Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Page 1/8
Revision: 08.10.2015
GHS02
Signal word Warning
Hazard-determining components of labelling:
Distillates (petroleum), hydrotreated light
Hazard statements
H223-H229 Flammable aerosol. Pressurised container: May burst if heated.
Precautionary statements
P210
Keep away from heat, hot surfaces, sparks, open flames and other ignition sources. No smoking.
P251
Do not pierce or burn, even after use.
P211
Do not spray on an open flame or other ignition source.
P410+P412 Protect from sunlight. Do not expose to temperatures exceeding 50 C/122 F.
(Contd. on page 2)
GB
41.2.6
Page 2/8
Revision: 08.10.2015
25-50%
10-25%
10-25%
2.5-10%
2.5%
41.2.6
Page 3/8
Revision: 08.10.2015
41.2.6
Page 4/8
Revision: 08.10.2015
Not determined.
Change in condition
Melting point/Melting range:
Boiling point/Boiling range:
undetermined
Not applicable, as aerosol
Flash point:
Not applicable.
Ignition temperature:
215 C
Decomposition temperature:
Not determined.
Self igniting:
Danger of explosion:
Not determined.
Explosion limits:
Lower:
Upper:
0.5 Vol %
10.9 Vol %
Vapour pressure at 20 C:
8300 hPa
Density at 20 C:
0.80-0.83 g/cm
(Contd. on page 5)
GB
41.2.6
Page 5/8
Revision: 08.10.2015
Relative density
Vapour density
Evaporation rate
Not determined.
Not determined.
Not applicable.
Not determined.
Not determined.
Solvent content:
Organic solvents:
12.0 %
Solids content:
9.2 Other information
6.5 %
The above data are typical values and do not constitute a specification.
Vapor pressure data are calculated unless otherwise noted.
41.2.6
Page 6/8
Revision: 08.10.2015
UN1950
Not applicable
UN1950
1950 AEROSOLS
AEROSOLS
AEROSOLS, flammable
Class
Label
2 5F Gases.
2.1
IMDG, IATA
Class
Label
2.1
2.1
Void
(Contd. on page 7)
GB
41.2.6
Page 7/8
Revision: 08.10.2015
No
Warning: Gases.
F-D,S-U
1L
Code: E0
Not permitted as Excepted Quantity
3
E
1L
Code: E0
Not permitted as Excepted Quantity
UN 1950 AEROSOLS, 2.1
12.0
15.2 Chemical safety assessment: A Chemical Safety Assessment has not been carried out.
41.2.6
Page 8/8
Revision: 08.10.2015