Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
RB28F*
RB29F*
RB29H*
RB30F*
RB31F*
RB31H*
RB32F*
RB33F*
RB34F*
RB39F*
Refrigerator
user manual
English
www.samsung.com/register
DA68-02833M-09.indb 1
2014-01-10 8:55:51
safety information
SAFETY INFORMATION
Before operating the
appliance, please read this
manual thoroughly and retain
it for your reference.
Use this appliance only for
its intended purpose as
described in this instruction
manual. This appliance is not
intended for use by persons
(including children) with
reduced physical, sensory
or mental capabilities, or
lack of experience and
knowledge, unless they have
been given supervision or
instruction concerning use
of the appliance by a person
responsible for their safety.
Warnings and Important
Safety Instructions in this
manual do not cover all
possible conditions and
situations that may occur.
It is your responsibility to use
common sense, caution,
and care when installing,
maintaining, and operating
your appliance.
Because these following
operating instructions
DA68-02833M-09.indb 2
2014-01-10 8:55:51
WARNING
CAUTION
Hazards or unsafe
practices that may result
in severe personal
injury or death.
Hazards or unsafe
practices that may result
in minor personal
injury or property
damage.
CE Notice
This product has been
determined to be in
compliance with the Low
Voltage Directive(2006/95/
EC), the Electromagnetic
Compatibility Directive
(2004/108/EC), RoHS Directive
(2011/65/EU), Commission
Delegated Regulation (EU)
Do NOT attempt.
No 1060/2010 and the EcoDo NOT disassemble.
Design Directive(2009/125/EC)
implemented by Regulation (EC)
Do NOT touch.
No 643/2009 of the European
Follow directions carefully. Union. (For products sold in
European Countries only)
safety information _03
DA68-02833M-09.indb 3
2014-01-10 8:55:52
WARNING
SEVERE WARNING
SIGNS FOR
TRANSPORTATION
AND SITE
WARNING
SEVERE WARNING
SIGNS FOR
INSTALLATION
Deteriorated insulation
of electrical parts may
When transporting
cause an electric shock
and installing the
or fire.
appliance,care should
Do
not
place this refrigerator
be taken to ensure
in direct sunlight or expose to
that no parts of the
the heat from stoves, room
refrigerating circuit are
heaters or other appliance.
damaged.
-- Refrigerant leaking from the
Do not plug several
pipe work could ignite or
appliances into the same
cause an eye injury. If a leak
multiple power board.
is detected, avoid any naked
The refrigerator should
flames or potential sources
always be plugged into its
of ignition and air the room
own individual electrical outlet
in which the appliance is
which has a voltage rating
standing for several minutes.
that matched the rating plate.
-- This appliance contains a
-- This provides the best
small amount of isobutane
performance and also
refrigerant(R-600a), a natural
prevents overloading house
gas with high environmental
wiring circuits, which could
compatibility that is, however,
cause a fire hazard from
also combustible. When
overheated wires.
transporting and installing the If the wall socket is loose, do
appliance, care should be
not insert the power plug.
taken to ensure that no parts -- There is a risk of electric
of the refrigerating circuit are
shock or fire.
damaged.
Do not use a cord that shows
cracks or abrasion damage
along its length or at either
end.
04_ safety information
DA68-02833M-09.indb 4
2014-01-10 8:55:52
-- Deteriorated insulation of
electrical parts may cause an
electric shock or fire.
Connect the power plug in
proper position with the cord
hanging down.
-- If you connect the power
plug upside down, wire can
get cut off and cause a fire or
an electric shock.
Make sure that the power
plug is not squashed or
damaged by the back of the
refrigerator.
When moving the refrigerator,
be careful not to roll over or
damage the power cord.
-- This constitutes a fire hazard.
Keep the packing materials
out of reach of children.
-- There is a risk of death from
suffocation if children put
them on their head.
This appliance should be
positioned in such a way that
This refrigerator must be
it is accessible to the power
properly installed and
plug.
located in accordance
-- Failing to do so may result in
with the manual before
an electric shock or fire due
it is used.
to electric leakage.
Do not install the refrigerator Do not install this appliance
in a damp place or place
near a heater, inflammable
where it may come in contact
material.
with water.
safety information _05
DA68-02833M-09.indb 5
2014-01-10 8:55:52
DA68-02833M-09.indb 6
2014-01-10 8:55:52
WARNING
DA68-02833M-09.indb 7
2014-01-10 8:55:52
DA68-02833M-09.indb 8
2014-01-10 8:55:52
DA68-02833M-09.indb 9
2014-01-10 8:55:52
DA68-02833M-09.indb 10
2014-01-10 8:55:52
DA68-02833M-09.indb 11
2014-01-10 8:55:52
CAUTION
CAUTION SIGNS
FOR CLEANING AND
MAINTENANCE
DA68-02833M-09.indb 12
2014-01-10 8:55:53
WARNING
SEVERE WARNING
SIGNS FOR
DISPOSAL
DA68-02833M-09.indb 13
2014-01-10 8:55:53
refrigerating appliance is
designed.
Do not store food which goes
In the event of a power
bad easily at low temperature,
failure, call the local office of
such as bananas, melons.
your Electricity Company and
Your appliance is frost free,
ask how long it is going to
which means there is no
last.
need to manually defrost
-- Most power failures that are
your appliance, as this will be
corrected within an hour
carried out automatically.
or two will not affect your
Temperature rise during
refrigerator temperatures.
defrosting can comply with
However, you should
ISO requirements.
minimize the number of door
But if you want to prevent an
openings while the power is
undue rise in the temperature
off.
of the frozen food while
-- But should the power failure
defrosting the appliance,
last more than 24 hours,
please wrap the frozen
remove all frozen food.
food up in several layers of
If keys are provided with the
newspaper.
refrigerator, the keys should
Any increase in temperature
be kept out of the reach of
of frozen food during
children and not be in the
defrosting can shorten its
vicinity of the appliance.
storage life.
The appliance might
Do not re-freeze frozen foods
not operate consistently
that have thawed completely.
(possibility of defrosting of
contents or temperature
becoming too warm in the
frozen food compartment)
when sited for an extended
period of time below the
cold end of the range of
temperature for which the
ADDITIONAL TIPS
FOR PROPER USAGE
DA68-02833M-09.indb 14
2014-01-10 8:55:53
DA68-02833M-09.indb 15
2014-01-10 8:55:53
contents
SETTING UP YOUR REFRIGERATOR 16
OPERATING YOUR REFRIGERATOR 23
TROUBLESHOOTING 28
100mm
1,850mm
or
1,780mm
50mm
595mm
135
1214.7 mm
at least
50mm
602.2mm
at least
50mm
1062.4mm
WARNING
994mm
16_ setting up
DA68-02833M-09.indb 16
2014-01-10 8:55:55
FLOORING
Spacer
Spacer
01 setting up
CAUTION
CAUTION
setting up _17
DA68-02833M-09.indb 17
2014-01-10 8:55:59
Required Tools
Not provided
Phillips Head
Driver (+)
11mm Wrench
(for hinge shaft)
Not provided
Additional part
8mm Socket
Wrench
(for bolts)
18_ setting up
DA68-02833M-09.indb 18
2014-01-10 8:56:00
(2)
(1)
01 setting up
CAUTION
CAUTION
CAUTION
setting up _19
DA68-02833M-09.indb 19
2014-01-10 8:56:03
(2)
(1)
after
(A)
CAUTION
(B)
20_ setting up
DA68-02833M-09.indb 20
2014-01-10 8:56:18
01 setting up
Assemble step
Assemble the Top hinge on the Fridge
door.
Assemble the Middle hinge on the
Fridge door.
Insert the Top Hinge on the Cabinet.
Assemble the screw.
setting up _21
DA68-02833M-09.indb 21
2014-01-10 8:56:20
(A)
(B)
22_ setting up
DA68-02833M-09.indb 22
2014-01-10 8:56:21
TYPE B
TYPE C
Freezer
-19C
-21C
-23C
-15C
-17C
02 operating
Fridge
2C
1C
7C
5C
DA68-02833M-09.indb 23
2014-01-10 8:56:22
Coolselect Zone
Temperature Alarm
(Only for Coolselect zone function model)
When the freezer compartment is too warm
because there has been a power failure, the
temperature LED are blinking and the alarm
sounded. Press Freezer or Fridge button to
stop them.
This warning may occur:
-- When the refrigerator is turned on.
-- The freezer compartment is too warm due to a
power failure.
ADDITIONAL SHELF
If the additional shelf is provided in
optional, you can remove all drawers
except for the bottom drawer (2) and
place the additional shelf just above the
bottom drawer.
It does not affect thermal and mechanical
characteristics.
A declared storage volume of the freezer
compartment is calculated with these
parts removed for the additional shelf
provided models.
24_ operating
DA68-02833M-09.indb 24
2014-01-10 8:56:23
02 operating
Freezing food
CAUTION
operating _25
DA68-02833M-09.indb 25
2014-01-10 8:56:24
CAUTION
CAUTION
CAUTION
Method 1.
-- Fill the water lifting the round lid in the arrow
direction to open.
Round lid
Dispenser Lever
LOCK
Water tank
UNLOCK
Dispenser cock
Method 2.
-- Please fill the water after holding and lifting the
large lid to open it.
CAUTION
CAUTION
26_ operating
DA68-02833M-09.indb 26
2014-01-10 8:56:29
Shelves
Gently lift up the shelves
with both hands and pull it
toward you. (Glass shelf)
CAUTION
Water tank
Lift up the Can Carry and
then firmly grab the water
tank with both hands and
lift it up towards you gently
to remove the water tanks.
Water tank may not be available
depending on the model.
WARNING
CAUTION
02 operating
Door guards
Drawers
Pull the drawers out fully
then slightly lift it up to
remove the drawers.
If the drawers get
stuck to door, remove drawer by lifting up after
remove shelves.
operating _27
DA68-02833M-09.indb 27
2014-01-10 8:56:30
troubleshooting
PROBLEM
SOLUTION
The appliance is
not operating at all
or the temperature
is too high.
Is the temperature control on the front panel set to the coldest temperature?
Is the surrounding temperature too low?
Heat-proof pipes are installed in the front corners of the appliance to prevent
condensation from forming. When the surrounding temperature rises, this may not
always be effective. However, this is not abnormal.
In very humid weather, condensation may form on the outer surface of the appliance
when the moisture in the air comes into contact with the cool surface of the appliance.
There is a bad
smell inside the
appliance.
There is a layer
of frost on the
appliances walls.
Are the air outlet vents blocked by food stored inside the refrigerator?
Space the food out as much as possible to improve ventilation.
Is the door fully closed?
Condensation
forms on the
inside wall of the
appliance and
around vegetables.
Food with a high water content is stored uncovered with a high humidity level or the
door has been left open for a long time.
Store the food with a cover or in sealed containers.
28_ troubleshooting
DA68-02833M-09.indb 28
2014-01-10 8:56:31
circuit diagram
DA68-02833M-09.indb 29
2014-01-10 8:56:31
circuit diagram
DA68-02833M-09.indb 30
2014-01-10 8:56:31
memo
DA68-02833M-09.indb 31
2014-01-10 8:56:32
Class
Symbol
Extended Temperate
SN
+10 to +32
Temperate
+16 to +32
Subtropical
ST
+16 to +38
Tropical
+16 to +43
Internal temperatures may be affected by such factors as the location of the fridge/freezer,
ambient temperature and the frequency with which you open the door.
Adjust the temperature as required to compensate for these factors.
English
DA68-02833M-09.indb 32
2014-01-10 8:56:32
SEGR
RB28F*
RB29F*
RB29H*
RB30F*
RB31F*
RB31H*
RB32F*
RB33F*
RB34F*
RB39F*
Samsung.
,
www.samsung.com/register
DA68-02833M-09.indb 1
2014-01-10 8:56:33
,
,
.
R-600a
.
R-134a.
,
,
.
(
.
)
,
( R-600a),
,
.
.
,
,
.
.
,
,
. ,
.
.
02_
DA68-02833M-09.indb 2
2014-01-10 8:56:33
1m 8g
R-600a
.
.
.
,
,
.
--
.
:
.
.
.
.
.
.
.
.
.
.
.
.
,
.
CE
(2006/95/E),
(2004/108/E),
(2011/65/E),
() . 1060/2010
(2009/125/)
() . 643/2009
. (
)
_03
DA68-02833M-09.indb 3
2014-01-10 8:56:33
,
.
--
.
,
.
--
(R-600a),
, ,
.
,
.
--
--
.
,
.
.
,
.
'
,
.
,
.
.
04_
DA68-02833M-09.indb 4
2014-01-10 8:56:33
.
.
.
,
,
.
-- ,
.
--
.
() .
--
.
--
.
,
--
--
-
-
,
.
.
.
.
,
.
.
,
.
.
.
.
.
_05
DA68-02833M-09.indb 5
2014-01-10 8:56:33
-- ,
.
.
,
,
( ).
.
--
.
,
Samsung Electronics.
--
.
(
, ,
, ,
, , )
.
--
, ,
.
--
---
.
,
.
.
, ,
.
.
,
.
.
-- ,
.
06_
DA68-02833M-09.indb 6
2014-01-10 8:56:33
.
-- ,
.
.
.
--
2
.
.
, ,
.
,
-- ,
.
,
, ,
(,
.
, , ,
,
, )
--
.
--
.
.
--
.
,
.
.
--
--
,
.
.
_07
DA68-02833M-09.indb 7
2014-01-10 8:56:34
/,
.
,
Samsung
Electronics.
,
Samsung Electronics.
--
.
,
.
,
.
.
.
--
,
,
.
.
.
--
.
,
,
(
).
-- ,
.
.
. ,
.
-- .
.
.
08_
DA68-02833M-09.indb 8
2014-01-10 8:56:34
.
--
.
.
--
.
,
.
.
.
.
--
.
( ,
, ),
.
.
-- .
--
.
LED
.
,
.
"",
.
. ,
.
.
.
,
.
.
,
.
_09
DA68-02833M-09.indb 9
2014-01-10 8:56:34
--
.
,
(
, .)
.
--
.
--
.
,
.
--
(.. ,
, )
.
--
.
-- ,
,
,
.
,
.
.
.
,
.
,
.
LED,
LED
.
.
.
,
.
.
.
10_
DA68-02833M-09.indb 10
2014-01-10 8:56:34
-- ,
.
.
UV LED
.
--
.
,
.
.
, ,
.
,
--
.
,
.
-- ,
.
--
.
.
.
--
--
.
.
.
--
,
Samsung,
.
Samsung
_11
DA68-02833M-09.indb 11
2014-01-10 8:56:34
--
.
.
,
,
.
.
.
.
,
Samsung Electronics.
--
-
.
---
.
,
.
.
,
,
,
, .
.
.
.
,
, Clorox
.
.
.
.
,
.
12_
DA68-02833M-09.indb 12
2014-01-10 8:56:35
--
.
,
.
,
.
R-600a R-134a.
,
.
(
R-600a),
.
.
.
--
.
,
.
.
,
/ ,
.
,
.
.
.
.
.
_13
DA68-02833M-09.indb 13
2014-01-10 8:56:35
,
.
--
.
.
-- ,
24 ,
.
,
.
(
)
.
,
.
,
,
.
ISO.
,
.
.
.
14_
DA68-02833M-09.indb 14
2014-01-10 8:56:35
--
,
.
.
--
,
(
,
).
, ,
--
.
.
--
.
--
.
,
.
--
,
.
,
.
-- ,
,
.
_15
DA68-02833M-09.indb 15
2014-01-10 8:56:35
16
23
28
100mm
1.850mm
1.780mm
50mm
.
-- ,
.
.
(
) .
595mm
50mm
50mm
135
1214,7mm
,
, .
,
.
.
.
602,2mm
Samsung.
.
,
.
.
--
,
.
--
.
.
1.062,4mm
994mm
16_
DA68-02833M-09.indb 16
2014-01-10 8:56:36
, ,
.
.
10C.
& .
,
,
.
.
.
,
.
.
.
01
()
.
,
.
.
( RB31F***B,
RB29F***B)
,
, ,
.
( 65 ).
,
.
,
.
1)
.
.
2)
.
< 1 >
< 2 >
_17
DA68-02833M-09.indb 17
2014-01-10 8:56:41
,
.
,
.
,
.
,
Samsung Electronics.
1.
.
.
2.
,
.
3.
.
.
4. ,
.
,
.
.
Freezer () Fridge
(). (
Coolselect)
23
.
()
, .
Samsung
Samsung.
.
.
.
1.
,
.
2.
,
Samsung
.
3.
.
Phillips (+)
(-)
11mm
(
)
8mm
( )
18_
DA68-02833M-09.indb 18
2014-01-10 8:56:42
1. (1)
(2).
4.
M ,
.
(2)
(1)
01
2.
.
, '
.
5. .
3. .
2
.
6.
,
.
, '
.
, '
.
_19
DA68-02833M-09.indb 19
2014-01-10 8:56:45
7. .
(1) (2).
(1)
10.
( ).
.
(2)
(1)
8. (1)
.
(2)
.
(1)
(2)
(2)
(3)
(1).
.
(2)
(3)
.
9.
Phillips (+). ,
.
.
11. - (1),
(2)
( ).
-
() (3).
(1)
(A)
(2)
(3)
(B)
20_
DA68-02833M-09.indb 20
2014-01-10 8:57:01
12. 11mm
.
.
14.
.
.
01
13.
,
.
15.
.
16.
.
.
.
.
.
_21
DA68-02833M-09.indb 21
2014-01-10 8:57:03
17.
.
18.
, ,
,
180.
,
().
,
(B).
180.
( RB31F***B,
RB29F***B)
(A)
(B)
22_
DA68-02833M-09.indb 22
2014-01-10 8:57:04
,
.
,
LED ,
CoolSelect Zone
. , LED
Power Freeze Vacation
. (
RB31F***B, RB29F***B)
1
Freezer ()
-15C -23C.
-19C
Freeze ()
.
-19C
-21C
-23C
-15C
-17C
Power Freeze ( ).
02
( )
.
50 .
.
,
. ,
.
.
, Freezer ()
3 .
,
20 .
Fridge ()
, 1C
7C.
3C
Fridge ()
.
3C
2C
1C
7C
5C
3
.
Vacation ( )
17C
,
.
,
.
.
,
.
, Coolselect Zone
.
,
Coolselect Zone .
_23
DA68-02833M-09.indb 23
2014-01-10 8:57:05
Coolselect Zone
Coolselect Zone (
)
Coolselect Zone.
( )
.
Coolselect Zone
Coolselect Zone ( )
.
,
Coolselect Zone (
).
(
Coolselect)
, LED
.
Freezer ()
Fridge () .
:
-- .
--
.
Cool Select Zone
( ) (1)
.
. ()
, (2)
.
,
(2)
.
.
.
.
,
.
24_
DA68-02833M-09.indb 24
2014-01-10 8:57:07
, .
.
,
.
1.
2.
3.
4.
.
.
.
.
:
, , ,
.
:
, ,
.
.
:
, , ,
.
.
,
:
.
.
-18C
.
.
.
-
.
,
.
.
02
,
:
.
.
, / .
.
.
( ).
.
. -18C:
( ),
(, ): 12
( , ),
, , : 6
, : 2
FDA (http://www.fda.gov/).
,
.
_25
DA68-02833M-09.indb 25
2014-01-10 8:57:07
()
,
.
(1).
1
2
(2).
--
,
.
--
.
.
.
-- 4,5l.
,
.
--
, 500ml .
--
.
1.
-- ,
.
,
.
--
.
.
,
.
. ,
.
, ..
.
.
,
.
UNLOCK
().
.
LOCK
UNLOCK
2.
--
.
,
. .
26_
DA68-02833M-09.indb 26
,
.
.
,
Front ()
.
2014-01-10 8:57:12
. (
)
.
,
.
,
,
.
,
.
,
Clorox .
.
,
,
.
,
,
.
02
-
-.
.
1. .
2.
.
.
3.
.
4. .
,
.
LED
LED
,
LED .
.
_27
DA68-02833M-09.indb 27
2014-01-10 8:57:13
.
;
;
;
;
;
.
, .
.
,
.
,
.
;
( ,
) .
.
;
,
.
;
(
) .
.
.
;
;
;
.
28_
DA68-02833M-09.indb 28
2014-01-10 8:57:14
DA68-02833M-09.indb 29
2014-01-10 8:57:14
DA68-02833M-09.indb 30
2014-01-10 8:57:14
DA68-02833M-09.indb 31
2014-01-10 8:57:15
/
.
(C)
SN
+10 +32
+16 +32
ST
+16 +38
+16 +43
/,
. .
( & )
Greece
( )
,
, (.. ,
, USB)
.
,
,
.
, ,
.
-
.
.
SAMSUNG ELECTRONICS
. 280, 15232 , .
:
: .: 80111 SAMSUNG (7267864)
: .: + 357 800 94000
Web: www.samsung.com
DA68-02833M-09
DA68-02833M-09.indb 32
2014-01-10 8:57:15