTEX system when compared to other systems is that __________.
A broadcasts are at scheduled times
B warnings are printed out for reading when convenient
C the information can be received on an ordinary FM radio
D a low frequency band is used for long distance transmissio
682-
683-
684-
685-
the Coast Guard broadcasts urgent marine storm warning messages on which of the following
frequencies?
A 156.80 MHz (VHF-FM Ch. 16)
B 2670 KHz
C 157.10 MHz (VHF-FM Ch. 22A)
D None of the above
686-
687-
688-
The welds used to join shell plates in flush construction are known as __________.
A continuous welds
66
689-
The numeral in the center of a wind rose circle on a pilot chart indicates the __________.
A percentage of calms
B average wind force on the Beaufort scale
C total number of observations
D average wind force in knots
690-
Metal Plates that cover the top of the hawsepipe are called __________.
A buckler Plates
B stop waters
C plugs
D footings
691-
The safety stopper that prevents the anchor cable from running free if the cable jumps the wildcat
is the __________.
A buckler Plate
B devil's claw
C spill pipe
D riding pawl (kastanyola sikmasi)
692-
Vertical structural members attached to the floors that add strength to the floors are called
__________.
A stiffeners
B boss plates
C buckler Plates
D breast hooks
693-
694-
Which of the following statements is/are TRUE concerning cranes being installed on the centerline
of vessels?
A One crane is able to work both sides of the ship.
B One crane is able to work one end of two adjacent hatches.
C They are more economical and weigh less.
D All of the above
695-
696-
Which device is designed to automatically hold the load if power should fail to an electric winch?
A Electromagnetic brake
B Hand brake
C Pneumatic brake
D Motor controller
697-
If an electric cargo winch is being used to lift a draft of cargo and the engine room loses all power,
which will occur?
A The load will fall rapidly to the deck unless the foot brake is engaged.
B An electromagnetic brake will hold the load where it is suspended.
C A pawl, forced by a spring mechanism, will engage the teeth of the bull gear and hold the load.
D The load will slowly lower to the deck under control of the drag of the winch motor.
698-
699-
700-
701-
702-
In cargo hold ventilation, the three-degree rule suggests that a .. shoul be ventilated when the
temperature of the outside air is at least 3 C below that of cargo temperature taken at loading
A cargo sweat
B hygroscopic cargo
C ship sweat
d- drying
e- dehumidifier
703-
The most important life-saving skills in an emergency treatment are articial respiration, heart
compression and .
applying CPR(Cardiopulmonary resuscitation)
oxygen administration
operation the patient
transportation of the casually
the control of severe bleeding
704-
Routine
Distress
Urgency
Security safety
True order of the priority of calls is
A 3-4-2-1
B 1-3-4-2
c- 2-1-3-4
d- 2-3-4-1
e- 2-4-3-1
705-
which type of certification survey includes a check that all the certificates,record books operating
manuals and other instructions and documentation specified in the requirements relevant to the
particular certificate have been placed on board the ship ?
a Initial
b- document approval
c- partcular
d- renewal
e- approval
706-
What is the name of region where the atmosphere pressure is lower than that of surrounding?
A anti- lyphoon
b- Low
c- tight
68
707-
record in writing what has been decided and who has to act
Masters system rewiew
Safety comite meeting
Emergency response team of company nstructons
The minutes of meeting
logbook
708-
The vessel's ............. is measured vertically from the lowest point of the hull, ordinarily from the
bottom of the keel, to the side of any deck that you may choose as a reference point
a-width b-height c-depth d-draft
709-
rolo sa yklemesi ile ilgili bir paragraf vard.paragrafta "locking coil" kelimesinin altn izerek
yerine kullanlacak kelimeyi sormu. key coil
710-
711-
05 martta bir sertifika expire olmakta ve geminin limana kadar varabilmesi iin 04 harizana kadar
uzatma alnm.renewal survey yaplrken balang tarihi hangisi olmaldr.
a-05th mar b-04th of jun c-04th of jan d-05th of jan
712-
Examination of the calculation and drawings for the sufficent safe working load of towing and
mooring equipment to enable the safe conduct of all towing and mooring operation in normal
operation of the ship is a subjenct of:
A Safety constructon certificate survey
b- safety equpment certfcate survey
c- load lne certfcate survey
d- class condtonal certfcate survey
e- certfcate of nspecton survey
713-
The most important life-saving skills in an emergency treatment are articial respiration,heart
compression and .
applying CPR(Cardiopulmonary resuscitation)
oxygen administration
operation the patient
transportation of the casually
the control of severe bleeding
714-
715-
716-
Which of the following is irrelevant with the survey of crude oil washing system?
a) Testing ballast pipelines that through Cargo tanks and those cargo pipelines that pass through
ballast tanks to ensure there is no cross contamination
b) Examing washing piping, pumps, valves and deck-mounted washing machines for leakage.
c) Carrying out pressure testing of the washing system to 1.5 times the working pressure
d) Checking that, when fitted, steam heaters for water washing can be properly isolated during oil washing
operations.
717-
718-
Damage to cargo caused by fumes or vapors from liquids, gases, or solids is known as TAINTING
720-
721-
When should a crane boom-up so high that the boom hits the stops?
a. Only if the load has not exceeded the limit at that angle
b. Only if the load contains non-hazardous materials
c. Only if necessary to perform a given lift
d. Never
722-
You have been towing astern and have just let go the tow. Your deckhands are pulling in and
faking the towline by hand on the stern. The most dangerous action to take is to
A-continue ahead at slow speed
B-continue ahead at half speed
C-stop your engines
D-back down on your engines
723-
724-
Which of the following statements is/are TRUE concerning cranes being installed on the centerline
of vessels?
A One crane is able to work both sides of the ship.
B One crane is able to work one end of two adjacent hatches.
C They are more economical and weigh less.
D All of the above
725-
The upward slope of a ships bottom from the keel to the bilge is known as __________.
a. camber
b. slope
c. deadrise
d. keel height
726-
727-
Under Hormanized System of Survey and Certification , what is the maxium period for inspection
of the ....
12 month
728-
A cloud of great width and an altitude of between 2000 and 7000 feet is called
..
a) nimbus
b) nimbostratus
c) stratus
d) cumulus
e) stratocumulus
729-
70
A fire started in the main engine room of a vessel when at sea. Both main engines were stopped
by the crew. The ship had full electrical power supply during the event due to having a separate
auxiliary engine room. The crew used CO2 and water to start the fire, which was finally
extinguished after about 4 hours.
Which of the underlined words must be changed to get a correct meaning?
a) at sea
b) stopped
c) used
d) start
e) finally
731-
Which statement about immersion suits is TRUE? belki bu sekilde bir soru olabilir mi?
a. Immersion suits should be worn during routine work on deck to provide maximum protection.
b. After purchasing, the suit should be removed from its storage bag and hung on a hanger where readily
accessible.
c. Immersion suits must have a PFD light attached to the front shoulder area.
d. Small leaks or tears may be repaired using the repair kit packed with the suit.
732-
733-
775-
776-
Your vessel is issued a load line certificate dated 29 April 2010. What is NOT an
acceptable date for one of the surveys for endorsements?
a) 28 January 2011
b) 29 February 2012
c) 26 September 2013
d) 24 June 2013
777-
778-
779-
71
801-
802-
803-
What document is issued after the final check discharged cargo at the port of
destination?
a)Cargo manifest
b)Mates receipt
c)The outturn report
d)Fixture note
e)The disbursement account
804-
What equipment for fog signals is required for a vessel 13 meters in.
a)whistle only
b)whistle and bell
c)bell only
d)bell and gong
e)whistle , bell and gong
805-
806-
807-
808-
809-
What peepens the channels and clears the muddy bottom of ports, canals rivers?
a) Pipe layers
b) Icebreakers
c) Dredgers
d) Reefers
e) Bulkers
810-
812.
813.
814.
815.
816-
817-
818-
819.
changes may be made to the scrap log but the official log is considered
permanent.............erasured
73
821.
all specifics and facts regarding the vessel's current condition and .......... are
covered in the marine survey conducted by the surveyors
a)only machinert
b)only inert gas systems
c)seaworthiness
d)the hull e)crewmembers
822.
a kind of thermometer the bulb of which is kept moistened while reading the level of
humidity is called.....
a) human thermometer
b) fever thermometer
c) doctor's thermometer
d) dry bulb thermometer
e) wet bulb thermometer
823.
824.
825.
The best know reason for the pollution during bunkerin is occured with ;
a) More pressure
b) first receiving the Bunker
c) final topping off
d) revoming the pipes and fixing back
e) sagging hose
826.
the masters of all merchant vessels must hold fire-fighting drills in the framework
of
A) Worid Health Organizaton.
B) The Merchant Shipping (Musters and Training regulations).
C) Prevention of Collision at Sea (The International Regulation).
D) Maritime Judges Resolutions.
E) Merchant Marine Cadets Achievement
827.
828.
829.
Before apply first layer of paint, last particles on bare metal removed with .....Line
a) Flat Brush
b) Wire Brush
c) Chipping Brush
d) hammer
e) Brush hammer
830.
Navigators find his position by using the tecniques of coastal navigation when..........
a) land is out of sight
b) land is in sight
c) land is out of mind
d) land is too far away
e) land is invisible
74
832.
The only portable electrical equipment permitted in a compartment which is not gas
free is a lamp that is __________.
a) battery fed
b) self-contained
c) approved explosion proof
d) All of the above
833.
During loading operation of steel bar, vessels crew recognize that goods have rusty
surface. Master of ship state the B/L RUSTY STAINED remark. Diye devam eden bir
cmle var. Daha sonra tahliye limanna gidiliyor ve ykte deep corrosion olduu
farkediliyor. 500.000$ bir zarar kyor. en sonra bu zararn neden olutuun savunmak
ilk bata b/l e ...... yazldndan dolay zordur diyor.
a) Forklift damage
b) Crane damage
c) Stevadorsdamage
d) Pitting and rusty
e) Powdered rusty whole surface
834.
835.
Which one is the Major advantages of Navtex over other transmission methods
a) It broadcasts in scheduled.
b) It transmits with low frequency and long distance
c) Transmissions can receive basic FM receiver
d) You can read and print message
e) Updated informations can be received continiously.
836.
837.
The carriage a variety of cargoes between various without salling on regular routes is:
a) time charter
b) voyage charter
c) best charter
d) combined charter
e) gencon charter
838.
initial surveys of cargo gear carried out completely and frequently surveys are made
in
a) Annually
839.
Hold, ballast and air dry spaces must have visual and audible signals acc to solas in...
a) Bulk carriers
b) Tankers
c) Passsenger
d) Ro-ro
e) passenger roro
840.
During loading cargo , chief difference is that the damage occurred, but the damage
had been written on the bill of loading .what it is called;
a) external bill of lading
b) Damage bill of loading
c)Exceptional bill of lading
841.
843.
844.
Carbon dioxide extingguishers should be held only by the handle and the thermaly
insulated grip on the hose. Otherwise, it will cause ...............
a) Insulation
b) Heart attack
c) Steam burns
d) Ice burns
e) Non conduction
845.
Marine animal with valved shell which atteched it self to hulls of ship?
a) Barnacle (Kaya midyesi)
b) Moss Yosun
c) Fish Balk
d) Algae Alg
e) Binnacle Pusula dolab
846.
847.
Which of the following equipment can not be used for Fire Fightining?
a) CO2 Fixed System
b) Dry Chemical Powder
c) Hand Flares
d) Fireman Outfit
e) Fire Alarm
848.
849.
850.
851.
852.
A victim has suffered a second-degree burn to a small area of the lower arm. What is
the proper treatment for this injury?
a) Immerse the arm in cold water for 1 to 2 hours, apply burn ointment, and bandage.
b) Open any blisters with a sterile needle, apply burn ointment and bandage.
c) Apply burn ointment, remove any foreign material and insure that nothing is in contact with
the burn.
d) Immerse the arm in cold water for 1 to 2 hours, open any blister and apply burn ointment.
853.
Unless there is danger of further injury, a person with a compound fracture should
not be moved until bleeding is controlled and ____.
a) the bone has been set
b) the fracture is immobilized
76
855.
856.
857.
858.
859.
First aid treatment for small cuts and open wounds is to _____.
a) lay the patient down and cover the wound when the bleeding stops
b) stop the bleeding, clean, medicate, and cover the wound
c) apply an ice pack to the wound and cover it when the bleeding stops
d) apply a hot towel to purge the wound, then medicate and cover it
860.
Depths which have been measured are indicated by the numbers shown on the chart.
Depths on charts published in most parts of the world use _____________.
a) meters b) feet c)fathom d)desimetre e)cable
861.
862.
the most effective cooling agent among those normally used to fight fires is ......
a)water fog or spray
b)chemical foam
c)mechanical foam
d)carbondioxide
863.
Dear sirs,
I am writing to find out whether the post advertised in the ''motor ship'' is still vacant.I am 38
years old and have been working as a met efor the past sever years. I got the master's
certificate in 1992 and since that time I have been worling for the Tukish Ocean Lines on board
General cargo , container and Ro-Ro vessels. As I am leave now I can be available for the job
any time. Looking forward to your prompt reply , I remain, This correspondense is an
example...
a) testimonial
b )master's report of the voyage
c) letter of exceptions
d) job application
e) exract of log book
864.
865.
............is available by either by vhf or by direct contact with a doctor from a port or
77
868.
869.
870.
871.
872.
873.
A weather forecast states that the wind will commence backing. In the Northern
Hemisphere, this would indicate that it will __________ .
A) shift in a clockwise manner
B) shift in a counterclockwise manner
C) continue blowing from the same direction
D) decrease in velocity
874.
875.
876.
Ullage is the.......................................................
A) space left for the explosion of the heated oil
B) space left for the passage of the heated oil.
C) space left for the expansion of the heated oil.
D) space left for the diffusion of the heated oil
E) space left for the interaction of the heated oil.
78
878.
879.
880.
The _________ is a person appointed by the company and the ships master for
ensuring the security of the ship. He coordinates with ship board personnel and port
authorities to carry out all ship operations with utmost security.
a) ship safety officer
b)ship security officer
c)designated person
881.
Ballast kept in tanks seperated from cargo pipes and tanks is called _________
Balast.
a)Permanent
b) Dirty
c)Clean
d) Segregated
882.
If casuality has severe bleeding which is the first thing you try?
a)Applying tourniquet
b)Applying pressure over wound with wad of sterile gauze or other clean material.
c)Applying antiseptic
883.
884.
885.
886.
887.
Baspike yaglama yagi falan filan konamaz die bi soru vardi hangisinin partidir
a) P&i assessment cert
b) Tank designation cert
c) Safety construction initial cert
d) Safety equip renewal cert
e) Loadline initial cert
888.
The nautical chart holds crucial information such as__________, landmarks, and
seamarks. There are symbols that describe the seabed, such as the depth of the ocean,
possible hazards, and tidal information.
a) seabed notification
889.
Oily rags stored in a pile that is open to the atmosphere are a hazard because they
may __________.
A) deteriorate and give off noxious gasses
79
CO2 cylinders forming part of a fixed fire extinguishing system must be pressure
tested at least every
__________.
A) year B) 2 years C) 6 years D) 12 years
891.
When dry chemical extinguishers are used to put out class B fires, there is a danger
of reflash because dry chemical_________.
A) is not an effective agent on Class B fires B) does little or no cooling
C) dissipates quickly D) is rapidly absorbed by the liquid
892-
893-
894-
Placing a lashing across a hook to prevent a fitting from slipping out of the hook is
called __________.
A) faking B) flemishing down C) mousing kanca bagi D) worming
896-
897-
The S.S. Microwave has been chartered to the Longline Steamship Company. The
Longline Steamship Company agrees to pay all expenses and employ and pay the crew.
Which type of contract is involved?
a. Bareboat Charter Party
b. Lease Charter Party
c. Time Charter Party
d. Voyage Charter Party
898-
Your vessel is chartered under a time charter party. Under this type of charter party,
your responsibility is __________.
a. solely to the charterer for all matters pertaining to cargo and ship administration
b. solely to the cargo shippers and consignees
c. solely to the owner, as under normal conditions
d. to the owner for vessel administration and to the charterer for cargo operations and
schedule
899-
900-
901-
902-
904-
A vessel has a charter party for one voyage to carry a full load of manganese from
Durban, South Africa, to Baltimore, Maryland, at a stipulated rate per ton. Which type of
contract is involved?
a. Bareboat charter party b. Voyage charter party c. Demise charter party d. Time charterparty
905-
The lashings on a stack of containers with interlocking fittings restrain the forces
that cause __________.
a. toppling
b. racking gerilme
c. buckling
d. crushing
906-
The part of a windlass which physically engages the chain during hauling or paying
out is the __________. (cekme ya da koloma etme)
a. devil's claw
b. bull gear
c. wildcat
d. cat head
907-
908-
When connecting the tow bridle to a tug, the end of the bridle is passed with a
a. heaving line b. shot line c. high line d. messenger line
909-
at the discretion of the inspector, but in no greater detail than required for original certification
at the discretion of the inspector, but in no lesser detail than required for original certification
generally similar in scope to the inspection required for certification, but in less detail
equivalent to the inspection required for certification
910-
Changing direction by bringing the stern of the vessel through the eye of the wind is
known as __________.
a. jibing b. running before the wind c. Tacking d. reefing
911.
The region containing 3/4 of the mass of the atmosphere and the region to which are
confined such phenomena as clouds, storms, precipitation and changing weather
condition is called __________.
a. stratosphere
b. troposphere
c. stratopause
d. tropopause
913.
914.
Select the proper prepositions for the blanks , to complete the sentence on that
occasion .
Kelly really was . luck it was as if every thing had combined her.
81
916.
Read the text carefully and answer the questions accordingly. Transporting oil by
tankers in the artic sea is mostly carried out by fleets of nuclear ice breakers and
relatively small. After the introduction of azipods vessel operating in the ice will be able
to transport crude oil without icebreaker asistance new tankers meet all the international
requirements related to the safety of navigation and the protection of the marine environment. so
ice is still a challenge but not a major problem anymore with the most advanced and unique
technical such as azipods.
According to passage what makes this ship so unique?
a)it means all the international requirements
b)it can operate at minus 40 celcius
c)it does not need the assistance of an ice-breaker
d)it is able to carry crude oil in the artic sea
e)it protect he marine environment
917.
Different dangerous good are considered in campatible if their stowage together may
result in undue hazard in the case of leakage , spillage or any other accidents. Which of
the following measures can be used to prevent above mentioned hazards.
a)discrepancy
b)segregation
c)disorder
d)decontamination
e)allotment
918.
919.
A sentence with five underlined word or phrases is given as below for the sentence.
Chose the one underlined word or phrase that incorrect in stamdadr writen Englishmark answer.
The congressman , accompained by secret service agent and aides , are preraring to enter the
convention hall within the next few minutes.
a)within the next b)by c)to enter d)are e)aides
920.
A short conversations betwen two people is given below. Chose the answer that
most accurately answer the questions on what is started or implied by speakers mark the answer.
Captain:Which broke the copt machine
Seafarer:I don't know it was jammed when tired it
Captain:it bugs me when some body does that and just leaves it that was
What does the captain imply.
a)he damaged the machine
b)He thinks the machine has been repaired
c)He thinks somebody broke machine and kept quict about it
d)There are inspects the machine
e)He thinks that the machine does perfectly the work
921.
Select the correct answer from the list of choices to complete the sentence
All crew onboard must have a feeling
a)off responsibility
b)to be responsibility
c)of responsibility
d)responsible e)resposibility
922.
923.
924.
925.
find the correct word of the phrase missing in the following sentence.
Hi mario i do actually have a homework_______to do. The deadlines Monday and i'm
afraid i will have to do in during weekend so i will be quite busy.
a)work b)duty c)job d)assignment e)mission
82
927.
928.
929.
930.
931.
932.
933.
Examining the arrangements for remote closing for the valves oil fuel, lubricating oil
and other flammable parts of
a-Safety Equipment Survey
b-Safety Construction Survey
c-Safety Engine Survey
d-Int. Oil. Pol. Prev. Cert.
e-Oil Seperation and Filtering Equipment Survey
934.
935.
The supplement of the IOPP Certificate what type of ... diye devam ediyor
a-A checklist of equipment instaded for controlling the discharge of oil
b-the grades of cargo that ship is permitted to carry
c-The trade routes upon which the vessel may operate
d-A list of underwrites who will assume financial responsibility in the event of an oil spill
937.
938.
941.
942.
943.
The quantity of oil in separated water is controlled by a control unit. what sentence
below has the same meaning?
a) Control unit controls the oil quantity and separate it.
b) quantity of oit is separad and controlled by control unit
c)theoil quantity in water is separated by control unit
d)Control unit controls the oil quantity in separated water.
e) Separated water in oil is controlled by control unit.
944.
945.
What occurs when the boundary between a cold and a warm air mass does not
move in any direction?
a)wave-like air mass b)cyclone c)occluded front d)stationary front e)anticyclone
946.
947.
During the inspection of the machinery spaces on board for oil and oily mixtures, the
port state control officer ( PSCO) may determine and takes into account:
a) If reception facilities have been used
b) If there is any inadequacy of such facilities
c) The quantity of oil residues generated
d) The capacity of sludge and bilge water tank and the capacity of the oily-water separator
948.
949.
The rescuer can best provide an airtight seal during mouth-to-mouth resuscitation
by pinching the victim's nostrils and_________________.
a)cupping a hand artund the patient's mouth
b) keeping the head elevated
c)applying his mouth tightty over the victims
d) holding the jaw down firmly
950.
951.
Hemlich
I-Bend the person sightly forward
II-Repeat untill the object is expelled from the airway
84
954.
955.
956.
957.
958.
For small, first-degree burns the quickest method to relieve pain is to __________.
A) immerse the burn in cold water
B) administer aspirin
C) apply petroleum jelly
D) apply a bandage to exclude air
959.
960.
961.
962.
The most important concern in treating a person with extensive burns is __________.
A) reducing disfigurement
B) preventing infection
C) cooling with ice water
D) reducing swelling
963.
964.
The wooden planking that protects the tank top from cargo loading is called
__________.
a) ceiling B) shores C) frames D) toms
966.
967.
A deck fitting, used to secure line or wire rope, consisting of a single body with two
protruding horns is called a __________.
A) bitt B) bollard C) capstan D) cleat (koc boynuzu)
968.
969.
970.
971.
972.
The lashings used on Ro-Ro vessels should be capable of withstanding the forces of
__________.
A) pitching and heaving
B) rolling
C) any force of gravity acting on the lashes
D) All of the above
974.
975.
Which statement about entry into a water ballast tank that has been sealed for a long
time is TRUE?
A) A "buddy system" should be used where someone enters the tank with you.
B) Sea water acts on the ship's metal and generates chlorine gas which may accumulate in
poisonous quantities.
C) You should always wear a gas mask.
D) After ventilation and testing, and the tank is found safe for entry, someone should
stand by at the tank entrance while you are inside.
976.
Which statement about entering into a tank which has been sealed for a long time is
TRUE?
A) The tank should be tested only once to ensure the oxygen content is at least 14% before
entry.
B) The tank must be tested at frequent intervals to ensure that hazardous gasses have
not regenerated.
C) The tank need not be tested for oxygen content if it is ventilated for more than 24 hours.
D) If the oxygen content tests at less than 12% you should wear an approved gas mask.
980.
Which hazard probably would NOT be encountered when entering an empty but
86
983.
984.
986.
987.
988.
989.
990.
991.
When the dew point of the outside air is higher than the dew point of the air in the
cargo hold, you should ______.
A) energize the exhaust blowers
B) energize the intake blowers
C) not ventilate the cargo holds
D) ventilate the cargo holds
992.
When the dew point of the outside air is lower than or equal to the dew point of the
air in the cargo hold, you should _______.
A) secure all ventilation
B) shut down the exhaust blowers
C) shut down the intake blowers
D) ventilate the cargo holds
87
994.
What is the danger to people when co2 discharged in small enclosed space
a) electric shock
b) respiratory (solunum) arrest
c) frostbite
995.
Difference in terms between in tonnes Displacement of the ship in Summer Line and
S.G: 1.025, and Light Weight of the ship.
a. Net tonaj
b. Gros tonaj
c. Constant
d. Deadweight
996.
997.
998.
999.
1000.
1001.
1002.
A power driven vessel pushing ahead or towing alongside on the Mississippi River
shall carry
a. two masthead lights, side lights and stern lights
b. two masthead lights, side lights and two towing lights
c. side lights and two towing lights
d. one masthead light, side lights and stern lights
1003.
1004.
1005.
You are an anchor watch. As an aid to preventing thievery on the vessel you should ..
a. show running lights, anchor lights and deck lights
b. only show the required anchor lights and keep the rest of the vessel darkened.
c. maintain water on deck with fire hoses led out and all purpose nozzles attached.
d. show anchor lights, deck lights and cargo lights hang over the vessels side.
88
1007.
1008.
Using a safety factor of five, determine what is the safe working load for 3-1/2 inch
Manila line with a breaking stress of 4,9 tons.
a. 0.85 tons
b. 0.96 tons
c. 2.45 tons
d. 12.25 tons
1009.
Which of the following statement (s) is/are TRUE regarding twin pedestal cranes ?
a. Each single boom is of the partial level luffing type and is capable of limited rotation.
b. A slew drive system provides for rotation of each crane.
c. An independent slew drive system rotates the turntable.
d. All of the above
1010.
1011.
A mean sun is used as the referance for solar time for three reasons. Which reason
is not a cause for use of a mean sun?
a. The motion of the apparent sun is along the ecliptic.
b. Measurement of the time is along the celestial equador.
c. The speed of the Earths revolution is not constant.
d. There are variations in the Earths rotational speed.
1012.
1013.
1014.
1016.
If is there more thab one unconscious and _____ casualt. You must start first aid in
order of dont have pulse,Have severe bleeding, conscious
a) Bleeding
b) Breathing
c) Vomitting
d) Asphyx.
1017.
What is NOT generally a characteristic of inhaling light naphtha? (Gaz ya benzeri bir eyi
soluma)
89
Dizziness
Headache
Vomiting
Coughing
1018.
You are attempting to recover a mooring buoy. If you approach the object on the port tack, how
would you slow the vessel as you draw near?
a. Quickly change to a starboard tack as you reach the object.
b. Shift the rudder from port to starboard several times as you reach the object.
c. Bring the wind so that it comes over the stern and ease all the sheets.
d. Bring the wind directly over the bow and allow the sails to luff.
1019.
1020.
1021.
A marker pole, with a horseshoe buoy and a sea anchor attached, should be used to __________.
a. mark the position of a lost mooring
b. determine your vessel's sideslip underway
c. determine your speed through the water
d. indicate location of a man overboard
1022.
What does the term "head" mean when applied to a fire pump?
a. Length of the discharge pipe
b. Height of the discharge pipe
c. Difference between the discharge and suction pressures
d. Sum of discharge and suction pressures
1023.
An uncontrolled flow of gas, oil, or other well fluids into the atmosphere is called a __________.
a. flow
b. breakout
c. kick
d. blowout
1024.
You are offloading garbage to another ship. Your records must identify that ship by name and
show her
__________.
a. home port
b. next port-of-call
c. Master
d. official number
1025.
An entry of water, gas, oil, or other formation fluid into the wellbore is called a __________.
a. blowout
b. kick
c. gusher
d. flow
1026.
1027.
1028.
1029.
The platform that supports the derrickman (vincci) when tripping pipe is called the __________.
90
1031.
1032.
1033.
As a vessel changes course to starboard, the compass card in a magnetic compass __________.
a. first turns to starboard then counterclockwise to port
b. also turns to starboard
c. remains aligned with compass north
d. turns counterclockwise to port
1034.
1035.
1036.
1037.
Under the Pollution Regulations, garbage disposal records must be kept __________.
a. two years
b. one year
c. until the next Coast Guard inspection
d. until the end of the voyage
1038.
1039.
If the result of loading a vessel is an increase in the height of the center of gravity, there will
always be an increase in the __________.
a. metacentric height
b. righting arm
c. righting moment
d. vertical moments
1040.
What is one of the FIRST actions you should take after abandoning and clearing away from a
vessel?
a. Identify the person in charge.
b. Gather up useful floating objects.
c. Prepare for arrival of rescue units.
d. Arrange watches and duties.
1041.
In the event of a fire, the doors to a stair tower must be closed to prevent the spread of fire by
__________.
a. ventilation
b. convection yayilim, iletimi
c. radiation
d. conduction
1043.
All of the following are part of the fire triangle EXCEPT __________.
a. fuel
b. electricity
c. oxygen
d. heat
1044.
Which statement is TRUE concerning life jackets which are severely damaged?
a. They should be replaced.
b. They must be tested for buoyancy before being continued in use.
c. They can be repaired by a reliable seamstress.
d. They can be used for children.
1045.
The discharge side of every fire pump must be equipped with a __________.
a. gate valve
b. pressure gauge
c. check valve
d. strainer
1046.
If a hurricane several hundred miles away is moving in your general direction your barometer would
start to fall gradually
The prevailing winds in the band of latitude from approximately 5N to 30N are the northeast trade
winds
1047.
1048.
1049.
1050.
1051.
1052.
1054.
Although KG for a MODU in lightweight is relatively high, the vessel is stiff because __________.
a. KM is small
b. KM is high
c. BL is small
d. KB is large
1055.
1056.
1057.
While retrieving (alinma) the survival craft, the engine should be stopped __________.
a. when the craft clears the water
b. when the cable has been attached
c. on approach to the platform
d. at the embarkation
1058.
To find the cause of a gasoline engine's failure to start, you should __________.
a. break the joint in the fuel line at the engine and let the gas run in the bilges
b. disconnect the wires at the spark plugs and make the spark jump the gap
c. prime the engine with ether through spark plug openings
d. ventilate the space, then check the battery, spark plugs, carburetor, and fuel line
1059.
The wooden plug fitted tightly in the vent of a damaged tank may prevent the tank from
__________.
a. filling completely
b. developing free surfaces
c. developing free surface moments
d. collapsing
1060.
1061.
The center of buoyancy and the metacenter are in the line of action of the buoyant force
__________.
a. only when there is positive stability
b. only when there is negative stability
c. only when there is neutral stability
d. at all times
1062.
1063.
1064.
93
Your sailing vessel is docked during a storm and is in continuous motion. If a mooring line parts
due to vessel motion, it will most likely do so __________.
a. where it is made fast on the vessel
b. midway between the vessel and the dock
c. at the eye
d. at the chock
1066.
1067.
1068.
1069.
1070.
While in port, what signal flag would inform the vessel's crew to report on board because the
vessel was about to proceed to sea?
a. "P"
b. "H"
c. "U"
d. "A"
1071.
When a sea anchor for a survival craft is properly rigged, it will __________.
a. completely stop the survival craft from drifting
b. help to prevent broaching
c. prevent the survival craft from pitching
d. prevent the survival craft from rolling
1072.
When fighting a fire in a space containing an IMO class 1 hazardous cargo, the most effective fire
fighting procedure is to __________.
a. shut down the ventilation and exclude all air to smother the fire
b. use water from fire hoses or a sprinkler system
c. activate the fixed CO2 firefighting system
d. use high-expansion foam
1073.
A message by flashing light consists of the call, the identity, the text, and the __________.
a. destination
b. answer
c. time
d. ending
1074.
You are alone and administering CPR to an adult victim. How many chest compressions and how
many inflations should you administer in each sequence?
a. 5 compressions then 1 inflation
b. 15 compressions then 2 inflations
c. 20 compressions then 3 inflations
d. 30 compressions then 4 inflations
1075.
When administering artificial respiration (tenefs) to an adult, the breathing cycle should be
repeated about
__________.
a. 12 to 15 times per minute
b. 18 to 20 times per minute
c. 20 to 25 times per minute
d. as fast as possible
1076.
The rescuer can best provide an airtight seal during mouth-to-mouth resuscitation by pinching the
victim's nostrils and __________.
a. cupping a hand around the patient's mouth
94
1078.
If the patient vomits during mouth-to mouth resuscitation (ayiltma), the rescuer should FIRST
__________.
a. ignore it and continue mouth-to-mouth ventilation
b. pause for a moment until the patient appears quiet again, then resume ventilation mouth-tomouth
c. switch to mouth-to-nose ventilation
d. turn the patient's body to the side, sweep out the mouth and resume mouth-to-mouth
ventilation
1079.
1080.
1081.
Physical exertion on the part of a person who has fallen into cold water would __________.
a. be the best thing to try if there was no rescue in sight
b. increase survival time in the water
c. increase the rate of heat loss from the body
d. not affect the heat loss from the body
1082.
A crew member has suffered frostbite to the toes of both feet. You should __________.
a. immerse the feet in warm water
b. warm the feet with a heat lamp
c. warm the feet at room temperature
d. rub the feet
1083.
1084.
A crew member has suffered frostbite to the toes of the right foot. Which is NOT an acceptable
first aid measure?
a. Rub (ovalamak) the toes briskly (serince).
b. Elevate the foot slightly.
c. Rewarm rapidly.
d. Give aspirin or other medication for pain if necessary.
1085.
What are the most important reasons for using water fog to fight fires?
Cools fire and adjacent surfaces, provides protective barrier
When evacuating a seaman by helicopter lift, which statement is TRUE?
Flags should be flown to provide a visual reference as to the direction of the apparent wind.
When the handle of an all-purpose nozzle is in the forward position, the nozzle will shut off the water
Which statement about firefighting foam is TRUE? Foam conducts electricity.
Limit switches on gravity davits should be tested by pushing the switch lever arm while the winch is running
1086.
1088.
Which procedure should be followed when individuals are rescued in cold climates and suffer from
hypothermia?
a. Give them brandy or other alcoholic stimulation to promote a return to normal body
temperature.
b. Move them to a warm room to gradually raise their body temperature.
c. Keep them moving to stimulate circulation to raise their body temperature.
d. Immerse them in a hot bath to rapidly raise their body temperature.
1089.
The most effective treatment for warming a crew member suffering from hypothermia is
__________.
a. running or jumping to increase circulation
b. raising body temperature rapidly by placing hands and feet in hot water
c. bundling the body in blankets to rewarm gradually
d. laying prone under heat lamps to rewarm rapidly
1090.
A crew member is unconscious and the face is flushed. (kizarmasi) You should __________.
a. lay the crew member down with the head and shoulders slightly raised
b. administer a liquid stimulant
c. lay the crew member down with the head lower than the feet
d. attempt to stand the crew member upright to restore consciousness
1091.
Which procedure should NOT be done for a person who has fainted?
a. Revive the person with smelling salts.
b. Loosen the clothing.
c. Lay the person horizontally.
d. Give pain reliever.
1092.
1093.
A rescuer can most easily determine whether or not an adult victim has a pulse by checking the
pulse at the __________.
a. carotid artery in the neck (sah damari)
b. femoral artery in the groin
c. brachial artery in the arm
d. radial artery in the wrist
1094.
Which should NOT be a treatment for a person who has received a head injury and is groggy or
unconscious?
a. Give a stimulant. (uyarici)
b. Elevate his head.
c. Stop severe bleeding.
d. Treat for shock.
1095.
In reviving a person who has been overcome by gas fumes, what would you AVOID doing?
a. Giving stimulants
b. Prompt removal of the patient from the suffocating atmosphere
c. Applying artificial respiration and massage
d. Keeping the patient warm and comfortable
1096.
A conscious victim who has suffered a blow to the head has symptoms that indicate the possibility
of concussion. If the patient feels no indication of neck or spine injury, recommended treatment
would include __________.
a. turning the victim's head to the side to keep his airway open
b. positioning the victim so the head is lower than the body
c. giving the victim water if he is thirsty, but no food
d. elevating the head and shoulders slightly with a pillow
1097.
A person who gets battery acid in an eye should IMMEDIATELY wash the eye with __________.
a. boric acid solution
b. water
c. baking soda solution
d. ammonia
96
A victim is coughing and wheezing from a partial obstruction of the airway. An observer should
__________.
a. perform the Heimlich maneuver
b. immediately start CPR
c. give back blows and something to drink
d. allow the person to continue coughing and dislodge the obstruction on his own
1099.
If a person gets something in his or her eye and you see that it is not embedded (gmlmemis),
you can
__________.
a. get them to rub their eye until the object is gone
b. remove it with a match or toothpick
c. remove it with a piece of dry sterile cotton
d. remove it with a moist, cotton-tipped applicator
1100.
1101.
A shipmate chokes suddenly, cannot speak, and starts to turn blue. You should __________.
a. perform the Heimlich maneuver
b. make the victim lie down with the feet elevated to get blood to the brain
c. immediately administer CPR
d. do nothing until the victim becomes unconscious
1102.
A shipmate suffers a heart attack and stops breathing. You must __________.
a. administer oxygen
b. immediately check his pulse and start CPR
c. make the victim comfortable in a bunk
d. immediately give a stimulant, by force if necessary
1103.
1104.
1105.
1106.
1107.
1108.
Seasickness is caused by rolling or rocking motions which affect fluids in the __________.
a. stomach
b. lower intestines
c. inner ear
d. bladder
1109.
1111.
1112.
What is the procedure for checking for spinal cord damage in an unconscious patient?
a. Beginning at the back of the neck, and proceeding to the buttocks, press the spine to find
where it hurts
b. Prick (sivri birseyle )the skin of the hands and the soles of the feet with a sharp object to check
for reaction
c. Selectively raise each arm and each leg and watch patient's face to see if he registers pain
d. Roll patient onto his stomach and prick along the length of his spine to check reaction
1113.
1114.
1115.
1116.
When whistle signals are used for launching lifeboats, one short blast means __________.
a. "use the float-free method only"
b. "lower all boats"
c. "raise all boats"
d. "drill is over, secure all boats"
1117.
You hear the general alarm and ship's whistle sound for over 10 seconds. Traditionally, this is the
signal for __________.
a. abandon ship
b. dismissal from fire and emergency stations
c. fire and emergency
d. man overboard
1118.
1119.
One of the first actions to be taken by survivors when they have boarded an inflatable liferaft is to
__________.
a. stream the sea anchor
b. take an anti-seasickness pill
c. open the pressure relief valve
d. drink at least one can of water
1120.
You have abandoned ship in tropical waters. Which procedure should be used during a prolonged
period in a liferaft?
a. Wet clothes during the day to decrease perspiration.
b. Get plenty of rest.
c. Keep the entrance curtains open.
d. All of the above
1121.
When using the rainwater collection tubes of a liferaft, the FIRST collection should be
__________.
a. passed around so all can drink
b. poured overboard because of salt washed off the canopy
98
When you hear three short blasts on the ship's whistle and the same signal on the general alarm
bells, you __________.
a. are required to be at your liferaft
b. are dismissed from drills
c. should point to the man overboard
d. should start the fire pump
1123.
During an abandonment or drill, the first person to arrive at the survival craft should __________.
a. pass out food and water to personnel
b. open the doors and start the sprinkler system
c. activate the emergency release handle
d. open the doors and prepare the craft for boarding
1124.
Which of the following steps should normally be taken first by those who have boarded a liferaft in
an emergency situation?
a. Ration food and water supplies
b. Search for survivors
c. Determine position and closest point of land
d. Check pyrotechnic supplies
1125.
If you have to jump in the water when abandoning ship, your legs should be __________.
a. spread apart as far as possible
b. held as tightly against your chest as possible
c. in a kneeling position
d. extended straight down and crossed at the ankles
1126.
Once the daily ration of drinking water in a survival situation has been established, the drinking
routine should include __________.
a. small sips at regular intervals during the day
b. a complete daily ration at one time during the day
c. one-third the daily ration three times during the day
d. small sips only after sunset
1127.
1128.
1129.
Which document will describe lifesaving equipment located aboard your vessel?
a. Muster List ("Station Bill")
b. Certificate of Inspection
c. Forecastle Card
d. Clearance Papers
1130.
1131.
You have hand launched an inflatable liferaft. What should be one of your FIRST actions after all
persons have boarded the liferaft?
a. Open the equipment pack.
b. Inflate the liferaft floor.
c. Decide on food and water rations.
d. Cut the sea painter and clear the vessel.
1132.
After abandoning ship which action should be taken IMMEDIATELY upon entering a liferaft?
a. Open equipment pack.
b. Issue anti-seasickness medicine.
c. Get clear of the ship.
d. Dry the liferaft floor and inflate.
1133.
You have abandoned ship in rough weather. After picking up other survivors in your liferaft, what
should you do next?
99
You board an inflatable liferaft that has been hand launched from a sinking vessel. What should
you do FIRST after everyone is onboard the liferaft?
a. Cut the painter.
b. Operate the radio equipment.
c. Open the equipment pack.
d. Ventilate the liferaft of CO2.
1135.
If you must swim through an oil fire, you should NOT __________.
a. wear as much clothing as possible
b. enter the water feet first
c. swim with the wind
d. cover eyes with one hand when entering the water
1136.
What is the most vulnerable (kolayca yararlanilabilir) part of the fire main system?
a. The fire pump
b. Exposed hard piping
c. The hydrant valve
d. The fire hose
1137.
If
a.
b.
c.
d.
1138.
1139.
1140.
1141.
1142.
The most important concern in treating a person with extensive burns is __________.
a. reducing disfigurement
b. preventing infection
c. cooling with ice water
d. reducing swelling
1143.
Under normal operating conditions, the rudder is hydraulically locked unless __________.
a. the manual trick wheel is engaged for steering
b. the variable stroke pump is off stroke
c. a rudder order is given by the control system
d. an electric power system failure occurs at the steering gear
1144.
Which of the following statements is FALSE concerning the proper procedure in handling a fire
hose?
a. A 1 inch hose should be deployed with a minimum of a nozzleman and hoseman.
b. The nozzleman should always hold the nozzle with one hand on top, to prevent kickback.
c. Back-up hosemen should be positioned wherever the hose makes a significant turn.
d. The fire hose should be partially charged before deploying it from the fire station.
1145.
Which of the following statements is FALSE concerning the proper procedure in handling a fire
hose?
a. A 1 inch hose should be deployed with a minimum of a nozzleman and hoseman.
100
1147.
1148.
Environmental loading consists of the forces caused by wind, waves, and __________.
a. drilling
b. soil reactions
c. temperature
d. current
1149.
1150.
Most covered lifeboats will right themselves after capsizing if the __________.
a. lower ballast tanks are filled with water
b. sea anchor is deployed to windward
c. fuel tanks are not less than half full
d. passengers are strapped (bagli) to their seats
1151.
After you activate your emergency position indicating radio beacon, you should __________.
a. turn it off for five minutes every half-hour
b. turn it off and on at five-minute intervals
c. turn it off during daylight hours
d. leave it on continuously
1152.
What should you do with your emergency position indicating radio beacon if you are in a liferaft in
a storm?
a. Bring it inside the liferaft and leave it on.
b. Bring it inside the liferaft and turn it off until the storm passes.
c. Leave it outside the liferaft and leave it on.
d. Leave it outside the liferaft but turn it off.
1153.
There is a fire aft aboard your vessel. To help fight the fire, you should __________.
a. put the wind off either beam
b. put the stern into the wind and decrease speed
c. put the stern into the wind and increase speed
d. head the bow into the wind and decrease speed
1154.
Which toxic gas is a product of incomplete combustion, and is often present when a fire burns in a
closed compartment?
a. Nitric oxide
b. Carbon dioxide
c. Hydrogen sulfide
d. Carbon monoxide
1155.
The most likely location for a liquid cargo fire to occur on a tanker would be __________.
a. in the pumproom
b. at the vent header
c. at the main deck manifold
d. the midships house
1156.
What percentage of the breaking strength is the generally accepted safe operating load of an
anchor cable?
a. 10%
b. 25%
101
The only wire rope termination which may be made in the field is __________.
a. swaged socket
b. thimbled mechanical splice
c. hand splice
d. spelter poured cinko dkme and resin recine sockets
1158.
Thirty-five percent of the breaking strength of an anchor cable is generally accepted as the
__________.
a. safe operating load
b. normal operating tension
c. emergency working load
d. allowable storm load
1159.
A device commonly used to secure the pendant (asili) wire when it is initially passed to an anchor
handling vessel is __________.
a. pelican hook
b. connecting link
c. shackle
d. retaining hook
1160.
The safest device used to secure the end of the pendant wire when it is initially passed to the
anchor handling vessel is a __________.
a. pelican hook
b. hydraulic deck stopper
c. connecting link
d. shackle
1161.
The length of chain between the anchor and the end of the pendant line is called the __________.
a. pigtail chain
b. thrash chain
c. crown chain
d. wear chain
1162.
1163.
1164.
The unit used to measure anchor line tensions in the offshore drilling industry is the __________.
a. long ton
b. short ton
c. metric ton
d. Kip
1165.
1166.
What device is used to measure the force exerted on the rig by a leg of the mooring system?
a. Advanced stability computer
b. Hole position indicator
c. Fathometer
d. Load cell
1167.
The two main types of load cells used in mooring tension gauges are __________.
a. distortion (bklme) and compression (sikistirma)
b. hydraulic and mechanical
c. magnetic and applied torque
d. frictionless and hydraulic
1168.
Why should you preload a mooring system above your precalculated operating mooring tensions?
a. This serves as a benchmark for increasing tensions in rough weather.
b. This allows you to determine existing bottom conditions.
c. This insures that the anchor cable is stretched out in a straight line.
102
1170.
Each fire hydrant must have at least one spanner and at least one __________.
a. hose rack or reel
b. all purpose nozzle
c. foam applicator
d. pick axe
1171.
1172.
The procedure of strengthening damaged structures on a MODU by using wood or steel is called
__________.
a. bracing
b. battening
c. blocking
d. shoring
1173.
When shoring a damaged bulkhead on a MODU, effort should be taken to spread the pressure over
the __________.
a. maximum possible area
b. minimum possible area
c. nearest watertight door
d. nearest longitudinal girder
1174.
1175.
On the cargo manifest, the total weight of a box containing cargo is the __________.
a. tare weight
b. net weight
c. gross weight
d. cargo weight
1176.
On the cargo manifest, the total weight of an empty cargo box is the __________.
a. tare weight
b. net weight
c. gross weight
d. cargo weight
1177.
On the cargo manifest, the gross weight of a box containing cargo is the weight of the
__________.
a. cargo
b. box
c. cargo and box
d. rate weight
1178.
On the cargo manifest, the weight of the cargo inside a box is called the __________.
a. gross weight
b. net weight
c. light weight
d. rate weight
1179.
To determine the number of portable fire extinguishers required on a mobile offshore drilling unit,
you should check the __________.
a. hot work permit
b. Certificate of Inspection
c. Safety of Life at Sea Certificate
d. Operations Manual
1180.
Fire in an engine compartment is best extinguished with carbon dioxide gas (CO2) and by
__________.
a. closing the compartment except for the ventilators
b. increasing the air flow to the compartment by blowers
103
If heavy smoke is coming from the paint locker, the FIRST firefighting response should be to
__________.
a. release the CO2 flooding system
b. open the door to evaluate the extent of the fire
c. enter and use a portable extinguisher
d. secure the ventilation
1182.
After extinguishing a paint locker fire using the fixed CO2 system, the next action is to have the
space __________.
a. opened and burned material removed
b. left closed with vents off until all boundaries are cool
c. checked for oxygen content
d. doused with water to prevent reflash
1183.
After abandoning ship, you should deploy the sea anchor from a liferaft to __________.
a. keep the liferaft from capsizing
b. navigate against the current
c. keep personnel from getting seasick
d. stay in the general location
1184.
If the liferaft capsizes, all personnel should leave the raft and __________.
a. climb onto the bottom
b. swim away from the raft
c. right the raft using the righting strap
d. inflate the righting bag
1185.
Fire in an engine compartment is best extinguished with carbon dioxide gas (CO2) and by
__________.
a. completely closing the compartment
b. closing the compartment except for the ventilators
c. leaving the compartment open to the air
d. increasing the air flow to the compartment by blowers
1186.
Immediately after abandoning a vessel, lookouts should be posted aboard liferafts to look for
__________.
a. survivors in the water
b. food and water
c. land
d. bad weather
1187.
The difference between the starboard and port drafts due to wind or seas is called __________.
a. list
b. heel
c. trim
d. flotation
1188.
To turn over an inflatable liferaft that is upside down, you should pull on the __________.
a. canopy
b. manropes
c. sea painter
d. righting strap
1189.
1190.
Records of tests and inspections of a cargo vessel's fire extinguishing systems shall be kept on
board
__________.
a. for 1 year
b. for 2 years
c. until the next Coast Guard inspection
d. until the vessel's Certificate of Inspection expires
1191.
In reference to accidental oil pollution, the most critical time during bunkering is when
__________.
a. you first start to receive fuel
b. hoses are being blown down
c. final topping off is occurring
d. hoses are being disconnected
104
1193.
1194.
1195.
1196.
Your small vessel is broken down and rolling in heavy seas. You can reduce the possibility of
capsizing by __________.
a. rigging a sea anchor
b. constantly shifting the rudder
c. moving all personnel forward and low
d. moving all personnel aft
1197.
You hear air escaping from the liferaft just after it has inflated. You should __________.
a. quickly hunt for the hole before the raft deflates
b. check the sea anchor line attachment for a tear if the seas are rough
c. check the painter line attachment for a tear caused by the initial opening
d. not panic since the safety valves allow excess pressure to escape
1198.
1199.
First aid treatment for small cuts and open wounds is to __________.
a. lay the patient down and cover the wound when the bleeding stops
b. stop the bleeding, clean, medicate, and cover the wound
c. apply an ice pack to the wound and cover it when the bleeding stops
d. apply a hot towel to purge the wound, then medicate and cover it
1200.
On a tankship, sanitary inspections of the crew's quarters are the responsibility of the
__________.
a. Master and Second Mate
b. Master and Chief Engineer
c. Master and union delegate
d. Master and Chief Mate
1201.
A person has suffered a laceration (kesik) of the arm. Severe bleeding has been controlled by
using a sterile dressing and direct pressure. What should you do next?
a. Apply a tourniquet to prevent the bleeding from restarting.
b. Apply a pressure bandage over the dressing.
c. Remove any small foreign matter and apply antiseptic.
d. Administer fluids to assist the body in replacing the lost blood.
1202.
1203.
In all but the most severe cases, bleeding from a wound should be controlled by __________.
a. applying direct pressure to the wound
b. submerging the wound in lukewarm water
c. cooling the wound with ice
d. applying a tourniquet
1204.
1206.
1207.
Which technique could be used to give a more comfortable roll to a stiff vessel?
a. Concentrate weights on upper decks
b. Add weight near the centerline of the lower hold
c. Move weights lower in the ship
d. Ballast the peak tanks
1208.
1209.
1210.
Which chemical is used to treat water in order to ensure its safety for drinking?
a. Nitrogen
b. Chlorine
c. Carbon
d. Oxygen
1210.
1211.
1212.
The Emergency Position Indicating Radio beacon on a cargo vessel must be stowed __________.
a. in an inside passageway
b. in an approved bracket
c. so that it is accessible from the bridge of the vessel
d. so that it will float free if the vessel sinks
1213.
1214.
Fuel oil tank vents are fitted with a screen which will stop __________.
a. oil from flowing out of the tank vent
b. air from entering the tank vent
c. vapors from leaving the tank vent
d. flames on deck from entering the tank vent
1215.
Unless there is danger of further injury, a person with a compound fracture should not be moved
untilbleeding is controlled and __________.
a. the bone has been set
b. the fracture is immobilized
c. radio advice has been obtained
d. the wound has been washed
1217.
1218.
1219.
1220.
In any major injury to a person, first aid includes the treatment for the injury and __________.
a. application of CPR
b. removal of any foreign objects
c. administration of oxygen
d. for traumatic shock
1221.
What does NOT affect the value of the free surface correction?
a. Width of the tank
b. Length of the tank
c. Registered tonnage
d. Specific gravity of the liquid in the tank
1222.
1223.
1224.
The maneuvering information required to be posted in the wheelhouse must be based on certain
conditions. Which of the following is NOT one of these conditions?
a. The hull must be clean.
b. There must be calm weather-wind 10 knots or less and a calm sea.
c. There must be no current.
d. The depth of the water must be at least one and one-half times the draft.
1225.
A man has suffered a burn on the arm. There is extensive damage to the skin with charring
present. How is this injury classified using standard medical terminology?
a. Dermal burn
b. Third-degree burn
c. Major burn
d. Lethal burn
1226.
1227.
A man has a burn on his arm. There is reddening of the skin, blistering, and swelling. Using
standard medical terminology this is a __________.
107
major burn
secondary burn
second-degree burn
blister burn
1228.
The supply of carbon dioxide used in the fixed extinguishing system aboard a cargo vessel MUST
be at least sufficient for __________.
a. all the spaces of a vessel
b. all cargo spaces
c. the engine room and largest cargo space
d. the space requiring the largest amount
1229.
A man has suffered a burn on the arm. There is a reddening of the skin but no other apparent
damage. Using standard MEDICAL terminology, this is a __________.
a. Minor burn
b. Superficial burn
c. Extremity burn
d. First-degree burn
1230.
1231.
A tank which carries liquid is dangerous to the stability of a vessel when it is __________.
a. low in the vessel
b. completely empty
c. completely full
d. slack
1232.
What should be used to remove corrosion from the swivel on the female coupling of a fire hose?
a. Bearing grease and a wire brush
b. Talc and fine sandpaper
c. Fish oil and a soft brush
d. Fresh water, soap, and a stiff brush
1233.
1234.
To lubricate the swivel (firdnd) or remove corrosion from a fire hose coupling, you should use
__________.
a. glycerine
b. graphite
c. kerosene
d. fresh water and soap
1235.
1236.
On the all-purpose nozzle, the position of the valve when the handle is all the way forward is
__________.
a. shut
b. fog
c. solid stream
d. spray
1237.
1238.
1239.
Of the following, the most important consideration for a tank vessel is __________.
108
Aluminum lifeboats are subject to damage by electrolytic corrosion (the aluminum being eaten
away). In working around boats of aluminum you must be very careful __________.
a. to keep the boats covered at all times
b. not to leave steel or iron tools lying in or near these boats
c. to keep an electric charge on the hull at all times
d. to rinse these boats regularly with salt water
1241.
1242.
Which item is of the most use in getting a lifeboat away from a moving ship?
a. The falls
b. Boat hook
c. Boat painter
d. Sea painter
1243.
You are calling another vessel by radiotelephone using the International Code of Signals. He
responds with the words "Alpha Sierra". This indicates that __________.
a. he cannot accept traffic immediately
b. you should proceed with your message
c. you should send your message in International Code
d. you should send your message in plain language
1244.
When fighting fires in spaces containing bottles of LPG (liquefied petroleum gas), you should
__________.
a. attempt to isolate the fire from the LPG
b. cool the bottles or remove them from the fire area
c. see that the valves on all LPG bottles are closed
d. place insulating material over the bottles
1245.
1246.
Ring life buoys used aboard a small passenger vessels on oceans or coastwise routes are required
to be what color?
a. White
b. White or international orange
c. Orange
d. Any highly visible color easily seen from the air
1247.
1248.
1249.
1250.
1251.
1253.
1254.
Carbon dioxide as a fire fighting agent has which advantage over other agents?
a. It causes minimal damage.
b. It is safer for personnel.
c. It is cheaper.
d. It is most effective on a per unit basis.
1255.
1256.
1257.
What is the lifesaving signal for "You are seen - Assistance will be given as soon as possible"?
a. Red star rocket
b. Orange smoke signal
c. Green star rocket
d. Vertical motion of a flag
1258.
After an accident the victim may go into shock and die. What should be done to help prevent
shock?
a. Slightly elevate the head and feet.
b. Keep the person awake.
c. Keep the person lying down and at a comfortable temperature.
d. Give the person a stimulant to increase blood flow.
1259.
If
a.
b.
c.
d.
1260.
1261.
1262.
Your vessel has just finished bunkering and has a small list due to improper distribution of the fuel
oil.
This list will cause __________.
a. a decrease in reserve buoyancy
b. a decrease in the maximum draft
c. the vessel to flop to port and starboard
d. None of the above
1263.
110
1265.
1266.
The lifesaving signal indicated by a horizontal motion of a white light or white flare means
__________.
a. "Landing here highly dangerous"
b. "Negative"
c. "Avast hauling"
d. All of the above
1267.
If your vessel will list with equal readiness to either side, the list is most likely caused by
__________.
a. negative GM
b. off-center weight
c. pocketing of free surface
d. excessive freeboard
1268.
1269.
1270.
1271.
1272.
1273.
1274.
1275.
If you observe any situation which presents a safety or pollution hazard during fuel transfer
operations, what action should you take FIRST?
a. Close the valves at the transfer manifold
111
If you must enter water on which there is an oil fire, you should __________.
a. protect your life preserver by holding it above your head
b. enter the water on the windward(rzgarin estigi yn) side of the vessel
c. keep both hands in front of your face to break the water surface when diving head first
d. wear very light clothing
1277.
1278.
1279.
1280.
1281.
The most common type of davit found on merchant vessels today is the __________.
a. radial
b. sheath-screw
c. gravity
d. quadrantal
1282.
What is the MOST important consideration when determining how to fight an electrical fire?
a. Whether the fire is in machinery or passenger spaces
b. Danger of shock to personnel
c. The amount of toxic fumes created by the extinguisher
d. Maintaining electrical power
1283.
If a powdered aluminum fire is being fought, the correct extinguishing agent would be
__________.
a. dry powder
b. water fog
c. CO2
d. steam
1284.
A vessel to which Annex V to MARPOL 73/78 applies is 24 nautical miles from the nearest land.
Which type of garbage is prohibited from being discharged?
a. Glass
b. Crockery
c. Metal
d. Dunnage
1285.
What do regulations allow to be marked with EITHER the name of the fishing vessel OR the name
of the person to whom it is assigned?
a. Immersion suit
b. Buoyant apparatus
c. Ring buoy
d. Life float
1286.
The boat command that means complete the stroke and level the oars horizontally with the blades
trimmed fore and aft is __________.
a. "Oars"
b. "Up oars"
c. "Way enough"
d. "Hold water"
112
You are approaching another vessel and see that she has the signal flag "J" hoisted. What should
you do?
a. Keep well clear of the vessel because she is on fire and has dangerous cargo on board or she is
leaking dangerous cargo.
b. Attempt to call the vessel on VHF radiotelephone because she is requesting to communicate.
c. Approach the vessel with caution because she is dragging her anchor.
d. Proceed on present course and speed since the vessel is requesting a tug.
1288.
1289.
1290.
1291.
1292.
How long must GMDSS Radio Logs be retained onboard the ship in original form?
a. 30 days
b. 3 months
c. 6 months
d. 1 year
1293.
How long must GMDSS Radio Logs be retained by the licensee when they relate to a distress
situation or disaster?
a. 6 months
b. 1 year
c. 2 years
d. 3 years
1294.
1295.
1296.
When there are small differences between the heights of two successive high tides or two low
tides, in a tidal day, the tides are called __________.
a. diurnal
b. semidiurnal
c. solar
d. mixed
1297.
A single line of position combined with a dead-reckoning position results in a(n) __________.
a. assumed position
b. estimated position
c. fix
d. running fix
1298.
When the moon is at first quarter or third quarter phase, what type of tides will occur?
a. Apogean
b. Perigean
c. Neap
d. Spring
1300.
1301.
A local wind which occurs during the daytime and is caused by the different rates of warming of
land and water is a __________.
a. foehn
b. chinook
c. land breeze
d. sea breeze (deniz meltemi)
1302.
In modern fathometers the sonic or ultrasonic sound waves are produced electrically by means of
a(n)
__________.
a. transmitter
b. transducer
c. transceiver
d. amplifier
1303. The description "Racon" beside an illustration on a chart would mean a __________.
a. radar conspicuous beacon
b. circular radio beacon
c. radar transponder beacon
d. radar calibration beacon
1304.
In using Loran-C, skywave reception gives greater range but is __________.
a. only accurate during daylight hours
b. much less accurate
c. only accurate at twilight
d. more accurate than using ground waves
1305. The horizon glass of a sextant is __________.
a. silvered on its half nearer the frame
b. mounted on the index arm
c. between the horizon and the shade glasses
d. All of the above
1306.
When navigating using GPS, what is an indicator of the geometry of the satellites that your
receiver is locked onto?
a. Horizontal Dilution of Precision
b. Selective Availability
c. Doppler Shifting
d. Precision Coding
1307. What is a lighted safe water mark fitted with to aid in its identification?
a. Red and white retroreflective material
b. A spherical topmark
c. A sequential number
d. A red and white octagon
1308. A sextant having an index error that is "on the arc" has a __________.
a. positive correction
b. dip error
c. negative correction
d. semidiameter error
1309. A sextant having an index error that is "off the arc" has a __________.
a. positive correction
b. dip error
c. negative correction
d. semidiameter error
1310. Neap tides occur when the __________.
a. Moon is in its first quarter and third quarter phases
b. Sun and Moon are on opposite sides of the Earth
c. Moon's declination is maximum and opposite to that of the Sun
d. Sun and Moon are in conjunction
114
A position obtained by crossing lines of position taken at different times and advanced to a
common time is a(n) __________.
a. running fix
b. dead-reckoning position
c. fix
d. estimated position
1321.
The Loran-C receiver __________.
a. is not affected by interference
b. can be used at any distance with accuracy
c. can be affected by interference engel
d. is reliable only from sunrise to sunset
1322.
Which of these sextant errors is nonadjustable?
a. Prismatic error
b. Graduation error
c. Centering error
d. All of the above
1323. The direction of the southeast trade winds is a result of the __________.
a. equatorial current
115
The ocean bottom that extends from the shoreline out to an area where there is a marked change
in slope to a greater depth is the __________.
a. abyssal plain
b. continental shelf
c. borderland
d. offshore terrace
1327. The wind speed and direction observed from a moving vessel is known as __________.
a. coordinate wind
b. true wind
c. apparent wind
d. anemometer wind
1328. A wind vane on a moving vessel shows __________.
a. dead reckoning wind direction
b. true wind direction
c. apparent wind direction
d. estimated wind direction
1329. On what does the operation of an aneroid barometer depend?
a. Thin, metal, air tight cell
b. Curved tube containing alcohol
c. Column of mercury supported by atmospheric pressure
d. Expansion of mercury in a closed tube
1330.
The height of eye correction is smaller than geometrical dip because of __________.
a. the angle between the horizontal and the line of sight to the visible horizon
b. index error
c. parallax
d. terrestrial refraction
1331. Which condition exists in the eye of a hurricane?
a. Wind rapidly changing direction
b. A temperature much lower than that outside the eye
c. Towering cumulonimbus clouds
d. An extremely low barometric pressure
1332. Which statement about a gnomonic chart is correct?
a. A rhumb line appears as a straight line. (Mercator)
b. Distance is measured at the mid-latitude of the track line.
c. Meridians appear as curved lines converging toward the nearer pole.
d. Parallels, except the equator, appear as curved lines.
1333. A special purpose buoy shall be __________.
a. lighted with a white light
b. striped black and red
c. lighted with a red light
d. yellow
1334. All straight lines represent great circle tracks on a chart based on a(n) __________.
a. Mercator projection
b. polyconic projection
c. orthographic projection
d. gnomonic projection
1335.
A radar display in which North is always at the top of the screen is a(n) __________.
a. unstabilized display
b. stabilized display
c. composition display
d. relative display
116
In the celestial equator system of coordinates, what is comparable to latitude on the terrestrial
sphere?
a. Altitude
b. Right ascension
c. Celestial meridians
d. Declination
1338. In a river subject to tidal currents, the best time to dock a ship without the assistance of tugs is
__________.
a. at high water
b. at slack water
c. at flood tide
d. when there is a following current
1339. A white buoy with an orange rectangle on it is used to indicate __________.
a. danger
b. a controlled area
c. an exclusion area
d. general information
1340. The only cylindrical chart projection widely used for navigation is the __________.
a. Lambert conformal
b. Mercator
c. azimuthal
d. gnomonic
1341.
A radar display which is oriented, so that north is always at the top of the screen, is called a(n)
__________.
a. relative display
b. composite display
c. stabilized display
d. unstabilized display
1342.
On a working copy of a weather map, an occluded front (sicak ve soguk cephelerin karsilasmasi) is
represented by which color line?
a. Red
b. Blue
c. Alternating red and blue
d. Purple
1343.
Buoys which mark dredging areas are painted __________.
a. black
b. yellow
c. green
d. red
1344.
Chart legends printed in capital letters show that the associated landmark is __________.
a. inconspicuous
b. conspicuous (belirgin besbelli)
c. a government facility or station
d. a radio transmitter
1345. Which is NOT a side of the celestial navigational triangle?
a. Co-latitude
b. Zenith distance
c. Altitude
d. Co-declination
1346. Information markers, when lighted, will display __________.
a. yellow lights
b. green lights
c. white lights
d. red lights
1347.
In the Northern Hemisphere, what type of cloud formations would you expect to see to the west of
an approaching tropical wave?
a. Cumulus clouds lined up in rows extending in a northeast to southwest direction
b. High altostratus clouds in the morning hours
c. Cirrostratus clouds lined up in rows extending in a northeast to southwest direction
117
On a working copy of a weather map, a stationary (duragan) front is represented by which color
line?
Red
Blue
Alternating red and blue
Purple
An "atoll cloud" forming over an island due to heating of the land during the daytime would be
which type?
a. Cirrus
b. Cumulus
c. Stratus
d. Nimbus
1371. The highest frequency of tropical cyclones in the North Atlantic Ocean occurs during __________.
a. January, February and March
b. April, May and June
c. August, September and October
d. July, November and December
1372.
When is the peak (zirve) of the hurricane season in the western North Pacific?
119
1373.
You would expect to find channels marked with the IALA-A Buoyage System in __________.
a. the Philippines
b. Australia
c. Republic of Korea
d. Chile
1374. The flow of air around an anticyclone in the Southern Hemisphere is __________.
a. clockwise and outward
b. counterclockwise and outward
c. clockwise and inward
d. counterclockwise and inward
An anticyclone in the Northern Hemisphere is outward and clockwise
A cyclone in the Northern Hemisphere is inward and counterclockwise
An anticyclone in the Southern Hemisphere is outward and counterclockwise
A cyclone in the Southern Hemisphere is inward and clockwise
1375.
The pillar shape that gives the greatest strength for the least weight is the __________.
a. octagonal pillar
b. "H" Beam pillar
c. "I" Beam pillar
d. circular type pillar
1376.
Uniform, grayish-white cloud sheets that cover large portions of the sky, and are responsible for a
large percentage of the precipitation in the temperate latitudes, are called __________.
a. altostratus
b. altocumulus
c. cirrostratus
d. cirrocumulus
a. low
b. high
c. warm front
d. cold front
1386. In which month will the equatorial counter current be strongest?
a. January
b. April
c. August
d. October
1387. If the sky was clear, with the exception of a few cumulus clouds, it would indicate __________.
a. rain
b. hurricane weatherba
c. fair weather
d. fog setting in
1388. Stormy weather is usually associated with regions of __________.
a. low barometric pressure
b. high barometric pressure
c. steady barometric pressure
d. changing barometric pressure
1389.
The form of cloud often known as "mackerel sky" (balik sirti seklinde - uskumbru)which is
generally associated with fair weather is
__________.
a. nimbostratus
b. stratus
c. cirrocumulus
d. cumulonimbus
1390. The set of the equatorial countercurrent is generally to the __________.
a. north
b. east
c. southwest
d. northwest
1391.
Clouds that form as small white flakes or scaly globular masses covering either small or large
portions of the sky are __________.
a. cirrus
b. cirrostratus
c. altostratus
d. cirrocumulus
While preparing to enter a Brazilian port, you see ahead a red and green horizontally-striped buoy.
The upper band is red. What action should you take?
a. Alter course to leave the buoy to port.
b. Alter course to leave the buoy to starboard.
c. Pass the buoy close aboard on either side.
d. Pass the buoy well clear on either side.
121
The cold ocean current which meets the warm Gulf Stream between latitudes 40 and 43N to
form the "cold wall" is called the __________.
a. North Cape Current
b. Labrador Current
c. Greenland Current
d. North Atlantic Current
1396. A thin, whitish, high cloud popularly known as "mares' tails" is __________.
a. altostratus
b. stratus
c. cumulus
d. cirrus
1397. Good weather is usually associated with a region of __________.
a. low barometric pressure
b. high barometric pressure
c. falling barometric pressure
d. pumping barometric pressure
1398. Which cloud commonly produces a halo about the Sun or Moon?
a. Cirrostratus
b. Cirrocumulus
c. Altostratus
d. Altocumulus
1399. Error may be introduced into a magnetic compass by __________.
a. making a structural change to the vessel
b. a short circuit near the compass
c. belt buckles
d. All of the above
1400. A warm air mass is characterized by __________.
a. stability
b. instability
c. gusty winds
d. good visibility
1401. Which current is responsible for the movement of icebergs into the North Atlantic shipping lanes?
a. Iceland Current
b. Baltic Current
c. Labrador Current
d. Baffin Current
1402. Warm air masses will generally have __________.
a. turbulence within the mass
b. stratiform clouds katmanli
c. heavy precipitation
d. good visibility
1403. A coastal current __________.
a. is generated by waves striking the beach
b. flows outside the surf zone
c. flows in a circular pattern
d. is also known as a longshore current
1404. A low, uniform layer of cloud resembling fog, but not resting on the ground, is called __________.
a. cumulus
b. nimbus
c. stratus
d. cirrus
The approximate positions of the stars are based on sidereal time, which is based upon rotation of
the Earth relative to __________.
a. winter solstice
b. autumnal equinox
c. summer solstice
d. vernal equinox
1409. A frontal thunderstorm is caused by __________.
a. pronounced local heating
b. wind being pushed up a mountain
c. a warm air mass rising over a cold air mass
d. an increased lapse rate caused by advection of warm surface air
1410. The radius of a circle of equal altitude for a body equals the body's __________.
a. declination
b. polar distance
c. altitude
d. zenith distance
1411. The steepness of a cold front depends on __________.
a. the direction of wind around the front
b. its velocity
c. the temperature of the air behind the front
d. the precipitation generated by the front
1412. One of the causes of ocean currents is density differences in the water. This is true because
__________.
a. in an area of high density the water's surface is lower than in an area of low density
b. surface water flows from an area of high density to one of low density
c. the lesser the density gradient the freer the water is to move
d. it is the density differences that cause the currents to stay in the troughs
1413. Isobars on a weather map are useful in predicting __________.
a. temperature
b. dew point
c. wind velocity
d. relative humidity
1414.
In waters where the cardinal system is used you would expect to find danger __________.
a. lying to the south of an eastern quadrant buoy
b. lying to the south of a northern quadrant buoy
c. lying to the east of an eastern quadrant buoy
d. beneath or directly adjacent to the buoy
1415. The dew point temperature is __________.
a. always higher than the air temperature
b. always lower than the air temperature
c. equal to the difference between the wet and dry bulb temperatures
d. the temperature at which the air is saturated (doymak) with water vapor
1416. Chart legends printed in capital letters show that the associated landmark is __________.
a. inconspicuous
b. a radio transmitter
c. conspicuous (belirgin)
d. a government facility or station
1417. As the temperature for a given mass of air increases, the __________.
a. dew point increases
b. dew point decreases
c. relative humidity increases
d. relative humidity decreases
1418. Which is TRUE concerning the speed of fronts?
a. Cold fronts move faster than warm fronts.
b. Cold fronts move slower than warm fronts.
c. Cold fronts and warm fronts move with equal speed.
d. Cold fronts move slower at the northern end and faster at the southern end.
123
In the Northern Hemisphere, gusty winds shifting clockwise, a rapid drop in temperature,
thunderstorms or rain squalls in summer (frequent rain/snow squalls in winter) then a rise in
pressure followed by clearing skies, indicate the passage of a(n) __________.
a. warm front
b. tropical cyclone
c. anticyclone
d. cold front
1429. If the compass heading and the magnetic heading are the same then __________.
a. the deviation has been offset by the variation
b. there is something wrong with the compass
c. the compass is being influenced by nearby metals
d. there is no deviation on that heading
1430.
Brief, violent showers frequently accompanied by thunder and lightning are usually associated
with
__________.
a. passage of a warm front
b. passage of a cold front
c. winds shifting counterclockwise in the Northern Hemisphere
d. stationary high pressure systems
124
A line of clouds, sharp changes in wind direction, and squalls are most frequently associated with
a(n)
__________.
a. occluded front
b. warm front
c. cold front
d. warm sector
1441. What type of clouds are associated with a cold front?
a. Altostratus and fracto-cumulus
b. Altostratus and cirrus
c. Cirrus and cirrostratus
d. Cumulus and cumulonimbus
1442. When a warm air mass overtakes a cold air mass, the contact surface is called a __________.
a. line squall
b. water spout
c. cold front
d. warm front
125
A cloud sequence of cirrus, cirrostratus, and altostratus clouds followed by rain usually signifies
the approach of a(n) __________.
occluded front
stationary front
warm front
cold front
1444. The first indications a mariner will have of the approach of a warm front will be __________.
a. large cumulonimbus (thunderclouds) building up
b. high cirrus clouds gradually changing to cirrostratus and then to altostratus
c. fog caused by the warm air passing over the cooler water
d. low dark clouds accompanied by intermittent rain
1445. Luminous range is the __________.
a. maximum distance at which a light may be seen in clear weather
b. maximum distance at which a light may be seen under existing visibility conditions
c. maximum distance at which a light may be seen considering the height of the light and the
height of the observer
d. average distance of visibility of the light
1446.
Weather observations provided by each weather station include all of the following except
__________.
a. temperature
b. visibility
c. predicted weather for the next twelve hours
d. barometric pressure and change in the last three hours
1447.
The difference in degrees between true north and magnetic north is called __________.
a. variation
b. deviation
c. drift
d. compass error
1448. The FIRST indications a mariner will have of the approach of a warm front will be __________.
a. large cumulonimbus clouds building up
b. low dark clouds with intermittent rain
c. fog caused by the warm air passing over the cooler water
d. high clouds gradually followed by lower thicker clouds
1449. The lunar (ay gn) day is __________.
a. longer than a solar day
b. shorter than a solar day
c. the same length as the solar day
d. longer than a solar day during the summer months and shorter in winter months
1450.
On the approach of a warm front the barometric pressure usually __________.
a. falls
b. rises
c. is steady
d. is unreliable
1451.
As a vessel changes course to starboard, the compass card in a magnetic compass __________.
a. first turns to starboard then counterclockwise to port
b. also turns to starboard
c. turns counterclockwise to port
d. remains aligned with compass north
1452.
Which statement about the gyrocompass is FALSE?
a. Its accuracy (dogruluk) remains the same at all latitudes.
b. It seeks the true meridian.
c. It can be used near the Earth's magnetic poles.
d. If an error exists, it is the same on all headings.
1453.
a.
b.
c.
d.
The nominal range of a light may be accurately defined as the maximum distance at which a light
may be seen __________.
under existing visibility conditions
under perfect visibility
with ten miles visibility
with fifteen miles visibility
1454.
The distance between the surface of the water and the tidal datum is the __________.
a. actual water depth
b. range of tide
c. charted depth
d. height of tide
126
The gyrocompass error resulting from your vessel's movement in OTHER than an east-west
direction is called __________.
a. damping error
b. ballistic deflection
c. quadrantal error
d. speed error
1456. Planetary aberration (sapma) is due, in part, to __________.
a. refraction of light as it enters the Earth's atmosphere
b. rotation of the Earth on it's axis
c. the body's orbital motion during the time required for its light to reach Earth
d. a false horizon
1457.
Radiation fog __________.
a. always forms over water
b. is formed by a temperature inversion
c. is thinnest at the surface
d. dissipates during the evening
1458. Which is an inferior planet? Dnya ile gnes arasindaki bir gezegen
a. Mars
b. Venus
c. Neptune
d. Pluto
1459.
Fog is most commonly associated with a(n) __________.
a. warm front at night
b. low pressure area
c. anticyclone
d. cold front in the spring
1460. What is NOT an advantage of filler cargo? Istif boslugu
a. Overcarriage is reduced or eliminated.
b. Dunnage costs are reduced.
c. Voids in the cargo stow are filled.
d. The hold space has maximum utilization
1461. Inferior conjunction is possible for __________.
a. Mars
b. Venus
c. Saturn
d. Jupiter
1462.
Fog forms when the air __________.
a. is 50% water saturated
b. is 90% water saturated
c. temperature is greater than the dew point temperature
d. temperature is equal to, or below the dew point temperature
1463. The presence of stratus clouds and a dying wind will usually result in __________.
a. heavy rain
b. heavy snow
c. thick fog
d. clearing skies
1464.
When is the rhumb line distance the same as the great circle distance?
a. Course 090T in high latitudes
b. Course 180T when you cross the equator
c. Course 045T in low latitudes
d. The rhumb line distance is always longer than the great circle distance.
1465.
Indications of the master gyrocompass are sent to remote repeaters by the __________.
a. follow-up system
b. transmitter
c. phantom element
d. azimuth motor
1466.
Atmospheric pressure may be measured with a(n) __________.
a. barograph
b. aneroid barometer
c. mercurial barometer
d. All of the above
1468.
The fog produced by warm moist air passing over a cold surface is called __________.
a. conduction fog
127
In general, the most effective period for observing stars and planets occurs during the darker limit
of
__________.
a. sunset
b. civil twilight
c. nautical twilight
d. astronomical twilight
1474. The strongest winds and heaviest rains in a hurricane are found in the __________.
a. outer bands
b. eye
c. cloud walls
d. spiral rainbands
1475. Hot air can hold __________.
a. less moisture than cold air
b. more moisture (nem) than cold air
c. the same amount of moisture as cold air
d. moisture independent of air temperature
1476. Air temperature varies with __________.
a. the altitude above sea level
b. the season of the year
c. the latitude or distance from the equator
d. All of the above
1477. Clouds with the prefix "nimbo" in their name __________.
a. are sheet or layer clouds
b. have undergone great vertical development
c. are middle or high altitude clouds
d. are rain clouds
1478.
The low, dark, sheet-like cloud which is associated with continuous precipitation (ani dss) for
many hours is
a __________.
a. cirrus cloud
b. cumulus cloud
c. cumulonimbus cloud
d. nimbostratus cloud
1479.
Which type of cloud formation should be of immediate concern to small craft operators?
a. cirrus
b. altostratus
c. nimbostratus
d. cumulonimbus
128
Cumulus clouds that have undergone vertical development and have become cumulonimbus in
form, indicate __________.
clearing weather
that a warm front has passed
probable thunderstorm activity
an approaching hurricane or typhoon
1481.
Which scale is used to estimate wind speed by observing sea conditions __________.
a. Metric scale
b. Wind scale
c. Coriolis scale
d. Beaufort scale
1482 . Cumulonimbus clouds are formed by __________.
a. vertical air movements
b. heavy rainstorms
c. horizontal air movements
d. any movement of moist air
1483. From which type of cloud can a tornado or waterspout develop?
a. Nimbostratus
b. Altostratus
c. Cumulonimbus
d. Cirrus
1484.
Small, visible mound-like protuberances on the bottom of cumulonimbus clouds, that are potential
breeding grounds for waterspouts and tornadoes, are called __________.
a. thunderheads
b. mamma
c. rime
d. ice prisms
1485.
In a weather report, the term "visibility" expresses __________.
a. how far you can see with the "naked eye"
b. how far you can see with a telescope or binoculars
c. how well you can identify an object at night
d. the distance in miles at which prominent objects are identifiable
1486.
Which weather element cannot be measured accurately while on board a moving vessel?
a. Visibility
b. Temperature
c. Wind direction
d. Atmospheric pressure
1487. Which instrument is most useful in forecasting fog?
a. A barometer
b. An anemometer
c. A sling psychrometer
d. A pyrometer
1488.
Fog is formed when __________.
a. the moisture in the air is condensed into small droplets
b. air is cooled to its dew point
c. the base of a cloud is on the ground
d. All of the above
1489.
Fog forms when the air temperature is at or below __________.
a. 32 F
b. the wet bulb temperature
c. the dew point
d. the dry bulb temperature
1490.
The type of fog that occurs on clear nights with very light breezes and forms when the earth cools
rapidly by radiation is known as __________.
a. radiation fog
b. frontal fog
c. convection fog
d. advection fog
1491.
Which of the following is TRUE of advection fog?
a. It commonly occurs on coastal waters during cold seasons.
b. It moves in a bank or dense cloud.
c. It is caused by warmer air moving to a cooler location.
d. All of the above
1492.
Advection fog may be formed by warm moist air passing over a __________.
129
Ascending and descending (ykselen / alcalan) air masses with different temperatures is part of
an important heat transmitting process in our atmosphere called __________.
conduction
radiation
convection isi yayimi
barometric inversion
The force resulting from the earth's rotation that causes winds to deflect to the right in the
Northern Hemisphere and to the left in the Southern Hemisphere is called __________.
a. pressure gradient
b. Coriolis effect
c. aurora borealis
d. ballistic deflection
1501.
a.
b.
c.
d.
A phenomenon where the atmospheric pressure is higher than that of other surrounding regions
is called __________.
the "trade winds"
a low front or an occluded front
a high pressure area; an anticyclone; or a "high"
the "doldrums"
1502.
In the Southern Hemisphere the wind circulation in a high pressure system rotates __________.
a. clockwise and inward
b. clockwise and outward
c. counterclockwise and outward
d. counterclockwise and inward
1503. Compared to a low pressure system, generally the air in a high is __________.
a. warmer, less dense, and less stable
b. cool, more dense, and drier
c. muggy and cloudy
d. extremely moist with high relative humidity
1504.
In the Northern Hemisphere, if the center of a high pressure area is due west of you, what wind
direction would you expect?
South to west
South to east
North to west
North to east
Which condition indicates that you are in a hurricane's dangerous semicircle in the Northern
hemisphere?
a. A backing wind
b. A veering wind
c. A norther
d. A strong, gusty wind
1511.
If you are in the dangerous semicircle of a hurricane you can expect all of the following except
__________.
a. backing winds
b. high seas
c. high winds
d. veering winds
1512. In the Northern hemisphere which semicircle of a hurricane is the navigable semicircle?
a. Left
b. Right
c. Front
d. Back
1513.
Which condition suggests that your present position lies in the navigable semicircle of a tropical
storm?
a. A backing wind
b. A veering wind
c. Sustained gale force winds
d. A strong wind that maintains a constant speed and direction
1515.
When your vessel is on the storm track but behind the storm's center the __________.
a. wind direction remains steady
b. wind speed decreases
c. barometer rises
d. All of the above
131
A phenomenon where the atmospheric pressure is higher than that of other surrounding regions is
called
__________.
a. the "trade winds"
b. an anticyclone
c. a low front or an occluded front
d. the "doldrums"
1521.
What is the major advantage of high altitude observations?
a. Errors due to unusual parallax are eliminated.
b. The same body can be used for a fix from observations separated by several minutes.
c. The declination is the only information needed from the almanac.
d. The semidiameter correction of the sextant altitude is eliminated.
1522. The difference between the DR position and a fix, both of which have the same time, is caused by
__________.
a. variation
b. deviation
c. current
d. leeway
1523.
Magnetic information on a chart may be __________.
a. found in the center(s) of the compass rose(s)
b. indicated by isogonic lines
c. found in a note on the chart
d. All of the above
1524. What is the brightest navigational planet?
a. Saturn
b. Jupiter
c. Mars
d. Venus
1524.
What sextant correction corrects the apparent altitude to the equivalent reading at the center of
the Earth?
a. Phase
b. Parallax
c. Semidiameter
d. Augmentation
1525.
In the horizon system of coordinates what is equivalent to longitude on the Earth?
a. Altitude
b. Azimuth angle
c. Horizon
d. Zenith distance
1526.
a.
b.
c.
d.
The prime vertical is the reference point from which the angle of which type of observation is
measured?
Sextant angle
Azimuth
Amplitude
Local apparent noon
132
The Moon appears larger in diameter at the zenith than when near the horizon. What is this
called?
a. Parallax in altitude
b. Augmentation (artis)
c. Horizontal parallax
d. Libration
1528. The point on the celestial sphere that is directly below an observer is the __________.
a. pole
b. nadir
c. node
d. zenith
1529.
Above-normal tides near the center of a hurricane may be caused by the __________.
a. high barometric pressure
b. jet stream
c. storm surge firtina kabarmasi
d. torrential rains
1530.
The prime vertical is the great circle on the celestial sphere that passes through the __________.
a. celestial poles and the zenith
b. zenith, nadir and the east point of the horizon
c. celestial poles and the celestial body
d. zenith, nadir and celestial body
1531. "Rotation" is the __________.
a. wobbling of the Earth about its axis
b. motion of bodies in the solar system relative to the stars
c. motion of a celestial body in its orbit
d. spinning of a celestial body about its axis
1532.
The phase correction should be applied to sights of Venus and Mars __________.
a. during day time observations only
b. during twilight observations only
c. at all times
d. when observed at altitudes of less than 25
1533.
The zenith is the point on the celestial sphere that is __________.
a. 90 away from the poles
b. directly over the observer
c. on the eastern horizon
d. over Greenwich
1534.
The great circle of the celestial sphere that passes through the zenith, nadir, and the eastern
point of the horizon is the __________.
a. principal vertical
b. hour circle
c. celestial meridian
d. prime vertical
1535. The parallel of latitude at 6633'N is the __________.
a. Tropic of Cancer
b. Tropic of Capricorn
c. Arctic Circle
d. ecliptic
1536.
The diameter of the Sun and Moon as seen from the Earth varies slightly but averages about
__________.
a. 1'
b. 52'
c. 32'
d. 15.5'
1537. Fog is likely to occur when there is little difference between the dew point and the __________.
a. relative humidity
b. air temperature
c. barometric pressure
d. absolute humidity
1538. Opposition occurs when __________.
a. the Sun, Earth, and Moon are at right angles
b. the Sun's declination is 0 and is moving south
c. an inferior planet is at the maximum angle to the line of sight to the Sun
d. the Earth is between a planet and the Sun
133
1558.
-
1559.
Midships
Port five
Hard-a-port
Ease to five
Steady
1560.
A yawl is a sailing vessel with two masts: with the mizzen stepped abaft the rudder post
1562.
You are taking the bow line from the port bow of a large vessel that is underway when the stern of
your tug comes in contact with the vessel. The forward motion of both vessels causes your tug to
be turned toward the other vessel and contact the stem thereby being "stemmed". You should
immediately ____.
A) go full ahead with the rudder amidships
B) go full astern with rudder amidships
C) go full ahead with the rudder hard over to starboard
D) stop engines and the vessel's wake will push you clear of the bow
1563.
1564. The size of fire hydrant hose connections on a cargo vessel must be either 1-1/2 inches or 2-1/2
inches
The Master or person in charge of a MODU is required to submit a casualty report of an intentional
grounding under what condition? If it creates a hazard to navigation
-
Which shipboard equipment will detect a signal from a SART? X-Band Radar
When electrical equipment is involved in a fire, the stream of dry chemicals should be aimed at the
source of the flames
What type of messages should the "urgent" priority be used for? containing information
concerning the safety of a mobile unit or person
When the height of the metacenter is greater than the height of the center of gravity, the upright
equilibrium position is stable and stability is positive
Your vessel is damaged and partially flooded. It is listing 12 to port and trimmed 8 feet down by
the head. It has a long, slow, sluggish roll. Which action should you take FIRST? Press up an after, slack,
centerline double bottom tank
One of the signals, other than a distress signal, that can be used by a rescue boat to attract
attention is a/an search light
-
A large oil fire on the deck of a ship can be fought most effectively with foam
In addition to weighing the cartridge, which other maintenance is required for a cartridgeoperated dry chemical extinguisher? Check the hose and nozzle for clogs.
How is the external flotation bladder of an immersion suit inflated? It is inflated by blowing
through an inflation tube.
If there are no alternatives for escape, what is the maximum height that the survival craft could
be dropped into the water? 10 ft
What time of day would an SSB radio have the longest transmitting range? During darkness
When a vessel is stationary and in a hogging condition, the main deck is under which type of
stress? Tension
When signaling by flashing light, how should you acknowledge a correctly received repetition of a
signal? OK
When evacuating a seaman by helicopter lift, which statement is TRUE? The litter (kurtarma
sepeti) should not be touched until it has been grounded.
-
Frapping lines reduce the swinging (SALLANMA) of the lifeboat at the embarkation level
An inflatable liferaft is floating in its container, attached to the ship by its painter, as the ship is
sinking rapidly. Which action should be taken with respect to the liferaft container? Take no action as the
pull on the painter will cause the liferaft to inflate and open the container.
-
When should you first have any food or water after boarding a lifeboat or liferaft? After 24 hours
Which statement about the Williamson turn is FALSE? It requires the highest degree of
shiphandling skills to accomplish.
Which of the following would be of immediate concern after discovering a large fire in the ship's
galley? A storeroom directly above, containing combustible fluids
136
A patient in shock should NOT be placed in which position? Arms above their head
A feature of an inflatable raft which helps keep people stationary in rough weather is lifelines on
the inside of the raft
Your vessel has grounded on a bar. What should you do? Switch to the high suction for condenser
circulating water, if it is submerged.
A wooden plug fitted tightly in the vent of a damaged tank may prevent the tank from filling
completely
A person is exhibiting signs of hypothermia and starts to shiver, what does this indicate? the body
is trying to generate more heat
If you have to jump in the water when abandoning ship, your legs should be extended straight
down and crossed at the ankles
While adrift in an inflatable liferaft in hot, tropical weather: deflating the floor panels may help to
cool personnel
Which statement about the free surface effect is TRUE? It decreases at increased angles of heel
due to pocketing when a tank is 90% full.
You have taken another vessel in tow at sea. You can tell that the towing speed is too fast when
the catenary comes clear of the water
The vertical motion of a floating vessel in which the entire hull is lifted by the force of the sea is
known as heave
-
What is the standard rate of signaling by flashing light? forty letters per minute
In a message sent by flashing light, what group of letters will direct the receiver of a message to
repeat the transmission back to the sender? RPT
Why is carbon dioxide (CO2) better than dry chemical for fighting a class "C" fire? The dry
chemical leaves a residue.
When do you use your FCC call sign when transmitting on channel 16? Always at the beginning
and ending of a transmission
-
When lowering a boat with gravity davits, it will be pulled into the embarkation deck by the tricing
pendants
Any extinguishing agent used on a Class "C" fire must have which important property?
Nonconductivity iletken olmayan
Which of the following terms defines the minimum temperature required to ignite gas or vapor
without a spark or flame being present? autoignition temperature kendiliginden tutusma sicakligi
The purpose of inert gas systems aboard tank vessels is to prevent outside air from entering the
tank
Crane Boom Indicator; All cranes, derricks and certain lift equipment require some form of boom
angle indication. Boom angle indicators must be visually readable by the operator
137
138