Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
- a painting guide by
Jonas Fring
Cloak Grey
Saga
Basecoat [photo:
Unbleached
Wool
Colours used:
Saga
Tanned Flesh
WP1127
The Army Painter Master Tip: Use different size brushes for
each layer of detail, this gives you complete control over even
the most difficult parts of your paint job
Leather
Brown
WP1123
Desert
Yellow
WP1121
Warpaints Quickshade
Inks
Viking Red
Preparation
The first step is clean the model from mould
lines using a thin file, than glue it together and
to the base. I filled the gap around the hands
with a bit of Green Stuff putty to strengthen
the joint. Mix the yellow and blue parts of the
putty and it turns green ready for modeling
into place using a sculpting tool.
Colour Primer
Spray
This next step is where you really save precious
time. Instead of traditional black or white
primers, The Army Painter Colour Primers
allow you to prime and colour the miniatures
in one coat. As the Sven miniature was
predominately clad in chainmail I opted for
the Colour Primer: Gun Metal as my starting
point. There is 24 different colour primer
sprays to choose from, so finding a
good starting point for your army
project is easy.
WP1124
Skeleton
Bone
WP1125
The Army Painter Master Tip: Some miniatures may be to fragile to DIP
and SHAKE, like our hero here, in that case simply paint on the Quickshade
for the same fatastic result as dipping - this is also an excellent technique for
large miniatures, like monsters, tanks and other vehicles
First Highlight
Second Highlight
Eyes
Colours used:
skin: WP Barbarian Flesh, dark leather: WP
Leather Brown, belt: WP Monster Brown, skull:
WP Skeleton Bone/Matt White mix, scabbard:
WP Desert Yellow/Skeleton Bone mix, shield
and rim: GB-WP Pure Red, hair: WP Ash Grey
and clothes: WP Matt White.
Oak Brown
The Base
Viking Warband
painting tutorial
Finished!
Preperation
Basecoat
Colour Primer
Spray
This spray step is where you really save
precious time. The Army Painter Colour
Primers allow you to prime and colour the
miniatures in one coat. And by chosing the
right spray for the right job, youre half way
done before you even begin. For my Saga
Warband I used:
Barbarian
Flesh
WP1126
Leather
Brown
WP1123
Desert
Yellow
WP1121
Skeleton
Bone
WP1125
Colour
Primer:
Barbarian
Flesh
for the half-naked
Berserkers
Army Green
WP1110
Other miniatures in
Svens warband
extra SHIELDS
The shields were left in the sprue for easier handling
and sprayed with Colour Primer: Leather Brown
in the back and Colour Primer: Matt White on the
front.
Glue on model
Glue in place using a spot of Super Glue and you
are done!
Adding transfers
Following the instructions from LBM I added the
transfers to the shields. Super quick!
www.TheArmyPainter.com