Sei sulla pagina 1di 2
Reg. No. B.E/B.Tech. DEGREE EXAMINATION, NOVEMBER/DECEM ‘Third Semester Mechanical Engineering ME 2205/ME 36/1012 ME 306/EE 1205 A/ 080120013 — ELACTRIQAL DRIVES AND CONTROL ©. (Common to Production Engineering, Chemical Engit . Petrochemical Engineering and Petrochemical Teglnolo} (Regulation 2008/2011 (Also common to PTME 2205 Electrical Drives ant or B.E, (Part—Time) ‘Third Semester ~ Production Engine < jation 2009) ‘Time : Three hours Maximum : 100 marks Give the examples where continous dgtyWt constant load is required. epee Draw the mechanical characte three phase induction motor. What are the methods of ig W electric motors? Draw the basic automatic rangement for shunt motor starting. of three phase induction motors? 1 used below rated speed? Draw the basic jopper controlled separately excited de motor drive. : 5 z a Zz tors (converters) used for V/f control of three phase induction yor. 10. State tl ations where stator voltage control is employed for three phase induet i PART B —(5 x 16 = 80 marks) ll. ‘xplain the thermal model of an electric motor for (16) heating the electric motor when starting from cold i)" cooling the electric motor when it is switched off from the mains. Or (>) @ A constant speed drive operating at a speed of 500 rpm has a cyclic loading as given below 200 Nm for 10 minutes 300 Nm for 20 minutes 12, 13, 14. (ii) What are the different classes of motor duty? 150 Nm for 20 minutes No load for 10 minutes Oo Estimate power rating of the motor. — (@) Explain the modifications to the speed-torque chara 8 of Oe shunt motor for the following : (with increase in armature resistance oY ® (ii) _ by field weakening. ® Or () A 220 V de series motor runs at 1200 @n aC. takes an armature current of 80 A when driving a | fnstant, torque. Armature resistance is 0.05 Q and field resifid 0.05 ©. Find the magnitude and direction of motor spee umyfare current if the motor terminal voltage is’ reversed ani r of turns in field winding is reduced to 80%. Assume lines circuit, (16) (a) A starter is required for a 220 minimum range of current values the number of sections of starter, each section. The armiatui wr. The maximum and 1d 30 A respectively. Find required and the resistance of fe motor is 0.5 Q. (16) (b) Explain the different sé fods for three phase squirrel cage induction motor. (16) (a) Explain the operatiopraty fase full converter fed sepaately excited de motor drive. (16) Or (&) With neat cire(ff is, explain chopper fed four quadrant de drive. (16) @ Explain icherbius drive which provides speeds below and above synch) (16) Or ©) ByplaXthe Gatant torque mode and constant power mode of operation source inverter fed induction motor drive with necessary = (16) 2 31561

Potrebbero piacerti anche