Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
INFORMATION TO CANDIDATE:
1.
2.
3.
4.
Return this test question paper once student has finished the drawing.
Question 1
The part shown in Figure Q1 (in the next page) is the symmetry component that called
lever hub.
1. Construct the orthographic Top view (elevation X),
(20 marks)
2. Create section A-A view as front view, and side view (elevation Y) in third angle
projection for the part.
(30 marks)
3. Complete with title block, correct scale and full dimensioning.
(20 marks)
4. Convert T1 from direct limits into natural tolerances (upper and lower deviation).
(10 marks)
5. A manufacturer has manufactured a lever hub and planned to drill T 2 hole with a 22
mm basic size. Determine the bolt neck and T 2 hole dimensions for a sliding and
location fit.
(10 marks)
6. Indicate the following technical information either as written notes in your drawing in
the top right corner or shown as leader notes (dimensioning style).
i)
ii)
iii)
The material part shall be machined steel carburize harden and grind
The part should be machined.
Surface finish all over is required
(10 marks)
(Total: 100 marks)
T2
A
A
T1