Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Installation
STEP1:OnceCADWorx2013isreceived,placediskinComputerandthedialogboxwillpopupbelow.Thereisnoneed
touninstallthepreviousversion.
STEP2:SelecttheRun_ReadMe.htmtoopenthefollowingwebpage:
STEP3:SelectthefirstoptionPlant_PID\setup.exetoinstallCADWorx2013.Thefollowingdialogboxwillappear:
STEP4:SelectNexttobegintheinstallationofCADWorx2013.
STEP5:SelecttheappropriateversionofAutoCADyouhaveonyourmachineandSelectNext.
STEP6:SelecttheCheckBoxforPlantProfessionalandtypeinyourSerialNumberprovidedonyourpackingslip.The
sameappliestoP&IDandP&IDProfessionalifpurchased.ClickNext.
STEP7:Verifythedestinationfolder.ThiswillcreateanewDirectoryandwillNOTaffectpreviousversionsofCADWorx
installedonyourmachine.SelectNext.
STEP8:SelectNext
STEP9:SelecttheGreenUSBbutton,andthenclickNext.DONOTSELECTTHEREDUSBEVER.
STEP10:KeepselectingOK,untilyougettothescreenbelow.
STEP11:SelectOK.ThiswillbegininstallationoftheHASPHLDriver.
STEP12:AfterinstatllationofHASPDriver,selectFinishtorestartyourmachine.
Quickstart
STEP1:TobeginCADWorx2013,selectthebelowicononyourdesktop:
STEP2:Selectyoudrawingenvironment.ThedefaultisImperial.IfyouwouldliketorunMetric,selecttheappropriate
oneandselectClose.
STEP3:Tobeginmodelingpipe,selectthesetupiconontheribbonorfromthepulldownmenu(Plant>Setup).
STEP4:Inthesetupdialogbox,selectConfigurationSettings.Thedefaultconfigurationfileisbasedonthedrawing
environmentselected.InthiscaseImperialwasselected.Thisiswhereyouhavetheoptiontoselectacustom
configurationfileifnecessary.
STEP5:SelecttheSpecification/Sizetab.
STEP6:SelectBrowsetoselecttheappropriateProjectfile(.PRJ)thenewprojectspecificationfiletype.
STEP7:ScrolldownuntilyouseetheSample_Inch.Prj.Thiscontainsthe150#,300#,600#,Example,asseenbelow.
STEP8:Selecttheappropriateratingyouwilluseandthenselecttheappropriatemainandreductionsizes.Pressthe
ApplyandClosebutton.
STEP9:OpentheSpecPaletteandStartPipingasbefore.