Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Page 1
Introduction
This guide provides step-by-step instructions on how to program clusters and resiliency for a
network of three 3300 ICPs and OPS Manager. Resiliency programming depends on cluster
programming, which this guide will demonstrate. For detailed information about Resiliency and
clusters, see the “Resiliency “and “Portable Directory Number (Clusters)” guides. Both these
guides are located at http://edocs.mitel.com under 3300 ICP Networking.
Programming Steps
• Program cluster in each 3300 ICP
• Program IP trunk and ARS between 3300 ICPs
• Program cluster in OPS Manager
• Program Resilient IP Phones in OPS Manager
Network Diagram
Page 2
Programming Cluster in each 3300 ICP
Site 1:
Launch the 3300 ICP System Administration Tool and go to System Administration Tool /System
Configuration/ Unites/Module. Enter the following information:
• OpsMgrIPAddress Enter Ops-Manager IP address
• OpsMgrHostName Enter Ops-Manager Host name
• OpsMgrFtpUsername Enter Ops-Manager Ftp username
• OpsMgrFtpPassword Enter Ops-Manager Ftp user password
2. Program IP Trunks
The first step in Programming IP trunks is programming the ICP/PBX Assignment. The PBX
number can be any 3 or 4-digit number, (the same digits must be used for Cluster Element Index
Number), and the IP address of the 3300 RTC should be programmed (see 3300 ICP help for
complete IP trunks programming)
Page 3
3. Program ARS:
• In the ARS Dialed Digits Assignment form, program the Cluster Element Digits as
leading digits, which point to the other 3300 ICP.
• The Cluster Element ID (CEID) is the ICP network ID and it should be the same in all
3300 ICPs in the cluster; therefore, the Cluster Element Assignment form must be the
same in all 3300 ICPs. The only difference is the Local field set to YES for the Cluster
Element ID of the 3300 ICP that you are programming.
• Feature DN field must be programmed with any 4-digit number and the number
should be the same in all ICP. This number is used to enable network features such
as Remote DSS/BLF.
5. Repeat the above four programming steps at every 3300 ICP in the clustered network.
Page 4
Programming OPS Manager
Page 5
2. Program Portable Directory Group
• Open Configuration > Directory Management > Portable Directory Group Setup
and assign the Portable Directory Group a group name. Select the 3300 ICPs and
then click Commit.
Page 6
3. Program Distribution List
Page 7
4. Collection of the Telephone Directory from each 3300 ICP
Check Windows event viewer/ Application to make sure that no errors occurred during
collection.
Page 8
5. Synchronization with all 3300 ICPs
Page 9
6- Collect Unused Directory Numbers/Circuits
• Click Configuration, Network Element and then click Collect Unused Directory
Numbers/Circuit.
Page 10
Enabling Resiliency
Page 11