Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
qc
7/28/00
13:53
Page 733
A P P E N D I X
PC Error Codes,
Beeps, and
Diagnostic
Messages
BM PCcompatible systems provide a number of selfdiagnostics to help you determine the nature of any major
or minor flaws in your systems hardware. The following tables
will help you in diagnosing the visual and audible error messages you could receive from many PC systems when a
problem exists.
The first four audible indications listed in Tables F-1 through
F-5 are standard for IBM systems and most compatibles.
Following these are numerically coded audible indications
used in some newer non-IBM systems, shown as a pattern
of a number of beeps, with pauses between them.
3510-2 appF.f.qc
734
7/28/00
13:53
Page 734
Appendixes
Table F-1
Audible Indications
Indication
Possible Causes
Table F-2
Fatal Error Beep Codes
Beep Sequence
Meaning
1-1-3
1-1-4
1-2-1
1-2-2
1-2-3
1-3-1
1-3-3
1-3-4
1-4-1
1-4-2
1-4-3
1-4-4
2-1-1
2-1-2
2-1-3
2-1-4
3510-2 appF.f.qc
7/28/00
13:53
Page 735
Beep Sequence
Meaning
2-2-1
2-2-2
2-2-3
2-2-4
2-3-1
2-3-2
2-3-3
2-3-4
2-4-1
2-4-2
2-4-3
2-4-4
3-1-1
3-1-2
3-1-3
8259 1 error
3-1-4
8259 2 error
3-2-4
3-3-1
3-3-4
3-4-1
3-4-2
3-4-3
Table F-3
Nonfatal Error Beep Codes
Beep Sequence
Meaning
4-2-1
4-2-2
4-2-3
735
3510-2 appF.f.qc
736
7/28/00
13:53
Page 736
Appendixes
Meaning
4-2-4
4-3-1
4-3-3
4-3-4
4-4-1
4-4-2
4-4-3
Many vendors have adopted IBMs standard numerical error coding scheme for
onscreen error messages. Table F-4 is a compilation of XT, AT, PS/2, and later model
error messages. These messages may or may not be accompanied by audible indications (as described previously), or contain extra leading or trailing zeros. These
messages are fairly specific as to the area, board, or component of the system that
needs to be replaced.
Table F-4
IBM BIOS, POST, and Diagnostic Error Messages and Meanings
Error Code
Description
101
102
103
104
105
106
107
108
109
110
111
3510-2 appF.f.qc
7/28/00
13:53
Page 737
Error Code
Description
112
113
114
115
116
118
119
120
121
122xx
Run diagnostics
130
131
132
133
134
151
152
161
162
163
164
165
166
199
201
202
203
301
Keyboard did not respond to software reset correctly or a stuck key failure
was detected; if a stuck key was detected, the scan code for the key is
displayed (check keyboard connection)
302
737
3510-2 appF.f.qc
738
7/28/00
13:53
Page 738
Appendixes
Description
303
304
305
306
307
365
Replace keyboard
366
367
401
408
416
424
432
5xx
501
Color memory test failed, horizontal sync frequency test, or video test failed
508
516
524
532
540
548
556
564
6xx
601
602
603
604
605
3510-2 appF.f.qc
7/28/00
13:53
Page 739
Error Code
Description
606
607
608
610
611
612
613
614
615
616
621
622
623
624
625
626
627
628
Diskette removed
655
System board
662
663
668
Diskette drive (see 73xx series messages for 3.5-inch diskette drives)
7xx
9xx
901
914
11xx
System board
1101
1002
739
3510-2 appF.f.qc
740
7/28/00
13:53
Page 740
Appendixes
Description
1047
10xx
1101
1102
1106
1107
1108
1109
1110
1111
1112
1113
1114
1115
1116
1117
1118
1119
1120
1121
1122
1123
1124
1125
1126
1127
1128
1129
1130
3510-2 appF.f.qc
7/28/00
13:53
Page 741
Error Code
Description
1131
1132
1133
1134
1135
ASYNC No interrupts
1136
1137
1138
1139
1140
1141
ASYNC No interrupts
1142
1143
1144
1145
1146
1148
1149
1150
1151
1152
1153
ASYNC No delta
1154
1155
1156
1157
1112
1118
1119
741
3510-2 appF.f.qc
742
7/28/00
13:53
Page 742
Appendixes
Description
1201
1202
1206
1207
1208
1209
1212
1218
1219
1227
1233
1234
12xx
1201
1210
1211
1212
1213
ALT ASYNC Receive and delta receive line signal detect failure
1211
1215
1216
1217
1218
1219
1220
1221
1222
1223
1224
3510-2 appF.f.qc
7/28/00
13:53
Page 743
Error Code
Description
1225
1226
1227
1228
1229
1230
1231
1232
1233
1234
1235
1236
1237
1238
1239
1240
1241
1242
1243
1244
1245
1246
1248
1249
1250
1251
1252
1253
1254
743
3510-2 appF.f.qc
744
7/28/00
13:53
Page 744
Appendixes
Description
1255
1256
1257
1301
1302
13xx
Game controller
1401
14xx
1510
1511
1512
1513
1514
1515
1516
1517
1518
1519
1520
1521
1522
1523
1524
1525
1526
1527
1528
1529
1530
3510-2 appF.f.qc
7/28/00
13:53
Page 745
Error Code
Description
1531
1532
1533
1534
1536
1537
1538
1539
1540
1541
1542
1547
1548
1549
15xx
SLDC adapter
16xx
1604
1608
1624
1634
1644
1652
1654
1658
1664
1662
1668
1674
1684
745
3510-2 appF.f.qc
746
7/28/00
13:53
Page 746
Appendixes
Description
1688
17xx
System board, hard disk drive, cable, power supply (see 104xx series
messages for PS/2 ESDI hard disk errors)
1701
1702
1703
1704
1705
No record round
1706
1707
Track 0 error
1708
1709
Bad ECC
1710
1711
1712
1713
1714
1730
Replace adapter
1731
Replace adapter
1732
Replace adapter
1780
1781
1782
1790
1791
1801
1810
Enable/disable failure
1811
1812
1813
3510-2 appF.f.qc
7/28/00
13:53
Page 747
Error Code
Description
1814
1815
1816
1817
1818
1819
1820
1821
19xx
20xx
BSC adapter
2001
2010
2011
2012
2013
2014
2016
2017
2018
2019
2020
2021
2022
2023
2024
2025
2026
2027
2028
747
3510-2 appF.f.qc
748
7/28/00
13:53
Page 748
Appendixes
Description
2029
2030
2031
2033
2034
2035
2036
2037
2038
2039
2040
2041
2042
2043
2044
2045
2046
2047
2048
2049
2050
2051
2052
209x
21xx
2101
2110
2111
2112
3510-2 appF.f.qc
7/28/00
13:53
Page 749
Error Code
Description
2113
2114
2116
2117
2117
2118
2119
2120
2121
2122
2123
2124
2125
2126
2128
2129
2130
2131
2133
2134
2135
2136
2137
2138
2139
2140
2142
2142
2143
749
3510-2 appF.f.qc
750
7/28/00
13:53
Page 750
Appendixes
Description
2144
2145
2146
2147
2148
2149
2150
2151
2152
2201
2221
23xx
24xx
24xx
2401
2402
2409
Display
2410
26xx
XT/3270 errors
27xx
AT/3270 errors
28xx
29xx
2901
3001
3002
3003
3004
3005
3006
3510-2 appF.f.qc
7/28/00
13:53
Page 751
Error Code
Description
3007
3008
3009
3010
3011
3012
3013
3015
Analog failure
3040
3041
3042
31xx
3101
3102
3103
3104
3105
3106
3107
3108
3109
3110
3111
3112
3113
3115
Analog failure
3140
3141
3142
751
3510-2 appF.f.qc
752
7/28/00
13:53
Page 752
Appendixes
Description
32xx
33xx
35xx
3504
3508
3588
3588
36xx
38xx
39xx
401x
44xx
45xx
50xx
Device/drive error
51xx
Device/drive error
52xx
56xx
60xx
SCSI device/adapter
61xx
SCSI device/adapter
62xx
64xx
Ethernet adapter
69xx
71xx
73xx
7306
7307
7308
7310
7311
3510-2 appF.f.qc
7/28/00
13:53
Page 753
Error Code
Description
7312
7313
7314
7315
7316
7321
7322
7323
7324
7325
74xx
75xx
76xx
7601
7602
7603
7604
78xx
High-speed adapter
79xx
7901
7902
7902
7903
80xx
PCMCIA adapter
82xx
84xx
Speech adapter
85xx
86xx
8601
753
3510-2 appF.f.qc
754
7/28/00
13:53
Page 754
Appendixes
Description
8602
8603
89xx
91xx
9101
Optical disk POST error drive #1 failed reseat cables and adapter
9102
9102
Reseat adapter
9103
Optical disk POST error drive #1 failed reseat cables and adapter
9104
Optical disk POST error drive #2 failed reseat cables and adapter
9105
9105
9106
Optical disk POST error drive #2 failed reseat cables and adapter
9107
9110
9111
9112
9113
Optical disk diagnostics error controller error check adapter, drive, cable
9113
9114
9115
Optical disk diagnostics error scramble buffer error check drive, adapter
9115
Check cable
9116
Optical disk diagnostics error data buffer error check drive, adapter
9116
Check cable
9117
Optical disk diagnostics error drive RAM/ROM error check drive, adapter
9117
Check cable
3510-2 appF.f.qc
7/28/00
13:53
Page 755
Error Code
Description
9118
9119
9120
Optical disk diagnostics error laser error check drive, adapter, or cable
9121
9122
Optical disk diagnostics error motor sync error cartridge upside down
9122
9123
Optical disk diagnostics error write fault check drive, adapter, or cable
9124
Optical disk diagnostics error general drive error check drive, adapter
9124
Check cable
9125
9125
Check cable
9126
9127
9127
Check cable
9128
Optical disk diagnostics error disk not initialized check drive, adapter
9128
Check cable
9129
Optical disk diagnostics error disk ID did not match check drive, adapter
9129
Check cable
9130
9130
9130
Check cable
9131
9131
9132
9132
755
3510-2 appF.f.qc
756
7/28/00
13:53
Page 756
Appendixes
Description
9132
Check cable
9133
9133
Check cable
9134
9134
Check cable
9135
Optical disk diagnostics error illegal disk detected check drive, adapter
9135
Check cable
9136
9136
Check cable
9138
Optical disk diagnostics error no disk change detected retry test again
9138
9138
Check cable
9141
9141
9141
Check cable
9144
9144
Check drive
9144
Check adapter
9144
Check cable
9145
9145
9145
Check cable
9146
9146
Check drive
9146
Check adapter
9146
Check cable
9148
Optical disk diagnostics error adapter card check adapter, drive, or cable
3510-2 appF.f.qc
7/28/00
13:53
Page 757
Error Code
Description
9150
Optical disk diagnostics error seek command railed check drive, adapter
9150
Check cable
9151
Optical disk diagnostics error not at track zero check drive, adapter
9151
Check cable
9152
Optical disk diagnostics error track address error check drive, adapter
9152
Check cable
9153
Optical disk diagnostics error not at track 17099 check drive, adapter
9153
Check cable
9154
Optical disk diagnostics error track address error check drive, adapter
9154
Check cable
9155
Optical disk diagnostics error track address 17K not found check drive
9155
Check adapter
9155
Check cable
9156
Optical disk diagnostics error seek time too long check drive, adapter
9156
Check cable
9157
9157
Check cable
9158
9158
Check cable
9159
Optical disk diagnostics error no null sector found check drive, adapter
9159
Check cable
9160
9160
Check cable
9161
9161
Check cable
9162
Optical disk diagnostics error data compare error check drive, adapter
9162
Check cable
Continued
757
3510-2 appF.f.qc
758
7/28/00
13:53
Page 758
Appendixes
Description
9163
Optical disk diagnostics error read verify error check drive, adapter
9163
Check cable
9164
Optical disk diagnostics error demark verify failed check drive, adapter
9164
Check cable
9165
Optical disk diagnostics error demark bit not set check drive, adapter
9165
Check cable
9166
Optical disk diagnostics error seek 1/3 timing error check drive, adapter
9166
Check cable
9167
Optical disk diagnostics error seek 2/3 timing error check drive, adapter
9167
Check cable
9168
Optical disk diagnostics error seek 3/3 timing error check drive, adapter
9168
Check cable
9170
Optical disk diagnostics error seek error set check drive, adapter, cable
9171
9171
Check cable
9172
9172
Check cable
9173
Optical disk diagnostics error detected error set check drive, adapter
9173
Check cable
9174
9174
Check adapter
9174
Check cable
9175
9176
9177
3510-2 appF.f.qc
7/28/00
13:53
Page 759
Error Code
Description
9178
9179
9181
9181
Check cable
9182
9185
Optical disk diagnostics error diagnostic track error check drive, adapter
9185
Check cable
9186
9186
Check cable
9187
9198
100xx
10001
10002
10003
10004
10006
10007
10008
10009
10010
10011
DIAGS error internal wrap test of 16550 modem control lines failed
10012
DIAGS error external wrap test of 16550 modem control lines failed
10013
10014
759
3510-2 appF.f.qc
760
7/28/00
13:53
Page 760
Appendixes
Description
10015
10016
10017
10018
10019
10026
10027
10028
10029
10030
10031
10032
10033
10034
10035
10035
10035
10035
10036
10036
10036
10037
10038
10039
10040
10041
10042
10044
10045
3510-2 appF.f.qc
7/28/00
13:53
Page 761
Error Code
Description
10046
10050
10051
10052
10053
10054
10055
10056
10057
10058
10059
10060
10061
10062
10063
10064
10002
10006
10007
10008
10009
10012
10018
10019
10042
10056
104xx
10480
10481
761
3510-2 appF.f.qc
762
7/28/00
13:53
Page 762
Appendixes
Description
10482
10483
10490
10491
106xx
Ethernet adapter
106x1
10635
149xx
14901
14902
14922
14932
152xx
152xx
XGA errors
156xx
160xx
16000
Set configuration
161xx
162xx
Power, battery
1630
16400
Set configuration
164xx
Table F-5
Hardware Errors
Error Code
Description
16451
16452
16453
3510-2 appF.f.qc
7/28/00
13:53
Page 763
Error Code
Description
16454
16455
16456
16457
16458
16459
16460
16461
16462
16463
16464
16465
16466
16467
16468
16469
Defective cartridge
165xx
16520
16540
16600
Set configuration
16700
Set configuration
16xxxx
166xx
167xx
168xx
169xx
170xx
171xx
172xx
System board
Continued
763
3510-2 appF.f.qc
764
7/28/00
13:53
Page 764
Appendixes
Description
173xx
Set configuration
174xx
175xx
176xx
177xx
System board
178xx
System board
179xx
System error log full, note errors in log, clear log, run diagnostics
181xx
182xx
183xx
Wrong password
184xx
185xx
186xx
187xx
188xx
189xx
Wrong password entered three times clear error log and restart
191xx
194xx
199xx
1999xxxx
1999
20xxy, 217xy
210xx
211xx
21xxx
22xxx
231xx
24xxx
252xx
Processor board
3510-2 appF.f.qc
7/28/00
13:53
Page 765
Error Code
Description
253xx
Processor cache
254xx
Processor cache
255xx
290xx
29xxx
298xx
2xx00
100203
System board
17xxxx
1803xx
System board
186xxx
Set configuration
18xxxx
240xxx
2410xx
System board
37xxxx
46xxxx
Multiport/2 interface
56xxxx
62xxxx
63xxxx
64xxxx
Network adapter
71xxxx
Voice adapter
101xxxx
Modem, fax/modem
10117xx
104xxxx
106xxxx
107xxxx
109xxxx
ActionMedia adapter
110100
110xxx
765
3510-2 appF.f.qc
766
7/28/00
13:53
Page 766
Appendixes
Description
111xxx
112xxxx
SCSI adapter
120xxx
121xxxx
300/1200/2400 modem
129xxxx
129020
137xxxx
System board
141xxxx
143xxxx
147xxxx
148xxxx
Display adapter
149xxxx
152xxxx
161xxxx
Fax adapter
164xxxx
165xxxx
Streaming tape
166xxxx
18001xx
Wizard adapter
18031xx
184xxxx
185xxxx
194xxxx
2000xxx
Image adapter
201xxxx
Printer/scanner option
206xxxx
208xxxx