Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
LC-37D90U
SERVICE MANUAL
No. S56S8LC37D90U
MODEL
LC-37D90U
In the interests of user-safety (Required by safety regulations in some countries) the set should
be restored to its original condition and only parts identical to those specified should be used.
CONTENTS
SAFETY PRECAUTION
CHAPTER 1. SPECIFICATIONS
CHAPTER 2. OPERATION MANUAL
CHAPTER 3. DIMENSIONS
CHAPTER 4. REMOVING OF MAJOR PARTS
CHAPTER 5. ADJUSTMENT
CHAPTER 6. TROUBLE SHOOTING TABLE
CHAPTER 7. OVERALL WIRING/BLOCK DIAGRAM
CHAPTER 8. SCHEMATIC DIAGRAM
CHAPTER 9. PRINTED WIRING BOARD ASSEMBLIES
Parts Guide
LC-37D90U
CONTENTS
SAFETY PRECAUTION
IMPORTANT SERVICE SAFETY PRECAUTION.........................................................i
PRECAUTIONS A PRENDRE LORS DE
LA REPARATION............................................ ii
PRECAUTIONS FOR USING LEADFREE SOLDER.............................................. iii
CHAPTER 1. SPECIFICATIONS
[1] SPECIFICATIONS ...................................... 1-1
CHAPTER 2. OPERATION MANUAL
[1] OPERATION MANUAL ............................... 2-1
CHAPTER 3. DIMENSIONS
[1] DIMENSIONS ............................................. 3-1
CHAPTER 4. REMOVING OF MAJOR PARTS
[1] REMOVING OF MAJOR PARTS ................ 4-1
CHAPTER 5. ADJUSTMENT
[1] ADJUSTMENT PROCEDURE.................... 5-1
[2] MAJOR IC INFORMATIONS .................... 5-17
CHAPTER 6. TROUBLE SHOOTING TABLE
[1] TROUBLE SHOOTING TABLE................... 6-1
CHAPTER 7. OVERALL WIRING/BLOCK DIAGRAM
[1] OVERALL WIRING DIAGRAM ................... 7-1
[2] SYSTEM BLOCK DIAGRAM ...................... 7-3
[3] MAIN BLOCK DIAGRAM ............................ 7-5
[4] POWER BLOCK DIAGRAM ....................... 7-7
CHAPTER 8. SCHEMATIC DIAGRAM
[1] DESCRIPTION OF SCHEMATIC DIAGRAM ......................................................... 8-1
[2] R/C, LED Unit ............................................. 8-2
[3] IF Unit ......................................................... 8-3
[4] MAIN Unit.................................................... 8-7
[5] KEY Unit ................................................... 8-53
[6] SPEAKER TERMINAL-L Unit ................... 8-54
[7] SPEAKER TERMINAL-R Unit................... 8-54
CHAPTER 9. PRINTED WIRING BOARD ASSEMBLIES
[1] IF Unit ......................................................... 9-1
[2] MAIN Unit.................................................... 9-3
[3] R/C, LED Unit ............................................9-11
[4] KEY Unit ....................................................9-11
[5] SPEAKER TERMINAL-L Unit ................... 9-12
[6] SPEAKER TERMINAL-R Unit................... 9-12
Parts Guide
LC-37D90U
LC-37D90U
SAFETY PRECAUTION
Service Manual
WARNING
Use an AC voltmeter having with 5000 ohm per volt, or higher, sensitivity or measure the AC voltage drop across the resistor.
DVM
AC SCALE
1.5k ohm
10W
0.15 F
TEST PROBE
Using two clip leads, connect a 1.5k ohm, 10 watt resistor paralleled by a 0.15F capacitor in series with all exposed metal cabinet
parts and a known earth ground, such as electrical conduit or electrical ground connected to an earth ground.
TO EXPOSED
METAL PARTS
CONNECT TO
KNOWN EARTH
GROUND
///////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////
SAFETY NOTICE
Many electrical and mechanical parts in LCD color television have
special safety-related characteristics.
These characteristics are often not evident from visual inspection, nor
can protection afforded by them be necessarily increased by using
replacement components rated for higher voltage, wattage, etc.
The use of a substitute replacement parts which do not have the same
safety characteristics as the factory recommended replacement parts
shown in this service manual, may create shock, fire or other hazards.
LC-37D90U
PRECAUTIONS A PRENDRE LORS DE LA REPARATION
Ne peut effectuer la rparation qu' un technicien spcialis qui s'est parfaitement accoutum toute vrification de scurit et aux
conseils suivants.
AVERTISSEMENT
PRECAUTION: POUR LA
PROTECTION CONTINUE
CONTRE LES RISQUES
D'INCENDIE, REMPLACER LE
FUSIBLE
La tension de pointe mesure ne doit pas dpasser 0.75V (correspondante au courant CA de pointe de 0.5mA).
DVM
ECHELLE CA
1.5k ohm
10W
0.15 F
SONDE D'ESSAI
Brancher le cordon d'alimentation directem-ent une prise de courant de 120V. (Ne pas utiliser de transformateur d'isolation pour cet
essai).
AUX PIECES
METALLIQUES
EXPOSEES
BRANCHER A UNE
TERRE CONNUE
///////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////
///////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////
ii
LC-37D90U
PRECAUTIONS FOR USING LEAD-FREE SOLDER
Employing lead-free solder
"PWBs" of this model employs lead-free solder. The LF symbol indicates lead-free solder, and is attached on the PWBs and service manuals. The
alphabetical character following LF shows the type of lead-free solder.
Example:
When fixing the PWB soldered with the lead-free solder, apply lead-free wire solder. Repairing with conventional lead wire solder may cause damage or accident due to cracks.
As the melting point of lead-free solder (Sn-Ag-Cu) is higher than the lead wire solder by 40 C, we recommend you to use a dedicated soldering
bit, if you are not familiar with how to obtain lead-free wire solder or soldering bit, contact our service station or service branch in your area.
Soldering
As the melting point of lead-free solder (Sn-Ag-Cu) is about 220 C which is higher than the conventional lead solder by 40 C, and as it has poor
solder wettability, you may be apt to keep the soldering bit in contact with the PWB for extended period of time. However, Since the land may be
peeled off or the maximum heat-resistance temperature of parts may be exceeded, remove the bit from the PWB as soon as you confirm the
steady soldering condition.
Lead-free solder contains more tin, and the end of the soldering bit may be easily corroded. Make sure to turn on and off the power of the bit as
required.
If a different type of solder stays on the tip of the soldering bit, it is alloyed with lead-free solder. Clean the bit after every use of it.
When the tip of the soldering bit is blackened during use, file it with steel wool or fine sandpaper.
Be careful when replacing parts with polarity indication on the PWB silk.
J
J
J
Description
0.3mm 250g(1roll)
0.6mm 500g(1roll)
1.0mm 1kg(1roll)
Code
BL
BK
BM
iii
LC-37D90U
CHAPTER 1. SPECIFICATIONS
LC-37D90U
Service Manual
[1] SPECIFICATIONS
Item
Model: LC-37D90U
LCD panel
Number of dots
TV-standard
TV
Function
Receiving
Channel
1080
3 dots)
CATV
Digital Terrestrial
2-69ch
Broadcast (8VSB)
Digital cable*
1-135ch (non-scrambled channel only)
(64/256 QAM)
Audio multiplex
BTSC System
Audio out
10W
AV in, COMPONENT in
INPUT 2
AV in, S-VIDEO in
INPUT 3
INPUT 4
INPUT 5
Air ANTENNA
75
Cable ANTENNA
75
i.LINK
IEEE1394
Audio out
OSD language
English/French/Spanish
Power Requirement
AC 120 V, 60 Hz
Power Consumption
230 W
Weight
Dimension
(W H
D)
w/o stand
50.7 lbs./23.0 kg
with stand
62.9 lbs./28.5 kg
w/o stand
365/ 8
269/ 64
with stand
365/ 8
2845/ 64
Accessories
Operating temperature
1 (PCM/Dolby Digital)
413/ 16 inch
121/ 16 inch
Remote control unit ( 1), AC cord ( 1), "AAA" size battery ( 2), Cable clamp ( 1),
Cable tie ( 1), Operation manual ( 1)
32F to 104F (0C to 40C)
11
POWER
indicator**
Channel buttons
(CH / )
OPC indicator*
POWER button
INPUT button
21
AUDIO OUTPUT
terminals
INPUT1 terminals
RS-232C terminal
AIR IN terminal
CABLE IN terminal
i.LINK terminals
AC INPUT terminal
INPUT2
terminals
AUDIO input
terminals
(INPUT4)
DVI AUDIO
terminal
(INPUT5)
DIGITAL AUDIO
OUTPUT
terminal
DVI terminal
(INPUT5)
TV (Rear)
Part names
LC-37D90U
OPC sensor*
TV (Front)
Part names
LC-37D90U
Service Manual
22
32
31
30
29
28
27
24
25
26
NOTE
When using the remote control unit, point it at the TV.
16
15
14
13
10
11
12
20
21
22
23
19
18
7
8
9
17
2
3
2
3
NOTE
Angular mounting
0 or 5
Detach the cable clamp on the rear of the TV when using the optional mount bracket.
Vertical mounting
CAUTION
Installing the TV requires special skill that should only be performed by quali-ed service personnel. Customers
should not attempt to do the work themselves. SHARP bears no responsibility for improper mounting or
mounting that results in accident or injury.
NOTE
To attach the stand, perform the above steps in reverse order.
Do not remove the stand from the TV unless using an optional wall mount bracket to mount it.
CAUTION
Before detaching (or attaching) stand, unplug the AC cord from the AC INPUT terminal.
Appendix
Part names
LC-37D90U
No picture
23
No sound
When the unit is used in a low temperature space (e.g. room, office), the picture may leave trails or appear slightly delayed.
This is not a malfunction, and the unit will recover when the temperature returns to normal.
Do not leave the unit in a hot or cold location. Also, do not leave the unit in a location exposed to direct sunlight or near a
heater, as this may cause the cabinet to deform and the Liquid Crystal panel to malfunction.
_
_
Storage temperature: 4F to + 140F ( 20C to + 60C)
Possible Solution
No power
Problem
Troubleshooting
Appendix
E203
No broadcast now.
800 x 600
1024 x 768
1360 x 768
1280 x 1024
1600 x 1200
640 x 480
832 x 624
1024 x 768
XGA
WXGA
SXGA
UXGA*
VGA
SVGA
XGA
640 x 480
720 x 400
Resolution
SVGA
VGA
70 Hz
60 Hz
72 Hz
75Hz
56 Hz
60 Hz
72 Hz
75 Hz
60 Hz
70 Hz
75 Hz
60 Hz
60 Hz
60 Hz
67 Hz
75 Hz
75 Hz
31.5 kHz
37.9 kHz
37.5 kHz
35.1 kHz
37.9 kHz
48.1 kHz
46.9kHz
48.4 kHz
56.5 kHz
60.0 kHz
47.7kHz
64.0 kHz
75.0 kHz
34.9 kHz
49.7 kHz
60.2 kHz
Vertical Frequency
31.5 kHz
Horizontal Frequency
MAC13"
MAC16"
MAC19"
PC
PC/MAC
PC compatibility chart
O
O
O
O
O
O
O
O
O
O
O
O
O
VESA Standard
Displayed when the device you have selected is already being used by another
i.LINK connected device. To operate the selected device from the TV, you will first
have to override control from the other device.
Displayed when you have selected a device that is not compatible with the TV, or
that does not have DTLA copy protection technology installed.
Possible Solution
Possible Solution
Caution sentence
E202
Error code
Troubleshooting-Digital broadcasting
Appendix
LC-37D90U
8 bits
None
1 bit
None
Data length:
Parity bit:
Stop bit:
Flow control:
24
+ CR
When "?" is input for some commands, the present setting value responds.
Parameter
Input the parameter values, aligning left, and fill with blank(s) for the remainder. (Be sure that 4 values are input for
the parameter.)
When the input parameter is not within an adjustable range, "ERR" returns. (Refer to "Response code format".)
Any numerical value can replace the "x" on the table.
Command 4-digits
C1 C2 C3 C4 P1 P2 P3 P4
Command format
Communication procedure
Send the control commands from the PC via the RS-232C connector.
The TV operates according to the received command and sends a response message to the PC.
Do not send multiple commands at the same time. Wait until the PC receives the OK response before sending the
next command.
9,600 bps
Baud rate:
Communication conditions
Set the RS-232C communication settings on the PC to match the TV's communication conditions.
The TV's communication settings are as follows:
NOTE
This operation system should be used by a person who is accustomed to using computers.
PC Control of the TV
When a program is set, the TV can be controlled from the PC using the RS-232C terminal. The input signal
(PC/AV) can be selected, the volume can be adjusted and various other adjustments and settings can be made,
enabling automatic programmed playing.
Attach an RS-232C cable cross-type (commercially available) to the supplied Din/D-Sub RS-232C for the
connections.
Appendix
K
Return code (0DH)
R
Return code (0DH)
1
1
U
D
S
L
0
1
P
W
L
C L C P
C
C
H
H
C
D C 2
D
D
C
C
A
*
*
x
x
0
1
2
x
*
*
_
_
_
_
_
_
*
*
_
_
_
_
_
_
*
*
_
_
_
_
_
_
(0-9999)
(0-6383)
The channel number of TV + 1
The channel number of TV _ 1
(Toggle)
AIR
CABLE
(Toggle)
_ (0-999)
)
)
CONTROL CONTENTS
It shifts to standby.
Effective only when the Standby Mode is set to "Mode1".
It input-switches by the toggle. (It is the same as an input change key)
It input-switches to TV. (A channel remains as it is. (Last memory))
It input-switches to INPUT1~INPUT5.
It input-switches to i.LINK.
An input change is also included.
NOTE
If an underbar (_) appears in the parameter column, enter a space.
If an asterisk (*) appears, enter a value in the range indicated in brackets under CONTROL CONTENTS.
As long as that from which the parameter ( X ) in the table is a numerical value, it may write anything.
CC
Air/Cable SELECT
CH UP
CH DOWN
(DIGITAL)
COMMAND PARAMETER
P O W R 0 _ _ _ Power Off
1 _ _ _ Power On
INPUT SELECTION A TOGGLE
I T G D x _ _ _ (Toggle)
TV
I T V D x _ _ _
INPUT1-5
I A V D * _ _ _ Input terminal number (15)
L I N K x _ _ _
i.LINK
INPUT SELECTION B INPUT 1
I N P 1 0 _ _ _ AUTO
1 _ _ _ VIDEO
2 _ _ _ COMPONENT
INPUT 5
I N P 5 5 _ _ _ DIGITAL
6 _ _ _ ANALOG
AV MODE SELECTION
A V M D 0 _ _ _ (Toggle)
1 _ _ _ STANDARD
2 _ _ _ MOVIE
3 _ _ _ GAME
4 _ _ _ USER
5 _ _ _ DYNAMIC (Fixed)
6 _ _ _ DYNAMIC
7 _ _ _ PC
VOLUME
V O L M * * _ _ Volume (060)
H-POSITION H P O S * * * _ AV mode. ( 10)
POSITION
* * * _ PC mode. (0180)
V-POSITION V P O S * * * _ AV mode. ( 20)
* * * _ PC mode. (0100)
CLOCK
C L C K * * * _ Only PC mode. (0180)
PHASE
P H S E * * * _ Only PC mode. (040)
VIEWMODE
W I D E 0 _ _ _ (Toggle) [AV]
1 _ _ _ Side Bar [AV]
2 _ _ _ S.Stretch [AV]
3 _ _ _ Zoom [AV]
4 _ _ _ Stretch [AV]
5 _ _ _ Normal [PC]
6 _ _ _ Zoom [PC]
7 _ _ _ Stretch [PC]
8 _ _ _ Dot by Dot [AV] [PC]
9 _ _ _ Full Screen [AV]
MUTE
M U T E 0 _ _ _ (Toggle)
1 _ _ _ On
2 _ _ _ Off
Surround
A C S U 0 _ _ _ (Toggle)
1 _ _ _ On
2 _ _ _ Off
AUDIO SELECTION
A C H A x _ _ _ (Toggle)
SLEEP TIMER
O F T M 0 _ _ _ OFF
1 _ _ _ OFF TIMER 30 MIN.
2 _ _ _ OFF TIMER 60 MIN.
3 _ _ _ OFF TIMER 90 MIN.
4 _ _ _ OFF TIMER 120 MIN.
CHANNEL
DIRECT
D C C H * * * _ The channel number of TV
CHANNEL
(1135)
(ANALOG)
DIRECT
D A 2 P * * * * (0101-9999)
D C 2 U * * * _ (0-999)
CHANNEL
CONTROL ITEM
POWER SETTING
Command table
Commands not indicated here are not guaranteed to operate.
Normal response
Appendix
LC-37D90U
25
Setup
Power Control
Audio
Audio Setup
i.LINK Setup
Digital Setup
Audio Only
Digital Noise Reduction
Input Select
Output Select
Quick Shoot
Color System
Caption Setup
Program Title Display
Favorite CH
Option
EZ Setup
CH Setup
Antenna Setup-DIGITAL
Input Skip
Input Label
Parental CTRL
Position
Picture Flip
Standby Mode
Language
Reset
No Signal Off
No Operation Off
Treble
Bass
Balance
Surround
OPC
Backlight
Contrast
Brightness
Color
Tint
Sharpness
Advanced
Color Temp.
Black
3D-Y/C
Monochrome
Film Mode
Range of OPC
Picture
Option
Setup
Power Control
Audio
i.LINK Setup
Digital Setup
Audio Only
Digital Noise Reduction
Input Select
HDMI Setup
Output Select
Quick Shoot
Input Skip
Input Signal
Auto Sync.
Input Label
Fine Sync.
Position
Picture Flip
Standby Mode
Language
Reset
No Signal Off
No Operation Off
Treble
Bass
Balance
Surround
OPC
Backlight
Contrast
Brightness
Color
Tint
Sharpness
Advanced
Color Temp.
Black
Monochrome
Film Mode
Range of OPC
Picture
LC-37D90U
LC-37D90U
CHAPTER 3. DIMENSIONS
LC-37D90U
Service Manual
[1] DIMENSIONS
Unit: inch/(mm)
2627/ 64 (671)
43/ 32
(104)
365/ 8 (930)
413/ 16
(122)
179/ 32 (439)
121/ 16 (306)
77/ 8 (200)
77/ 8 (200)
361/ 64 (100)
231/ 64 (63)
2845/ 64 (729)
269/ 64 (664)
231/ 32 (585)
1817/ 64 (463.8)
3225/ 64 (822.6)
31
LC-37D90U
Service
CHAPTER 4. REMOVING OF MAJOR PARTS
LC-37D90U
Manual
Front Cabinet
5
1
SD Card Cover
5
SP Wire (R)
5
Rear Cabinet
3
SP Wire (L)
2
Stand Cover
Stand
41
Speaker Box
LC-37D90U
6. Remove the Stand Bottom Cover.
7. Disconnect the [FB] connector. Remove the 2 lock screws and detach the Fan Angle C Assy.
8. Remove the 4 lock screws and detach the SUS Angle (L)(R).
9. Remove the 5 lock screws and detach the Stand Fixing Angle.
10.Remove the 6 lock screws and detach the Main Shield.
Main Shield
10
42
LC-37D90U
12.Remove the 3 lock screws and detach the Fan Angle L Assy.
13.Remove the 2 lock screws and detach the SP (L) PWB.
14.Remove the 3 lock screws and detach the SP Fixing Angle (L).
15.Remove the 2 lock screws and detach the SP (R) PWB.
16.Remove the 3 lock screws and detach the SP Fixing Angle (R).
17.Remove the 2 lock screws and detach the R/C, LED PWB.
18.Remove the 2 lock screws and detach the Top Control Cover.
19.Remove the 3 lock screws and detach the KEY PWB.
20.Remove the 4 lock screws and detach the Try Chassis.
20
Try Chassis
18
Top Control Cover
12
KEY PWB
19
Fan Angle L Ass'y
17
14
16
16
15
14
SP (R) PWB
13
SP (L) PWB
43
LC-37D90U
21.Remove the 9 lock screws and detach the Jack Angle Long.
22.Remove the 6 lock screws and detach the POWER PWB.
23.Remove the 6 lock screws and detach the IF PWB.
24.Remove the 5 lock screws and detach the MAIN PWB Radiator and MAIN PWB.
24
MAIN PWB Radiator
MAIN PWB
22
21
POWER PWB
21
21
IF PWB
25.Remove the 2 lock screws from the Panel Fixing Angle (C), the 2 lock screws from the Panel Fixing Angle (L)(R) and detach the LCD Panel Ass'y.
26.Remove the 3 lock screws and detach the Panel Fixing Angle (C).
27.Remove the 4 lock screws and detach the Panel Fixing Angle (L)(R).
25
25
26
27
25
Panel Fixing
Angle (L)
Panel Fixing
Angle (R)
44
LC-37D90U
CHAPTER 5. ADJUSTMENT
LC-37D90U
Service Manual
1. After replacement of any PWB unit and/or IC for repair, please note the following.
When replacing the following units, make sure to prepare the new units loaded with updated software.
MAIN Unit: DKEYDD743FM21
Main software
The main software and the monitor microprocessor software can be upgraded by using a general-purpose SD memory card.
The followings are the procedures for upgrading, explained separately for each of the main software, the monitor microprocessor software.
2.2.2 Preparations
To upgrade the main software, it is necessary to get ready the SD card for version upgrade before you start. Follow the steps below and create the SD
card for version upgrade.
1. Insert the SD card into the SD card reader/writer. Start the SD card formatting software. Click [Format]. (When you have the drive options, select
the drive where the SD card is inserted before you proceed.)
51
LC-37D90U
2. When the formatting is over, the following window appears. Click [OK].
4. Copy the binary image file OLYMAxxx.SDC (named temporarily) for version upgrade to the root directory (folder) of the SD card drive.
NOTE: In the SD card drive, do not store other folders or unrelated files, or more than one binary image files for version upgrade.
Now the SD card for version upgrade is ready.
52
LC-37D90U
5. If any of the procedures fails, the following upgrade failure screen shows up. For the failing procedure, the NG marking turns red.
NOTE: In such case, try to upgrade the software again. If it still fails, the hardware may be in trouble.
6. When all the procedures are complete, the following upgrade success screen shows up. The new software version can be confirmed on screen.
The version number appears when each item has been successfully upgraded. Finally the main version number appears on screen.
7. Turn off the AC power (Unplug the AC power cord). Take out the upgrading SD card.
8. Now the software has been upgraded.
NOTE: Then get the set started and call the process adjustment screen 1/27 to check the main software version.
CAUTION: 1) Do not take out and put in the SD memory card during formatting.
2) With the SD formatted, all the data stored on the medium will be deleted.
3) Do not start the SD formatting with the memory cards WRITE PROTECT switch still on.
4) If the SD memory card format software does not recognize the SD memory card, take out and put in the SD memory card again, and
click the UPDATE button.
5) After checking the performance, use the set under its interface environment.
6) The SD formatting is impossible on drives that are not recognized REMOVABLE.
2.3.2 Preparations
As discussed in Upgrading the main software earlier, create the SD card for upgrading the monitor microprocessor software. For this SD card, use
the monitor microprocessor upgrading binary image file.
53
LC-37D90U
4. A couple to dozen seconds after the set starts, the upgrade screen below shows up. The upgrade progress is indicated on screen. The power LED
indicator goes out once and then starts flashing in blue. (It takes 2-3 minutes to get the monitor microprocessor software upgraded.)
5. If the procedure fails, the following upgrade failure screen shows up and the NG marking turns red. The power LED indicator fails to start flashing
in blue. Even if the usual screen reappears in several seconds, do the procedure from Step 1 again.
NOTE: In case of failure, try to upgrade the software again. If it still fails, the hardware may be in trouble.
6. When the procedure is complete, the following upgrade success screen shows up. The new software version can be confirmed on screen. The
upgrade success can also be confirmed when the power LED indicator and the OPC LED indicator start flashing alternately in blue and green,
respectively. Double-check the upgrading and turn off the AC power (Unplug the AC power cord). Take out the upgrading SD card. Now the software has been upgraded.
Finally get the set started and call the process adjustment screen 1/27 to check the monitor microprocessor software version.
54
LC-37D90U
3. Entering and exiting the adjustment process mode
1) Before entering the adjustment process mode, the AV position RESET in the video adjustment menu.
2) While holding down the VOL () and "INPUT" keys at a time, plug in the AC cord of the main unit to turn on the power.
The letter <K> appears on the screen.
3) Next, hold down the VOL () and CH (
(The "VOL ()" and "CH (
) keys at a time.
)" keys should be pressed and held until the display appears.)
Multiple lines of blue characters appearing on the display indicate that the unit is now in the adjustment process mode.
When you fail to enter the adjustment process mode (the display is the same as normal startup), retry the procedure.
4) To exit the adjustment process mode after the adjustment is done, unplug the AC cord from the outlet to make a forced shutdown. (When the
power was turned off with the remote controller, once unplug the AC cord and plug it again. In this case, wait 10 seconds or so before plugging.)
CAUTION: Use due care in handling the information described here lest your users should know how to enter the adjustment process mode. If the
settings are tampered in this mode, unrecoverable system damage may result.
4. Remote controller key operation and description of display in adjustment process mode
1) Key operation
Remote controller key
CH (
/
)
VOL (+/)
Cursor (UP/DOWN)
Cursor (LEFT/RIGHT)
INPUT
ENTER
Function
Moving an item (line) by one (UP/DOWN)
Changing a selected item setting (+1/ 1)
Turing a page (PREVIOUS/NEXT)
Changing a selected line setting (+10/ 10)
Input switching (toggle switching)
(TUNERINPUT1INPUT2INPUT3INPUT4INPUT5)
Executing a function
*Input mode is switched automatically when relevant adjustment is started so far as the necessary input signal is available.
2) Description of display
1/27
[INFO]
INPUT5
AUTO
USA
MAIN Version
0.95 ( U 2006/02/02 1)
BOOT Version
OLYM0.92
Monitor Version
0.88
EQ DATA CHECKSUM
ROM
TEMPAERATURE
7B
37_UNDER
(7) Adjustment
process menu
header
(8) Parameters
LAMP ERROR
1)
4)
00H 00M
00H 00M
2)
5)
55
00H 00M
00H 00M
3)
00H 00M
LC-37D90U
5. List of adjustment process mode menu
The character string in brackets [ ] will appear as a page title in the adjustment process menu header.
Page
1
Line
1
2
3
4
5
6
7
8
2
1
2
3
4
5
6
7
8
9
10
11
12
13
3
1
2
3
4
5
4
1
2
3
4
5
1
2
3
4
5
6
7
6
1
2
3
4
5
6
7
7
1
2
3
4
5
6
7
Item
[INFO]
MAIN Version
BOOT Version
Monitor Version
EQ DATA CHECKSUM
TEMPERATURE
LAMP ERROR
NORMAL STANDBY CAUSE
ERROR STANDBY CAUSE
[INIT]
INDUSTRY INIT (Cause)
INDUSTRY INIT
HOTELMODE
Center Acutime
RESET
BacklightAcutime
RESET
LAMP ERROR RESET
VIC XPOS
VIC YPOS
VIC COLOR
VIC SIGNAL TYPE
VIC READ
[N358MAIN]
N358 ALL ADJ
N358 MAIN ADJ
TUNER DAC ADJ
N358 MAIN CONTRAST
TUNER A DAC
[TUNER TEST]
TUNER VCHIP TEST(69ch)
TUNER VCHIP TEST(7ch)
TUNER VCHIP TEST(10ch)
TUNER VCHIP TEST(15ch)
[COMP15KMAIN]
COMP15K MAIN ADJ
COMP15K MAIN CONTRAST
COMP15K MAIN Cb GAIN
COMP15K MAIN Cr GAIN
COMP15K Y OFFSET
COMP15K Cb GAIN
COMP15K Cr GAIN
[HDTV]
HDTV ADJ
CONTRAST
Cb GAIN
Cr GAIN
HDTV Y OFFSET
HDTV Cb OFFSET
HDTV Cr OFFSET
[DVI ANALOG]
DVI ANALOG ADJ
R CUTOFF
G CUTOFF
B CUTOFF
R DRIVE
G DRIVE
B DRIVE
Description
56
LC-37D90U
Page
8
Line
1
2
3
4
5
6
7
8
9
1
2
3
4
5
6
7
8
9
10
11
10
1
2
3
4
5
6
7
8
9
10
11
11
1
2
3
4
5
6
7
8
9
10
11
12
1
2
3
4
5
6
Item
[M GAMMA IN]
MONITOR GAMMA IN 1
MONITOR GAMMA IN 2
MONITOR GAMMA IN 3
MONITOR GAMMA IN 4
MONITOR GAMMA IN 5
MONITOR GAMMA IN 6
GAMMA WRITE
GAMMA RESET
[M GAMMA R1]
MONITOR GAMMA R 1
MONITOR GAMMA G 1
MONITOR GAMMA B 1
MONITOR GAMMA R 2
MONITOR GAMMA G 2
MONITOR GAMMA B 2
MONITOR GAMMA R 3
MONITOR GAMMA G 3
MONITOR GAMMA B 3
GAMMA WRITE
GAMMA RESET
[M GAMMA R4]
MONITOR GAMMA R 4
MONITOR GAMMA G 4
MONITOR GAMMA B 4
MONITOR GAMMA R 5
MONITOR GAMMA G 5
MONITOR GAMMA B 5
MONITOR GAMMA R 6
MONITOR GAMMA G 6
MONITOR GAMMA B 6
GAMMA WRITE
GAMMA RESET
[SOUND 1]
AUDIO SELECT
INPUT_TRIM_SP
INPUT_TRIM_HP
CLIPPER_LEVEL
ANGLE
MASTER_VOLUME
SCART_PRESCALE
FM_AM_PRESCALE
I2S1_PRESCALE
SCART1_VOLUME
SCART2_VOLUME
[SOUND 2]
AIN1_ADC_VOLUME
AIN2_ADC_VOLUME
AIN3_ADC_VOLUME
AIN4_ADC_VOLUME
AIN5_ADC_VOLUME
AIN6_ADC_VOLUME
Description
57
LC-37D90U
Page
13
Line
1
2
3
4
5
6
7
8
9
10
11
12
14
1
2
3
4
5
6
7
8
9
10
11
12
13
15
1
2
3
4
16
1
2
3
4
5
6
7
8
9
10
11
12
17
1
2
3
4
5
6
7
8
9
10
11
Item
[SOUND 3]
SUB_VOLUME_SURROUND
SUB_VOLUME_FLAT
SUB_VOLUME_EQ
SUB_VOLUME_HP
SUB_VOLUME_HP_CENTERSP
SUB_VOLUME_CENTERSP_EQ
SUB_VOLUME_CENTERSP_FLAT
BBE_HF_ADJUST
BBE_LEVEL
BBE_MACH3_F0
BBE_MACH3_Q
BBE_MACH3_GAIN
[SOUND 4]
EQ_MODE
PEQ1_F0
PEQ1_Q
PEQ1_GAIN
PEQ2_F0
PEQ2_Q
PEQ2_GAIN
PEQ3_F0
PEQ3_Q
PEQ3_GAIN
PEQ4_F0
PEQ4_Q
PEQ4_GAIN
[SOUND 5]
PEQ5_F0
PEQ5_Q
PEQ5_GAIN
EALA_GAIN
[M OPC1]
BRIGHTNESS DA0
BRIGHTNESS DA1
BRIGHTNESS DA2
BRIGHTNESS DA3
BRIGHTNESS DA4
BRIGHTNESS DA5
BRIGHTNESS DA6
BRIGHTNESS DA7
BRIGHTNESS DA8
BRIGHTNESS DA9
BRIGHTNESS DA10
BRIGHTNESS DA11
[M OPC2]
BRIGHTNESS DA12
BRIGHTNESS DA13
BRIGHTNESS DA14
BRIGHTNESS DA15
BRIGHTNESS DA16
BRIGHTNESS DA17
BRIGHTNESS DA18
BRIGHTNESS DA19
BRIGHTNESS DA20
BRIGHTNESS DA21
BRIGHTNESS DA22
Description
58
LC-37D90U
Page
18
Line
1
2
3
4
5
6
7
8
9
10
19
1
2
3
4
5
6
7
8
9
10
11
12
20
1
2
3
4
5
6
7
8
9
10
11
21
1
2
3
4
5
6
7
8
9
22
1
2
3
4
5
6
7
23
1
2
3
4
5
6
7
Item
[M OPC3]
BRIGHTNESS DA23
BRIGHTNESS DA24
BRIGHTNESS DA25
BRIGHTNESS DA26
BRIGHTNESS DA27
BRIGHTNESS DA28
BRIGHTNESS DA29
BRIGHTNESS DA30
BRIGHTNESS DA31
BRIGHTNESS DA32
[M ADL1]
OPC33 ADLEVEL 0
OPC33 ADLEVEL 1
OPC33 ADLEVEL 2
OPC33 ADLEVEL 3
OPC33 ADLEVEL 4
OPC33 ADLEVEL 5
OPC33 ADLEVEL 6
OPC33 ADLEVEL 7
OPC33 ADLEVEL 8
OPC33 ADLEVEL 9
OPC33 ADLEVEL 10
OPC33 ADLEVEL 11
[M ADL2]
OPC33 ADLEVEL 12
OPC33 ADLEVEL 13
OPC33 ADLEVEL 14
OPC33 ADLEVEL 15
OPC33 ADLEVEL 16
OPC33 ADLEVEL 17
OPC33 ADLEVEL 18
OPC33 ADLEVEL 19
OPC33 ADLEVEL 20
OPC33 ADLEVEL 21
OPC33 ADLEVEL 22
[M ADL3]
OPC33 ADLEVEL 23
OPC33 ADLEVEL 24
OPC33 ADLEVEL 25
OPC33 ADLEVEL 26
OPC33 ADLEVEL 27
OPC33 ADLEVEL 28
OPC33 ADLEVEL 29
OPC33 ADLEVEL 30
OPC33 ADLEVEL 31
[M V6THE]
V6 OS THERMO 1
V6 OS THERMO 2
V6 OS THERMO 3
V6 OS THERMO 4
V6 OS THERMO 5
V6 OS THERMO 6
V6 OS THERMO 7
[M V5THE]
V5 OS THERMO 1
V5 OS THERMO 2
V5 OS THERMO 3
V5 OS THERMO 4
V5 OS THERMO 5
V5 OS THERMO 6
V5 OS THERMO 7
Description
59
LC-37D90U
Page
24
Line
1
2
3
25
1
26
1
2
3
4
5
6
27
1
2
3
Item
[M EEP SET]
MONITOR TIME OUT
MONITOR MAX TEMP
MONITOR STANDBY CAUSE
[M TESTPTRN]
LCD TEST PATTERN
[MEMORY CLR]
KEY LOCK(1217)
KOUTEI AREA ALL CLEAR
A MODE AREA CLEAR
BACKUP AREA CLEAR
B MODE AREA CLEAR
EXECUTION
[ETC]
EEP SAVE
EEP RECOVER
STANDBY CAUSE RESET
Description
6. Special features
*
Composite signal
15K component signal
:
:
Y level
PB, PR level
Y level
PB, PR level
RGB level
:
:
:
:
:
5 10
LC-37D90U
7.3. N358 composite signal adjustment (Tuner)
Adjustment item
Adjustment
Adjustment conditions
N358 signal
Adjustment procedure
Feed the PAL split field color bar signal (75% color saturation) to VIDEO
1 input. Feed the RF signal (by use of US-10ch) to TUNER-A.
[US-10CH]
100% white
Auto adjustment
performance
Page 3/27
100% white
Adjustment item
Adjustment
Adjustment conditions
480i signal
Adjustment procedure
Feed the 100% color bar signal to INPUT 1 component input.
100% white
2
Auto adjustment
performance
Page 5/27
Bring the cursor on [COMP 15K ALL ADJ] and press [ENTER].
[COMP 15K ALL ADJ FINISH] appears when finished.
Adjustment item
Adjustment
Adjustment conditions
1080i signal
Adjustment procedure
Feed the 100% color bar signal to INPUT 1 component input.
100% white
2
Auto adjustment
performance
Page 6/27
Adjustment item
Adjustment
Adjustment conditions
DVI-I (analog)
XGA (1024 x 768)
60Hz
H,V SYNC
Adjustment procedure
Feed the 100% white 1/2 window pattern signal to DVI-I (analog) input.
1/4
1/2
100% White
1/4
0% Black
1/4
5 11
1/2
1/4
LC-37D90U
2
Adjustment item
Auto adjustment
performance
Adjustment conditions
Page 7/27
Adjustment procedure
Bring the cursor on [DVI ANALOG] and press [ENTER].
[DVI ANALOG ADJ FINISH] appears when finished.
Adjustment item
Adjustment
Adjustment conditions
Auto adjustment
performance
Adjustment procedure
1) Apply the following settings to the set.
AV MODE: [DYNAMIC]
Aging Time: 60 Min.
Backlight: +16
2) Connect a white balance jig and the set.
Optical measuring machine: [Minolta CA-210]
PC
RS-232C communication cable
3) Use an RS-232C command to display the screen for multipoint adjustment.
Multipoint adjustment mode (MSET0001)
Adjustment value initialization (MSET0004)
Standard value 6 (LEV60232)
Standard value 5 (LEV50200)
Standard value 4 (LEV40164)
Standard value 3 (LEV30132)
Standard value 2 (LEV20088)
Standard value 1 (LEV10048)
Write setting (MSET0003)
[Adjustment]
1) Enter the monitor adjustment process mode.
2) Set the specified gradation for standard value 6. Set the strongest
color as the fixed color and adjust RGB by reducing to the standard
value.
3) Set the specified gradation for standard value 5. Set the correction
value of G [(default of standard value 5) x (G of standard value 6) /
(default of standard value 6)] and adjust RB to the standard value.
4) Set the specified gradation for standard value 4. Set the correction
value of G [(default of standard value 4) x (G of standard value 6) /
(default of standard value 6)] and adjust RB to the standard value.
5) Set the specified gradation for standard value 3. Set the correction
value of G [(default of standard value 3) x (G of standard value 6) /
(default of standard value 6)] and adjust RB to the standard value.
6) Set the specified gradation for standard value 2. Set the correction
value of G [(default of standard value 2) x (G of standard value 6) /
(default of standard value 6)] and adjust RB to the standard value.
7) Set the specified gradation for standard value 1. Set the correction
value of G [(default of standard value 1) x (G of standard value 6) /
(default of standard value 6)] and adjust RB to the standard value.
8) Write the adjustment values with MSET0003 command and turn off
AC power.
[Adjustment values]
Optical measuring machine: [Minolta CA-210] (Focus on the center of the screen.)
Standard value 6
Level
232
Standard value 5
200
Standard value 4
164
Standard value 3
132
Standard value 2
88
Standard value 1
48
Standard value
x = 0.272
y = 0.272
x = 0.272
y = 0.272
x = 0.272
y = 0.272
x = 0.272
y = 0.272
x = 0.272
y = 0.272
x = 0.272
y = 0.272
Adjustment value
0.001
0.001
0.001
0.001
0.001
0.001
0.001
0.001
0.002
0.002
0.002
0.002
5 12
Tolerance
0.0020
0.0020
0.0020
0.0020
0.0020
0.0020
0.0020
0.0020
0.004
0.004
0.004
0.004
LC-37D90U
Level
Note
Standard value
Adjustment value
Set the following before adjustment.
AV MODE: [DYNAMIC]
Monochrome: ON
Aging Time: 60 Min.
Tolerance
9,600 bps
8 bit
None
1 bit
None
5. If the settings are correct, the terminal software indicates ERR against pressing of the ENTER key.
6. After the settings are done correctly, it is possible to make an adjustment by typing in the command shown in the table below and pressing the
ENTER key on the keyboard.
7. Command entry is successful if the terminal software indicates OK when the ENTER is pressed. If ERR is shown, retry to enter the command.
8. Send the process mode switching command to switch from the RS232C operation mode to the process mode.
KRSW0001: ERR is returned.
KKT10037: When OK is returned, the process mode becomes active. When ERR, start over from KRSW0001.
9. Send each adjustment command.
5 13
LC-37D90U
8.3. White balance adjustment sequence
Adjustment is available in any input or position. There is no specific order to adjust high and low, either.
PC
Set
5 14
LC-37D90U
Start of measurement
Pattern display
Pattern display
Pattern display
5 15
LC-37D90U
Start of measurement
Adjust RB to the target xy values.
MG2RXXXX
MG2BXXXX
* XXXX indicates adjustment values between 0000 - 1023 (4 digit decimal number with zero fill).
* G is fixed.
* Default adjustment value of RGB is the parameter value of LEV2 command multiplied by 4.
Repeat until values are
properly adjusted.
Pattern display
Adjustment value is set.
OK
Correct G value.
MG1GXXXX
When G is changed at adjustment gradation setting (standard value 6 = 236 gradation), calculate
the ratio of the change and set the following value to XXXX: (the value set with LEV1) x 4 x (the ratio).
Adjustment value is set.
OK
Start of measurement
Adjust RB to the target xy values.
MG1RXXXX
MG1BXXXX
* XXXX indicates adjustment values between 0000 - 1023 (4 digit decimal number with zero fill).
* G is fixed.
* Default adjustment value of RGB is the parameter value of LEV1 command multiplied by 4.
Adjustment item
Initialization
Adjustment conditions
It turns off with AC power
supply.
Adjustment procedure
Enter the adjustment process mode.
Bring the cursor on to [INDUSTRY INIT] in page 2/27.
Set to [ON] using [VOL] key, and press [ENTER] to execute the initialization.
When the version number screen shows up on the green background and SUCCESS
gets displayed at the top on screen, it means the procedure has been successfully carried out.
(If an error occurs, ERROR is displayed on the red background.)
Turn off the AC power.
*Never shut off the power during the initialization process.
The following settings are initialized in this adjustment.
1) User setting
2) Channel data (e.g. broadcast frequencies)
3) Password data
4) Operation time
5) Auto installation flag
6) V-CHIP block setting
5 16
LC-37D90U
5 17
LC-37D90U
1.11. IC8101 (RH-iXB281WJZZQ)
This LSI with MPEG-2 system decoder performs back-end processing for digital broadcasting. It is equipped with a CPU (processor core: AM33-3),
descrambler (DES), transport stream de-multiplexer, video decoder (MPEG-2 MP@HL compatible), graphic processor, audio decoder (AC3 compatible), and an NTSC video encoder.
After receiving transport stream from the tuner, the LSI decrypts pay-TV broadcasts with the descrambler. Then using the de-multiplexer, it separates
and decodes the compressed audio and video data to send the signals. In the visual system, the graphic processor makes it possible to overlap subtitles and perform scaling. Digital video signals (Y, Pb and Pr, or 480I/P, 720P and 1081I) and down-converted NTSC signals (Y/C and composite, or
480I) can be sent simultaneously. As for the audio system, decoded AC3 audio can be overlapped with sound effects.
The LSI also contains various interfaces (I2C x 2, UART x 3, an SD Memory Card interface, a Cable CARD interface, etc.) and a GPIO. Using these
interfaces, the CPU controls peripheral circuits of the tuner, SD Memory Cards, Cable CARDs, etc. One of the UARTs is used by the CPU to establish
communications with the monitor microcomputer in the unit, where remote control information or other data is exchanged. Another UART is used for
RS-232C serial communications to connect the unit to a PC.
5 18
LC-37D90U
2. MAJOR IC INFORMATIONS (BLOCK DIAGRAM AND PIN FUNCTION)
2.1. VHiMM1630CQ-1Q (ASSY: IC501)
Video Switch with I2C-bus
Pin Name
C3
C4
C5
C1
C2
S-3
S-4
S-5
S-1
S-2
V4
V5
V6
V7
V8
VIN
V1
V2
V3
I/O
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
Pin Function
Chroma signal input.
SW of S-terminal.
5 19
LC-37D90U
Pin No.
4
10
68
74
80
5
11
67
73
79
8,47,53,57
14
16
18,44,62
20
26
32
21
27
33
39
22
28
34
23
29
35
41
24
30
36
25
31
37
43
38
40
42
45
46
48
61
49
50
51
52
54
58
55
59
56
60
64
66
72
78
Pin Name
S2-4
S2-5
S2-1
S2-2
S2-3
Y4
Y5
Y1
Y2
Y3
Vcc
ADR
BIAS
GND
L11
L12
L13
CY1
CY2
CY3
CY4
L21
L22
L23
PB1
PB2
PB3
PB4
L31
L32
L33
PR1
PR2
PR3
PR4
SW1
SW2
SW3
SDA
SCL
VOUT4
VOUT
DCOUT
COUT3
VOUT3
YOUT3
PROUT2
PROUT1
PBOUT2/COUT2
PBOUT1/COUT1
CYOUT2/YOUT2/VOUT2
CYOUT1/YOUT1/VOUT1
O1
O2
O3
O4
I/O
I
I
I
I
I
I
I
I
I
I
--I
I
--I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I/O
I
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
Pin Function
Detect of S-terminal.
Power supply.
Slave address select terminal.
Bias.
GND.
Detect of D-terminal scanning line.
5 20
LC-37D90U
2.2. VHiTA2024++-1Y (ASSY: IC2303)
STEREO DIGITAL AUDIO AMPLIFIER
Pin Name
DCAP2,
DCAP1
I/O
4,9
5,8,17
-----
12
V5D, V5A
AGND1,
AGND2,
AGND3
REF
OVERLOADB
OAOUT1,
OAOUT2
INV1,
INV2
MUTE
16
18
BIASCAP
SLEEP
19
FAULT
6
7
10,14
11,15
20,35
22
24,27,
31,28
25,26,
29,30
13,21,23,
32,34
33
36
1
PGND2,
PGND1
DGND
OUTP2 & OUTM2,
OUTP1 & OUTM1
VDD2,VDD2,
VDD1,VDD1
NC
VDDA
CPUMP
5VGEN
---
Pin Function
Charge pump switching pins. DCAP1 (pin 3) is a free running 300kHz square wave between
VDDA and DGND (12Vpp nominal). DCAP2 (pin 2) is level shifted 10 volts above DCAP1 (pin 3)
with the same amplitude (12Vpp nominal), frequency, and phase as DCAP1.
Digital 5VDC, Analog 5VDC.
Analog Ground.
---
Single-ended inputs. Inputs are a virtual ground of an inverting opamp with approximately
2.4VDC bias.
When set to logic high, both amplifiers are muted and in idle mode. When low (grounded), both
amplifiers are fully operational. If left floating, the device stays in the mute mode. This pin should
be tied to GND if not used.
Input stage bias voltage (approximately 2.4VDC).
When set to logic high, device goes into low power mode. If not used, this pin should be
grounded.
A logic high output indicates thermal overload, or an output is shorted to ground, or another output.
Power Grounds (high current).
--O
---
---
Analog 12VDC.
Charge pump output (nominally 10V above VDDA).
Regulated 5VDC source used to supply power to the input section (pins 4 and 9).
5 21
LC-37D90U
2.3. VHiAN5832SA-1Y (ASSY: IC1401)
United States TV SAP SIF_DECODER
Pin Name
N.C
WB TIM
WB DET
SAP TIM
SAP DET
SPE FIL
I2C/PARA
AGC SW
MODE
FOMO
MUTE
SIF/BB
NOISE DET
SAP DET
L+R REF
N.C
PILOT DET
PLL
VCC
N.C
INPUT
SIF REF
STEREO REF
SDA/SAP ID
GND
PE
SCL/STID
AGC DET
ROUT
LOUT
N.C
L-R REF
I/O
----I
--I
--I/O
I
I
I
I
I
----------------I
----I/O
----I
--O
O
-----
Pin Function
Non connection.
Wide band timing.
Wide band level sensor input terminal.
Spectral timing.
Spectral level sensor input terminal.
Spectral filter.
I2C/Pararel switch.
AGC switch.
Mode switch.
Force mono switch.
Mute switch.
SIF/Base band switch.
SAP noise level detector.
SAP carrier detector.
L+R REF.
Non connection.
Pilot signal detector.
Stereo PLL filter.
Power supply.
Non connection.
Input.
SIF REF.
STEREO REF.
SDA/SAP ID.
Ground.
PE.
SCL/STID.
AGC DET.
R-channel output.
L-channel output.
Non connection.
L-R REF.
5 22
LC-37D90U
2.4. VHiAK4683EQ-1Q (ASSY: IC1403)
Asynchronous Multi-Channel Audio CODEC with DIR/T.
Pin Name
PVDD
RX0
I2C
I/O
--I
I
RX1
RX2
RX3
INT
I
I
I
O
Pin Function
PLL Power supply, 4.5V~5.5V.
Receiver Channel 0 (Internal biased pin. Internally biased at PVDD/2).
Control Mode Select.
L : 4-wire Serial, H : I2C Bus.
Receiver Channel 1.
Receiver Channel 2.
Receiver Channel 3.
Interrupt.
5 23
LC-37D90U
Pin No.
8
DZF
Pin Name
I/O
O
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
CDTO
LRCKB
BICKB
SDTOB
OLRCKA
ILRCKA
BICKA
SDTOA
MCKO
TVDD
DVSS
DVDD
XTI
XTO
TX
O
I/O
I/O
O
I/O
I/O
I/O
O
O
------I
O
O
24
25
MCLK2
PDN
I
I
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
SDA
SCL
CSN
SDTIA1
SDTIA2
SDTIA3
SDTIB
HVDD
HVSS
HPR
HPL
MUTET
LOUT2
ROUT2
LOUT1
ROUT1
VCOM
AVDD2
AVSS2
LISEL
LOPIN
ROPIN
RISEL
AVSS1
AVDD1
LIN1
RIN1
LIN2
RIN2
LIN3
RIN3
LIN4
RIN4
LIN5
RIN5
LIN6
RIN6
PVSS
R
I/O
I
I
I
I
I
I
----O
O
--O
O
O
O
------O
O
O
O
----I
I
I
I
I
I
I
I
I
I
I
I
-----
Pin Function
Zero Input Detect.
When the input data of DAC follow total 8192 LRCK cycles with 0 input data, this pin goes to H. And
when RSTN1 bit is 0, PWDA bit is 0, this pin goes to H.
Control Data Output in Serial Mode and I2C pin= L.
Channel Clock B.
Audio Serial Data Clock B.
Audio Serial Data Output B.
Output Channel Clock A.
Input Channel Clock A.
Audio Serial Data Clock A.
Audio Serial Data Output A.
Master Clock Output.
Output Buffer Power Supply, 2.7V~5.5V.
Digital Ground.
Digital Power Supply, 4.5V~5.5V.
X'tal Input.
X'tal Output.
Transmit Channel Output.
When DIT bit= 0 , RX0~3 Through.
When DIT bit= 1 , Internal DIT Output.
Master Clock Input
Power-Down Mode & Reset.
When L, the AK4683 is powered-down, all registers are reset. And then all digital output pins go L.
The AK4683 must be reset once upon power-up.
Control Data in Serial Mode and I2C pin= H.
Control Data Clock in Serial Mode and I2C pin= H.
Chip Select in Serial Mode and I2C pin= L.
Audio Serial Data Input A1.
Audio Serial Data Input A2.
Audio Serial Data Input A3.
Audio Serial Data Input B.
HP Power Supply, 4.5V~5.5V.
HP Ground.
HP Rch Output.
HP Lch Output.
HP Common Voltage Output.
DAC2 Lch Positive Analog Output.
DAC2 Rch Positive Analog Output.
DAC1 Lch Positive Analog Output.
DAC1 Rch Positive Analog Output.
DAC/ADC Common Voltage Output.
DAC Power Supply, 4.5V~5.5V.
DAC Ground.
Lch Feedback Resistor Output.
Lch Feedback Resistor Input. 0.5 x AVDD1.
Rch Feedback Resistor Input. 0.5 x AVDD1.
Rch Feedback Resistor Output.
ADC Ground.
ADC Power Supply, 4.5V~5.5V.
Lch Input 1.
Rch Input 1.
Lch Input 2.
Rch Input 2.
Lch Input 3.
Rch Input 3.
Lch Input 4.
Rch Input 4.
Lch Input 5.
Rch Input 5.
Lch Input 6.
Rch Input 6.
PLL Ground.
External Resistor.
5 24
LC-37D90U
2.5. VHiNJU26111-1Q (ASSY: IC1406)
SOUND_DSP
Pin Name
SDO2
SDO1
SDO0
GPIO0
SCL/SCK
SDA/SDOUT
AD1/SDIN
AD2/SSb
VDDO
XI
XO
VSSO
RESETb
VDDC
VSSC
GPIO1
VDDC
VSSC
VDDR
VSSR
SDI0
SDI1
SDI2
LRI
BCKI
MCK
BCKO
LRO
I/O
O
O
O
I/O
I
I/O
I
I
--I
O
--I
----I/O
--------I
I
I
I
I
O
O
O
Pin Function
Audio Data Output CH2.
Audio Data Output CH1.
Audio Data Output CH0.
General Purpose IO.
I2C Clock / Serial Clock.
I2C I/O / Serial Output.
I2C Address / Serial Input.
I2C Address / Serial Enable.
OSC Power Supply+2.5V.
X'tal Clock Input.
OSC Output.
OSC GND.
RESET (active Low).
Core Power Supply+2.5V.
Core GND.
General Purpose IO.
Core Power Supply+2.5V.
Core GND.
I/O Power Supply+2.5V.
I/O GND.
Audio Data Input CH0.
Audio Data Input CH1.
Audio Data Input CH2.
LR Clock Input.
Bit Clock Input.
Master Clock Output.
Bit Clock Output.
LR Clock Output.
5 25
LC-37D90U
2.6. VHiTMDS341+-1Y (ASSY: IC1507)
3-TO-1 DVI/HDMI SWITCH
1, 20, 41, 60
42
19
3
64
46
38
2
63
45
39
21, 22, 23
7, 13, 17, 27, 33,
43, 50, 56, 61,
69, 75, 79
18
34, 31, 28, 25
35, 32, 29, 26
Pin name
A11, A12, A13, A14
A21, A22, A23, A24
A31, A32, A33, A34
B11, B12, B13, B14
B21, B22, B23, B24
B31, B32, B33, B34
GND
I/O
I
I
I
I
I
I
---
Pin Function
HPD1
HPD2
HPD3
HPD_SINK
O
O
O
I
NC
OE
PRE
--I
I
SCL1
SCL2
SCL3
SCL_SINK
SDA1
SDA2
SDA3
SDA_SINK
S1, S2, S3
VCC
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I
---
VSADJ
Y1, Y2, Y3, Y4
Z1, Z2, Z3, Z4
I
O
O
5 26
LC-37D90U
2.7. VHiSii9011L-1Q (ASSY: IC1508)
HDMI/DVI Receiver
Pin Name
I/O
Pin Function
QE23-0
QO23-0
DE
HSYNC
VSYNC
ODCK
O
O
O
O
Data enable.
Horizontal Sync.
Vertical Sync.
Output Data Clock.
XTALIN
XTALOUT
MCLK
SCK
WS
SD0
SD1
SD2
SD3
SPDIF
MUTE
I
O
I/O
O
O
O
O
O
O
O
O
INT
RESET#
O
I
Interrupt Output.
Reset Pin. Active LOW.
5 27
LC-37D90U
Pin No.
42
41
40
39
90
38
44
88
48
43
Differential Signal Data Pins
51
50
55
54
59
58
63
62
Power and Ground Pins
12, 24, 36, 45, 81, 112, 125
13, 25, 37, 80, 113, 126
7, 19, 31, 68, 77, 98, 107,
120
6, 18, 30, 69, 78, 97, 106,
118
49, 53, 57, 61
52, 56, 60, 64
47
46
82
83
66
65
86
87
Pin Name
DSCL
DSDA
CSCL
CSDA
SCDT
CI2CA
PWR5V
RSVDL
RSVD
NC
I/O
I
I/O
I
I/O
O
I
I
I
-----
Pin Function
DDC I2C Clock for DDC (5V-tolerant)3.
DDC I2C Data for DDC (5V-tolerant)3.
Configuration I2C Clock (5V-tolerant)3.
Configuration I2C Data (5V-tolerant)3.
Indicates active video at HDMI input port.
I2C Device Address Select.
TMDS Port Transmitter Detect. (5V-tolerant)3.
Reserved, must be tied LOW.
Reserved Pin, Leave unconnected.
No connect.
RXC+
RXCRX0+
RX0RX1+
RX1RX2+
RX2-
I
I
I
I
I
I
I
I
CVCC18
CGND
IOVCC
-------
IOGND
---
AVCC
AGND
PVCC
PGND
AUDPVCC18
AUDPGND
DVCC18
DGND
XTALVCC
REGVCC
---------------------
5 28
LC-37D90U
2.8. RH-iXB345WJZZQ (ASSY: IC2002)
Monitor microcomputer
Pin Name
OPC
CCKM
AVCC
X2
X1
VCL
RESET
TEST
VSS
OSC2
OSC1
VCC
NMI
F_MODE2
F_MODE3
F_MODE4
LVDS_PD1
LVDS_PD2
LED_ING
LED5(OPC)
LED4(YOYAKU)
LED3(OSHIRASE)
LED2(POWER_LED)
LED1(POWER_BLUE)
IREM
CSEN1
CSEN2
SR_UP
SCL_M
SDA_M
DDC_POW
POW_CHK2
POW_CHK1
POWDTC_M
STBY_SW
MAIN_SW
SCL2_M
SDA2_M
TXD_M
RXD_M
REQ
TVPOW4
LED_IND
LFB_ERR
CS_ERR
POW_ERR
L_FL_ERR
VSH_IN
FAN_ERR
VSS
PS_ON
TVPOW
FRAME
TMDS_RST
FAN_CONT
W_PROT_M
IC1_CONF
IC1_DONE
MODE1
I/O
I
I
--O
I
--I
----O
I
--I
I
I
I
O
O
O
O
O
O
O
O
I
I
I
I
O
I/O
I
----I
I
I
O
I/O
O
I
I
O
O
I
I
I
I
I
I
--O
O
I
O
O
O
O
I
I
Pin Function
Brightness sensor.
Cable check.
A/D conversion reference voltage (3.3V).
Oscillator (32.768kHz) connected.
Oscillator (32.768kHz) connected.
Internal step-down power terminal.
Reset signal input.
Not used (VSS pull-down).
GND.
Oscillator (10.00MHz) connected.
Oscillator (10.00MHz) connected.
3.3V power supply.
FLASH rewriting.
Terminal for emulator connection.
Terminal for emulator connection.
Terminal for emulator connection.
LVDS power control-1.
LVDS power control-2.
Automatic adjust line switching.
IC2 reset.
IC3 reset.
H sync presence/absence judge.
Monitor power red LED control.
Monitor power green LED control.
Remote control signal input.
AVC momentary power failure detection.
Start request notice from AVC.
AVC_BU5V line detection.
I2C clock Line (I2C ch0).
I2C data Line (I2C ch0).
DVI Connector check.
Not used (3.3V pull-up).
Not used (3.3V pull-up).
LCD PWB power monitoring.
Monitor standby switch input.
Main power switch input.
Control of I2C clock line (I2C ch1) at AVC side.
Control of I2C data line (I2C ch1) at AVC side.
Communication data output (MONI -> MAIN).
Communication data input (MAIN -> MONI).
Return request to main.
LCD TOP PWB 3.3V power control.
Not used.
Not used.
CS control power check terminal.
A_D3.3V line check terminal.
Backlight error detection.
VSH power error detection.
FAN Error detection.
GND.
AVC main regulator control signal.
Monitor main regulator control signal.
FRAME.
TMDS reset control.
FAN control.
Microprocessor EEPROM write protect control.
Gamma table read request.
Gamma tabled end detection.
Input signal state detection.
5 29
LC-37D90U
Pin No.
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
Pin Name
MODE2
PMUTE
DDCRST
TVPOW2
STB
PANEL_POW
VSH_OUT
MP_CLK
MP_DI
MP_DO
CPLD_OE
MP_CS
DAC_CS
PANEL_SW
AVSS
QSTEMP
KEY1
KEY2
KEY3
AREA1
AREA2
I/O
I
O
O
O
O
O
O
I
I
O
O
O
O
O
--I
I
I
I
I
I
Pin Function
Input signal state detection.
Video mute.
IC1 reset.
LCD TOP PWB 1.2V/2.5V power control.
Backlight control.
Panel power control signal.
Panel 3.3V control.
3-wire serial clock.
3-wire serial input.
3-wire serial output.
CPLD output permit control.
3-wire serial chip select.
3-wire serial chip select (only for MB88146).
Panel power control signal.
GND.
Monitor internal temperature check.
On-set key input 1.
On-set key input 2.
On-set key input 3.
Destination setting 1.
Destination setting 2.
5 30
LC-37D90U
2.9. RH-iXB723WJQZQ (ASSY: IC3301)
VIDEO_PROCESSER
I/O
I/O
I
I
I
I
I/O
I
I
AE1
XTALO
I/O
AD3
MLF1
I
AC3
PLF2
I
K1
RSET1
--J4
RSET2
--Ball Assignments for Analog Input Interface.
M4
CVBS1
I
N4
CVBS2
I
N3
CVBS3
I
N2
CVBS4
I
N1
CVBS5
I
P1
CVBS6
I
P2
CVBS7
I
P3
CVBS8
I
P4
CVBS9
I
R4
CVBS10
I
U3
Y_G1
I
U2
Y_G2
I/O
U1
Y_G3
I
V1
Y_G4
I
P5
CVBS_N
I
U4
Y_G_N
I
W4
AIN_N2
I
AA2
AIN_N3
I
K4
CVBS_OUT1
I
K3
CVBS_OUT2
I
K2
CVBS_OUT3
I
T1
C4
I
T2
C6
I
T3
C8
I
T4
C10
I
AA1
PB_B1
I
AB1
PB_B2
I
AB2
PB_B3
I
AB3
PB_B4
I
W3
PR_R1
I
W2
PR_R2
I
W1
PR_R3
I
Y1
PR_R4
I
H4, H3, H2
FS3, FS2, FS1
I
H1, J1
H1, J1
I
F1
F1
I
G1
G1
I
Ball Assignments for Capture Interface(TV & RGB).
AF2, AF1, AG1, AH1, AJ1, DP_B [29:20]
I
AK1, AK2, AJ2, AH2, AG2
Pin Function
Multiplexed address and data bus with CPU Host Interface.
CPU Address.
Address latch enables.
CPU Write.
CPU Read.
I2C data.
I2C clock.
Input for Clock Synthesizer. Supports 14.31818MHz Oscillator or crystal powered by
analog PLL.
Used in conjunction with XTALI for 14.31818 crystal output powered by analog PLL.
Low pass filter node for memory clock PLL powered by analog PLL.
Low pass filter node for video clock PLL powered by analog PLL.
Reference Voltage for ADC.
Reference Voltage for ADC.
Composite video input 1.
Composite video input 2.
Composite video input 3.
Composite video input 4 or Y input of S-Video 1.
Composite video input 5.
Composite video input 6 or Y input of S-Video 2.
Composite video input 7.
Composite video input 8 or Y input of S-Video 3.
Composite video input 9.
Composite video input 10 or Y input of S-Video 4.
Y input 1 of component or G input 1 of PC RGB.
Y input 2 of component or G input 2 of PC RGB.
Y input 3 of component or G input 3 of PC RGB.
Y input 4 of component or G input 4 of PC RGB.
Ground return for CVBS input.
Ground return for Y signal input.
Ground return for Component input Port 1.
Ground return for Component input Port 2.
CVBS Output 1.
CVBS Output 2.
CVBS Output 3.
C input of S-Video 1.
C input of S-Video 2.
C input of S-Video 3.
C input of S-Video 4.
PB input 1 of component or B input 1 of PC RGB.
PB input 1 of component or B input 2 of PC RGB.
PB input 1 of component or B input 3 of PC RGB.
PB input 1 of component or B input 4 of PC RGB.
PR input 1 of component or R input 1 of PC RGB.
PR input 1 of component or R input 2 of PC RGB.
PR input 1 of component or R input 3 of PC RGB.
PR input 1 of component or R input 4 of PC RGB.
SCART FS input for Port 1, Port 2, Port 3.
SCART FB input for Port 1, Port 2.
Hsync input (PC RGB input).
Vsync input (PC RGB input).
Digital input port B [29:20].
5 31
LC-37D90U
Pin No.
Pin Name
DP_B [19:10]
AG3, AH3, AJ3, AK3,
AH4, AG4, AG5, AH5,
AJ5, AK5
DP_B [9:0]
AK6, AJ6, AH6, AG6,
AG7, AH7, AJ7, AK7, AK8,
AJ8
AH9, AG9, AG10, AH10, DP_A [29:20]
AJ10, AK10, AG11, AJ11,
AK11, AK12
AJ12, AH12, AG12, AG13, DP_A [19:10]
AH13, AG14, AH14, AJ14,
AK14, AK15
AJ15, AG15, AK16, AJ16, DP_A [9:0]
AH16, AG16, AG17,
AH17, AJ17, AK17
AG19, AH19, AJ19, AK19, DP_C [9:0]
AK20, AJ20, AH20, AG20,
AG21, AH21
AG22, AG23, AH23, AJ23, DP_D [9:0]
AK23, AH24, AG24,
AG25, AH25, AG26
AH26
CLK_D
AK21
CLK_C
AK4
CLK_B
AK13
CLK_A
AK9
DE_B
AH18
DE_A
AH8
HS_B
AK18
HS_A
AG8
VS_B
AJ18
VS_A
AG18
FLD_A
AJ9
FLD_B
AK22
HS
AJ22
VS
Ball Assignments for Frame Buffer Memory.
B14, A14, C15, B15, C16, MD [63:0]
D16, D17, C17, B17, A17,
C18, B18, C19, D19, D20,
C20, B20, A20, C21, B21,
C22, D22, D23, C23, B23,
A23, C24, B24, C25, D25,
D26, C26, K29, K30, L28,
L29, M28, M27, N27, N28,
N29, N30, P28, P29, R28,
R27, T27, T28, T29, T30,
U28, U29, V28, V27, W27,
W28, W29, W30, Y28,
Y29, AA28, AA27, AB27,
AB28
MA [11-0]
K28, K27, J27, J28, J30,
H30, H29, H28, G28, G29,
G30, F30
A28
RAS#
A27
CAS#
B27
WE#
B28
CS1#
C28
CS0#
F29
MCK0
B29
MCK1
E30
MCK0#
A29
MCK1#
A16, A19, A22, A25, M30, DQM [7:0]
R30, V30, AA30
C27
CLKE
A15, A18, A21, A24, L30, DQS [7:0]
P30, U30, Y30
I/O
I
Pin Function
Digital input port B [19:10].
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I
I/O
I
I/O
I
I/O
I
I/O
I/O
I
I/O
I/O
I/O
Memory data.
I/O
Memory Address.
O
O
O
O
O
O
O
O
O
O
O
I/O
5 32
LC-37D90U
Pin No.
Pin Name
B30
MVREF
A26
BA0
B26
BA1
Ball Assignments for Power and Ground.
VDDC
A2, A3, A4, A5, B3, B4,
B5, B6, C4, C5, C6, D4,
D5, D6, E4, E5, E6, E7,
E8, E11,E12, E13, E18,
E19, E20, E21, F4, F5,
G4, G5, H5, J26, K26,
L26, M26, W26, Y26,
AA26, AC5, AD5, AE5,
AF5, AF6, AF7, AF8, AF9,
AF10, AF11, AF20, AF21,
AF22, AF23
C29, D21, V26
VSSR
A30, E22, U26
VDDR
C30, D28, D29, D30, E14, VDDM
E15, E16, E17, E23, E24,
E25, E26, E27, E28, E29,
F26, F27, F28, G26, G27,
H26, N26, P26, R26, T26,
AB26, AC26, AD26, AE26
AF12, AF13, AF14, AF15, VDDH
AF16, AF17, AF18, AF19,
AF24, AF25
E9, E10, J5, K5
VDDH_CPU
B7
V5SF
B16, B19, B22, B25, C14, VSS
D15, D18, D24, D27, H27,
J29, L5, L27, M5, M12,
M13, M14, M15, M16,
M17, M18, M19, M29, N5,
N12, N13, N14, N15, N16,
N17, N18, N19, P12, P13,
P14, P15, P16, P17, P18,
P19, P27, R5, R12, R13,
R14, R15, R16, R17, R18,
R19, R29, T12, T13, T14,
T15, T16, T17, T18, T19,
U5, U12, U13, U14, U15,
U16, U17, U18, U19, U27,
V12, V13, V14, V15, V16,
V17, V18, V19, V29, W5,
W12, W13, W14, W15,
W16, W17, W18, W19, Y5,
Y27, AA5, AA29, AB5,
AC27, AC28, AF4, AF26,
AH11, AH15, AH22, AJ4,
AJ13, AJ21
AB4
DVSS
AC1
DVDD
J3
AVSS_BG_ASS
J2
AVDD3_BG_ASS
AD4
PAVDD1
AE2
PAVSS
AD2
PAVSS1
AC4
PAVSS2
AE3
PAVDD
AC2
PAVDD2
AF3
PDVDD
AE4
PDVSS
G2, R1, Y2, V2, L1
AVDD_ADC [56, 4,
3, 2, 1]
G3, T5, AA4, V5, L2
AVSS_ADC [56, 4,
3, 2, 1]
AA3, M3
AVDD3_ADC [2, 1]
L3
AVDD3_OUTBUF
I/O
--O
O
Pin Function
---
-------
Digital Ground.
Digital power for Memory.
---
-------
---------------------------
---
-----
5 33
LC-37D90U
Pin No.
Pin Name
L4
AVSS_OUTBUF
AD27, AG27
LVDS_VSSO
AE24
LVDS_VSSD
AF27
LVDS_VSSA
AH27
LVDS_VSSP
AH28
LVDS_VDDP
AF28
LVDS_VDDA
AE28
LVDS_VDDD
AD28, AG28
LVDS_VDDO
Ball Assignments for Reference Voltage.
M1
VREFP_1
M2
VREFN_1
V3
VREFP_2
V4
VREFN_2
Y3
VREFP_3
Y4
VREFN_3
R3
VREFP_4
R2
VREFN_4
Miscellaneous Ball Assignments.
A6
RESET
I/O
-------------------
-----------------
A7
INTN
C7
PWM0
D7
PWM1
C8
TESTMODE0
D8
TESTMODE1
A1, B2
GPIO 0, GPIO 1
F2, F3, E3, E2, E1, D1,
AUDIO_P [11:0]
D2, D3, C3, C2, C1, B1
B13
MCU_CS
C13
MCU_CSN
LVDS Output Ball Assignments.
AK27
TCLK2M
AJ27
TCLK2P
AK25
TE2M
AJ25
TE2P
AK26
TD2M
AJ26
TD2P
AK28
TC2M
AJ28
TC2P
AB29
TA1P
AB30
TA1M
AC29
TB1P
AC30
TB1M
AD29
TC1P
AD30
TC1M
AF29
TD1P
AF30
TD1M
AG29
TE1P
AG30
TE1M
AE30
TCLK1M
AE29
TCLK1P
AK30
TA2M
AJ30
TA2P
AK29
TB2M
AJ29
TB2P
AH29
TF1P
AH30
TF1M
AJ24
TF2P
AK24
TF2M
I/O
I/O
I/O
I
I
I/O
I/O
Pin Function
System reset powered by VDDH/VSS. RESET# forces the chip to a known state. This
pin should be tied to CPU reset.
Interrupt signal (active low) powered by VDDH/VSS.
General purpose I/O.
General purpose I/O.
Reserved (Connected to ground).
Reserved (Connected to ground).
Programmable general purpose I/O.
Audio Data Input/Output.
I
I
Initial LX setting for choosing I2C address & CPU bus Configuration.
Initial LX setting for choosing I2C address & CPU bus Configuration.
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
5 34
LC-37D90U
2.10. RH-iXB375WJZZQ (ASSY: IC3501, 3502)
128Mbit GDDR SDRAM
Pin Name
CK, CK*1
I/O
I
12N
CKE
2N
CS
2M
RAS
2L
CAS
3L
WE
DQS0 DQS3
DM0 - DM3
I/O
I
Pin Function
The differential system clock Input.
All of the inputs are sampled on the rising edge of the clock except DQs and DMs that are sampled on
both edges of the DQS.
Activates the CK signal when high and deactivates the CK signal when low.
By deactivating the clock, CKE low indicates the Power down mode or Self refresh mode.
CS enables the command decoder when low and disabled the command decoder when high.
When the command decoder is disabled,new commands are ignored but previous operations continue.
Latches row addresses on the positive going edge of the CK with RAS low.
Enables row access & precharge.
Latches column addresses on the positive going edge of the CK with CAS low.
Enables column access.
Enables write operation and row precharge.
Latches data in starting from CAS, WE active.
Data input and output are synchronized with both edge of DQS.
DQS0 for DQ0 - DQ7, DQS1 for DQ8 - DQ15, DQS2 for DQ16 - DQ23,DQS3 for DQ24 - DQ31.
Data In mask.
Data In is masked by DM Latency=0 when DM is high in burst write.
DM0 for DQ0 - DQ7, DM1 for DQ8 - DQ15, DM2 for DQ16 - DQ23, DM3 for DQ24 - DQ31.
5 35
LC-37D90U
Pin No.
7B, 6C, 6B,
5B, 2C, 3D,
2D, 2E, 13K,
12K, 13J,
12J, 13G,
12G, 13F,
12F, 3F, 2F,
3G, 2G, 3J,
2J, 3K, 2K,
13E, 13D,
12D, 13C,
10B, 9B, 9C,
8B
4N, 5M
5N, 6N, 6M,
7N, 8N, 9M,
9N, 10N, 11N,
8M, 6L, 7M
4E, 4L, 7D,
7L, 8D, 8L,
11E, 11L, 5E,
5L, 6F, 6G,
6H, 6J, 6K,
7E, 7F, 7G,
7H, 7J, 7K,
8E, 8F, 8G,
8H, 8J, 8K,
9F, 9G, 9J,
9K, 10E, 10L
3C, 3E, 4F,
4G, 4J, 4K,
5C, 7C, 8C,
10C, 11F,
11G, 11J,
11K, 12C,
12E, 4B, 4D,
5D, 5F, 5G,
5H, 5J, 5K,
6D, 6E, 9D,
9E, 10F, 10G,
10H, 10J,
10K, 11B,
11D
13N
3M, 3N, 4C,
4H, 4M, 11C,
11H, 12L,
13L, 9L, 10L
13M
Pin Name
DQ0 - DQ31
I/O
I/O
Pin Function
Data inputs/Outputs are multiplexed on the same pins.
BA0, BA1
A0 - A11
I
I
VDD/VSS
---
Power and ground for the input buffers and core logic.
VDDQ/VSSQ
---
Isolated power supply and ground for the output buffers to provide improved noise immunity.
VREF
NC/RFU
-----
MCL
---
*1 : The timing reference point for the differential clocking is the cross point of CK and CK.
For any applications using the single ended clocking, apply VREF to CK pin.
5 36
LC-37D90U
2.11. RH-iXB281WJ (ASSY: IC8101)
MPEG2 System Decoder LSI
Pin Name
SDAD12
SDAD11
SDAD10
SDAD9
SDAD8
SDAD7
SDAD6
SDAD5
SDAD4
SDAD3
SDAD2
SDAD1
SDAD0
I/O
O
O
O
O
O
O
O
O
O
O
O
O
O
Pin Function
SDRAM address bus.
5 37
LC-37D90U
Pin No.
AJ2
AH4
AH3
AG4
AG3
AF4
AF3
AE4
AH1
AG2
AG1
AF2
AF1
AE3
AE2
AE1
V4
W3
W4
W2
W1
Y2
Y1
AA1
AA2
AA3
AA4
AB1
AB2
AB3
AC1
AC2
N2
N3
M3
M4
N1
M1
M2
L1
L2
K1
K2
J1
J2
H1
H2
G1
B1
C2
C1
D1
D3
D2
E4
E3
E2
E1
F2
F1
F3
G3
G2
H4
Pin Name
SDMD63
SDMD62
SDMD61
SDMD60
SDMD59
SDMD58
SDMD57
SDMD56
SDMD55
SDMD54
SDMD53
SDMD52
SDMD51
SDMD50
SDMD49
SDMD48
SDMD47
SDMD46
SDMD45
SDMD44
SDMD43
SDMD42
SDMD41
SDMD40
SDMD39
SDMD38
SDMD37
SDMD36
SDMD35
SDMD34
SDMD33
SDMD32
SDMD31
SDMD30
SDMD29
SDMD28
SDMD27
SDMD26
SDMD25
SDMD24
SDMD23
SDMD22
SDMD21
SDMD20
SDMD19
SDMD18
SDMD17
SDMD16
SDMD15
SDMD14
SDMD13
SDMD12
SDMD11
SDMD10
SDMD9
SDMD8
SDMD7
SDMD6
SDMD5
SDMD4
SDMD3
SDMD2
SDMD1
SDMD0
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
Pin Function
SDRAM address bus.
Dual Data Rate.
5 38
LC-37D90U
Pin No.
AD3
J3
AC4
K4
V1
AD4
K3
U2
U1
V2
AH2
AD2
Y4
AC3
N4
L4
G4
J4
T2
T1
AJ1
AD1
Y3
AB4
P4
L3
F4
H3
A32
B33
B32
B31
C30
C31
C32
C33
D33
D32
D31
D30
E29
E30
E31
E32
E33
F33
F32
F31
F30
F29
G30
G31
G32
Pin Name
SDCLK1
SDCLK0
SDBCLK1
SDBCLK0
SDCKE
SDCS1_N
SDCS0_N
SDRAS_N
SDCAS_N
SDWE_N
SDDM7
SDDM6
SDDM5
SDDM4
SDDM3
SDDM2
SDDM1
SDDM0
SDBA1
SDBA0
SDDQS7
SDDQS6
SDDQS5
SDDQS4
SDDQS3
SDDQS2
SDDQS1
SDDQS0
SBADD25
SBADD24
SBADD23
SBADD22
SBADD21
SBADD20
SBADD19
SBADD18
SBADD17
SBADD16
SBADD15
SBADD14
SBADD13
SBADD12
SBADD11
SBADD10
SBADD9
SBADD8
SBADD7
SBADD6
SBADD5
SBADD4
SBADD3
SBADD2
SBADD1
I/O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
Pin Function
SDRAM clock1.
SDRAM clock0.
SDRAM clock1 for DDR.
SDRAM clock0 for DDR.
SDRAM clock enable.
SDRAM chip select1.
SDRAM chip select0.
SDRAM row address strobe.
SDRAM column address strobe.
SDRAM write enable.
SDRAM I/O mask7.
SDRAM I/O mask6.
SDRAM I/O mask5.
SDRAM I/O mask4.
SDRAM I/O mask3.
SDRAM I/O mask2.
SDRAM I/O mask1.
SDRAM I/O mask0.
SDRAM bank address select1.
SDRAM bank address select0.
SDRAM data strobe7 for DDR.
SDRAM data strobe6 for DDR.
SDRAM data strobe5 for DDR.
SDRAM data strobe4 for DDR.
SDRAM data strobe3 for DDR.
SDRAM data strobe2 for DDR.
SDRAM data strobe1 for DDR.
SDRAM data strobe0 for DDR.
Address.
5 39
LC-37D90U
Pin No.
G33
H33
H32
H31
H30
J30
J31
J32
J33
K33
K32
K31
K30
L30
L31
L32
A31
L33
M33
M32
M31
M30
N30
N31
N32
N33
P32
P33
R30
P30
P31
B30
A30
A29
B29
C29
D29
E28
D28
C28
B28
A28
A27
B27
C27
D27
D26
C26
B26
A26
A25
B25
C25
D24
C24
B24
A24
A23
B23
C23
D22
C22
B22
Pin Name
SBDAT15
SBDAT14
SBDAT13
SBDAT12
SBDAT11
SBDAT10
SBDAT9
SBDAT8
SBDAT7
SBDAT6
SBDAT5
SBDAT4
SBDAT3
SBDAT2
SBDAT1
SBDAT0
SBWE_N
SBOE_M
SBCE7_N
SBCE6_N
SBCE5_N
SBCE4_N
SBCE3_N
SBCE2_N
SBCE1_N
SBCE0_N
SBBE1_N
SBBE0_N
SBACK_N
SBCLK0
SBCLK1
PCIAD31
PCIAD30
PCIAD29
PCIAD28
PCIAD27
PCIAD26
PCIAD25
PCIAD24
PCIAD23
PCIAD22
PCIAD21
PCIAD20
PCIAD19
PCIAD18
PCIAD17
PCIAD16
PCIAD15
PCIAD14
PCIAD13
PCIAD12
PCIAD11
PCIAD10
PCIAD9
PCIAD8
PCIAD7
PCIAD6
PCIAD5
PCIAD4
PCIAD3
PCIAD2
PCIAD1
PCIAD0
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
Pin Function
Data.
5 40
LC-37D90U
Pin No.
A22
A21
B21
C21
C20
B20
A20
A19
B19
C19
B18
A18
A17
D20
C18
B17
C17
D17
A15
A16
B16
C16
A14
B14
B15
C15
AN8
AN9
AM9
AL9
AK9
AK10
W31
AN3
AM3
AL4
AK5
AJ6
AN4
AM4
AL5
AK6
Pin Name
CBE3_N
CBE2_N
CBE1_N
CBE0_N
PAR
FRAME_N
IRDY_N
TRDY_N
DEVSEL_N
STOP_N
IDSEL
LOCK_N
PME_N
PCICLKI
PCICLKO
RST_N
PERR_N
SERR_N
REQ3_N
REQ2_N
REQ1_N
REQ0_N
GNT3_N
GNT2_N
GNT1_N
GNT0_N
IRQ5
IRQ4
IRQ3
IRQ2
IRQ1
IRQ0
NMI_N
UARXD0
UARTS0_N
UATXD0
UACTS0_N
UA0EXCLK
SC0RST
SC0DET_N
SC0VPPEN_N
SC0CLK
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I
I
I/O
I
O
I
I/O
I/O
I
I
I
I
I/O
I/O
I/O
I/O
I
I
I
I
I
I
I
I
O
O
I
I
O
I
O
O
AM5
SC0VCCEN_N
AN5
SC0C7IO
I/O
AN6
SC1RST
AM6
SC1DET_N
AL7
SC1VPPEN_N
AK7
SC1CLK
AM7
AL6
SC1VCCEN_N
SC1C7IO
O
I/O
AM1
ACLRST_N
Pin Function
Bus Command Byte enable. (Not used: Pull-Down)
External Interrupt.
5 41
LC-37D90U
Pin No.
AL1
Pin Name
ACLSYC
I/O
O
AK2
ACLSDI
AL2
ACLSDO
AK3
ACLBCLK
AH5
TM0EXCLK
AJ4
TMOUT0
AJ5
TM1EXCLK
AK4
TMOUT1
AL3
TM2EXCLK
AM2
TMCAP0
AN2
TMCAP1
AN10
AM10
AL10
AK11
AL11
AM11
AN11
AN12
AM12
AL12
AK12
AK13
AL13
AM13
AN13
AN14
AM14
AL14
AK14
AK15
AL15
AN7
AL8
AM8
AK8
C3
E5
D4
B2
A2
A8
B8
C8
D8
D9
C9
B9
A9
C10
B10
D10
D11
PIO20
PIO19
PIO18
PIO17
PIO16
PIO15
PIO14
PIO13
PIO12
PIO11
PIO10
PIO9
PIO8
PIO7
PIO6
PIO5
PIO4
PIO3
PIO2
PIO1
PIO0
I2CDATA0
I2CCLK0
I2CDATA1
I2CCLK1
USBCLK48M
USBDPLS
USBDMNS
USBOVCRNT
USBPRTPOR
TS0DATA7
TS0DATA6
TS0DATA5
TS0DATA4
TS0DATA3
TS0DATA2
TS0DATA1
TS0DATA0
TS0VALID
TS0SYNC
TS0ERROR
TS0CLK
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I
I/O
I/O
I
O
I
I
I
I
I
I
I
I
I
I
I
I
Pin Function
Pin condition control.
Shared with UACTS3_N.
Serial data input.
Shared with UARXD3.
Serial data output.
Shared with UATXD3.
Bit clock.
Shared with UA3EXCLK.
Timer0 clock.
Shared with and PIO26.
Timer0 output.
Shared with and PIO27.
Timer1 clock.
Shared with and PIO28.
Timer1 output.
Shared with and PIO29.
Timer2 clock.
For watch dog timer.
Shared with and PIO30.
Capture Timer0.
Shared with and PIO31.
Capture Timer1.
Shared with and PIO32.
21bits Parallel I/O.
5 42
LC-37D90U
Pin No.
A5
B5
C5
E6
D6
C6
B6
A6
C7
B7
A7
D7
B3
C4
B4
A3
D5
A10
A4
D13
C13
B13
A13
A12
B12
C12
D12
D14
C14
C11
B11
A11
R33
R32
R31
T31
T32
T30
T33
U33
V31
V32
U30
V30
V33
U32
U31
AJ28
AH29
AJ29
AK29
AL29
AM29
AN29
AN30
AM30
AL30
AK30
AJ30
AK31
AL31
AM31
AN31
AN32
Pin Name
TS1DATA7
TS1DATA6
TS1DATA5
TS1DATA4
TS1DATA3
TS1DATA2
TS1DATA1
TS1DATA0
TS1VALID
TS1SYNC
TS1ERROR
TS1CLK
TS2DATA
TS2VALID
TS2SYNC
TS2ERROR
TS2CLK
TSREQ0
TSREQ1
TSOUTDATA7
TSOUTDATA6
TSOUTDATA5
TSOUTDATA4
TSOUTDATA3
TSOUTDATA2
TSOUTDATA1
TSOUTDATA0
TSOUTCLKI
TSOUTCLKO
TSOUTVALID
TSOUTCGMS
TSOUTSYNC
ASDO4
ASDO3
ASDO2
ASDO1
ASDO0
AMCLK
ALRCKO
ABCKO
ASDI1
ASDI0
ALRCKI
ABCKI
CMPREQ_N
CMPDAT
CMPCLK
VIDINCLK
VIDINH
VIDINV
VIDINDATA7
VIDINDATA6
VIDINDATA5
VIDINDATA4
VIDINDATA3
VIDINDATA2
VIDINDATA1
VIDINDATA0
VIDINCBCR7
VIDINCBCR6
VIDINCBCR5
VIDINCBCR4
VIDINCBCR3
VIDINCBCR2
I/O
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
O
O
O
O
O
O
O
O
O
O
I
O
O
O
O
O
O
O
O
O
I
O
O
I
I
I
I
I
O
O
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
Pin Function
Transport stream port1 data input (Parallel).
5 43
LC-37D90U
Pin No.
AM32
AM33
AL23
AK24
AK23
AK22
AL22
AM22
AN22
AN21
AM21
AL21
AK21
AK20
AL20
AM20
AN20
AN19
AM19
AL19
AK19
AK18
AL18
AM18
AN18
AN17
AM17
AL17
AK17
AK16
AL16
AM16
AN16
AN15
AM15
AM23
AN23
AN24
AM24
AL24
AK25
AL25
AN26
AM25
AN25
AK26
AE31
AF31
AG31
AA31
AB31
AC31
AE32
AF32
AG32
AA32
AB32
AC32
AL28
AM28
AK28
AN27
AN28
D16
Pin Name
VIDINCBCR1
VIDINCBCR0
HDOUT
VDOUT
DOUTCLK
DOUTY9
DOUTY8
DOUTY7
DOUTY6
DOUTY5
DOUTY4
DOUTY3
DOUTY2
DOUTY1
DOUTY0
DOUTPB9
DOUTPB8
DOUTPB7
DOUTPB6
DOUTPB5
DOUTPR4
DOUTPR3
DOUTPB2
DOUTPB1
DOUTPB0
DOUTPR9
DOUTPR8
DOUTPR7
DOUTPR6
DOUTPR5
DOUTPR4
DOUTPR3
DOUTPR2
DOUTPR1
DOUTPR0
FLPH
HBLANK
VBLANK
BGATE
YS
DCLKI74M
DCLKI54M
DCLKICAP
PWM74M
PWM54M
VCRCLKO
YOUT
PBOUT
PROUT
VCRYOUT
VCRCOUT
VCRCVOUT
YNEG
PBENG
PRNEG
VCRYNEG
VCRCNEG
VCRCVNEG
HSYNC
VSYNC
FASTBLK
CSYNC1
CSYNC0
CLKX12
I/O
I
I
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
I
I
I
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
I
Pin Function
External video data CB/CR input1. Shared with DBUGTPC1.
External video data CB/CR input0.
Horizontal sync output.
Vertical sync output.
Display clock output.
Video Y output9 or Video G output9. Shared with PIO30.
Video Y output8 or Video G output8. Shared with PIO29.
Video Y output7 or Video G output7. Shared with PIO28.
Video Y output6 or Video G output6. Shared with PIO27.
Video Y output5 or Video G output5. Shared with PIO26.
Video Y output4 or Video G output4. Shared with PIO25.
Video Y output3 or Video G output3. Shared with PIO24.
Video Y output2 or Video G output2. Shared with PIO23.
Video Y output1 or Video G output1. Shared with PIO22.
Video Y output0 or Video G output0. Shared with PIO21.
Video PB output9 or Video B output9. Shared with PIO32.
Video PB output8 or Video B output8. Shared with DBUGPCST8.
Video PB output7 or Video B output7. Shared with DBUGPCST7.
Video PB output6 or Video B output6. Shared with DBUGPCST6.
Video PB output5 or Video B output5. Shared with DBUGPCST5.
Video PB output4 or Video B output4. Shared with DBUGPCST4.
Video PB output3 or Video B output3. Shared with DBUGPCST3.
Video PB output2 or Video B output2. Shared with DBUGPCST2.
Video PB output1 or Video B output1. Shared with DBUGPCST1.
Video PB output0 or Video B output0. Shared with DBUGPCST0.
Video PR output9 or Video R output9. Shared with PIO31 and VCRDOUT7.
Video PR output8 or Video R output8. Shared with DBUGTCK and VCRDOUT6.
Video PR output7 or Video R output7. Shared with DBUGDCLK and VCRDOUT5.
Video PR output6 or Video R output6. Shared with DBUGTDO and VCRDOUT4.
Video PR output5 or Video R output5. Shared with DBUGTDI and VCRDOUT3.
Video PR output4 or Video R output4. Shared with DBUGTMS and VCRDOUT2.
Video PR output3 or Video R output3. Shared with DBUGTRST_N and VCRDOUT1.
Video PR output2 or Video R output2. Shared with DBUGTPC3 and VCRDOUT0.
Video PR output1 or Video R output1. Shared with DBUGTPC2.
Video PR output0 or Video R output0. Shared with DBUGTPC1.
Frame field.
Horizontal blanking signal.
Vertical blanking signal.
Black level ID zone specifying signal.
Video Graphic ID signal.
74MHz clock input for HD.
54MHz clock input for SD.
Clock input for capture 74M/54M.
PWM for 74MHz clock.
PWM for 54MHz clock.
Clock output for VCR standard digital video output.
YOUT for playback.
PBOUT for playback.
PROUT for playback.
VOUT for recording.
COUT for recording.
CVBS OUTPUT for recording.
YOUT inversed signal for playback should be connect pull-down resister.
PBOUT inversed signal for playback should be connect pull-down resister.
PROUT inversed signal for playback should be connect pull-down resister.
YOUT inversed signal for recording should be connect pull-down resister.
COUT inversed signal for recording should be connect pull-down resister.
CVBS OUT inversed signal for recording should be connect pull-down resister.
Horizontal sync.
Vertical sync.
Fast Blanking signal.
Composite sync1.
Composite sync0.
PLL for Micro processor.
5 44
LC-37D90U
Pin No.
D15
AH30
AK32
AJ31
AL32
AL33
AK33
AF33
AB33
AG33
AC33
AE33
AA33
AM27
AL27
W33
W32
W30
AM26
AL26
AK27
AD30
AE30
AF30
AA30
AB30
AC30
AF29
AC29
AD29
AA29
AE29
AB29
A1, A33, AB28,
AD31, AD32, AD33,
AE28, AG30, AH31,
AH32, AH33, AJ32,
AJ33, AN1, AN33,
Y30, Y31, Y32, Y33
AJ3
AA5, AB6, AE5,
AF5, AF6, H5, J5,
J6, K5, N6, P5, U6,
V6
AA28, AC5, AD6,
AF28, AH13, AH17,
AH18, AH22, AH26,
AH9, AJ10, AJ14,
AJ21, AJ25, E10,
E14, E21, E25,
F13, F17, F18, F22,
F26, F9, G6, J28,
K29, L6, M5, N28,
P29, R6, T5, U28,
V29, W5, Y6
AH11, AH15, AH20,
AH24, AH28, AH6,
AH8, AJ12, AJ16,
AJ19, AJ23, AJ27,
AJ9, E12, E16,
E18, E19, E22,
E23, E26, E9, F11,
F15, F20, F24, F27,
F8, G28, H29, L28,
M29, R28, T29,
W28, Y29
Pin Name
CLKX8
JTAGTCK
JTAGTDO
JTAGTDI
JTAGTMS
JTAGTRST_N
JTAGGDBGSEL
VBS_HD
VBS_VCR
VREF_HD
VREF_VCR
FSADJ_HD
FSADJ_VCR
STC0PWM
STC1PWM
RESET_N
COLDRST_N
ENDIAN
STCCLKO
STC0CLKI
STC1CLKI
APVD_HD1
APVD_HD2
APVD_HD3
APVD_VCR1
APVD_VCR2
APVD_VCR3
APVS_HD
APVS_VCR
DPVD_HD
DPVD_VCR
DPVS_HD
DPVS_VCR
NC
I/O
I
I
O
I
I
I
I
------------O
O
I
I
I
O
I
I
---------------------------
Pin Function
SDVREF
VDD2
-----
VDDC
---
VDDS
---
5 45
LC-37D90U
Pin No.
E8, AA6, AC6, AE6,
AG28, AG29, AG5,
AG6, AH10, AH12,
AH14, AH16, AH19,
AH21, AH23, AH25,
AH27, AH7, AJ8,
E20, E24, E27,
F10, F12, F14, F16,
F19, F21, F23, F25,
F28, F5, F6, F7,
G29, H28, H6, K28,
K6, M28, M6, P28,
P6, T28, T6, V28,
W6, Y28
AB5, AC28, AD28,
AD5, AJ11, AJ13,
AJ15, AJ17, AJ18,
AJ20, AJ22, AJ24,
AJ26, AJ7, D18,
D19, D21, D23,
D25, E11, E13,
E15, E17, E7, G5,
J29, L29, L5, N29,
N5, R29, R5, U29,
U5, V5, W29, Y5
Pin Name
VSS1
I/O
---
Pin Function
VSS2
---
5 46
LC-37D90U
2.12. RH-iXB024WJZZQ (ASSY: IC8301-4)
256Mb F-die DDR SDRAM
Pin Name
CK, CK
I/O
I
44
CKE
24
CS
23, 22,
21
20, 47
RAS, CAS, WE
L(U)DM
26, 27
BA0, BA1
29, 30,
31, 32,
35, 36,
37, 38,
39, 40,
28, 41,
42
A [0 : 12]
Pin Function
Clock : CK and CK are differential clock inputs. All address and control input signals are sampled on the
positive edge of CK and negative edge of CK. Output (read) data is referenced to both edges of CK.
Internal clock signals are derived from CK/CK.
Clock Enable : CKE HIGH activates, and CKE LOW deactivates internal clock signals, and device input
buffers and output drivers. Deactivating the clock provides PRECHARGE POWER-DOWN and SELF
REFRESH operation (all banks idle), or ACTIVE POWER-DOWN (row ACTIVE in any bank). CKE is
synchronous for all functions except for disabling outputs, which is achieved asynchronously. Input buffers, excluding CK, CK and CKE are disabled during power-down and self refresh modes, providing low
standby power. CKE will recognize an LVCMOS LOW level prior to VREF being stable on power-up.
Chip Select : CS enables (registered LOW) and disables(registered HIGH) the command decoder. All
commands are masked when CS is registered HIGH. CS provides for external bank selection on systems with multiple banks. CS is considered part of the command code.
Command Inputs : RAS, CAS and WE (along with CS) define the command being entered.
Input Data Mask : DM is an input mask signal for write data. Input data is masked when DM is sampled
HIGH along with that input data during a WRITE access. DM is sampled on both edges of DQS.
Although DM pins are input only, the DM loading matches the DQ and DQS loading. LDM corresponds
to the data on DQ0~D7 ; UDM corresponds to the data on DQ8~DQ15. DM may be driven high, low, or
floating during READs.
Bank Addres Inputs : BA0 and BA1 define to which bank an ACTIVE, READ, WRITE or PRECHARGE
command is being applied.
Address Inputs : Provide the row address for ACTIVE commands, and the column address and AUTO
PRECHARGE bit for READ/WRITE commands, to select one location out of the memory array in the
respective bank. A10 is sampled during a PRECHARGE command to determine whether the PRECHARGE applies to one bank (A10 LOW) or all banks (A10 HIGH). If only one bank is to be precharged, the bank is selected by BA0, BA1. The address inputs also provide the op-code during a
MODE REGISTER SET command. BA0 and BA1 define which mode register is loaded during the
MODE REGISTER SET command (MRS or EMRS).
5 47
LC-37D90U
Pin No.
2, 4, 5, 7,
8, 10, 11,
13, 54,
56, 57,
59, 60,
62, 63,
65
16, 51
14, 17,
19, 25,
43, 50,
53
3, 9, 15,
55, 61
6, 12, 52,
58, 64
1, 18, 33
34, 48,
66
49
Pin Name
DQ [0 : 15]
I/O
I/O
Pin Function
L(U)DQS
I/O
NC
---
Data Strobe : Output with read data, input with write data. Edge-aligned with read data, centered in write
data. Used to capture write data. LDQS corresponds to the data on DQ0~D7 ; UDQS corresponds to
the data on DQ8~DQ15.
No Connect : No internal electrical connection is present.
VDDQ
---
VSSQ
---
DQ Ground.
VDD
VSS
-----
VREF
5 48
LC-37D90U
2.13. VHiS29GL64A-1Q (ASSY: IC8451)
64-Mbit Page Mode Flash Memory
Pin Name
A21-A0
I/O
I
22 Address inputs.
Pin Function
DQ14-DQ0
I/O
15 Data inputs/outputs.
DQ15
CE#
OE#
WE#
WP#/ACC
RESET#
RY/BY#
BYTE#
Vcc
Vss
I/O
I
I
I
I
I
O
I
-----
5 49
LC-37D90U
2.14. RH-iXB323WJZZQ (ASSY: IC8503)
IEEE 1394a Link-Layer Controllers
I/O
I
K10
REF_SYT
J11
DIV_VCO
Pin Function
Input from VCO. This is used to generate internal audio clocks for receive clock recovery.
Audio frequency: 24.576MHz.
Output for external phase detector. This signal represents the SYT match for received audio packets. The phase detector uses it as an input to detect differences between the SYT match and the
VCO clock.
Output for external phase detector. This signal is the divided VCO_CLK. It is used by the external
phase detector to compare with the REF_SYT signal. The divide ratios are set up in CFR.
Audio Interface
Note: When DAC I/F is not used, DAC_* can be directly tied to GND as long as AudCfg. Enable is set to 0.
When AudCfg. Enable to 1, DAC_* outputs are enabled.
B13
DAC_MCK
O
Audio master clock.
D12
DAC_BCK
I/O
Audio DAC Interface Bit clock.
The audio DAC interface can be used with any also path. However, only one audio stream can be
transmitted or received at one time using either the DAC interface or the 60958 interface.
D11
DAC_LRCK
I/O
Audio DAC Interface Left-Right Clock.
D13
DAC_DATA
I/O
Audio DAC Interface Data. Contains Channel 1 and Channel 2 information.
DAC_LRCK determines which channel is present.
G12
60958_IN
I
60958 Bi-phase encoded data input.
H10
60958_OUT
O
60958 Bi-phase encoded data output.
A12
AUDIO_ERR
O
Audio Error Signal. The RH-IXB323WJZZQ assert this signal whenever an audio error condition
occurs. (Receive from 1394 only.)
B14
AUDIO_MUTE
O
Audio Mute Signal. The RH-IXB323WJZZQ assert this signal whenever an audio error condition
occurs. (Receive from 1394 only.)
PHY Interface
A6
TPA0N
I/O
Twisted Pair A Differential Signal Terminals. For an unused port, TPAN and TPAP signals can be left
open.
C4
TPA1N
B6
B3
E7
C5
E6
B4
D5
A3
TPA0P
TPA1P
TPB0N
TPB1N
TPB0P
TPB1P
TPBIAS0
TPBIAS1
A1
B1
E1
E2
B7
A7
R1
R0
XI
XO
CPS
CAN
E8
WAKEUP
D8
BIASDIS
C11
PHY_TEST_MODEn
Other Function
A8
PHYHCLK
A9
PHY8CLK
N10
RESETn
G4
RESET_HOSTn
C8
RESET_LINKn
JTAG Interface
L9
JTAG_TMS
K9
JTAG_TDI
L10
JTAG_TDO
I/O
Twisted Pair B Differential Signal Terminals. For an unused port, TPBN and TPBP signals should be
tied to GND.
I/O
Twisted Pair Bias Output. These signals provide the 1.86V nominal bias voltage needed for proper
operation of the twisted pair driver and receivers for signaling an active connection to a remote
node.
Current Setting Resistors.
-----
Crystal Oscillator Inputs. These terminals connect to a 24.576MHz parallel resonant fundamental
mode crystal.
I
O
O
O
I
PHY half clock output. 24.576MHz clock is output from this pin.
PHY Eighth Clock output. Programmable clock output.
Device reset. This signal resets all logic. This includes the PHY, link core, buffers, and random logic.
The system should be able to control this signal for AKE process.
Host Reset. In PCI mode, this signal functions as PCI RST#. It is for connection to PCI RST# on the
PCI bus.
Link Reset. Turns off clocks to all logic except PHY logic necessary for 1394 repeater mode.
I
I
O
5 50
LC-37D90U
Pin No.
Pin Name
I/O
Pin Function
P9
JTAG_TCK
I
JTAG Test Clock pin.
N9
JTAG_TRSTn
I
JTAG Reset pin. Active Low only.
MCIF Interface (PCI, 68K and SRAM-Like Interface
A14
MCIF_SEL1
I
Microcontroller Interface Select. This pin is sampled at power-up and reset.
MCIF_SEL [1: 0].
E9
MCIF_SEL0
00: SRAM-like I/F with fixed wait.
01: SRAM-like I/F with handshake.
10: 68k I/F.
11: PCI interface.
F4
PCI_CLK
I
PCI Clock. Max frequency is 33MHz.
F2
PCI_INTAn
O
PCI Interrupt A. Open drain signal.
(MCIF_INTn)
SRAM-like Interface Interrupt. (Active low)
68k-I/F Interrupt. (Active low)
K6
PCI_C/BE0n
I/O
PCI Bus Command/Byte Enable 0.
L5
PCI_C/BE1n
I/O
PCI Bus Command/Byte Enable 1.
M1
PCI_C/BE2n
I/O
PCI Bus Command/Byte Enable 2.
H4
PCI_C/BE3n
I/O
PCI Bus Command/Byte Enable 3.
P1
PCI_DEVSELn
I/O
PCI Device Select. (Active low)
(MCIF_ACKn)
SRAM-like Interface Acknowledge. (Active low)
68k-I/F Acknowledge. (Active low)
I/O
PCI Cycle Frame. (Active low)
M2
PCI_FRAMEn
(MCIF_REn/
SRAM-like Interface Read Enable. (Active low)
MCIF_R_nW)
68k-I/F Read/Write enable. Ex-CPU drives this signal to 1 for aread operation and 0 for a write operation.
G2
PCI_GNTn
I
PCI Grant. (Active low)
J3
PCI_IDSEL
I
PCI Initialization Device Select.
N1
PCI_IRDYn
I/O
PCI Initiator Ready. (Active low)
N5
PCI_PERRn
I/O
PCI Parity Error. (Active low)
I/O
PCI Parity.
M4
PCI_PAR
(MCIF_LITTLE_ENDIA
SRAM-like Interface Endianness setting. When set to 1, the interface will be byte swapped (based
N)
on 4 bytes). When set to 0, the interface byte order will not be changed.
68k-I/F Endianness setting. When set to 1, the interface will be byte swapped (based on 4 bytes).
When set to 0, the interface byte order will not be changed.
F1
PCI_REQn
O
PCI Request. (Active low)
P4
PCI_SERRn
O
PCI System Error. (Active low)
P2
PCI_STOPn
I/O
PCI Stop. (Active low)
(MCIF_CSn)
SRAM-like Interface Chip Select. (Active low)
68k-I/F Chip Select. (Active low)
I/O
PCI Target Ready. (Active low)
M3
PCI_TRDYn
(MCIF_Wen/
SRAM-like Interface Chip Select. (Active low)
MCIF_STRBn)
68k-I/F Strobe Signal. (Active low)
Note: Please note that PCI address/data line sequencing does not match SRAM or 68K mode. For example PCI_AD [6] is multiplexed with MCIF_D
[7]. Signals with mismatching sequence are highlighted in RED.
Please be extra cautious with routing data/address line correctly on PCB.
F5
PCI_AD [31]
I/O
PCI Address/Data 31.
G3
PCI_AD [30]
I/O
PCI Address/Data 30.
G1
PCI_AD [29]
I/O
PCI Address/Data 29.
H3
PCI_AD [28]
I/O
PCI Address/Data 28.
H1
PCI_AD [27]
I/O
PCI Address/Data 27.
H5
PCI_AD [26]
I/O
PCI Address/Data 26.
PCI_AD [25-16]
I/O
PCI Address/Data 25-16.
H2,J4,
(MCIF_A [11-2])
SRAM-Like or 68k-I/F Address 11-2.
J1, K4,
J2, K1,
L1, L3
I/O
PCI Address/Data 15-0.
P3, M5, PCI_AD [15-0]
SRAM-Like or 68k-I/F Data 15-0.
P5, N6, (MCIF_D [15-0])
P6, L6,
M6, N7,
P7, L7,
M8, K7,
P8, L8,
N8, K8
Note: Please note that PCI address/data line sequencing does not match SRAM or 68K mode. For example PCI_AD [6] is multiplexed with MCIF_D
[7].
External DMA
5 51
LC-37D90U
Pin No.
B10
Pin Name
DMAREQ_CH0n
I/O
O
A13
DMAACK_CH0n
D10
DMAREQ_CH1n
C9
DMAACK_CH1n
Pin Function
External DMA Request Signal-Channel 0. The RH-IXB323WJZZ will drive this signal low when it is
ready for the system DMA controller. This signal is hi-Z when not driven low.
External DMA Acknowledge Signal-Channel 0. The system DMA controller will drive this high when
it has received DMAREQ_CH0n signal and is ready to transfer data. The RH-IXB323WJZZ stop
driving the DMAREQ_CH0n signal once this signal is received.
External DMA Request Signal-Channel 1. The RH-IXB323WJZZ drive this signal low when it is
ready for the system DMA controller. This signal is hi-Z when not driven low.
External DMA Acknowledge Signal-Channel 1. The system DMA controller will drive this high when
it has received the DMAREQ_CH1n signal and is ready to transfer data. The RH-IXB323WJZZ stop
driving the DMAREQ_CH1n signal once this signal is received.
HSDI0
Note: If this port is not used, all HSD1 signals can be tied to GND as long as HSDI0Cfg. Enable is set to 0.
G13
HSDIO_CLKz
I/O
HSDI Port 0 Clock. All signals and data on HSDI Port 0 are clocked using this clock.
G10
HSDIO_SYNCz
I/O
HSDI port 0 synchronization signal. This signal is used to indicate the start of packet (or MPEG2
cell.)
For transmit onto 1394, this signal is input to the RH-IXB323WJZZ from the system with the data.
For receive from 1394, the RH-IXB323WJZZ outputs this signal with the data.
If not used in transmit mode, this signal can be tied low.
G11
HSDIO_DVALIDz
I/O
HSDI port 0 Data Valid Pin. This pin indicate if data on the HSDI data bus is valid for reading or writ(HSDIO_ENz)
ing.
For transmit onto 1394, this signal is input to the RH-IXB323WJZZ by the system with the data.
For receive from 1394, the RH-IXB323WJZZ outputs this signal with the data.
If not used in transmit mode, this signal can be tied low.
HSDI port 0 enable pin (HSDI0_Enz) in HSDI RX mode 8/9 (celynx sync mode B compatible
modes).
This signal is always an input in HSDI RX mode 8/9. This signal indicates whether data can be
driven onto the HASID bus. (i.e. if HSDI0_ENz is disserted, HSDI0 data bus and HSDI0 sync will be
tri-stated).
G14
HSDIO_ERRORz
I/O
HSDI port 0 Error pin in MPEG2-DSS mode. This signal is used to indicate the value of the TS error
(HSDI0_FrameSyncz)
bit in the 10 bytes DSS header.
HSDI1_Frame Sync pin HSDI DV mode (TX modes 6/7, RX modes 6-9). This signal is used to indicate the start of DV frames.
This pin is not used in MPEG2-DVB mode. This signal can be left open when HSDI0 is programmed
for RX direction (1394 RX) only. This signal should be pulled up/down when HSDI0 is programmed
for TX direction (1394 TX) or used for both directions.
M10
DSSCIK27
I
DSS 27MHz system clock count. The 27MHz clock input on this pin is used to generate the SCC
timestamp in the DSS 10 bytes header.
This pin is used to generate the SCC field for all three HSDI ports (HSDI0, HSDI1, and HSDI2.)
This pin is valid on MPEG2-DSS transmit only. This pin can be tied directly to GND in other video or
audio modes.
D14
HSDIO_D0
I/O
HSDI port 0 data 0 pin. Data 0 is the least significant bit on the HSDI data bus.
In serial mode, only HSDI0_D [0] is used, HSDI0_D [7:1] are not used.
E13
HSDIO_D1
I/O
HSDI port 0 data 1 pin. In HSDI transmit serial mode (1394 TX), HSDI0_D [7:1] are in don't care status. In HSDI receive serial mode (1394 RX), HSDI0_D [7:1] are Hi-Z. In serial mode, HSDI0_D [7:1]
can be tied directly to GND.
E14
HSDIO_D2
I/O
HSDI Port 0 Data 2 Pin.
(For serial mode operation, see PIN description for HSDI0_D1 above.)
E12
HSDIO_D3
I/O
HSDI Port 0 Data 3 Pin.
(For serial mode operation, see PIN description for HSDI0_D1 above.)
E11
HSDIO_D4
I/O
HSDI Port 0 Data 4 Pin.
(For serial mode operation, see PIN description for HSDI0_D1 above.)
F10
HSDIO_D5
I/O
HSDI Port 0 Data 5 Pin.
(For serial mode operation, see PIN description for HSDI0_D1 above.)
F12
HSDIO_D6
I/O
HSDI Port 0 Data 6 Pin.
(For serial mode operation, see PIN description for HSDI0_D1 above.)
F11
HSDIO_D7
I/O
HSDI Port 0 Data 7 Pin. Data 7 is the most significant bit on the HSDI data bus.
(For serial mode operation, see PIN description for HSDI0_D1 above.)
HSDI1
Note: If this port is not used, all HSD1 signals can be tied to GND as long as HSDI1Cfg. Enable is set to 0.
L12
HSDI1_CLKz
I/O
HSDI port 1 clock. All signal and data on HSDI port 1 are clocked using this clock.
K12
HSDI1_SYNCz
I/O
HSDI port 1 synchronization signal. This signal is used to indicate the start of packet (or MPEG2
cell.)
For transmit onto 1394, this signal is input to the RH-IXB323WJZZQ from the system with the data.
For receive from 1394, the RH-IXB323WJZZQ outputs this signal with the data.
If not used in transmit mode, this signal can be tied low.
5 52
LC-37D90U
Pin No.
L14
Pin Name
HSDI1_DVALIDz
(HSDI1_Enz)
I/O
I/O
L13
HSDI1_ERRORz
(HSDI1_FrameSyncz)
I/O
H12
HSDI1_D0
I/O
H13
HSDI1_D1
I/O
H11
HSDI1_D2
I/O
J10
HSDI1_D3
I/O
J14
HSDI1_D4
I/O
J13
HSDI1_D5
I/O
J12
HSDI1_D6
I/O
K14
HSDI1_D7
I/O
Pin Function
HSDI port 1 data Valid pin. This pin indicates if data on the HSDI data bus is valid for reading or writing.
For transmit onto 1394, this signal is input to the RH-IXB323WJZZQ by the system with the data.
For receive from 1394, the RH-IXB323WJZZQ outputs this signal with the data.
If not used in transmit mode, this signal can be tied low.
HSDI port 1 enable pin (HSDI1_Enz) in HSDI RX mode 8/9 (celynx sync mode B compatible
modes).
This signal is always an input in HSDI RX mode 8/9. This signal indicates whether data can be drive
onto the HSDI bus. (i.e. if HSDI1_Enz is disserted, HSDI1 data bus and HSDI1 sync will be tristated).
HSDI port 1 Error pin in MPEG2-DSS mode. This signal is used to indicate the value of the TS error
bit in the 10 bytes DSS header.
HSDI1_Frame Sync pin HSDI DV mode (TX modes 6/7, RX modes 6-9). This signal is used to indicate the start of DV frames.
This pin is not used in MPEG2-DVB mode. This signal can be left open when HSDI1 is programmed
for RX direction (1394 RX) only. This signal should be pulled up/down when HSDI1 is programmed
for TX direction (1394 TX) or used for both directions.
HSDI port 1 data 0 pin. Data 0 is the least significant bit on the HSDI data bus.
In serial mode, only HSDI1_D [0] is used, HSDI1_D [7:1] are not used.
HSDI port 1 data 1 pin. In HSDI transmit serial mode (1394 TX), HSDI1_D [7:1] are in don't care status. In HSDI receive serial mode (1394 RX), HSDI1_D [7:1] are Hi-Z. In serial mode, HSDI1_D [7:1]
can be tied directly to GND.
HSDI Port 1 Data 2 Pin.
(For serial mode operation, see PIN description for HSDI1_D1 above.)
HSDI Port 1 Data 3 Pin.
(For serial mode operation, see PIN description for HSDI1_D1 above.)
HSDI Port 1 Data 4 Pin.
(For serial mode operation, see PIN description for HSDI1_D1 above.)
HSDI Port 1 Data 5 Pin.
(For serial mode operation, see PIN description for HSDI1_D1 above.)
HSDI Port 1 Data 6 Pin.
(For serial mode operation, see PIN description for HSDI1_D1 above.)
HSDI Port 1 Data 7 Pin. Data 7 is the most significant bit on the HSDI data bus.
(For serial mode operation, see PIN description for HSDI1_D1 above.)
HSDI2
Note: If this port is not used, all HSD1 signals can be tied to GND as long as HSDI2Cfg. Enable is set to 0.
M11
HSDI2_CLKz
I/O
HSDI Port 2 clock. All signals and data on HSDI port 2 are clocked using this clock.
N11
HSDI2_SYNCz
I/O
HSDI Port 2 Synchronization signal is used to indicate the start of packet (or MPEG2 cell.)
For transmit onto 1394, this signal is input to the RH-IXB323WJZZQ from the system with the data.
For receive from 1394, the RH-IXB323WJZZQ outputs this signal with the data.
If not used in transmit mode, this signal can be tied low.
P13
HSDI2_DVALIDz
I/O
HSDI Port 2 Data Valid Pin This pin indicates if data on the HSDI data bus is valid for reading or writ(HSDI2_Enz)
ing.
For transmit onto 1394, this signal is input to the RH-IXB323WJZZQ from the system with the data.
For receive from 1394, the RH-IXB323WJZZQ outputs this signal with the data.
If not used in transmit mode, this signal can be tied low.
HSDI port 2 enable pin (HSDI2_ENz) in HSDI RX mode 8/9 (ceLynx Sync mode B compatible
modes).
This signal always an input in HSDI RX mode 8/9. This signal indicates whether data can be driven
onto the HSDI bus. (i.e. if HSDI2_ENz is disserted, HSDI2 data bus and HSDI2_Sync will be tristated).
N12
HSDI2_ERRORz
I/O
HSDI Port 2 Error pin in MPEG2-DSS mode. This signal is used to indicate the value of the TS error
(HSDI2_FrameSyncz)
bit in the 10 bytes DSS header.
HSDI2_Frame Sync pin in HSDI DV mode (TX Modes 6/7, RX Modes 6-9). This signal is used to
indicate the start of DV frames.
This pin is not used in MPEG2-DVB mode. This signal can be left open when HSDI2 is programmed
for RX direction (1394 RX) only. This signal should be pulled up/down when HSDI2 is programmed
for TX direction (1394 TX) or used for both directions.
P12
HSDI2_D0
I/O
HSDI1 port 2 Data 0 pin.
HSDI port 2 only supports serial data. HSDI2_D0 is the only data pin.
GPIO (General-Purpose Input/Output)
P10
GPIO0
I/O
GPIO. Output is controlled by the internal register.
Input is monitored by internal register.
Can be used as watermark for also buffer 0.
L11
GPIO1
I/O
GPIO. Output is controlled by the internal register. Input is monitored by internal register.
For HSDI0 RX mode 8/9 (ceLynx Sync mode B compatible), it can be configured for HSDI0 AV output.
5 53
LC-37D90U
Pin No.
M13
Pin Name
GPIO2
I/O
I/O
N14
GPIO3
I/O
M14
GPIO4
I/O
B11
GPIO5
I/O
A10
GPIO6
I/O
A11
GPIO7
I/O
E10
GPIO8
I/O
B9
GPIO9
I/O
C7
GPIO10
I/O
Test Modes
D9
TEST_MODE
A2, A4, NO_CONNECT
C2, C3,
D3
Power and Ground Signals
VDD3.3
F3, J5,
L2, K5,
M9, P14,
K11,
C14, B8
E3, E4, VDD1.5
N2, N3,
M12,
N13,
C13, C12
D1
PLLVDD1.5
C1
PLLVSS
G5, L4, VSS
N4, M7,
P11,
K13,
H14,
F13,
B12, C10
D2, D7, AVdd3.3
C6, A5
D6, B5, AVSS
D4, B2
Thermal Balls
--E5, J6,
J7, J8,
J9, H6,
H7, H8,
H9, G6,
G7, G8,
G9, F6,
F7, F8,
F9
Pin Function
GPIO. Output is controlled by the internal register. Input is monitored by internal register.
Can be used as watermark for also buffer 1.
GPIO. Output is controlled by the internal register. Input is monitored by internal register.
For HSDI1 RX mode 8/9 (ceLynx Sync mode B compatible), it can be configured for HSDI1 AV output.
GPIO. Output is controlled by the internal register. Input is monitored by internal register.
Can be used as watermark for also buffer 2.
GPIO. Output is controlled by the internal register. Input is monitored by internal register.
For HSDI2 RX mode 8/9 (ceLynx Sync mode B compatible), it can be configured for HSDI2 AV output.
GPIO. Output is controlled by the internal register. Input is monitored by internal register.
Can be used as watermark for any Async buffer.
GPIO. Output is controlled by the internal register. Input is monitored by internal register.
Can be used as watermark for any Async buffer.
GPIO. Output is controlled by the internal register. Input is monitored by internal register.
Can be used as watermark for any Async buffer.
GPIO. Output is controlled by the internal register. Input is monitored by internal register.
Can be used as watermark for any Async buffer.
GPIO. Output is controlled by the internal register. Input is monitored by internal register.
Can be used as watermark for any Async buffer.
I
---
Used for internal TI testing. Should be tied to GND for normal operation.
These pins should not be connected to any signal, power, or ground.
---
---
-------
---
Analog VDD.
---
Analog Ground.
---
The center device balls are connected together, but electrically isolated from the device. For thermal
purposes, its recommended to connect these balls to a thermal dissipating ground plane (e.g. Vss).
5 54
LC-37D90U
2.15. RH-iXB684WJQZQ (ASSY: IC8601)
DEMODULATOR
I/O
Pin Function
I
I
O
O
I
O
O
O
O
O
O
O
O
O
O
MPEG clock.
MPEG parallel data output bit 0.
MPEG parallel data output bit 1.
MPEG parallel data output bit 2.
MPEG parallel data output bit 3.
MPEG parallel data output bit 4.
MPEG parallel data output bit 5.
MPEG parallel data output bit 6.
MPEG parallel data output bit 0 OR Serial Data.
O
O
O
I
I
I/O
I/O
I
I
O
I
I
Boundary scan serial clock. Must be pulled down to DGND through 10 KO resistor.
Boundary scan serial input. Must be pulled up to 3.3V.
Boundary scan serial output.
Boundary scan test mode select. Must be pulled up to 3.3V.
Boundary scan asynchronous reset. Must be pulled up to 3.3V.
I/O
I/O
I/O
GPIO_3
GPIO_4
GPIO_5
GPIO_6
GPIO_7
GPIO_8
GPIO_9
GPIO_10
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
GPIO_2/PDET_COMP_IN
111
PDET_REF_OUT
114
RF_AGC
117
AUX_AGC
119
IF_AGC
General purpose I/O bit 2 - or -Demodulator RF AGC input from the peak power comparator.
Demodulator RF AGC - SDM peak power comparator reference output to tuner power
comparator; requires external low-pass filter.
Demodulator RF AGC - SDM output to the tuner's RF AGC amplifier; requires external
low-pass filter.
Demodulator AGC - SDM output to auxiliary IF or RF AGC; requires external low-pass filter.
Demodulator IF AGC - SDM output to the IF AGC amplifier; requires external low-pass filter.
5 55
LC-37D90U
Pin No.
8, 13, 16, 18,
19, 21, 24, 29,
30, 124
20, 23, 27, 28
12, 15
9
125
2, 4, 26, 34, 36,
46, 49, 53, 58,
60, 62, 74, 75,
85, 86, 96, 97,
101, 108, 109,
113, 121, 123
3, 35, 45, 52,
61, 70, 81, 92,
107, 112, 122
5, 33, 44, 56,
69, 80, 91, 106,
116
1, 37, 38, 43,
55, 64, 68, 79,
90, 102, 105,
115,
120
110
AGND
Pin Name
I/O
---
Analog Ground.
AVDD
AVDD_ADC
AVDD_OSC
AVDD_PLL
DGND
-----------
VDD1.0
---
VDD1.8
---
VDD3.3
---
VREF
Pin Function
5 56
LC-37D90U
2.16. VHiTC6384AF1EQ (ASSY: IC8702)
SD_CARD_CONTROLER
I/O
I
I
Pin Function
Chip select (accessible in #CS= 0).
Address bit 7-0.
I/O
I
I
I
I
I
O
O
I
I
I
I
Read enable. The content of the register is output to D [15:0] when making it to 0.
Write enable. When 0 is connected by three clocks, D [15:0] value is written in the register.
Byte enable. Most Significant Byte becomes accessible at BE1=BEPOL.
Byte enable. Least Significant Byte becomes accessible at BE0=BEPOL.
Polarity setting of BE [1:0].
Acnorigge signal when register is accessed.
Interrupt output.
Change of method in host interface.
Main clock.
SD card detection clock.
Main reset.
O
I/O
I/O
I
I
I/O
I/O
I/O
I/O
I/O
I
I
I
O
O
O
O
O
I/O
I
O
I
O
I
I
O
I
O
O
I
I
O
5 57
LC-37D90U
Pin No.
61
Pin Name
LED2
I/O
O
60
LED1
59
LED0
51
#TEST
Power/Ground
VDD
3, 19, 33,
43, 53, 63,
84, 92
9, 28, 69,
VDDS
78, 96
VSS
5, 15, 26,
40, 48, 58,
65, 80, 90
Pin Function
LED output terminal for debugging. It is controlled by an internal register and it synchronizes with the
operation of SD2.
LED output terminal for debugging. It is controlled by an internal register and it synchronizes with the
operation of SD1.
LED output terminal for debugging. It is controlled by an internal register and it synchronizes with the
movement of each card.
Test signal. Fix to 1 at a normal mode.
---
---
---
Ground.
5 58
LC-37D90U
2.17. RH-iXB732WJQZQ (ASSY: IC9101)
CPLD
Pin Name
ED16
ED17
ED18
ED19
ED20
ED21
ED22
ED23
VCC
GND
GNDINT
ECLK
VCC
N_DBG_RST
XEWE
XERE
EA21
EA22
EA23
EA24
RF_SW
TMS
TDI
TCK
TDO
BS1_SYNC_INT
N_BS1_INT
N_DEMORST
N_SD_INT
N_SD_RST
VCC
GND
TP
FLADD22
N_FLCS1
N_FLRST
N_FLOE
TP
FPI2CEN1
N_AUDIORST
SDSP_RST
RST_MSP
TP
VC_INT
VCC
GND
N_EXT_RST
N_HOST_CE1
N_EXT_BOOT
CBOOTS
SMPOWHOLD
FLS_RST
FLS_W
RST_VC
N_PHY_RESET
N_LINK_RESET
PM_REQ
N_DBOOTS
VCC
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
I/O
------I
--I
I
I
I
I
I
I
O
I
I
I
O
I
I
O
I
O
------O
O
O
O
--O
O
O
O
--I
----O
O
I
I
O
O
O
O
OD
O
I
I
---
Pin Function
SBDAT0.
SBDAT1.
SBDAT2.
SBDAT3.
SBDAT4.
SBDAT5.
SBDAT6.
SBDAT7.
Power Supply.
Ground.
Ground.
Bus Clock.
Power Supply.
Debugger Reset Input.
N_SBWE.
N_SBOE.
SBADD21.
SBADD22.
SBADD23.
SBADD24.
RF Switch Control.
Tuner Interrupt.
Tuner Interrupt.
Demodulator Reset.
Power Supply.
Ground.
Flash ADD22.
Flash CS1.
Flash Reset Output.
Flash OE.
PH1_I2C1 Line Switch Control (CMOS Level).
Audio Reset.
MSP Reset (CPLD3_33pin).
Power Supply.
Ground.
PC Card PWB Reset.
PC Card PWB CS.
PC Card Boot Detect.
Card Boot Detect.
Power Supply.
5 59
LC-37D90U
Pin No.
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
Pin Name
GND
PWB_VER1
CLK33MB
VCC
N_SRESET
GND
PWB_VER0
HDMI_HPG1
HDMI_HPG2
HDMI_HPG3
HDMI_RST
HDMI_SW_EMP
HDMI_INT
HDMI_SW_OE
HDMI_SEL1
HDMI_SEL2
HDMI_SEL3
HDMI_PLG_EN
HDMI_WP
GND
VCC
HP_WATCH
HP_IPDET
CPLD_INT1
TUNER_INT
CPLD_INT0
N_CPU_RST
EA5
EA4
EA3
EA2
EA1
HP_RST
GND
VCC
HP_IPEN
TP
TP
TP
N_SBCE5
N_SBCE0
I/O
--I
I
--I
--I
I
I
I
O
O
I
O
O
O
O
O
O
----I
I
O
O
O
O
I
I
I
I
I
O
----O
------I
I
Pin Function
Ground.
PWB ID.
Clock (33MHz).
Power Supply.
System Reset.
Ground.
PWB ID.
Ground.
Power Supply.
EX Model Control Line.
EX Model Control Line.
CPLD Interrupt (Reservation).
Tuner Interrupt Notice.
CPLD Interrupt.
CPU Reset.
SBADD5.
SBADD4.
SBADD3.
SBADD2.
SBADD1.
EX Model Control Line.
Ground.
Power Supply.
EX Model Control Line.
5 60
LC-37D90U
2.18. VHiTPS40055-1Y (ASSY: IC9603, 9606, 9607)
DC/DC CONVERTER
Pin Name
BOOST
I/O
O
BP5
11
BP10
COMP
13
HDRV
16
ILIM
KFF
10
LDRV
PGND
---
2
5
6
RT
SGND
SS/SD
I
--I
12
4
SW
SYNC
I
I
VFB
15
VIN
Pin Function
Gate drive voltage for the high side N-channel MOSFET.
The BOOST voltage is 9V greater than the input voltage.
A 0.1-F ceramic capacitor should be connected from this pin to the drain of the lower MOSFET.
5-V reference.
This pin should be bypassed to ground with a 0.1-F ceramic capacitor.
This pin may be used with an external DC load of 1mA or less.
10-V reference used for gate drive of the N-channel synchronous rectifier.
This pin should be bypassed by a 1-f ceramic capacitor.
This pin may be used with an external DC load of 1 mA or less.
Output of the error amplifier, input to the PWM comparator.
A feedback network is connected from this pin to the VFB pin to compensate the overall loop.
The comp pin is internally clamped above the peak of the ramp to improve large signal transient response.
Floating gate drive for the high-side N-channel MOSFET.
This pin switches from BOOST (MOSFET on) to SW (MOSFET off).
Current limit pin, used to set the overcurrent threshold.
An internal current sink from this pin to ground sets a voltage drop across an external resistor
connected from this pin to VCC.
The voltage on this pin is compared to the voltage drop (VIN SW) across the high side MOSFET
during conduction.
A resistor is connected from this pin to VIN to program the amount of voltage feed-forward.
The current fed into this pin is internally divided and used to control the slope of the PWM ramp.
Gate drive for the N-channel synchronous rectifier.
This pin switches from BP10 (MOSFET on) to ground (MOSFET off).
Power ground reference for the device.
There should be a low-impedance path from this pin to the source(s) of the lower MOSFET(s).
A resistor is connected from this pin to ground to set the internal oscillator and switching frequency.
Signal ground reference for the device.
Soft-start programming pin.
A capacitor connected from this pin to ground programs the soft-start time.
The capacitor is charged with an internal current source of 2.3A.
The resulting voltage ramp on the SS pin is used as a second non-inverting input to the error amplifier.
The output voltage begins to rise when VSS/SD is approximately 0.85V.
The output continues to rise and reaches regulation when VSS/SD is approximately 1.55V.
The controller is considered shut down when VSS/SD is 125mV or less. All internal circuitry is inactive.
The internal circuitry is enabled when VSS/SD is 210mV or greater.
When VSS/SD is less than approximately 0.85V, the outputs cease switching and the output voltage
(VOUT) decays while the internal circuitry remains active.
This pin is connected to the switched node of the converter and used for overcurrent sensing.
Syncronization input for the device.
This pin can be used to synchronize the oscillator to an external master frequency.
If synchronization is not used, connect this pin to SGND.
Inverting input to the error amplifier.
In normal operation the voltage on this pin is equal to the internal reference voltage, 0.7V.
Supply voltage for the device.
5 61
LC-37D90U
2.19. 95KUCY0273AY (ASSY: IC4701)
HIGH VOLTAGE RESONANT CONTROLLER (E-L6598D13TR)
Pin Name
CSS
Rfstart
Cf
Rfmin
Opout
OPonOPon+
EN1
EN2
GND
LVG
Vs
N.C.
OUT
HVG
Vboot
I/O
--I
--I
O
I
I
I
I
--O
----O
O
O
Pin Function
Soft Start Timing Capacitor.
Soft Start Frequency Setting - Low Impedance Voltage Source - See also Cf.
Oscillator Frequency Setting - see also Rfmin, Rfstart.
Minimum Oscillation Frequency Setting - Low Impedance Voltage Source - See also Cf.
Sense OP AMP Output - Low Impedance.
Sense Op Amp Inverting Input - High Impedance.
Sense Op Amp Non Inverting Input - High Impedance.
Half Bridge Latched Enable.
Half Bridge Unlatched Enable.
Ground.
Low Side Driver Output.
Supply Volatge with Internal Zener Clamp.
Not Connected.
High Side Driver Reference.
High Side Driver Output.
Bootstrapped Supply Voltage.
Pin Name
CS
FB
IS
GND
OUT
VCC
N.C.
VH
I/O
--I
I
--O
----I
Pin Function
Soft start, latch-mode stop.
Input for controlling current comparator threshold voltage.
Input for monitoring MOSFET current.
Power supply ground.
Output for directly driving a MOSFET.
Power supply for ICs.
No connection.
Input terminal for start-up circuit.
5 62
LC-37D90U
MEMO
5 63
LC-37D90U
Service
CHAPTER 6. TROUBLE SHOOTING TABLE
LC-37D90U
Manual
YES
Are the harnesses and FFCs tightly connected?
YES
Does F701 function?
NO
Replace F701 with new one and turn on the power. If the fuse blows out
again, replace the following parts with new ones and check the fuse
again: VZ701, DS4701, F4701, F4702, F5701, Q4701, Q4702, Q5701,
IC4701 and IC5701.
YES
YES
Is there the BU5V output?
YES
Check F5702, D5705, IC5706 and
D5717 for defects.
NO
Check the primary-side parts
for defects. See if the secondary output is short-circuited.
YES
YES
Check the UR6V regulator circuit,
UR13V rectifier circuit and UR10V
DC/DC circuit.
NO
Make sure the set is not in
STANDBY MODE2. Check the
main unit for trouble.
YES
YES
61
NO
L C -3 7 D 9 0 U
Check D4705 and D4706 for defects.
YES
YES
Turn on the power again and make sure the set functions
as specified.
(Remarks)
Status of the set
MODE1
STDBY
MODE2
PowerON
PS_ON
(CN5702(1))
High
Low
High
PNL_POW
(CN5702(4))
High
Low
High
BU5V
(CN5702(5))
5V
5V
5V
UR6V
(CN5701(1))
6V
6V
62
UR10V
(CN5701(7))
10V
10V
UR13V
(CN5701(11))
13V
13V
PNL12V
(CN5701(3))
12V
12V
24V
(CN5703(1))
24V
24V
LC-37D90U
No video (1)
NO
Select INPUT-1 on the input
select menu screen for the
right input signal.
NO
Check the line between pin
(4) of J501 and pin (65) of
IC501.
YES
NO
Select INPUT-2 on the
input select menu
screen.
YES
NO
Check the line between
pin (1) of J501 and pin
(3) of IC501.
YES
YES
[COMPOSITE signal input] Is there the COMPOSITE video signal output at pin (60) of IC501?
NO
Select INPUT-2 on the input
select menu screen.
NO
Check the line between pins
(3)(Y)/(4)(C) of J503 and pins
(5)/(7) of J501.
YES
NO
[S-VIDEO signal input] Is there the video signal output at pins (60)(Y) and (59)(C) of IC501?
YES
[COMPOSITE signal input] Is there the COMPOSITE video signal output at pin (2) of connector (SC501) on the
IF unit?
NO
[S-VIDEO signal input] Is there the video signal output at pins (2)(Y) and (4)(C) of connector (SC501) on the IF
unit?
YES
[COMPOSITE signal input] Is there the COMPOSITE video signal input at pin (2) of connector (SC1101) on the
main unit?
NO
[S-VIDEO signal input] Is there the video signal input at pins (2)(Y) and (4)(C) of connector (SC1101) on the
main unit?
63
LC-37D90U
YES
[COMPOSITE signal input] Is there the COMPOSITE video signal input at pins (M4, N4) of IC3301 (VPC)?
NO
[S-VIDEO signal input] Is there the video signal input at pins (M4, N4)(Y) and (T1)(C) of IC3301 (VPC)?
YES
Is there the LVDS signal output at the LVDS 1st channel and 2nd channel of IC3301?
TA2_P/M(AJ30/AK30), TB2_P/M(AJ29/AK29), TC2_P/M(AJ28/AK28), TD2_P/M(AJ26/AK26), TE2_P/M(AJ25/
AK25), TF2_P/M(AJ24/AK24), TCLK2_P/M(AJ27/AK27), TA1_P/M(AB29/AB30), TB1_P/M(AC29/AC30),
TC1_P/M(AD29/AD30), TD1_P/M(AF29/AF30), TE1_P/M(AG29/AG30), TF1_P/M(AH29/AH30), TF1_P/
M(AH29/AH30), TCLK1_P/M(AE29/AE30)
YES
Check the panel module.
64
NO
LC-37D90U
No video (2)
NO
Select INPUT-1 on the input
select menu screen for the
right input signal.
YES
Does the INPUT-1 C1.PLUG
detection function?
Check the line between pin (8)
of input terminal (J501) and
pin (38) of IC501
(AV_SWITCH).
NO
Check the line between the
input terminals of J501 and
IC501.
NO
Check the tuner, IC8601 (DEMODULATOR) and their peripheral circuits (TUN_SDA/SCL,
Q8601).
NO
Is there the video signal output at pin (5) of
IC1103 (LEVEL_ADJ)?
YES
NO
Does the level adjustment control signal come from pin (6) of
IC1103 to pin (1) of IC1104?
NO
Check IC1104 and its peripheral
circuits. Replace as required.
Is there the COMPONENT video signal output at pins (60)(Y), (59)(Pb) and (58)(Pr) of
IC501?
YES
YES
NO
65
YES
NO
Check the tuner, IC8601 (DE-MODULATOR) and their peripheral circuits (TUN_SDA/SCL, Q8601).
NO
Are there the MPEG signal outputs
(US_TS_PKTSYNC, US_TS_EN,
US_TS_DATA, US_TS_CLK) from IC8601?
YES
NO
Check IC8601 and its peripheral
control circuits.
YES
NO
Check the line between IC8601 and
IC8101.
LC-37D90U
Is there the COMPONENT video signal output at pins (2), (4) and (6) of connector
(SC501) on the IF unit?
YES
YES
NO
Check the line between IC501
and SC501 (Q501 thru Q506,
etc.).
NO
Check IC8101 and its peripheral
circuits.
YES
NO
Check the line between IC8101 and
IC3301.
NO
Check the SC501 and SC1101
connectors.
YES
NO
Check the line between
SC1101 and IC3301 and their
peripheral circuits (Q2202,
Q2203, Q2206, etc.).
NO
Is there the LVDS signal output at the LVDS 1st channel and 2nd channel of IC3301?
TA2_P/M(AJ30/AK30), TB2_P/M(AJ29/AK29), TC2_P/M(AJ28/AK28), TD2_P/M(AJ26/AK26), TE2_P/M(AJ25/AK25), TF2_P/M(AJ24/AK24),
TCLK2_P/M(AJ27/AK27), TA1_P/M(AB29/AB30), TB1_P/M(AC29/AC30), TC1_P/M(AD29/AD30), TD1_P/M(AF29/AF30), TE1_P/M(AG29/AG30),
TF1_P/M(AH29/AH30), TF1_P/M(AH29/AH30), TCLK1_P/M(AE29/AE30)
YES
Check the panel module.
NO
Check IC3301 and its peripheral control circuits (IC5301, IC5302, IC8101, etc.).
66
LC-37D90U
<HDMI signal input>
No video (3)
NO
Select INPUT-3 on the input select menu screen for the
right input signal.
NO
Select INPUT-4 on the input select menu screen for the
right input signal.
NO
Does the HOT PLUG detection function?
NO
Does the HOT PLUG detection function?
Does the HDMI_HPG3 signal come from pin (18) of connector (SC1501) to pin (69) of IC9101 (CPLD)?
Does the HDMI_HPG2 signal come from pin (18) of connector (SC1502) to pin (68) of IC9101 (CPLD)?
YES
NO
Check the line between SC1501 and IC9101
(CPLD) (Q1506, Q1508, etc.).
YES
NO
Check the line between IC1901 and IC1507/
IC1508.
Does the HDP3 signal come from pin (44) of IC1507 to pin
(19) of SC1501?
NO
Check the line between IC1507 and SC1501.
67
YES
NO
Check the line between SC1502 and
IC9101 (CPLD) (Q1505, Q1507, etc.).
YES
NO
Check the line between IC1901 and
IC1507/IC1508.
NO
Check the line between IC1507 and
SC1502.
LC-37D90U
Does the signal come from connector (SC1501) to the input pins (48 and
49) (CLK), (51 and 52) (D0), (54 and 55) (D1), and (57 and 58)
(D2), all of IC1507?
YES
Does the signal come from connector (SC1502) to the input pins (67
and 68) (CLK), (70 and 71) (D0), (73 and 74) (D1), and (76 and 77)
(D2), all of IC1507?
YES
NO
Is IC1501 (EEPROM) accessed by I2C, with HDMI connected, to read the DDC_I2C CLOCK/DATA data?
NO
Is IC1502 (EEPROM) accessed by I2C, with HDMI connected, to read the DDC_I2C CLOCK/DATA data?
NO
Check the DDC line and its peripheral circuits
(IC1501 (EEPROM) and its peripherals).
Does the signal come from pins (34 and 35) (CLK), (31 and 32) (D0), (28 and 29)
(D1), and (25 and 26) (D2) of IC1507 to pins (50 and 51), (54 and 55), (58 and 59), and
(62 and 63) of IC1508?
YES
Are there the U3VINY[7:0], U3VINR[7:0], U3VINPBPR[7:0], U3VDIN, U3HDIN, U3DEIN
and U3VINCLK signal outputs from IC1508?
YES
Are there the U3VINY[7:0], U3VINR[7:0], U3VINPBPR[7:0], U3VDIN, U3HDIN, U3DEIN
and U3VINCLK signal inputs at IC3301 (VPC)?
YES
Is there the LVDS signal output at the LVDS 1st channel and 2nd channel of IC3301?
TA2_P/M(AJ30/AK30), TB2_P/M(AJ29/AK29), TC2_P/M(AJ28/AK28), TD2_P/M(AJ26/
AK26), TE2_P/M(AJ25/AK25), TF2_P/M(AJ24/AK24), TCLK2_P/M(AJ27/AK27), TA1_P/
M(AB29/AB30), TB1_P/M(AC29/AC30), TC1_P/M(AD29/AD30), TD1_P/M(AF29/AF30),
TE1_P/M(AG29/AG30), TF1_P/M(AH29/AH30), TF1_P/M(AH29/AH30), TCLK1_P/
M(AE29/AE30)
YES
Check the panel module.
68
NO
Check the DDC line and its peripheral circuits (IC1502 (EEPROM) and its peripherals).
NO
NO
NO
LC-37D90U
<DVI signal input>
NO
Select INPUT-5 on the input select menu screen for
the right input signal (AUTO or DIGITAL).
No video (4)
NO
Select INPUT-5 on the input select menu screen for the
right input signal (AUTO or ANALOG).
YES
NO
NO
Does the HOT PLUG detection function? Does the HDMI_HPG1 signal come from pin (14) of DVI connector
(SC1503) to pin (67) of IC9101 (CPLD)?
YES
NO
Check the line between SC1503 and IC9101 (CPLD)
(Q1501, Q1502, etc.).
Does the HDMI_PLG_EN signal come from pin (77) of IC9101 to pin (44) of IC1508 (HDMI/HDCP/DVI COMPLIANT
RECEIVER) and pin (40) of IC1507 (DVI/HDMI SWITCH)?
YES
NO
Check the line between IC1901 and IC1507/IC1508.
Does the HDP1 signal come from pin (80) of IC1507 to pin (16) of SC1503?
NO
Check the line between IC1507 and SC1503.
Does the signal come from DVI connector (SC1503) to the input
pins (5 and 6) (CLK), (8 and 9) (D0), (11 and 12) (D1), and (14
and 15) (D2), all of IC1507?
YES
NO
NO
69
YES
LC-37D90U
Is IC1505 (EEPROM) accessed by I2C, with DVI connected, to read the DDC_I2C CLOCK/DATA data?
Does the signal come from pins (34 and 35) (CLK), (31 and 32)
(D0), (28 and 29) (D1), and (25 and 26) (D2) of IC1507 to pins
(50 and 51), (54 and 55), (58 and 59), and (62 and 63) of IC1508?
YES
NO
Check the DDC line and its peripheral circuits (IC1505
(EEPROM) and its peripherals).
NO
Check IC1507, IC1508 and their peripheral circuits.
YES
NO
Check IC1508 and its peripheral circuits.
YES
NO
Check the line between IC1508 and IC3301.
Is there the LVDS signal output at the LVDS 1st channel and 2nd channel of IC3301?
TA2_P/M(AJ30/AK30), TB2_P/M(AJ29/AK29), TC2_P/M(AJ28/AK28), TD2_P/M(AJ26/AK26), TE2_P/M(AJ25/AK25), TF2_P/M(AJ24/AK24),
TCLK2_P/M(AJ27/AK27), TA1_P/M(AB29/AB30), TB1_P/M(AC29/AC30), TC1_P/M(AD29/AD30), TD1_P/M(AF29/AF30), TE1_P/M(AG29/AG30),
TF1_P/M(AH29/AH30), TF1_P/M(AH29/AH30), TCLK1_P/M(AE29/AE30)
YES
Check the panel module.
NO
Check IC3301 and its peripheral control circuits (IC5301,
IC5302, IC8101, etc.).
6 10
LC-37D90U
No audio (1)
[INPUT-1 input]
Is INPUT-1 selected on the input select menu
screen?
[INPUT-2 input]
Is INPUT-2 selected on the input select menu
screen?
YES
NO
Is the audio output selected for
VARIABLE on the menu
screen?
YES
Set the audio output to FIXED.
NO
Check the audio signal from
J501 to SC502, and their
peripheral circuits.
NO
Is the audio output selected for VARIABLE on the menu screen?
YES
YES
Set the audio output to FIXED.
NO
Is the audio output selected
for VARIABLE on the menu
screen?
YES
Set the audio output to
FIXED.
YES
NO
(HDMI analog input)
Check the line between J1501 and
IC1403, and their peripheral circuits.
YES
No audio (2)
YES
Is the SII9011_MUTE line as specified?
YES
NO
Check Q1301, IC1303 and
their peripheral circuits.
NO
6 11
LC-37D90U
Check the SC502 and SC1102
connectors.
YES
NO
Check the line between
IC1508 and IC1403 and their
peripheral circuits.
YES
NO
Check the line between SC1102
and IC1403 and their peripheral
circuits.
Is there the audio signal output at pins (38)(L) and (39)(R) of IC1403?
YES
Is there the audio signal output at pins (8)(L) and (11)(R) of connector
(SC1301) on the main unit?
YES
Is there the audio signal input at pins (8)(L) and (11)(R) of connector
(P2704) on the IF unit?
YES
Is there the audio signal input at pins (11)(L) and (15)(R) of IC2701
(STEREO_AMP)?
NO
YES
Is the audio output from IC2701 as specified?
YES
Does the speaker select relay (T2701) function?
NO
YES
Check the connector (P2703), speakers and their peripheral circuits.
6 12
LC-37D90U
No audio (4)
YES
Move the sound volume key.
Does the volume icon indicate
the speakers?
NO
Are there the IF_OUT_N and
IF_OUT_P signal outputs at
pins (20) and (21) of tuner
(TU1101)?
YES
Are there the IF_OUT_N and
IF_OUT_P signal inputs at
pins (10) and (11) of IC8601
(DEMODULATOR)?
YES
Do the US_TS_CLK/DATA/
EN/PKTSYNC signals come
from pins (51, 59, 63 and 66)
of IC8601 to pins (D11, A9,
C10, B10) of IC8101 (CPU/
DECODER)?
YES
NO
NO
NO
NO
Is there the SIF signal output
at pin (3) of tuner (TU1101)?
YES
Is there the SIF signal input at
pins (21) of IC1401
(SIF_DECODER)?
YES
Are the audio signal outputs at
pins (30)(L) and (29)(R) of
IC1401?
YES
Are the audio signal inputs at
pins (51)(L) and (52)(R) of
IC1403?
YES
Is the communication
between IC8101 and IC8801
(DAC) as specified?
(DTV_I2SMCLK/
DTV_I2SCLK/
DTV_I2SLRCK)?
YES
Are the DTV_L/R audio signal
outputs at pins (19)(L) and
(18)(R) of IC8801 (DAC)?
NO
NO
YES
6 13
YES
YES
NO
NO
NO
Check IC1401
(SIF_DECODER) and
its peripheral circuits.
Replace as required.
NO
LC-37D90U
Are the audio signal inputs at
pins (61)(L) and (62)(R) of
IC1403?
NO
YES
YES
Are the audio signal outputs
at pins (8)(L) and (11)(R) of
connector (SC1301) on the
main unit?
YES
Are the audio signal inputs at
pins (8)(L) and (11)(R) of connector (P2704) on the IF unit?
YES
Are the audio signal inputs at
pins (11)(L) and (15)(R) of
IC2701 (STEREO_AMP)?
YES
Is the audio output from
IC2701 as specified?
YES
Does the speaker select relay
(T2701) function?
NO
NO
NO
NO
NO
NO
YES
Check the P2703 connector,
speakers and their peripheral
circuits.
6 14
LC-37D90U
No audio signal at DIGITAL AUDIO OUTPUT terminal (Analog sound heard)
YES
Does the HDMI_SPDIF
signal come from pin (70)
of IC1508 to pin (2) of
IC1403 (CODEC)?
NO
NO
YES
Are there the IF_OUT_N
and IF_OUT_P signal
inputs at pins (10) and (11)
of IC8601 (DEMODULATOR)?
YES
Do the US_TS_CLK/DATA/
EN/PKTSYNC signals
come from pins (51, 59, 63
and 66) of IC8601 to pins
(D11, A9, C10, B10) of
IC8101 (CPU/DECODER),
respectively?
YES
YES
Is the DTV_SPDIF signal
output at pin (R33) of
IC1801?
YES
YES
Is there the SPDIF signal
input at pin (1) of IC1408
(SPDIF_FUFF.)?
NO
NO
YES
Is the DTV_SPDIF signal
input at pin (5) of IC1403?
NO
NO
NO
NO
NO
No monitor audio
YES
6 15
LC-37D90U
YES
Is there the MUTE signal
input at pin (2) of IC1408?
YES
Is there the SPDIF signal
input at pin (1) of DIGITAL
AUDIO OUTPUT terminal
(D1402)?
NO
Check the
MUTE_A_ALL and
ACDET_MUTE signals.
YES
Are the audio signal outputs
at pins (40)(L) and (41)(R)
of IC1403?
NO
NO
NO
YES
Are the audio signal inputs
at pins (3)(L) and (4)(R) of
IC1407 (BUFF_AMP.)?
YES
Are the audio signal outputs
at pins (1)(L) and (7)(R) of
IC1407?
YES
Are the audio signal outputs
at pins (16)(L) and (14)(R)
of connector (SC1102) on
the main unit?
YES
Are the audio signal inputs
at pins (16)(L) and (14)(R)
of connector (SC502) on
the IF unit?
YES
Check the signal up to the
monitor audio output terminal (J502).
6 16
NO
NO
NO
NO
NO
LC-37D90U
LED flashing timing chart for error notification.
250ms
1sec
Power failure
Flashes twice
H: On
L: Off
H: On
L: Off
Vsync
IC3301 operation failure.
Flashes 4 times
Panel temperature failure
Flashes 5 times
H: On
L: Off
H: On
L: Off
2) Power failure details (Power LED flashes twice and OPC LED flashes)
Error type
PS_ON
UR+13V/UR+10V failure
Flashes once
EU_POW
D3.3V failure
Flashes twice
H: On
D_POW
UR+6V failure
Flashes 3 times
H: On
PANEL_POW
Panel 12V failure
Flashes 5 times
H: On
L: Off
Main failure
Flashes 7 times
L: Off
L: Off
H: On
L: Off
3) Communication failure details (Power LED flashes 3 times and OPC LED flashe
Error type
Initial communication
reception failure
Flashes once
6 17
LC-37D90U
Error type
Time-out setting reception failu
Start-up confirmation reception failure
Flashes twice
H: On
L: Off
6 18
LC-37D90U
Service Manual
CHAPTER 7. OVERALL WIRING/BLOCK DIAGRAM
LC-37D90U
71
10
LC-37D90U
10
11
12
13
14
15
72
16
17
18
19
LC-37D90U
73
10
LC-37D90U
10
11
12
13
14
15
74
16
17
18
19
LC-37D90U
75
10
LC-37D90U
10
11
12
13
14
15
76
16
17
18
19
LC-37D90U
77
10
LC-37D90U
10
11
12
13
14
15
78
16
17
18
19
LC-37D90U
Service Manual
81
LC-37D90U
82
LC-37D90U
[3] IF Unit
IF Unit-1/2
83
10
LC-37D90U
10
11
12
13
14
15
84
16
17
18
19
LC-37D90U
IF Unit-2/2
85
10
LC-37D90U
10
11
12
13
14
15
86
16
17
18
19
LC-37D90U
MAIN Unit-1/23
87
10
LC-37D90U
10
11
12
13
14
15
88
16
17
18
19
LC-37D90U
MAIN Unit-2/23
89
10
LC-37D90U
10
11
12
13
14
15
8 10
16
17
18
19
LC-37D90U
MAIN Unit-3/23
8 11
10
LC-37D90U
10
11
12
13
14
15
8 12
16
17
18
19
LC-37D90U
MAIN Unit-4/23
8 13
10
LC-37D90U
10
11
12
13
14
15
8 14
16
17
18
19
LC-37D90U
MAIN Unit-5/23
8 15
10
LC-37D90U
10
11
12
13
14
15
8 16
16
17
18
19
LC-37D90U
MAIN Unit-6/23
8 17
10
LC-37D90U
10
11
12
13
14
15
8 18
16
17
18
19
LC-37D90U
MAIN Unit-7/23
8 19
10
LC-37D90U
10
11
12
13
14
15
8 20
16
17
18
19
LC-37D90U
MAIN Unit-8/23
8 21
10
LC-37D90U
10
11
12
13
14
15
8 22
16
17
18
19
LC-37D90U
MAIN Unit-9/23
8 23
10
LC-37D90U
10
11
12
13
14
15
8 24
16
17
18
19
LC-37D90U
MAIN Unit-10/23
8 25
10
LC-37D90U
10
11
12
13
14
15
8 26
16
17
18
19
LC-37D90U
MAIN Unit-11/23
8 27
10
LC-37D90U
10
11
12
13
14
15
8 28
16
17
18
19
LC-37D90U
MAIN Unit-12/23
8 29
10
LC-37D90U
10
11
12
13
14
15
8 30
16
17
18
19
LC-37D90U
MAIN Unit-13/23
8 31
10
LC-37D90U
10
11
12
13
14
15
8 32
16
17
18
19
LC-37D90U
MAIN Unit-14/23
8 33
10
LC-37D90U
10
11
12
13
14
15
8 34
16
17
18
19
LC-37D90U
MAIN Unit-15/23
8 35
10
LC-37D90U
10
11
12
13
14
15
8 36
16
17
18
19
LC-37D90U
MAIN Unit-16/23
8 37
10
LC-37D90U
10
11
12
13
14
15
8 38
16
17
18
19
LC-37D90U
MAIN Unit-17/23
8 39
10
LC-37D90U
10
11
12
13
14
15
8 40
16
17
18
19
LC-37D90U
MAIN Unit-18/23
8 41
10
LC-37D90U
10
11
12
13
14
15
8 42
16
17
18
19
LC-37D90U
MAIN Unit-19/23
8 43
10
LC-37D90U
10
11
12
13
14
15
8 44
16
17
18
19
LC-37D90U
MAIN Unit-20/23
8 45
10
LC-37D90U
10
11
12
13
14
15
8 46
16
17
18
19
LC-37D90U
MAIN Unit-21/23
8 47
10
LC-37D90U
10
11
12
13
14
15
8 48
16
17
18
19
LC-37D90U
MAIN Unit-22/23
8 49
10
LC-37D90U
10
11
12
13
14
15
8 50
16
17
18
19
LC-37D90U
MAIN Unit-23/23
8 51
10
LC-37D90U
10
11
12
13
14
15
8 52
16
17
18
19
LC-37D90U
8 53
LC-37D90U
8 54
LC-37D90U
Service Manual
CHAPTER 9. PRINTED WIRING BOARD ASSEMBLIES
LC-37D90U
[1] IF Unit
IF Unit (Side-A)
91
LC-37D90U
J503
C520
LUG502
R503
C502
SC502
R594
R593
SC501
k001
LUG2701
P2704
C2703
C2710 C2711
C2713 R2704
V1
C2722
C2724
FB2701
FB2703
C2701 FB2702
R2719
FB2704
C2708
C2709
R2703
C2712
R2710
L2701
L2702
L2703
L2704
C2736
R2720
C2744 R2721
C2745
LUG2702
D2707
D2705
R532
C518
D506
R531
D502
C503
R505
Q507
R2705
R2715 Q2701
C2702
IC2701
D507
FB519
C519
R533
R534
FB518
D508
C522
FB502
R535
D503
FB501
Q508
P2703
kame1
D2709
D2706
D2708
FB503
LUG501
R583
Q506
R581
R2702 R2701
C2718 C2705 C2704
C2716
C2725
R2714
C2721 C2715
C2735
Q509
R577
Q504
R575
R598
R599
C563
P502
T2701
R501
R591
R571
Q502
R569
Q511
IC502
C2714
C2720
C2729
C2727
C2730
C2726
C2728
C2731
C2732
Q2702
D501
C540
R561
R585
R2713
R2716
C501
C509
R559
C539 R560
C538
R580
D2701
D2702
D2703
D2704
C567
R570 R572
R506
R504
R502
C506
FB504
C558
C504
R508
R507
FB505 R509 C505
R510 C570
FB506
R511
R514
C510
C528
R605
R536 C523
D509 R537 C542
R538
C521 R610
C569
D510 R539
R540
D511
R541
C525
R543
C524
C564
C526
C527
C529
C531 R544
R548 C530
R545
R546 R547
R549
92
R513 C571
FB507 R512 C507
FB508 R515 C508
R516 C572
D504
FB509
R517
C511
FB510
FB511
D505
R550
FB7506
C560
C562
R600
C561
L501
R586
Q505
UNT501
R2711 R2712
C2723
LUG504
R519
R518
R520
R525
C513
R527
FB515 R526 C515
R524 C573
FB513 R523 C514
FB514
C517
R576 R578
C568
C546
C551
FB520 C553
C548
C552
R573
C565
C549
R579
Q503
C566
R574
Q501
kame2
C550
C7503
C7504
R7510
C7506
C554
C555 R587
SC7501
C7502
C547
R7513
R7512
C7507
FB7503 R7515
C536
C556 R588
R589
C541
R563
D518
R562
C537
R557
R602
R558
C557
D7504
FB2712
C2737
FB2711
C2738
FB2710
C2739
FB2709
C2740
R530
R542 R606
R592
C7505
IC7501
C7501
R521
FB512
C512
R522
FB516 C574
R528 R529 C516
FB517
LUG503
C532
R590
FB7504 R7517
D7503
FB7501 R7518
D7505
FB7502 R7516
D7506
IC501
R551
R552
R553
C533
R554
R555
C534
C535
R556
D512
D513
D514
R568
R567
C544 R601
C545 R607
C543
R608
R609
R604
R566
D519 R603
R564 R565
J501
J502
R582 R584
C559
LC-37D90U
93
10
LC-37D90U
10
11
12
13
14
15
94
16
17
18
19
Q1506
95
7
R1529
8
Q1510
Q1511
C1638
C1639
C1640
SC1503
9
C8507
R2044
R2048
R2080 C2013
R2053
C8508
FB8502
R2042
P9101
R9105
R9124
C8517
R8514
R2059
R2064
C2022
IC2004
R9303
C8516
C8520
L8501
R2046
R9128
C8511
C8522
L8502
10
C2016
R3344
R2041
R8179
R8147
D9004
R9302
R2055
R2056
R2054 TP2012
IC2006
R8518
R8538
C8528
C8529
R8519
C8510
C8526
R8558
D2003
R8162
R8169
R8352
R9654
D9612
D9611
C9650
C9621
R8542
C8532
IC2003
R2047
R2049
R2065
R8393
C9622
C9638
Q9601
C9608
C9651
C9620
C9653
C9655
L9602
C8530
C1540
C2023
R8346
R8529
R9101
R8343
R8532
R8535
R8384
R8190
R8191
R8319
R8317
R8332
R8350
R8194
R8145
D8102
R8168
R8144 D8101
R8342
IC8301
R8522
R8303
R8335
C8346
C9654
R8517 C8514
R9301
C2021
IC8303
C8513
R8513
C8515
C2025
R8336
C8345
C9606
R9617
C9602
R9614
C8525
TP9107
C2019
C8358
FB8501
C8349
R9613
C9605
R2612
C8523
C8501
R3352 C3411
R8347
C8307
C8352
C8502
Q1509
R2611
R8510 R8511
R8509
C8518
R8339
R8318
C8338
R9648
C9607
R2614
FL2611
FL2604
R2606
R2607
FL2603
FL2601
R2604
L2605
L2610
L2604
L2609
L2603
L2608
L2602
L2607
L2601
L2606
P9002
C8512
C8359
C8335
R2005
C8357
C9623
FB8503
R8340
C9617
C8503
C8321
C8339
C8340
L9604
C8504
R9315
R9337
R9336
TP9108
Q9607
IC8501
R1575
R9314
R9312 R9311
R9310 R9309
R8368
C3430
R9132
R8367
C9611
R9621
R1579
R9358
R9316
R9320
R9324
R9329
R9333
R9332
R9313
C9601 R9623
C9604 R9627
R9611
R9612
C9603
IC8502
C1530
R1550
R1578
R9344
R9345
R1565
R8372
C8327
R1569
TP9105
R8371
C3432
IC9603
R1566
R1567
R1570
C9103
R8379 C8319
R9127
R9305
R8301
C1529
C1641
R8378
R1574
R8383 C8305
C1528
D1507
R1577
R8382 C8313
R1549
Q1501
R1563
R1642
R1568
R1562
R8329
R1564
C8330
R8325
FB1506
R1601
R1595
R9318
C1525
R1560 R1645
C9102
C1527
TP9104
C1526
R3312
R3317
R1548
R9343
R9341
R9340
FB1507
IC1504
R9106
C8311 C8309
C9613
R9649
FB1508
C1643
R9355
R9354
R1573
R9342
D3301
D1512
R1580
R9348
R1513
C1531
TP9106
C1524
IC1507
R9325
R1627
C1523
C1541
R9317
TP1502
L1505
R9327
R9335
R9334
R1643 R1644
R1621
R1571
R1606
IC3302
R1561
X3301
D1508
C3370
IC1503
C8301
C8303
C3429
R1526
R1611
R1616
C8325 C8323
R3339
R3538
R3531
FB1509
R1632
FB3501
C1522
C8315
C8317
R3559
R9352 R9349
R9353
R3575
R1528
R1603
C1588
C1590
P9301
R3544
FB1505
R1559 R1633
C1521
R1620
R9326
R3340
R3518
C3501
R1525
D1519
C1561
C1560
R1572
C1610
C1612
C1600
C1604
VA1502
IC1508
R1610
VA1503
VA1501
R3341
R3514
R3570
L1501
C3323
VA1506
VA1504
R3308 R3310
R3359
R3572
R3530
R3573
R3535
R3515
R3522
L1502
R1617
R1635
R1615
R1613
VA1508
VA1507
C1621
C1622
C1618
C1619
VA1505
IC3301
R3320
R3318
L1504
L1503
C3420
C3409 R3346
X1501
R1626
C1620
R3342
R1612
R1631
R3347
C3396
C1617
R1630
L3306
C3385
FB1520
R3343
C3386
C3390
C3399
C3369
C3374
C3379
C3355
C3358
R3322
R3323
R3507
FB1517
C1603
C1605
C1595
C1598
R1618
R1629
L3305
L3304
C3354
C1556
L3302
R3540
FB2601
P2601
J8502
SC1501
Q1502
C1549
D1501
R1557
C3356 C3373
C3371
C1550
C1518
L1511
C1637
C3351
R3558
R3577
R3560
L1512
TL9033
R1628
R1599
R1600
C1564
C1565
R1622
R1609
R1607
R1608
R1614
k1
C1585
C3336
C3333
C3346
C3357
R3576
LUG1106
IC3501
L1513
R1516
C1563
C1562
E
L3301
C1543
R1551
C1596
C1599
C1520
R1636
R3555
R1169
R1170
P2602
J8501
R1555
C1554
C3339
C1544
C1537
C1552
FB1516
R3526
L1510
Q1508
C1551
C1536
R1505
B
D1523
R9655
R3302 C3319
R3552
R3545
R3511
R1519
D1511
FB1513
R3301
R3568
R3561
R3567
Q1507
C2029
R3303
R3313
IC3502
R1634
R1520
Q1505
L1509
IC1506
FB2003
C2028
D
C2027
R3350
R3319
P3301
R3565
L1506
FB2005
P2002
C2601
L1507
FB9007
L1508
P9007
R1502
D1514
k2
R3548
R1501
LUG1104
v1
k3
LC-37D90U
P2603
R2613
C9652
L9603
Q9
C964
R3501
C8332
R8351
R8392
R8105
R8389
R8388
R8324
C8353
R3306
R8311
R8341
R8320
R8355
R8396
R8397
R8356
R8385
TP8120
R8181
R8180
R8328
C8336
S8101
FB2004
tptp3
IC2005
TP2011
R2063
R2061 C2018
C2020
R2071
R2060 C2017
R2062
R2050
TP20
R8545
R8571
R8567
R8562
C8537
R854
C8509
SC1502
D1301
C1420
R8123
SC1301
R1409
Q1307
R1418
C2024
IC2007
R8125
TL1405
C1452
TL1406
R1424
R1422
C1451
C1454
FB8601
R1317
R1456 R1468
C1449
R1478
C8601
L8607
C8612
C8631
C8644
C8646
C8648
C8670
C8674
C8651
C8661
C8660
C8659
C8656
C8640
FB8607
C8675
C8610
C8621
C8620
L8604
C8615
L8605
C8630
C8629
L8606
L8603
C8634
C8639
C8638
C8637
L8602
FB8608
C8614
C8654
C8653
C8676
FB8602
L8608
R8619
R8614
C8602
C8607
L8601
IC8603
C8611
R8133
C1310
IC1401
C1403
C1401
C1405
R1425
R1411
R1414
R1445
R1412
R1436
R1440
R1443
R1447
R1444
C1453
FB8604
C8127
R8139
C8128
Q1308
IC1403
R1455
R8126
R8303
R1415
R1417
R8342
C1459
R1404
C8123
R8136
R8138
R1318
C1423
C1463
C1468 C1462
X1401
FB1402
IC8101
C1402
C1434
C1469
R1459
R8311
R8341
R8320
C1411
C1447
R8101
R1416
X1402
R1466
Q1401
R8103
C1484
R1405
R1402
C1448
R8118
C1483
C1406
C1410
R1433 R1408
R8105
R1428
IC1406
R1489
R8107
C1409
C1408
C1404
R1401
C1436
R8179
FB1408
R8102
R1403
C1407
R1471
C1421
R1406
C1412
FB1405
R8343
R1472
C1482
R8393
R8108
R1427
C1418
C1417
C1414
C1477
C1474
C1422
C1416
C1424
C1415 C1413
C1419
D1401
Q1402
FB1406
R1479
C1464
C9614
D9602
R1476
R9650
R1490
R9615
R1475
D9601
R9616
R9619
FB1301
D1302
IC1302
R1301
C1304
R1312 R1316
R1313
D1310
D1311
D9605
D9606
R1439
C9618
D9603
D9604
R9618
C1306
R1407
C1302
D1305
C9612
C9656
Q9605
FDC1
D1403
IC9602
L9603
C9649
L9601
C9615
LUG1102
IC1301
R1319
R1321
R1320
Q1302
C9619
Q9606
C9706
C9705
FB9701
C9704
FB9705
C9703
C9702
FB9704
FB9703
C9648
C9638
C9651
C9609
C9650
Q9601
C1305
C9701
FB9702
R9624
Q9602
D1307
P9702
P9701
R2613
9602
R1310
C1301
LUG1105
R1304
LC-37D90U
C1124
C8609
C1107
C8608
C1109
C1119
C1481
C1471
X8601
C1106
R8613
C8613
C8603
C8623
R8604
C8618
C8622
C8628
X8402
C8405
R8602
S8101
R8609 C8605
C8617 R8608 C8604
C8624
C8619
IC8601
C8401
C8403
R8410
R8170
R8401
FL8101
R8163
R8161
R8156
R8157
R8632
C8673
C8645
R2237
TP1101
C9004
IC9001
C1111
C1103
R8709
R8706
R8707
C8701
IC8701
C8703
C2026
R8703
R8722
R8701
R8720
R8721
R9005
R9006
C8702
C8708
IC1102
R8727
R1507
R1518
C1503
C1509
C1504
R1514
IC1408
C1512
FB1503
R1506
R1517
C1511
SC8701
LUG1101
C1487
C1510
R1503
R1512
C1508
C1480
R1438
R1515
FB1501
FB1504
C1501
R1434
C1507
R1509
FB1502 R1504
C1502
R8541
C1505
R1508
R2016
R2045
R2043
R8563
IC2008
R8579
R8575
R8564
C8705
R8711
R1118
C1112
C1114
C8704
L1105
L1102
C1113
P2001
R8580
R8551
P9003
R8549
C8535
R8561
R8562
L1101
R1125
R9033
R9032
C1110
R2017 R2030
C1478
D1402
J1501
J8502
J8501
IC1103
FL8501
L1402
10
C1118
C2006 R2012
R2004
R2013
C2007
R8570 R8574
C8533
C8530
R8558
R1101
J1502
L8502
TP2016
TP2002
R8578
R8573
R8566
R8565
C8525
R8529
C8523
C8526
C8522
C1131
R1107
C1101
R8571 R8569
R8567
R8532
R8535
C8511
L8501
R8542
C8532
C8534
R8550
R8517 C8514
C8513
R8513
C8515
R8510 R8511
R8509
C8518
R8514
TP2005
R8572
R8545
C8529
R8519
C8510
508
C8531
R8582
R8518
R8522
C8516
R8538
C8528
TP2009
R2033
R2032
R2070
R2040
TP2013
IC2006
R2002
R2031
C2023
R2050
C1120
TP2004
R2060 C2017
R2062
C8517
R1136
IC1104
R1135
C1115
R1108
IC1105
R2071
C2020
C8520
R1164
R1163
SC1102
R2255
R2063
R2061 C2018
IC2004
TU1101
R2236
IC2202
R2079
R2009
R2008
R2019
C1116
IC2002
C2211
R1510
C1506
R2046
C2016
R2047
R2049
R2059
R2064
C2022
C2001
R2018
R2078 R2020
R2042
R2044
R2048
R2080 C2013
IC2005
LUG1103
C2009
TP2011
IC2003
R1168
R1167
R2027
R2254
R2028
R2253
R2034
TP2003
X2001
C2011
FL2001
R2039
R2029
D2003
R2041
R2055
R2056
R2054 TP2012
CN9201
R9201
C1122
R8617
R8615
R8635
C1104
C8632
R8616
R8618
R8634
C8652
C8650
C8649
D8601
R9360
R9361
R8418
R8402
C8404
R8417
FL8404
R8414
FL8405
R8413
IC8402
IC8403
R8416 R8415
C8643
C8642
R8606
FL8406
C8658
C8657
C8655
R8147
R8184
R8162
R8169
R8194
R8145
D8102
R8168
R8144 D8101
R8190
R8191
R8149
R8181
R8180
SC1101
FB8605
C8626
C8625
TP8120
R8603
C8606
C8627
R9208
R8601
11
12
13
14
15
96
16
17
18
19
LC-37D90U
97
10
LC-37D90U
10
11
12
13
14
15
98
16
17
18
19
LC-37D90U
TL9701 TL9714
C9633
C9643
C9642
R9643
IC9607
C9645
R9640
C9639
C9647
C9644
R9646
C9717
R9639
R9638
R9715
C9708
R9702 R9701
R9714
TL9720
R1469
C1446
R1463
C1450
FB8801
R8826
R1470
R1465
IC1405
IC1404
FL8801
R9644
R9645
R9641
C9640
R9647
R9610
TL9723
FB9706
C9641 R9642
Q9603
C9646
IC9701
R8827
FL8802
R9
C9635
R9637
C9637
Q9604
R9634
R9632 C9630
C9712
L1401
C9634
R9635
C9631
D9608
R9633
R9625
IC9705
D9607
C9632
TL9601
D9610
C9707
R9713
TL9602
R9626
IC9606
C9629
R9631
TL9603
R9636
R9712
Q9701
Q9702
R9704
D9609
R9629
C9628
R9630
TL9724
C9714
C9711
D9702
R1311
C8808
TL1320
R9628
D9701
C1308
R8807
C8804
C8806
TL1319
R1305
C8805
TL1318
R1314
IC8801
C8807
R9003
TL9709
R1315
C1303
C8801
R8802
R8801
C8802
R8804
R8803
R8832
C8803
R8825
R8805
R8833
R8812
C8818
R8818
R8814
TL1317
TL9705
R9705
C9715
Q1306
Q1303
Q1304
C8809
R8809 C8814
C8821
R8823
C8810
R8810
C8813
IC8803
TL1330
R8821
C8823
TL1316
C8820
R8820
C8822
R8822
TL1331
TL1166
D1312
C8819
TL1315
D1308
R1308
D1309
R8813
R8815
C8817
R8816
D1303
IC8802
C8815
L8801
C8812
D1306
R1323
D1304
C8811
IC1303
R1306
R1307
R9008
TL9712 TL9718 TL9708 TL9715 TL9711 TL9717 TL9702 TL9703 TL9716 TL9710
TL9706
Q1301
R1302
R1322
R1309
R8811
R8808
FDC2
TL2622
TL9713
TL9719
TL9707
R1303
FL2610
TL1321
C1486
TL1322
TL1323
TL1403
C1485
C1432
R1441
R1413
C1429
R8114
R8121
R8117 C8113 C8152 C8111 C8117
C8115
R8309
C8153
C8119
C8138
R8817
C8139
R8167 R8166
R8151
R8150
R9004
R9007
R8165
C8144
R8164
R8189
R8177
R8155
R8349
R8178
R8196
R8407
C8402
R9203
TL9203
Q1104
R9204
TL9204
TL8451
R1109
R8469
R2076
D8451
R8453
R2015
R2014
R2011
R2052
C2014
C2015
R2051
R8583
R8584
Q8502
IC8454
C9005
IC9002
R9017
C8505
R8515
R8516
R8521
R8520
TL1542
TL8515
TL8514 TL8512
TL8509 TL8507
TL8513 TL8511
TL8708
TL1407
TL1408
TL8508 TL8506
TL1404
TL8706
TL1543
TL1540
99
C8519
TL8707
TL8704
R8568
R8555
R9031
R8525
R8526
R8534
R8533
TL8709
TL9024
R8527
R8528
R8530
R8537
R8536
R8544
R8543
R8548
R8547
C8710
TL8705
TL8703
TL8702
R8502
R8501
TL2013
TL1541
TL1539
TL8701
TL9026
R9030
TL1538
C8506 R8507
TL9027
TL2011
TL2014
TL8712
R8508
TL9030
TL9028
TL2012
TL2017
TL9031
TL9029
IC8503
R8576
TL2009
TL2010
R1166
C8709
R8723
C8711
R8724
R8725
R8726
R8728
R8704
R8708
R85
R8577
C8457
R8459
C8459
R8458
R8713
TL2007 TL9032
TL2008
TL9025
FB8701
R8512
TL2006
R8702
TL8710
R9010
TL8453
TL8711
R8705
R8581
R8504
TL1185
C8707
IC8702
R8505
R8554
R8552
R8556
R8553
R8710
C8706
C8455
IC8453
C8451
TL8518
TL8517
R8546
R9016
TL1101
R8559
TL8520 TL8516
C8539 C8536 R8557
R9011
TL1126
R8714
R8715
R8716
R8717
R8718
R8719
IC8504
R9018
TL1128
R1102
TL8519
C8538
TL1130
Q8501
TL1121
TL1129
R8470 C8460
C8462
TL1131
R8474
R8475
C8461
TL1134
IC8451
R2006
R2001
R9014
R9015
R2022
R2021
TL1133
TL1132
Q8452
R2035
Q2006
R2003
TL1103
TL1136
C8453
R8452
C2004
C1105
TL1102
Q8451
C2005
R8467
C8452
R8451
R2010
C9006
TL1104
TL1138
R2023
R2024
R9012
R1106
TL1137
Q9003
TL1105
TL1135
C2010
R9013
TL1106
TL1142
C2012
TL1141
TL1139
D2004
Q2001
R2026
R2025
CF1101
TL1107
TL8452
Q2007
C2008
TL1108
R2036
R2038
R2037
IC2001
C2002
R2007
TL1109
C2003
R1160
TL9205
TL9206
C1136
FB1101
R1116
R1117
TL1110
C1102
R1131 C1127
R1129
R1133
R1130
TL1143
C8145
IC8102
R8185
IC8401
R9202
Q1103
Q1105
R1103 R1104
R1141
TL9202
R1165
C1117
R1124
TL1111
TL1127
TL1140
R8358
R8399
FL8102
R8628
C8662
TP8119
R8143
C8143
R8141
D1104
R1121
R1132
Q1108
C1132
IC1101
TL1112
R1127
R1122
TL1145
TP8105
TL1114
C1123
TL1144
R8154
R8305 R8307
TP8118
TP8107
TL9201
Q1102
TL1147
R8310
TP8603
C8663
R8412
TH2001
TL1149
R8304
R8306
R8137
R8148
TL1153
TL1151
R8113
C8101
C8147
R8159
FL8403
R8405
TL1115
TL8801
R8160
FL8401
R8626
R8624
TL8606
C8672
R8638
R8622
R8623
TL8601
R8621
TP8606
C8665
C8664
R8411
TL8605
TL8604 TL8607
TL8603
R8605
R8627 TP8604
R8631
R8408 R8404
TL8602
R8620
R8637
R8636
Q8601
R8633
TL1116
C1121
R1110
C8126
C8142
Q1109
R1111
R1139
R1134
R1105
TL1117
C8666
TP8602
FL8402
TP8605
TL8608
TL1118
TL1156
TL1155
C8140
R8200
R8406 R8403
TL8609
R8629
C1108
R1114
R8625
C1133
R1143
TL1157
C1134
R1142
TL1119
R8153
R9206
TP8601
R8630
TL8610
TL1122
C8131
C8141
TL1123
TL1160
TL1158
C8137
C8136
R8158
R9207
TL1162
TL1161
C8148
C8122
R9205
C8669
C8668
C8667
TL1163
TL1159
TL8101
C8135 C8133
C8129 C8134
C8647
C8636
C8635
C8633
TL1168
R8182
C8120
TP8901
R8140
C8641
TL1171
TL1169
C8146
TP8902
TL8103
TL8102
FL8105
C8124
R8607 FB8606
TL1172
R8819
R8640
R8639
C8616
TL1173
R8130
R8131
C8116
C8118
D8103
R8135
R8134
TP8104
R8902
R8903
R8142
TL1170
TL1174
R8132
R8146
R8128
TP8110
R8192
R8193
C8112
R8124
C8114
TP8106
TP8103
C8105
C8110
R8127
R8129
TP8102
C8104
R8116
R8122
C8671
R1500
R1494
C1476 R1498
R1448
R1452
IC8602
R1115
C1135
TL1146
C9713
IC9703
R1484
R1488
TL1175
R8176
R8111
R9703
R1437
R1487
C1475
R1491
R1497
IC1407
C1479
C8102 C8103
R8152
R1492
R1499
TL1154
TL1150
R8119
TL9722
R1483
R1482
R1481
C1458
C1457
R1480
C1461
C1460
R1419
R1421
C1470
TL1148
C9710
R1467
TL1176
TL1152
R8834
C1440
R8106
R8104
R8172
R1449
R8115
TP8101
R8120
TL1329
R8109
R8186
R8112
R1442
R1446
TL1328
C1430
R1423
R1429
R1432
R1451
R1454
R1458
R1462
TL1326
TL1327
R1420
R1426
C1431
TL1325
R8187
R9307
R9308
R1410
R8110
TL1324
10
TL8510
LC-37D90U
TL2634
TL2623
TL2645
TL2644
TL2646
TL2626
TL2637
FL2602
R2615 R2616
C3518
R3504
R3532
R3505
C3514
C3537
C3516
C3508
C3515
R2602
C3506
C3503
C3507
C3504
C3517
R9652
C3502
R3517
C9616
Q9608
C9610
C9643
R9643
C9642
Q9603
Q9609
C3539
R9653
TL2630
TL2631 TL2629
C3505
R9651
TL9607
C9641 R9642
TL2638
TP2601
TL2624
TL2625
IC9605
R2601
R9644
R9645
TL2640
R2605
R2608
FL2605
FL2606
R2609
R2610
R9001
C9626
C9634
C9627
D9005
FL2607
R9002
TL2627
C3513
TL2641
D9001
R9019
C9633
R9636
R9637
R9023
R9022
FB9004
FB9003
FB9006
FB9005
FL2608
FL2610
FL2609
TL9608
R9601
C9635
C9002
TL9047
TL2636
TL2628
R9003
TP2602
IC9003
R9021
D9003
D9002
C9001
TL2622
R9008
R3520
R9640
R3537
R3529
R3523
R9641
C9640
R3533
C9639
R9639
R9638
C3431
IC8305
R3513
TL9609
R3502
R3528
R3516
R3509
R3524
R3571
C3535
C3532
C3533
C3526
R3506 R3562 C3536
R3503
R3305
R2215
L2201
C2204
R2209
X3302
X3303
R3373 C3364
IC3304
FB9008
C1575
D1513
D1509
TL1537
TL1519
IC1501
tptp1
R1535
R1530
TL1534
R1532
Q1514
D1505
C1513
FB1510
R1546 R1604
C1515
TL1508 TL1512
tptp2
TL1535
C1516
TL1513
D1506
R1527
Q1515
R1594
C1514
C1545
TL1518
IC1502
FB1511
C1546
C1547
C1579 R1537
TL1510
D1502
C1587
R1593
C1548
R1556
D1515
C1586 R1543
R1542
R1538
C1578 R1534
R1533
D1510
TL1523
Q1504
R1637
TL9034
TL1527
D1503
TL1536
TL8510
TL1521
TL1501
TL1520
TL8513 TL8511
C2205
Q2208
C3387 R3374
IC3303
R1624
FL1501
R1539
R1536
Q1503
TL1522
TL1517 TL1511
R1547
R1552
R1540
C1519
C1517
R1553
TL9043
C1613
C1614
IC1505
Q1513
R1554
TL8504
D1520
TL8505
FB1512
TL8509 TL8507
R1589
R1588
C1582
C1583
R1587
R1586
R1585
TL8514 TL8512
C1532
R8515
R8516
R8521
R8520
R8525
R8526
R8534
R8533
R8527
R8528
R8530
TL1516
C1533
TL8503
C1558 R1605
C1555
R1531
R1545
D1516
R1596
R1597
R1598
C1534
D1517
R1583
D1504
D1518
Q1512
D1522
C1535
D1521
D1524
C1597
C1592
Q1516
C1608
Q1517
C1589
C1591
R1584
R1591
C8505
TL8501
TL9312
TL8502
C8519
C1615
C1616
TL9344
R1590
R1646
L1530
TL9302
TL9346
TL9345
TL1531
TL1532
X8501
C8506 R8507
R8508
TL2002
TL8455
C1542
C1538
TL1533
TL9332
C1634
TL9354
FB1515
IC8503
TL2003
C1623
C1624
C1553
TL9333
TL9355 TL9356
R1602
TL9334
R9304
TL9350
TL9348
TL9347
TL9335
C1559
R9321
R9357
TL9331 TL9349
TL9310
TL9306
C1577
R9319
TL9303
R9330
R9126
R9125
R9118
R9356
TL9309
TL9339
TL9336
C1539
TL1524
TL9338
TL9337
R9322
TL9304 TL9308
TL8454
C1593
C1602
R9130
R9108
R9122
TL9314
TL9305
C1633
R9347
R9346
R9351
R9350
C9106
C9107
TL9343
C1584
C1581
TL9353
TL9340
C1628
C1627
C1625
C1626
R9109
R8506
C9108
TL9307
TL9317 TL9313
IC8505
C8540
R8503
R8512
R9323
C1611
C1607
FB1519
TL9357
TL9341
R9338
R9339
TL9316 R9331
C1609
C1606
FB1521
TL9358
TL9342
R1623
C1630
C1629
C1580
C1576
IC8451
TL1526
TL9352 TL9321
TL9324
TL9320
TL9315 TL9311
TL2004
C3317
TL1528
TL1530
C1631
C1632
FB1518
C1557
R8453
C1566
TL9326
TL9327
C1594
C9104
Q8452
TL1525
R9328
R8504
C1601
FB1522
TL9319
TL2005
R3354
TL1529
TL9328
TL9322
C8451
TL3302
C2202
R3353
R3372
TL9325
TL9329
TL9323
R8581
C2206
R2214
C2208
R2221
FB3309
R9116
TP9101
TL8518
R2204 R2208
C2230
Q2201
C2234
R9112
R9113
R9131
C9101
R9107
R9111
TL1164
TL9318
R8505
TL3301
TL3303
TL9103
C9105
R8559
R2222
Q2207
Q2204
C2231
R2201
R2205
R8337
TL9104
TL9105
TL9102 TL9101
TL8517
L2202
C2229
R2206 R2202
Q2202
L2203
C2209
R2219
C8351
Q8451
R8468
IC9101
8557
R3307
R2212
C3325
R2052
C2014
C2015
R2051
8516
R3311
C2203
FB3302
FB3303
Q2209
C2210
C2233
R2217
R8374
Q2205
R2213
R8196
R8331
C2207
R2223
C3344
C3348
Q2206
C8326 C8324
R8349
R8178
R2203 R2207
R3316
R3325
R2224
R2218 R2216
C2232
R8314
R8316
C8144
R8164
R2220
R2211
C3312
C3338
R3324
R3326
L3303
L3307
C3405
C3305
C3343
C3360
Q2203
R8376
C8350
C8453
C3538
R3327
R3332
R3335
R3371
C8318
R8348
R9004
R9007
R8165
R8467
R3569
R3321
R3304
C3308
C3347
C3345
C3326
C8452
R3563
R3309
C3327
C3394
R3338
C3398
FB3304
IC8304
R8452
C3524
R3554
C3321
C3307
R3328
R3337
C3322
C8343
R8451
C3534
C3523
C3520
R3315
R3314
TP3304 TP3303
R2210
C8328
C3522
TL3504 TL3503
C3324
C3341
C3350
R3330
C3362
C3353
C3376
R3331
C3382
C3361 R3329
C3383
C3433
C3359
C3377
C3384
R3333
C3408
C3349
C3363
C3372
C3388
C3401
C3392
C3403
R3334
C3434
C3313
C3315
C3352
C8334
C8342
R8387
R3550
R3542
C3332
C3340
C3375
C3378
C3402
C3397
C3395
C3367
C3404
FB3305
C8320 R8377
C3368
C3365
C3410
FB3306
R8330
C8316
R8373
C8322
R8386
R8398
R8357
R8358
R8399
C3381
C3389
C3419
C3406
C3316
C3301
C3414
C8344
R8338
R8167 R8166
R8143
C8143
R8141
C3412
C3310
C3366
C3380
C3393
C3413
C3415
C8356
TP8119
C3426
C3424
C3425
R8309
C8119
C8153
TP8118
C3407
R3345
C8341
TP8105
C3302
C3309
R3336
R3370
R3358
R8333
C8355
C8115
C3391
R8310
TP8107
C3521
C3525
FB3301
R8327
C8354
R8375
R3553
R3547
R3546
FB3308
C8314 R8380
C8337
R8305 R8307
C3318
C3306
C3328
C8312 C8310
R8345
R8370
R8391
C3531
R3574
FB3307
IC8302
R8354
R8395
R8304
R8306
C3320
C3418
C3422
C3304
C3314
C3331
C3337
C3311
C3303
C3335
C8304
R8121
8109
R3367
R3369
R3368
C3334
C3342
C3329
R3357
R3363
R3365
R3364
R3360
R3362
C3330
R3361
C3421
C3416 C3417
C3423
R3366
C8306 R8381
R8315
R8313 C8333
R8344
R8114
R8394
R8353
C3427 R3349
C3428
R3356
R3355
C8302
R8326
R8369
TP8101
TP3302
R3348
R3351
R8390
C8308
R8176
R8334
C8348
C8329
R8110
C8347
TL1509
TL8508 TL8506
TL1503
TL1504
TL1507
TL1505
TL1502
10
11
12
13
14
15
9 10
16
17
18
19
LC-37D90U
D102
Q101
R106
C104
R111
D101
R110
R105
D103
Q103
R112
Q102
R109
R108
R104
R107
IC101
C103
SLD101
R101
RMC101
Q104
R102
R115
C101
P101
C102
9 11
LC-37D90U
9 12
LC-37D90U
MEMO
9 13
LC-37D90U
PartsGuide
PARTS GUIDE
No. S56S8LC37D90U
Note:
The reference numbers on the PWB
are arranged in alphabetical order.
Please exchange MAIN unit, when you
exchange IC8301, IC8302, IC8303,
IC8304 and IC8453.
MODEL
LC-37D90U
CONTENTS
[1]
[2]
[3]
[4]
[5]
[6]
[7]
DUNTKD744WE01 (SPEAKER
TERMINAL-L Unit)
[8]
DUNTKD745WE01 (SPEAKER
TERMINAL-R Unit)
[9]
Parts marked with " " are important for maintaining the safety of the set. Be sure to replace these
parts with specified ones for
This document has been published to be used
for after sales service only.
The contents are subject to change without notice.
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
[2] LCD PANEL (NOTE: THE PARTS HERE SHOWN ARE SUPPLIED AS AN ASSEMBLY BUT NOT INDEPENDENTLY.)
R1LK370D3LZ1AB
AD
AB
AA
AC
AB
AG
AD
AG
AD
AB
AB
AA
AA
AA
AA
AA
AA
AA
AE
AD
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
AC
AC
AB
AC
AC
AB
AC
AC
AB
AC
AC
AA
AA
AA
AA
AC
AA
AF
AA
AA
AA
AC
AA
AA
AA
AA
AA
AA
AB
AB
AB
AB
AB
AA
AA
AA
AA
AD
AA
AA
AA
AF
AB
AB
AA
AC
AA
AB
AB
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
EZ
VCERMZ1CN107MY
VCKYTV1CF225ZY
VCKYCY1HF103ZY
VCEASX1CN106MY
RH-EXA092WJZZY
RH-PXA087WJZZY
RH-PX0421CEZZY
VHiTPS850++-1Y
QPLGNA331WJZZY
VS2SC3928AR-1Y
VS2SC3928AR-1Y
VRS-CY1JF101JY
VRS-CY1JF000JY
VRS-CY1JF273JY
VRS-CY1JF221JY
VRS-CY1JF103JY
VRS-CY1JF161JY
VRS-CY1JF000JY
RRMCUA053WJZZ
PSLDM4646CEFW
VCKYTV1CB105KY
VCKYTV1CB105KY
RC-KZA510WJPZY
VCKYTV1CB105KY
VCKYTV1CB105KY
RC-KZA510WJPZY
VCKYTV1CB105KY
VCKYTV1CB105KY
RC-KZA510WJPZY
VCKYTV1CB105KY
VCKYTV1CB105KY
VCKYCY1EF104ZY
VCKYCY1HB103KY
VCKYCY1HB103KY
VCKYCY1HB103KY
VCKYTV1CB105KY
VCKYCY1EF104ZY
VCAAPF1CJ396MY
VCKYCY1EF104ZY
VCKYCY1EF104ZY
VCKYCY1EF104ZY
VCERML1CN226MY
VCKYCY1EF104ZY
VCKYCY1EF104ZY
VCKYCY1EF104ZY
VCKYCY1EF104ZY
VCKYCY1EF104ZY
VCKYCY1EF104ZY
VCKYCH1CB104KY
VCKYCH1CB104KY
VCKYCH1CB104KY
RC-KZA510WJPZY
VCKYCH1CB104KY
VCKYCY1EF104ZY
VCKYCY1EF104ZY
VCKYCY1EF104ZY
VCKYCY1EF104ZY
VCERMZ1CN107MY
VCKYCY1EF104ZY
VCKYCY1EF104ZY
VCKYCY1EF104ZY
VCAAPF1CJ396MY
RC-KZA154WJZZY
RC-KZA154WJZZY
RC-KZA104WJZZY
RC-KZA109WJZZY
VCKYCY1EF104ZY
VCKYCH1CB104KY
VCKYCH1CB104KY
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
VCKYCY1EF104ZY
VCKYCY1HB222KY
VCKYCY1HB222KY
RC-KZA104WJZZY
RC-KZA104WJZZY
VCKYCY1EF104ZY
RC-KZA104WJZZY
VCKYCY1EF104ZY
VCKYCY1EF104ZY
VCKYCY1EF104ZY
VCKYCY1EF104ZY
VCERMZ1EN227MY
VCKYCY1EF104ZY
VCKYCY1EF104ZY
VCERMZ1EN227MY
VCKYCY1EF104ZY
VCKYCY1EF104ZY
VCKYCY1EF104ZY
VCKYCY1EF104ZY
VCKYTV1EB474KY
VCKYTV1EB474KY
VCKYTV1EB474KY
VCKYTV1EB474KY
VCKYTV1EB474KY
VCKYTV1EB474KY
VCKYCY1HB104KY
VCKYCY1HB104KY
VCCCCY1HH151JY
VCCCCY1HH151JY
VCKYCY1HF223ZY
VCERML1CN476MY
VCKYCY1HB104KY
VCKYCY1HB104KY
VCKYCY1HB104KY
VCKYCY1HB104KY
VCCCCY1HH151JY
VCCCCY1HH151JY
RC-KZA109WJZZY
VCKYCY1EF104ZY
RC-KZA212WJZZY
RC-KZA212WJZZY
RC-KZA212WJZZY
RC-KZA212WJZZY
RC-KZA212WJZZY
RH-EX1400CEZZY
RH-EX1400CEZZY
RH-EX1400CEZZY
RH-EX1400CEZZY
RH-EX1400CEZZY
RH-EX1400CEZZY
VHDDAN217U+-1Y
VHDDAN217U+-1Y
VHDDAN217U+-1Y
RH-EX1400CEZZY
VHDLi114+++-1Y
VHDLi114+++-1Y
VHDLi114+++-1Y
VHDLi114+++-1Y
RH-EX1283CEZZY
RH-EX1283CEZZY
RH-EX1283CEZZY
RH-EX1283CEZZY
VHD1SS355//-1Y
VHDMA3120WA-1Y
VHDMA3120WA-1Y
RBLN-A204WJZZY
RBLN-A204WJZZY
RBLN-A204WJZZY
RBLN-0065TAZZY
RBLN-0065TAZZY
RBLN-A204WJZZY
RBLN-0065TAZZY
RBLN-0065TAZZY
RBLN-A204WJZZY
RBLN-0065TAZZY
RBLN-0065TAZZY
RBLN-A204WJZZY
RBLN-A204WJZZY
RBLN-0039TAZZY
RBLN-0237TAZZY
RBLN-0237TAZZY
RBLN-0237TAZZY
RBLN-A049WJZZY
RBLN-0064TAZZY
RBLN-0064TAZZY
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AE
AA
AA
AE
AA
AA
AA
AA
AC
AC
AC
AC
AC
AC
AA
AA
AA
AA
AB
AC
AA
AA
AA
AA
AA
AA
AC
AA
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AC
AC
AC
AC
AB
AB
AB
AB
AB
AD
AD
AA
AA
AA
AA
AA
AA
AB
AB
AB
AB
AB
AB
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
RBLN-0064TAZZY
RBLN-0064TAZZY
RBLN-0060TAZZY
RBLN-0060TAZZY
RBLN-0252TAZZY
VHiMM1630CQ-1Q
VHiTA2024++-1Y
VHiUPD4721G-1Y
QTANJA092WJZZ
QTANJA095WJZZ
QSOCDA020WJZZ
VPCEM100MR70NY
RCiLPA001WJZZY
RCiLPA001WJZZY
RCiLPA001WJZZY
RCiLPA001WJZZY
QLUGHA006WJZZY
QLUGHA006WJZZY
QLUGHA006WJZZY
QLUGHA006WJZZY
QLUGHA006WJZZY
QPLGNA345WJZZY
QPLGNA173WJZZY
QCNCMA250WJZZ
VS2SA1530AR-1Y
VS2SC3928AR-1Y
VS2SA1530AR-1Y
VS2SC3928AR-1Y
VS2SA1530AR-1Y
VS2SC3928AR-1Y
VSDTC314TK/-1Y
VSDTC314TK/-1Y
VS2SA1530AR-1Y
VSRT1N141U/-1Y
VSDTC314TK/-1Y
VS2SC3928AR-1Y
VRS-TQ2BD750JY
VRS-CY1JF102JY
VRS-TQ2BD750JY
VRS-CY1JF102JY
VRS-TQ2BD750JY
VRS-CY1JF102JY
VRS-CY1JF221JY
VRS-CY1JF104JY
VRS-CY1JF221JY
VRS-CY1JF104JY
VRS-TQ2BD750JY
VRS-CY1JF221JY
VRS-CY1JF104JY
VRS-TQ2BD750JY
VRS-CY1JF221JY
VRS-CY1JF104JY
VRS-CY1JF221JY
VRS-CY1JF104JY
VRS-CY1JF221JY
VRS-CY1JF104JY
VRS-CY1JF102JY
VRS-TQ2BD750JY
VRS-CY1JF274JY
VRS-CY1JF103JY
VRS-TQ2BD750JY
VRS-CY1JF101JY
VRS-CY1JF220JY
VRS-CY1JF220JY
VRS-CY1JF220JY
VRS-CY1JF101JY
VRS-CJ1JF470JY
VRS-CY1JF223JY
VRS-CY1JF101JY
VRS-CY1JF223JY
VRS-CY1JF101JY
VRS-CY1JF223JY
VRS-CY1JF223JY
VRS-CY1JF331JY
VRS-CY1JF331JY
VRS-CY1JF000JY
VRS-TV1JD102JY
VRS-CY1JF820JY
VRS-CY1JF331JY
VRS-CY1JF331JY
VRS-CY1JF000JY
VRS-TV1JD102JY
VRS-CY1JF820JY
VRS-CY1JF331JY
VRS-CY1JF331JY
AB
AB
AB
AB
AA
AS
AX
AN
AC
AC
AF
AF
AF
AF
AC
AC
AC
AC
AC
AD
AD
AE
AB
AB
AB
AB
AB
AB
AC
AC
AB
AB
AC
AB
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
IC, MM1630CQ
IC, TA2024
IC, UPD4721GS-GJG-E1
Jack
Jack
Socket
Coil, Peaking 10H
Coil
Coil
Coil
Coil
Lug
Lug
Lug
Lug
Lug
Plug, 11pin
Plug, 4pin (SP)
Plug, 23pin
Transistor, 2SA1530A-T112-1R
Transistor, 2SC3928A-T112-1R
Transistor, 2SA1530A-T112-1R
Transistor, 2SC3928A-T112-1R
Transistor, 2SA1530A-T112-1R
Transistor, 2SC3928A-T112-1R
Transistor, DTC314TKT146
Transistor, DTC314TKT146
Transistor, 2SA1530A-T112-1R
Transistor, RT1N141U-T111-1
Transistor, DTC314TKT146
Transistor, 2SC3928A-T112-1R
Resistor, 75 1/8W Metal Oxide
Resistor, 1k 1/16W Metal Oxide
Resistor, 75 1/8W Metal Oxide
Resistor, 1k 1/16W Metal Oxide
Resistor, 75 1/8W Metal Oxide
Resistor, 1k 1/16W Metal Oxide
Resistor, 220 1/16W Metal Oxide
Resistor, 100k 1/16W Metal Oxide
Resistor, 220 1/16W Metal Oxide
Resistor, 100k 1/16W Metal Oxide
Resistor, 75 1/8W Metal Oxide
Resistor, 220 1/16W Metal Oxide
Resistor, 100k 1/16W Metal Oxide
Resistor, 75 1/8W Metal Oxide
Resistor, 220 1/16W Metal Oxide
Resistor, 100k 1/16W Metal Oxide
Resistor, 220 1/16W Metal Oxide
Resistor, 100k 1/16W Metal Oxide
Resistor, 220 1/16W Metal Oxide
Resistor, 100k 1/16W Metal Oxide
Resistor, 1k 1/16W Metal Oxide
Resistor, 75 1/8W Metal Oxide
Resistor, 270k 1/16W Metal Oxide
Resistor, 10k 1/16W Metal Oxide
Resistor, 75 1/8W Metal Oxide
Resistor, 100 1/16W Metal Oxide
Resistor, 22 1/16W Metal Oxide
Resistor, 22 1/16W Metal Oxide
Resistor, 22 1/16W Metal Oxide
Resistor, 100 1/16W Metal Oxide
Resistor, 47 1/16W Metal Oxide
Resistor, 22k 1/16W Metal Oxide
Resistor, 100 1/16W Metal Oxide
Resistor, 22k 1/16W Metal Oxide
Resistor, 100 1/16W Metal Oxide
Resistor, 22k 1/16W Metal Oxide
Resistor, 22k 1/16W Metal Oxide
Resistor, 330 1/16W Metal Oxide
Resistor, 330 1/16W Metal Oxide
Resistor, 0 1/16W Metal Oxide
Resistor, 1k 1/16W Metal Oxide
Resistor, 82 1/16W Metal Oxide
Resistor, 330 1/16W Metal Oxide
Resistor, 330 1/16W Metal Oxide
Resistor, 0 1/16W Metal Oxide
Resistor, 1k 1/16W Metal Oxide
Resistor, 82 1/16W Metal Oxide
Resistor, 330 1/16W Metal Oxide
Resistor, 330 1/16W Metal Oxide
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
VRS-CY1JF000JY
VRS-TV1JD102JY
VRS-CY1JF820JY
VRS-CY1JF561JY
VRS-CY1JF561JY
VRS-CY1JF564JY
VRS-CY1JF564JY
VRS-CJ1JF102JY
VRS-CY1JF473JY
VRS-CY1JF473JY
VRS-CY1JF332JY
VRS-CY1JF000JY
VRS-CY1JF102JY
VRS-CY1JF101JY
VRS-CY1JF000JY
VRS-CY1JF101JY
VRS-CY1JF000JY
VRS-CY1JF103JY
VRS-CY1JF101JY
VRS-CY1JF101JY
VRS-CY1JF101JY
VRS-CY1JF000JY
VRS-CY1JF103FY
VRS-CY1JF103FY
VRS-TV1JD000JY
VRS-CY1JF822FY
VRS-CY1JF333JY
VRS-CY1JF183FY
VRS-CY1JF223FY
VRS-CY1JF183FY
VRS-CY1JF223FY
VRS-TV1JD000JY
VRS-CY1JF105FY
VRS-TW2HF100JY
VRS-TW2HF100JY
VRS-CY1JF102FY
VRS-CY1JF104JY
VRS-CY1JF000JY
VRS-CY1JF000JY
VRS-CZ1JF000JY
VRS-CZ1JF000JY
VRS-CZ1JF000JY
VRS-TV1JD101JY
VRS-TV1JD101JY
QCNCMA250WJZZ
QCNCMA250WJZZ
QSOCN0437FJZZ
RRLYDA002WJZZY
RUNTZA050WJQZ
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AE
AE
AM
AK
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
Diode, MTZJT-7215B
Diode, MTZJT-7215B
Diode, MTZJT-7215B
Plug, 4pin (KM)
Resistor, 8.2k 1/8W Carbon
Resistor, 12k 1/8W Carbon
Resistor, 8.2k 1/8W Carbon
Switch, CH-UP
Switch, CH-DOWN
Switch, INPUT
Switch, VOL-UP
Switch, VOL-DOWN
Switch, POWER
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
RH-EX0646GEZZY
RH-EX0646GEZZY
RH-EX0646GEZZY
QPLGNA058WJZZ
VRD-RA2BE822JY
VRD-RA2BE123JY
VRD-RA2BE822JY
QSW-K0003AJZZ+
QSW-K0003AJZZ+
QSW-K0003AJZZ+
QSW-K0003AJZZ+
QSW-K0003AJZZ+
QSW-K0003AJZZ+
AA
AA
AA
AC
AA
AA
AA
AB
AB
AB
AB
AB
AB
VCKYCZ1EF104ZY
VCKYCZ1EB103KY
VCAAPE0JJ107MY
RC-KZA104WJZZY
VCKYCZ1EB103KY
VCKYCZ1EF104ZY
VCAAPE0JJ107MY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
RC-KZA237WJZZY
VCKYCZ1EB103KY
VCKYCZ1EB103KY
VCERML1CN476MY
VCKYCZ1EB103KY
VCKYCZ1HB102KY
RC-KZA237WJZZY
VCKYCZ1HB102KY
VCKYCZ1HB102KY
AA
AA
AE
AA
AA
AA
AE
AA
AA
AA
AB
AA
AA
AC
AA
AB
AB
AB
AB
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
VCKYCZ1EF104ZY
VCERMZ1CN477MY
RC-KZA069WJZZY
VCKYCY1AB105KY
VCKYCZ1EF104ZY
VCERMZ1VN227MY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
RC-KZA030WJZZY
VCKYTV1CB105KY
VCKYCY1AB334KY
VCKYTV1CB105KY
RC-KZA030WJZZY
VCKYCZ1AB104KY
VCKYCZ1CB223KY
RC-KZA383WJZZY
RC-KZA508WJQZY
RC-KZA030WJZZY
RC-KZA069WJZZY
VCKYCZ1HB102KY
VCKYCZ1AB104KY
VCKYCZ1CB333KY
VCKYCY1CB224KY
VCKYCZ1AB104KY
RC-KZA030WJZZY
VCKYCY1AB334KY
VCKYCZ1EF104ZY
VCERML1CN476MY
VCKYCZ1EF104ZY
RC-KZA237WJZZY
VCCCCZ1HH330JY
VCCCCZ1HH330JY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
RC-KZA237WJZZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCERML1CN106MY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCAAPC1CJ335MY
VCKYTV1CB105KY
VCKYTV1CB105KY
VCERMZ1CN107MY
VCKYTV1CB105KY
VCKYTV1CB105KY
VCKYCZ1EF104ZY
VCCCCZ1HH220JY
VCCCCZ1HH220JY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
VCERML1CN476MY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCCCCZ1HH101JY
VCCCCZ1HH101JY
VCCCCZ1HH6R0DY
RC-KZA237WJZZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCERMZ1CN107MY
VCCCCZ1HH6R0DY
RC-KZA237WJZZY
VCKYCZ1EF104ZY
RC-KZA237WJZZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1HB221KY
VCKYCZ1HB221KY
VCKYCZ1HB221KY
VCKYCZ1HB221KY
VCKYCZ1HB102KY
VCKYCZ1HB102KY
VCKYCZ1HB102KY
VCKYCZ1HB102KY
VCKYTV1CB105KY
VCKYTV1CB105KY
VCKYTV1CB105KY
VCKYTV1CB105KY
RC-KZA237WJZZY
RC-KZA237WJZZY
VCKYCZ1EB103KY
VCKYCZ1EB103KY
AA
AE
AB
AB
AA
AD
AA
AA
AB
AC
AB
AC
AB
AB
AC
AC
AC
AB
AB
AB
AB
AA
AB
AB
AB
AB
AA
AC
AA
AB
AB
AB
AA
AA
AB
AA
AA
AA
AC
AA
AA
AE
AC
AC
AD
AC
AC
AA
AB
AB
AA
AA
AB
AC
AA
AA
AB
AB
AA
AB
AA
AA
AD
AA
AB
AA
AB
AA
AA
AA
AA
AA
AA
AB
AB
AB
AB
AC
AC
AC
AC
AB
AB
AA
AA
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
RC-KZA237WJZZY
RC-KZA237WJZZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCCCCZ1HH470JY
VCCCCZ1HH470JY
RC-KZA237WJZZY
VCKYCZ1EF104ZY
VCKYCY1HB103KY
RC-KZA154WJZZY
VCKYCY1HB103KY
RC-KZA154WJZZY
VCKYCY1HB103KY
RC-KZA154WJZZY
RC-KZA115WJZZY
RC-KZA237WJZZY
VCKYCZ1EB103KY
RC-KZA237WJZZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCERML1CN476MY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCAAPE0JJ227MY
VCAAPE0JJ107MY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
RC-KZA237WJZZY
VCKYCZ1EF104ZY
RC-KZA237WJZZY
VCAAPE0JJ227MY
VCKYCZ1EF104ZY
RC-KZA237WJZZY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
RC-KZA237WJZZY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
RC-KZA237WJZZY
VCKYCZ1EF104ZY
RC-KZA237WJZZY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
VCKYCZ1HB102KY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
VCKYCZ1HB102KY
RC-KZA237WJZZY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
VCKYCZ1HB102KY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
VCKYCZ1HB102KY
VCKYCZ1HB102KY
VCKYCZ1HB102KY
RC-KZA237WJZZY
AB
AB
AA
AA
AB
AB
AB
AA
AA
AB
AA
AB
AA
AB
AB
AB
AA
AB
AA
AA
AC
AA
AA
AE
AE
AA
AA
AB
AA
AB
AA
AB
AA
AB
AB
AA
AB
AE
AA
AB
AA
AB
AA
AA
AB
AA
AB
AA
AB
AB
AA
AB
AA
AB
AA
AB
AA
AB
AB
AA
AB
AA
AB
AB
AA
AA
AB
AB
AB
AA
AB
AB
AA
AA
AB
AA
AA
AA
AA
AA
AB
AB
AB
AB
AB
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
RC-KZA237WJZZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
RC-KZA237WJZZY
VCKYCZ1HB102KY
VCKYCZ1HB102KY
VCKYCZ1HB102KY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
VCCCCY1HH150JY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
VCCCCY1HH120JY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
RC-KZA237WJZZY
RC-KZA237WJZZY
VCAAPE0JJ227MY
VCKYCZ1EB103KY
VCKYCZ1EB103KY
VCKYCZ1EB103KY
VCAAPE0JJ107MY
VCKYCZ1EF104ZY
RC-KZA237WJZZY
VCKYCZ1HB152KY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1HB102KY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCCCCZ1HH120JY
VCCCCZ1HH120JY
VCCCCZ1HH3R0CY
VCCCCZ1HH3R0CY
VCCCCZ1HH270JY
VCCCCZ1HH270JY
VCCCCZ1HH120JY
VCCCCZ1HH3R0CY
VCCCCZ1HH270JY
VCERMZ1CN107MY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1HB102KY
RC-KZA237WJZZY
VCKYCZ1HB102KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1HB102KY
VCKYCZ1AB104KY
VCKYCZ1HB102KY
VCKYCZ1HB102KY
RC-KZA237WJZZY
VCKYCZ1HB102KY
VCKYCZ1HB102KY
VCKYCZ1HB102KY
RC-KZA237WJZZY
RC-KZA237WJZZY
RC-KZA237WJZZY
AB
AA
AA
AB
AA
AA
AB
AB
AB
AB
AA
AA
AB
AA
AB
AA
AA
AB
AA
AA
AB
AA
AB
AA
AB
AA
AB
AA
AB
AA
AB
AB
AB
AE
AA
AA
AA
AE
AA
AB
AB
AA
AA
AA
AA
AA
AA
AB
AA
AA
AA
AB
AB
AA
AA
AB
AB
AB
AA
AB
AD
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1HB102KY
VCKYCZ1AB104KY
VCKYCZ1HB102KY
VCKYCZ1AB104KY
RC-KZA237WJZZY
VCKYCZ1HB102KY
VCKYCZ1AB104KY
VCKYCZ1HB102KY
VCKYCZ1AB104KY
RC-KZA237WJZZY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
RC-KZA237WJZZY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
RC-KZA237WJZZY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
RC-KZA237WJZZY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
RC-KZA237WJZZY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCY1AB224KY
VCKYCY1AB224KY
VCKYCZ1AB104KY
RC-KZA237WJZZY
VCKYCZ1AB104KY
VCKYCY1AB224KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCY1AB224KY
VCKYCZ1AB104KY
VCKYCY1AB224KY
VCKYCZ1AB104KY
RC-KZA237WJZZY
VCKYCZ1AB104KY
RC-KZA237WJZZY
VCKYCZ1AB104KY
VCKYCY1AB224KY
VCKYCZ1AB104KY
RC-KZA237WJZZY
VCKYCZ1AB104KY
RC-KZA237WJZZY
VCKYCZ1HB272KY
VCKYCZ1AB104KY
RC-KZA237WJZZY
VCCCCZ1HH120JY
VCKYCZ1HB272KY
VCCCCZ1HH120JY
VCKYCZ1AB104KY
RC-KZA237WJZZY
VCKYCZ1AB104KY
RC-KZA237WJZZY
VCKYCZ1HB102KY
VCKYCZ1HB102KY
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AA
AB
AB
AB
AA
AB
AB
AB
AB
AB
AB
AB
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
RC-KZA237WJZZY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCAAPE0JJ107MY
VCAAPE0JJ107MY
VCKYCZ1EB103KY
VCAAPE0JJ107MY
RC-KZA237WJZZY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1HB102KY
VCKYCZ1HB102KY
VCKYCZ1HB102KY
VCKYCZ1HB102KY
RC-KZA237WJZZY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1HB102KY
VCKYCZ1HB102KY
VCKYCZ1EB103KY
RC-KZA237WJZZY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1HB102KY
VCKYCZ1HB102KY
VCKYCZ1HB102KY
VCKYCZ1HB102KY
RC-KZA237WJZZY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1HB102KY
VCKYCZ1HB102KY
VCKYCZ1EB103KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
RC-KZ0124TAZZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
RC-KZ0124TAZZY
RC-KZ0124TAZZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1AB104KY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
RC-KZ0124TAZZY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
RC-KZ0124TAZZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
RC-KZA069WJZZY
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AE
AE
AA
AE
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AA
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AA
AB
AB
AC
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AC
AC
AA
AA
AA
AB
AA
AA
AC
AB
AB
AA
AA
AA
AA
AA
AA
AA
AC
AA
AA
AA
AA
AA
AB
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
10
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
VCKYCZ1EF104ZY
RC-KZ0124TAZZY
RC-KZA069WJZZY
VCKYCZ1EB103KY
RC-KZA069WJZZY
VCKYCZ1EB103KY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
RC-KZ0124TAZZY
RC-KZ0124TAZZY
VCEASX0JN227MY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
RC-KZ0124TAZZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
RC-KZA030WJZZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCCCCZ1HH100DY
VCCCCZ1HH100DY
VCKYCZ1AB104KY
VCKYCZ1EB103KY
RC-KZA069WJZZY
VCKYCZ1AB104KY
VCCCCZ1HH120JY
VCCCCZ1HH120JY
RC-KZA237WJZZY
AA
AC
AB
AA
AB
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AC
AC
AC
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AC
AA
AA
AA
AA
AA
AA
AA
AA
AB
AA
AA
AA
AA
AA
AB
AB
AB
AB
AB
AB
AA
AB
AB
AB
AB
AB
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
11
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
RC-KZA237WJZZY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ0JF105ZY
VCKYCZ1AB104KY
VCKYCZ1HB271KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ0JF105ZY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1HB271KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
RC-KZA069WJZZY
VCKYCZ1HB102KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1EB103KY
VCKYCY1AB105KY
VCKYCY1AB105KY
VCKYCZ1AB104KY
RC-KZA237WJZZY
VCCCCZ1HH330JY
VCCCCZ1HH330JY
VCKYCZ1EB103KY
RC-KZA237WJZZY
VCKYCY1AB105KY
RC-KZA237WJZZY
VCKYCY1AB105KY
VCCCCZ1HH390JY
VCKYCY1AB105KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCCCCZ1HH560JY
VCCCCZ1HH560JY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCCCCZ1HH220JY
VCCCCZ1HH220JY
VCKYCY1AB105KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCCCCZ1HH390JY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCCCCZ1HH100DY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCCCCZ1HH100DY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AA
AB
AC
AB
AB
AA
AB
AB
AC
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AA
AB
AB
AB
AB
AB
AB
AA
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
12
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
RC-KZA237WJZZY
RC-KZA237WJZZY
RC-KZA237WJZZY
VCKYCZ1EB103KY
VCKYCY1AB105KY
VCKYCZ1EB103KY
VCKYCY1AB105KY
VCKYCZ1EB103KY
RC-KZA069WJZZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
VCKYCZ1EF104ZY
RC-KZA237WJZZY
RC-KZA237WJZZY
VCKYCZ1AF224ZY
RC-KZA237WJZZY
RC-KZA237WJZZY
VCKYCZ1EF104ZY
VCKYCZ1EB103KY
VCKYCZ1EB103KY
VCKYCZ1EB103KY
VCKYCZ1EB103KY
VCKYCZ1EB103KY
VCKYCZ1EB103KY
VCKYCZ1EB103KY
VCKYCZ1EB103KY
VCKYCZ1EB682KY
VCKYCZ1AB104KY
VCKYCZ1HB222KY
VCKYCZ1HB221KY
VCKYCZ1HB272KY
VCKYCY1EB104KY
VCCCCZ1HH101JY
VCKYTV1CB105KY
VCAAPE1CJ396MY
RC-KZA237WJZZY
VCAAPE1CJ396MY
VCKYCZ1EB103KY
VCKYCZ1HB272KY
VCKYCZ1HB221KY
VCKYTV1CB105KY
RC-KZA237WJZZY
RC-KZA237WJZZY
VCAAPE0JJ107MY
RC-KZA237WJZZY
RC-KZA237WJZZY
RC-KZA237WJZZY
RC-KZA237WJZZY
RC-KZA237WJZZY
RC-KZA069WJZZY
VCKYCZ1AB104KY
VCKYCZ1AB104KY
VCKYCZ1EB682KY
VCKYCZ1EB682KY
VCKYCZ1HB221KY
VCKYCZ1HB272KY
VCCCCZ1HH101JY
VCKYCY1EB104KY
RC-KZA237WJZZY
VCKYTV1CB105KY
RC-KZA237WJZZY
VCKYCZ1AB104KY
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AA
AB
AA
AB
AA
AB
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AB
AB
AA
AB
AB
AA
AA
AA
AA
AA
AA
AA
AA
AA
AB
AB
AB
AA
AA
AB
AB
AC
AE
AB
AE
AA
AA
AA
AC
AB
AB
AE
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AA
AA
AB
AB
AB
AC
AB
AB
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
13
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
VCKYCZ1EB822KY
VCKYCZ1EB682KY
VCKYCZ1HB221KY
VCKYCZ1HB272KY
VCCCCZ1HH101JY
VCKYCY1EB104KY
VCKYTV1CB105KY
RC-KZA237WJZZY
VCAAPE1CJ396MY
RC-KZA237WJZZY
VCKYCZ1HB222KY
VCKYCZ1HB272KY
RC-KZA237WJZZY
RC-KZA237WJZZY
RC-KZA237WJZZY
RC-KZA237WJZZY
VCKYCZ1EB682KY
VCKYCZ1EB103KY
RC-KZA237WJZZY
RC-KZA154WJZZY
VCKYCY1AB105KY
VCKYCY1AB105KY
RC-KZA237WJZZY
RC-KZA069WJZZY
RC-KZA104WJZZY
RC-KZA237WJZZY
RFiLCA052WJQZY
RH-EX1234CEZZY
VHD1SS355//-1Y
VHD1SS355//-1Y
VHD1SS355//-1Y
VHD1SS355//-1Y
VHD1SS355//-1Y
VHD1SS355//-1Y
VHD1SS355//-1Y
VHD1SS355//-1Y
VHD1SS355//-1Y
VHD1SS355//-1Y
VHD1SS355//-1Y
VHD1SS355//-1Y
VHD1SS355//-1Y
VHPGPFM513T-1
VHD1SS355//-1Y
VHD1SS355//-1Y
VHDMA152WK/-1Y
VHDMA152WK/-1Y
VHDMA152WK/-1Y
VHD1SS355//-1Y
VHD1SS355//-1Y
RH-EX1394CEZZY
RH-EX1394CEZZY
VHD1SS226//-1Y
VHD1SS226//-1Y
VHD1SS355//-1Y
VHDRB521S30-1Y
VHD1SS226//-1Y
VHD1SS355//-1Y
VHD1SS226//-1Y
VHDMA3120WA-1Y
VHDMA3120WA-1Y
VHDMA3120WA-1Y
VHDRB521S30-1Y
VHD1SS355//-1Y
VHD1SS226//-1Y
VHD1SS226//-1Y
VHD1SS355//-1Y
VHD1SS355//-1Y
RH-PXA018WJZZY
RH-PXA018WJZZY
RH-PXA018WJZZY
VHD1SS355//-1Y
VHD1SS355//-1Y
RH-EX1264CEZZY
RH-EX1264CEZZY
VHD1SS355//-1Y
VHD1SS355//-1Y
RH-EX1226CEZZY
VHDD1FH3+++-1Y
VHDDG1M3+++-1Y
RH-EXA089WJZZY
VHD1SS355//-1Y
VHD1SS355//-1Y
RH-EX1226CEZZY
VHD1SS355//-1Y
RH-EX1226CEZZY
AA
AB
AA
AA
AB
AB
AC
AB
AE
AB
AB
AA
AB
AB
AB
AB
AB
AA
AB
AB
AB
AB
AB
AB
AA
AB
AE
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AH
AB
AB
AB
AB
AB
AB
AC
AC
AB
AC
AC
AB
AC
AD
AD
AD
AC
AB
AC
AC
AB
AB
AC
AC
AC
AB
AB
AB
AB
AB
AB
AB
AD
AC
AB
AB
AB
AB
AB
AB
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
14
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
VHD1SS355//-1Y
VHD1SS355//-1Y
VHD1SS355//-1Y
VHD1SS355//-1Y
RBLN-0237TAZZY
RBLN-A191WJZZY
RBLN-A191WJZZY
RBLN-A191WJZZY
RBLN-A191WJZZY
RBLN-0062TAZZY
RBLN-0062TAZZY
RBLN-0062TAZZY
RBLN-0062TAZZY
RBLN-0067TAZZY
RBLN-0093GEZZY
RBLN-0093GEZZY
RBLN-0093GEZZY
RBLN-0067TAZZY
RBLN-0210TAZZY
RBLN-0210TAZZY
RBLN-0210TAZZY
RBLN-0210TAZZY
RBLN-0210TAZZY
RBLN-0210TAZZY
RBLN-0210TAZZY
RBLN-0210TAZZY
RBLN-0210TAZZY
RBLN-1043CEZZY
RBLN-0210TAZZY
RBLN-0210TAZZY
RBLN-A005WJZZY
RBLN-A005WJZZY
RBLN-A005WJZZY
RBLN-A206WJZZY
RBLN-0252TAZZY
RBLN-0210TAZZY
RBLN-0210TAZZY
RBLN-0210TAZZY
RBLN-0210TAZZY
RBLN-0210TAZZY
RBLN-0252TAZZY
RBLN-0252TAZZY
RBLN-0252TAZZY
RBLN-A213WJZZY
RBLN-A192WJZZY
RBLN-A192WJZZY
RBLN-A192WJZZY
RBLN-A192WJZZY
RBLN-A226WJZZY
RBLN-A226WJZZY
RBLN-A226WJZZY
RBLN-A192WJZZY
RBLN-A192WJZZY
RBLN-0237TAZZY
RBLN-A005WJZZY
RBLN-A005WJZZY
RBLN-A005WJZZY
RBLN-A005WJZZY
RBLN-0237TAZZY
RBLN-A192WJZZY
RBLN-A192WJZZY
RBLN-A206WJZZY
RBLN-A206WJZZY
RBLN-A192WJZZY
RFiLZA009WJZZY
RFiLNA044WJZZY
VHiPQ050DNA-1Y
VHiBA7655AF-1Y
VHiM62332FP-1Y
VHiM62320FP-1Y
VHiBU4842G+-1Y
VHiT7SET08U1EY
VHiAN5832SA-1Y
VHiAK4683EQ-1Q
VHi7SA34FU+-1Y
VHi7SA34FU+-1Y
VHiNJU26111-1Q
VHiNJM4565V-1Y
VHiT7SET08U1EY
VHi24LC2BiNHES
VHi24LC2BiNPES
VHiN74LVC14-1Y
VHiT7WH123U-1Y
VHi24LC2BiNKES
VHiPQ018EZ5-1Y
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AC
AB
AB
AB
AC
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AA
AA
AA
AA
AA
AB
AB
AB
AB
AB
AA
AA
AA
AB
AA
AA
AA
AA
AA
AA
AA
AA
AA
AB
AA
AA
AA
AA
AB
AA
AA
AA
AA
AA
AD
AC
AE
AG
AL
AH
AC
AC
AQ
AR
AD
AD
AT
AF
AC
AD
AF
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
Diode, 1SS355TE-17
Diode, 1SS355TE-17
Diode, 1SS355TE-17
Diode, 1SS355TE-17
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Ferrite core
Filter
Filter
IC, PQ050DNA1ZPH
IC, BA7655AF-T1
IC, M62332FPCF5J
IC, M62320FPDF5J
IC, BU4842G-TR
IC, TC7SET08FU(5L,JF,T)
IC, AN5832SA-E1V
IC, AK4683EQ
IC, TC7SA34FU(TE85L,F)
IC, TC7SA34FU(TE85L,F)
IC, NJU26111FR1
IC, NJM4565V-TE1
IC, TC7SET08FU(5L,JF,T)
IC
IC
IC, SN74LVC2G14DCK3
IC, TC7WH123FU(TE12L,F)
IC, 24LC02B-I/SN-G-GW975
IC, PQ018EZ5MZPH
15
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
VHiTMDS341+-1Y
VHiSii9011L-1Q
VHiBD5224G+-1Y
RH-iXB345WJNDQ
VHiTC7W66U/-1Y
VHiBR24L08F-1Y
VHiM62332FP-1Y
VHiTCVHC32T-1Y
VHiSN1G08DC-1Y
RH-iXB723WJQZQ
VHiPQ1X251M-1Y
RH-iXB375WJZZQ
RH-iXB375WJZZQ
RH-iXB281WJZZQ
VHiPQ1X251M-1Y
RH-iXB024WJZZQ
RH-iXB024WJZZQ
RH-iXB024WJZZQ
RH-iXB024WJZZQ
RH-iXA361WJZZY
RH-iXB268WJZZY
RH-iXB269WJZZY
VHiLV04AT++-1Y
RH-iXB775WJQZQ
VHiBR24L08F-1Y
VHiBR24L64F-1Y
VHiPQ1M335M-1Y
VHiBH15LB1G-1Y
RH-iXB323WJZZQ
VHiBD5229G+-1Y
VHiTC7SH08U-1Y
RH-iXB684WJQZQ
VHiR1173S10-1Y
VHiPQ1X181M-1Y
VHiPQ1X331M-1Y
VHiTC6384AF1EQ
VHiAK4363VF-1Y
VHiPQ1LAX95-1Y
RH-iXB732WJQZQ
VHiPQ1CX12H-1Y
VHiTPS40055-1Y
VHiPQ1X181M-1Y
VHiTPS40055-1Y
VHiTPS40055-1Y
VHiPQ090DNA-1Y
VHiBH33FB1G-1Y
VHiPQ050DNA-1Y
QJAKFA046WJZZ
QJAKEA073WJZZ
QJAKZ1055CEZZ
QJAKZ1055CEZZ
VPCEM100MR70NY
VPCEM100MR70NY
VPCBM470K2R4NY
VPCEM100MR70NY
RCiLFA116WJZZY
RCiLFA116WJZZY
RCiLFA116WJZZY
RCiLFA116WJZZY
VPD9M100KR86NY
RCiLFA116WJZZY
RCiLFA116WJZZY
RCiLFA116WJZZY
RCiLFA116WJZZY
RCiLFA116WJZZY
RCiLFA116WJZZY
RCiLFA116WJZZY
RCiLFA116WJZZY
VPCBM4R7MR25NY
VPD9M220J2R7NY
VPD9M220J2R7NY
VPD9M220J2R7NY
RCiLFA154WJZZY
RCiLFA154WJZZY
RCiLFA154WJZZY
RCiLFA154WJZZY
RCiLFA154WJZZY
RCiLFA154WJZZY
RCiLFA154WJZZY
RCiLFA154WJZZY
RCiLFA154WJZZY
RCiLFA154WJZZY
VPCEM2R2MR23NY
VPCEM2R2MR23NY
VPCEM2R2MR23NY
AS
AY
AD
AE
AE
AL
AE
AD
AD
BA
BA
BQ
AD
BB
BB
BB
BB
AM
AK
AK
AD
AE
AK
AD
AD
AY
AD
AF
BE
AD
AD
AW
AQ
AD
AK
AN
AD
AN
AN
AE
AD
AE
AC
AD
AF
AF
AC
AC
AC
AC
AE
AE
AE
AE
AC
AE
AE
AE
AE
AE
AE
AE
AE
AC
AC
AC
AC
AC
AC
AC
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
IC, TMDS341PFCR
IC, Sil9011CLU
IC, BD5224G-TR
IC, HD64F36049HV
IC, TC7W66FU(TE12L,F)
IC, BR24L08F-WE2
IC, M62332FPCF5J
IC, TC74VHC32FT(EL)
IC, SN74AHC1G08HDCK3
IC, SVP-LX62
IC, PQ1X251M2ZPH
IC, K4D263238G-VC36000
IC, K4D263238G-VC36000
IC, TC81240ATBG(O,5)
IC, PQ1X251M2ZPH
IC, K4H561638F-UCB3
IC, K4H561638F-UCB3
IC, K4H561638F-UCB3
IC, K4H561638F-UCB3
IC, LP2995MX/NOPB
IC, ICS422M-01LFT
IC, ICS422M-02LFT
IC, SN74LV04APWR
IC
IC, BR24L08F-WE2
IC, BR24L64F-WE2
IC, PQ1M335M2SPQ
IC, BH15LB1WG-TR
IC, TSB43DA42AZHC
IC, BD5229G-TR
IC, TC7SH08FU(TE85L,JF)
IC, 218T312ZGA21G
IC, R1173S101B-E2-F
IC, PQ1X181M2ZPH
IC, PQ1X331M2ZPH
IC, TC6384AFG-0001(JQZ)
IC, AK4363VF
IC, PQ1LAX95MSPQ
IC, EPM240T100C5N
IC, PQ1CX12H2ZPQ
IC, TPS40055PWPR
IC, PQ1X181M2ZPH
IC, TPS40055PWPR
IC, TPS40055PWPR
IC, PQ090DNA1ZPH
IC, BH33FB1WG-TR
IC, PQ050DNA1ZPH
Jack
Jack
Jack, 4pin
Jack, 4pin
Coil, Peaking 10H
Coil, Peaking 10H
Coil, Peaking 47H
Coil, Peaking 10H
Coil
Coil
Coil
Coil
Coil, Peaking 10H
Coil
Coil
Coil
Coil
Coil
Coil
Coil
Coil
Coil, Peaking 4.7H
Coil, Peaking 22H
Coil, Peaking 22H
Coil, Peaking 22H
Coil
Coil
Coil
Coil
Coil
Coil
Coil
Coil
Coil
Coil
Coil, Peaking 2.2H
Coil, Peaking 2.2H
Coil, Peaking 2.2H
16
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
VPCEM2R2MR23NY
VPCEM2R2MR23NY
VPCEM2R2MR23NY
VPCEM2R2MR23NY
RCiLFA122WJZZY
RCiLFA122WJZZY
VPMKMR39JR57VY
VPMKMR39JR57VY
VPMKMR33JR50VY
VPMKMR68JR84VY
VPMKMR68JR84VY
VPMKMR22JR37VY
VPMKMR22JR37VY
VPMKMR33JR50VY
RCiLPA086WJZZY
RCiLPA084WJZZY
RCiLCA029WJZZY
RCiLPA084WJZZY
QLUGHA006WJZZY
QLUGHA006WJZZY
QLUGHA006WJZZY
QLUGHA006WJZZY
QLUGHA006WJZZY
QLUGHA006WJZZY
QPLGN0060CEZZY
QPLGNA173WJZZY
QCNCWA507WJQZY
QPLGNA412WJZZY
QPLGNA173WJZZY
QPLGNA174WJZZY
QPLGN0060CEZZY
QCNCWA562WJQZY
QPLGNA181WJZZY
QPLGNA175WJZZY
VS2SC3928AR-1Y
VS2SC3928AR-1Y
VS2SC3928AR-1Y
VS2SA1530AR-1Y
VSDTC144EE/-1Y
VS2SA1530AR-1Y
VSDTC144EE/-1Y
VSDTC144EE/-1Y
VS2SA1530AR-1Y
VSDTC614TK+-1Y
VSDTC614TK+-1Y
VS2SC3928AR-1Y
VSDTC144EE/-1Y
VSDTC144EE/-1Y
VSDTC144EE/-1Y
VSUM6K1NTN+-1Y
VSUM6K1NTN+-1Y
VSDTC144EE/-1Y
VSDTC144EE/-1Y
VSDTC144EE/-1Y
VSDTC144EE/-1Y
VS2SC2735//-1Y
VS2SC2735//-1Y
VS2SC2735//-1Y
VSUM6K1NTN+-1Y
VSiMD2A////-1Y
VSiMD2A////-1Y
VSiMD2A////-1Y
VSDTC144EE/-1Y
VSDTC144EE/-1Y
VSDTC144EE/-1Y
VSRT1N141U/-1Y
VSRT1N141U/-1Y
VS2SC3928AR-1Y
VS2SC3928AR-1Y
VS2SC3928AR-1Y
VS2SC3928AR-1Y
VS2SC3928AR-1Y
VS2SC3928AR-1Y
VS2SA1530AR-1Y
VS2SA1530AR-1Y
VS2SA1530AR-1Y
VSRT1N141U/-1Y
VSKTA1298Y+-1Y
VSRT1N144U/-1Y
VSRT1N144U/-1Y
VSUM6K1NTN+-1Y
VSUM6K1NTN+-1Y
VSSP8K2++++-1Y
VSSP8K4++++-1Y
VSDTC144EE/-1Y
AC
AC
AC
AC
AD
AD
AB
AB
AB
AB
AB
AB
AB
AB
AE
AE
AD
AE
AC
AC
AC
AC
AC
AC
AE
AD
AM
AG
AD
AE
AE
AF
AF
AE
AB
AB
AB
AB
AA
AB
AA
AA
AB
AB
AB
AB
AA
AA
AA
AC
AC
AA
AA
AA
AA
AB
AB
AB
AC
AC
AC
AC
AA
AA
AA
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AC
AB
AB
AC
AC
AE
AF
AA
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
17
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
VSDTC144EE/-1Y
VSDTC144EE/-1Y
VSDTC144EE/-1Y
VSDTC144EE/-1Y
VSSP8K2++++-1Y
VS2SC3928AR-1Y
VSKRC103S//-1Y
VSKRA103S//-1Y
VRS-CZ1JF822FY
VRS-CZ1JF470JY
VRS-CZ1JF301FY
VRS-CZ1JF332FY
VRS-CZ1JF822FY
VRS-CZ1JF683JY
VRS-CZ1JF470JY
VRS-CZ1JF102FY
VRS-CZ1JF222FY
VRS-CZ1JF101FY
VRS-CZ1JF102FY
VRS-CZ1JF101FY
VRS-CZ1JF222FY
VRS-CZ1JF123FY
VRS-CZ1JF392FY
VRS-CZ1JF101FY
VRS-CZ1JF272FY
VRS-CZ1JF202JY
VRS-CZ1JF472JY
VRS-CZ1JF332FY
VRS-CJ1JF470JY
VRS-CZ1JF472JY
VRS-CZ1JF182FY
VRS-CZ1JF101FY
VRS-CZ1JF562FY
VRS-CZ1JF101FY
VRS-CJ1JF470JY
VRS-CZ1JF473FY
VRS-CZ1JF101FY
VRS-CZ1JF102FY
VRS-CZ1JF223FY
VRS-CZ1JF473FY
VRS-CZ1JF102FY
VRS-CZ1JF562FY
VRS-CZ1JF473FY
VRS-CZ1JF473FY
VRS-CZ1JF223FY
VRS-CZ1JF222FY
VRS-CZ1JF223FY
VRS-CZ1JF473FY
VRS-CZ1JF104FY
VRS-CZ1JF562FY
VRS-CZ1JF102FY
VRS-CZ1JF102FY
VRS-CZ1JF332FY
VRS-CZ1JF332FY
VRS-CZ1JF473FY
VRS-CZ1JF223FY
VRS-CZ1JF184JY
VRS-CZ1JF101FY
VRS-CZ1JF103FY
VRS-CJ1JF101JY
VRS-CZ1JF101FY
VRS-CZ1JF103FY
VRS-CZ1JF332FY
VRS-CZ1JF105JY
VRS-CZ1JF000JY
VRS-CZ1JF4R7JY
VRS-CZ1JF470JY
VRS-CZ1JF472JY
VRS-CZ1JF220JY
VRS-CZ1JF470JY
VRS-CZ1JF472JY
VRS-CZ1JF470JY
VRS-CZ1JF472JY
VRS-CZ1JF123FY
VRS-CZ1JF000JY
VRS-CZ1JF4R7JY
VRS-CZ1JF000JY
VRS-CZ1JF4R7JY
VRS-CZ1JF4R7JY
VRS-CZ1JF473FY
VRS-CZ1JF000JY
VRS-CZ1JF000JY
VRS-CZ1JF473FY
VRS-CZ1JF473FY
VRS-CZ1JF222FY
AA
AA
AA
AA
AE
AB
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AB
AA
AA
AA
AA
AA
AA
AA
AA
AA
AB
AA
AA
AB
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
Transistor, DTC144EETL
Transistor, DTC144EETL
Transistor, DTC144EETL
Transistor, DTC144EETL
Transistor, SP8K2TB
Transistor, 2SC3928A-T112-1R
Transistor, KRC103S-RTK/P
Transistor, KRA103S
Resistor, 8.2k 1/16W Metal Oxide
Resistor, 47 1/16W Metal Oxide
Resistor, 300 1/16W Metal Oxide
Resistor, 3.3k 1/16W Metal Oxide
Resistor, 8.2k 1/16W Metal Oxide
Resistor, 68k 1/16W Metal Oxide
Resistor, 47 1/16W Metal Oxide
Resistor, 1k 1/16W Metal Oxide
Resistor, 2.2k 1/16W Metal Oxide
Resistor, 100 1/16W Metal Oxide
Resistor, 1k 1/16W Metal Oxide
Resistor, 100 1/16W Metal Oxide
Resistor, 2.2k 1/16W Metal Oxide
Resistor, 12k 1/16W Metal Oxide
Resistor, 3.9k 1/16W Metal Oxide
Resistor, 100 1/16W Metal Oxide
Resistor, 2.7k 1/16W Metal Oxide
Resistor, 2k 1/16W Metal Oxide
Resistor, 4.7k 1/16W Metal Oxide
Resistor, 3.3k 1/16W Metal Oxide
Resistor, 47 1/16W Metal Oxide
Resistor, 4.7k 1/16W Metal Oxide
Resistor, 1.8k 1/16W Metal Oxide
Resistor, 100 1/16W Metal Oxide
Resistor, 5.6k 1/16W Metal Oxide
Resistor, 100 1/16W Metal Oxide
Resistor, 47 1/16W Metal Oxide
Resistor, 47k 1/16W Metal Oxide
Resistor, 100 1/16W Metal Oxide
Resistor, 1k 1/16W Metal Oxide
Resistor, 22k 1/16W Metal Oxide
Resistor, 47k 1/16W Metal Oxide
Resistor, 1k 1/16W Metal Oxide
Resistor, 5.6k 1/16W Metal Oxide
Resistor, 47k 1/16W Metal Oxide
Resistor, 47k 1/16W Metal Oxide
Resistor, 22k 1/16W Metal Oxide
Resistor, 2.2k 1/16W Metal Oxide
Resistor, 22k 1/16W Metal Oxide
Resistor, 47k 1/16W Metal Oxide
Resistor, 100k 1/16W Metal Oxide
Resistor, 5.6k 1/16W Metal Oxide
Resistor, 1k 1/16W Metal Oxide
Resistor, 1k 1/16W Metal Oxide
Resistor, 3.3k 1/16W Metal Oxide
Resistor, 3.3k 1/16W Metal Oxide
Resistor, 47k 1/16W Metal Oxide
Resistor, 22k 1/16W Metal Oxide
Resistor, 180k 1/16W Metal Oxide
Resistor, 100 1/16W Metal Oxide
Resistor, 10k 1/16W Metal Oxide
Resistor, 100 1/16W Metal Oxide
Resistor, 100 1/16W Metal Oxide
Resistor, 10k 1/16W Metal Oxide
Resistor, 3.3k 1/16W Metal Oxide
Resistor, 1M 1/16W Metal Oxide
Resistor, 0 1/16W Metal Oxide
Resistor, 4.7 1/16W Metal Oxide
Resistor, 47 1/16W Metal Oxide
Resistor, 4.7k 1/16W Metal Oxide
Resistor, 22 1/16W Metal Oxide
Resistor, 47 1/16W Metal Oxide
Resistor, 4.7k 1/16W Metal Oxide
Resistor, 47 1/16W Metal Oxide
Resistor, 4.7k 1/16W Metal Oxide
Resistor, 12k 1/16W Metal Oxide
Resistor, 0 1/16W Metal Oxide
Resistor, 4.7 1/16W Metal Oxide
Resistor, 0 1/16W Metal Oxide
Resistor, 4.7 1/16W Metal Oxide
Resistor, 4.7 1/16W Metal Oxide
Resistor, 47k 1/16W Metal Oxide
Resistor, 0 1/16W Metal Oxide
Resistor, 0 1/16W Metal Oxide
Resistor, 47k 1/16W Metal Oxide
Resistor, 47k 1/16W Metal Oxide
Resistor, 2.2k 1/16W Metal Oxide
18
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
VRS-CZ1JF473FY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF223FY
VRS-CZ1JF473FY
VRS-CZ1JF000JY
VRS-CZ1JF473FY
VRS-CZ1JF101FY
VRS-CZ1JF473FY
VRS-CZ1JF223FY
VRS-CJ1JF470JY
VRS-CZ1JF473FY
VRS-CZ1JF223FY
VRS-CZ1JF473FY
VRS-CZ1JF000JY
VRS-CZ1JF243FY
VRS-CZ1JF473FY
VRS-CZ1JF103FY
VRS-CZ1JF473FY
VRS-CZ1JF220JY
VRS-CZ1JF472JY
VRS-CJ1JF472JY
VRS-CZ1JF243FY
VRS-CZ1JF220JY
VRS-CJ1JF103JY
VRS-CZ1JF102FY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CJ1JF243JY
VRS-CJ1JF470JY
VRS-CZ1JF221JY
VRS-CZ1JF221JY
VRS-CZ1JF221JY
VRS-CZ1JF221JY
VRS-CJ1JF104JY
VRS-CZ1JF102FY
VRS-CZ1JF102FY
VRS-CZ1JF101FY
VRS-CJ1JF103JY
VRS-CZ1JF473FY
VRS-CJ1JF103JY
VRS-CZ1JF473FY
VRS-CZ1JF105JY
VRS-CZ1JF271JY
VRS-CZ1JF101FY
VRS-CZ1JF101FY
VRS-CZ1JF102FY
VRS-CZ1JF102FY
VRS-CZ1JF102FY
VRS-CZ1JF102FY
VRS-CZ1JF102FY
VRS-CZ1JF102FY
VRS-CZ1JF102FY
VRS-CZ1JF102FY
VRS-CZ1JF104FY
VRS-CZ1JF104FY
VRS-CZ1JF104FY
VRS-CZ1JF104FY
VRS-CZ1JF102FY
VRS-CZ1JF102FY
VRS-CZ1JF103FY
VRS-CZ1JF102FY
VRS-CZ1JF102FY
VRS-CZ1JF103FY
VRS-CZ1JF222FY
VRS-CZ1JF222FY
VRS-CZ1JF101FY
VRS-CZ1JF101FY
VRS-CZ1JF473FY
VRS-CZ1JF473FY
VRS-CZ1JF473FY
VRS-CZ1JF100JY
VRS-CZ1JF473FY
VRS-CZ1JF100JY
VRS-CZ1JF473FY
VRS-CZ1JF100JY
VRS-CZ1JF473FY
VRS-CZ1JF100JY
VRS-CZ1JF473FY
VRS-CZ1JF473FY
VRS-CZ1JF473FY
VRS-CZ1JF103FY
VRS-TV1JD750JY
VRS-TV1JD750JY
VRS-TV1JD750JY
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AB
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AB
AB
AB
AB
AA
AA
AB
AA
AA
AB
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AB
AA
AA
AA
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
19
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
VRS-CZ1JF103FY
VRS-CZ1JF473FY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF102FY
VRS-CZ1JF330JY
VRS-CZ1JF562FY
VRS-CZ1JF103FY
VRS-CZ1JF562FY
VRS-CZ1JF103FY
VRS-CZ1JF562FY
VRS-CZ1JF103FY
VRS-CZ1JF680FY
VRS-CZ1JF680FY
VRS-CZ1JF680FY
VRS-CZ1JF330JY
VRS-CZ1JF223FY
VRS-TQ2BD561JY
VRS-TQ2BD561JY
VRS-TQ2BD561JY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRS-CZ1JF330JY
VRS-CZ1JF473FY
VRS-CZ1JF473FY
VRS-CZ1JF100JY
VRS-CZ1JF473FY
VRS-CZ1JF100JY
VRS-CZ1JF473FY
VRS-CZ1JF473FY
VRS-CZ1JF100JY
VRS-CZ1JF100JY
VRS-CZ1JF100JY
VRS-CZ1JF103FY
VRS-CZ1JF100JY
VRS-CZ1JF100JY
VRS-CZ1JF100JY
VRS-CZ1JF100JY
VRS-CZ1JF100JY
VRS-CZ1JF223FY
VRS-CZ1JF330JY
VRS-CZ1JF100JY
VRS-CZ1JF100JY
RR-SZA031WJZZY
VRS-CZ1JF100JY
VRS-CZ1JF100JY
VRS-CZ1JF472JY
VRS-CZ1JF471JY
VRS-CZ1JF223FY
VRS-CZ1JF105JY
VRS-CZ1JF103FY
VRS-CZ1JF472JY
VRS-CZ1JF223FY
VRS-CZ1JF100JY
VRS-CZ1JF472JY
VRS-CH1JF103JY
VRS-CZ1JF330JY
VRS-CZ1JF330JY
VRS-CZ1JF330JY
VRS-CZ1JF390FY
VRS-CZ1JF000JY
VRS-CH1JF101JY
VRS-CH1JF101JY
VRS-CH1JF101JY
VRS-CH1JF101JY
VRS-CH1JF101JY
VRS-CH1JF101JY
VRS-CZ1JF103FY
VRS-CZ1JF223FY
VRS-CZ1JF330JY
VRS-CZ1JF102FY
VRS-CZ1JF330JY
VRS-CZ1JF103FY
VRS-CZ1JF000JY
VRS-CZ1JF103FY
VRS-CZ1JF101FY
VRS-CZ1JF223FY
VRS-CZ1JF102FY
VRS-CZ1JF103FY
VRS-CZ1JF272FY
VRS-CZ1JF223FY
VRS-CZ1JF472JY
VRS-CZ1JF102FY
VRS-CZ1JF102FY
AB
AA
AB
AB
AA
AA
AA
AB
AA
AB
AA
AB
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AB
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AB
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AB
AA
AA
AA
AA
AB
AA
AB
AA
AA
AA
AB
AA
AA
AA
AA
AA
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
20
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
VRS-CJ1JF333JY
VRS-CZ1JF472JY
VRS-CZ1JF100JY
VRS-CZ1JF100JY
VRS-CZ1JF472JY
VRS-CZ1JF000JY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF472JY
VRS-CZ1JF393FY
VRS-CZ1JF102FY
VRS-CZ1JF102FY
VRS-CZ1JF102FY
VRS-CZ1JF000JY
VRS-CZ1JF101FY
VRS-CZ1JF223FY
VRS-CZ1JF101FY
VRS-CZ1JF105JY
VRS-CZ1JF223FY
VRS-CZ1JF223FY
VRS-CZ1JF223FY
VRS-CZ1JF223FY
VRS-CH1JF100JY
VRS-CZ1JF103FY
VRS-CZ1JF152JY
VRS-CH1JF101JY
VRS-CZ1JF100JY
VRS-CZ1JF101FY
VRS-CZ1JF472JY
VRS-CZ1JF272FY
VRS-CZ1JF101FY
VRS-CZ1JF100JY
VRS-CZ1JF100JY
VRS-CZ1JF102FY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF472JY
VRS-CZ1JF100JY
VRS-CZ1JF100JY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF100JY
VRS-CZ1JF100JY
VRS-CZ1JF102FY
VRS-CZ1JF103FY
VRS-CZ1JF223FY
VRS-CZ1JF101FY
VRS-CZ1JF101FY
VRS-CZ1JF101FY
VRS-CZ1JF101FY
VRS-TV1JD102FY
VRS-TV1JD102FY
VRS-TV1JD102FY
VRS-TV1JD102FY
VRS-CZ1JF101FY
VRS-CZ1JF911JY
VRS-CZ1JF911JY
VRS-CZ1JF101FY
VRS-TV1JD102FY
VRS-TV1JD102FY
VRS-CZ1JF911JY
VRS-TV1JD102FY
VRS-TV1JD102FY
VRS-TV1JD102FY
VRS-CZ1JF000JY
VRS-CH1JF223JY
VRS-CH1JF223JY
VRS-CZ1JF000JY
VRS-CZ1JF000JY
VRS-CZ1JF000JY
VRS-CZ1JF000JY
VRS-CZ1JF000JY
VRS-CZ1JF000JY
VRS-CZ1JF000JY
VRS-CZ1JF000JY
VRS-CZ1JF000JY
VRS-CZ1JF000JY
VRS-CZ1JF000JY
VRS-CZ1JF103FY
VRS-CH1JF100JY
VRS-CH1JF100JY
VRS-CZ1JF471JY
AA
AA
AA
AA
AA
AA
AB
AB
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AB
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AB
AB
AB
AA
AA
AA
AB
AB
AB
AB
AA
AA
AA
AB
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AB
AA
AA
AA
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
21
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
VRS-CZ1JF472JY
VRS-CZ1JF471JY
VRS-CZ1JF472JY
VRS-CZ1JF103FY
VRS-CZ1JF100JY
VRS-CZ1JF100JY
VRS-CZ1JF100JY
VRS-CZ1JF100JY
VRS-CZ1JF000JY
VRS-CZ1JF000JY
VRS-CZ1JF100JY
VRS-CZ1JF000JY
VRS-CZ1JF000JY
VRS-CZ1JF100JY
VRS-CZ1JF472JY
VRS-CZ1JF100JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF100JY
VRS-CZ1JF100JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF472JY
VRS-CH1JF103JY
VRK-CD1JJ681JY
VRK-CD1JJ681JY
VRK-CD1JJ103JY
VRK-CD1JJ103JY
VRK-CD1JJ103JY
VRS-CH1JF103JY
VRS-CZ1JF105JY
VRS-CZ1JF102FY
VRS-CZ1JF102FY
VRS-CZ1JF000JY
VRS-CZ1JF330JY
VRS-CZ1JF330JY
VRK-CD1JJ103JY
VRK-CD1JJ103JY
VRK-CD1JJ103JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF103FY
VRS-CH1JF680JY
VRS-CH1JF680JY
VRS-CZ1JF000JY
VRS-CZ1JF000JY
VRS-CZ1JF000JY
VRS-CZ1JF000JY
VRK-CD1JJ680JY
VRK-CD1JJ680JY
VRK-CD1JJ680JY
VRS-CH1JF680JY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRK-CD1JJ680JY
VRK-CD1JJ680JY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRK-CD1JJ680JY
VRK-CD1JJ680JY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRS-CZ1JF510FY
VRK-CD1JJ680JY
VRK-CD1JJ680JY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRS-CZ1JF510FY
VRK-CD1JJ680JY
VRK-CD1JJ680JY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRK-CD1JJ680JY
AA
AA
AA
AB
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AC
AC
AC
AA
AA
AA
AA
AA
AA
AA
AC
AC
AC
AA
AA
AA
AA
AA
AB
AA
AA
AA
AA
AA
AA
AC
AC
AC
AA
AB
AB
AB
AB
AC
AC
AB
AB
AC
AC
AB
AB
AB
AB
AA
AC
AC
AB
AB
AA
AC
AC
AB
AB
AB
AB
AC
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
22
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
VRK-CD1JJ680JY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRK-CD1JJ680JY
VRK-CD1JJ680JY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRS-CZ1JF510FY
VRK-CD1JJ680JY
VRK-CD1JJ680JY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRS-CZ1JF510FY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRK-CD1JJ392JY
VRK-CD1JJ392JY
VRK-CD1JJ392JY
VRS-CZ1JF392FY
VRS-CH1JF471JY
VRS-CZ1JF392FY
VRK-CD1JJ392JY
VRK-CD1JJ392JY
VRK-CD1JJ392JY
VRS-CZ1JF103FY
VRS-CZ1JF470JY
VRK-CD1JJ470JY
VRS-CZ1JF470JY
VRS-CZ1JF153FY
VRS-CH1JF392JY
VRS-CZ1JF470JY
VRS-CZ1JF153FY
VRS-CH1JF471JY
VRS-CZ1JF392FY
VRS-CZ1JF470JY
VRS-CZ1JF103FY
VRK-CD1JJ470JY
VRK-CD1JJ470JY
VRK-CD1JJ470JY
VRK-CD1JJ470JY
VRS-CH1JF470JY
VRS-CH1JF470JY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF470JY
VRS-CZ1JF103FY
VRS-CZ1JF102FY
VRS-CH1JF101JY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF301FY
VRK-CD1JJ103JY
VRS-CZ1JF390FY
VRS-CZ1JF390FY
VRS-CZ1JF472JY
VRS-CZ1JF182FY
VRS-CZ1JF103FY
VRS-CZ1JF182FY
VRS-CZ1JF102FY
VRS-CZ1JF102FY
VRS-CH1JF103JY
VRS-CZ1JF103FY
VRK-CD1JJ680JY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CH1JF103JY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF470JY
VRS-CH1JF103JY
VRS-CZ1JF103FY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRK-CD1JJ103JY
VRS-CZ1JF103FY
AC
AB
AB
AC
AC
AB
AB
AB
AB
AA
AC
AC
AB
AB
AA
AB
AB
AB
AB
AB
AB
AB
AB
AC
AC
AC
AA
AA
AC
AC
AC
AB
AA
AC
AA
AA
AA
AA
AA
AA
AA
AB
AC
AC
AC
AC
AA
AA
AB
AB
AA
AB
AA
AA
AB
AB
AA
AC
AA
AA
AA
AA
AB
AA
AA
AA
AA
AB
AC
AB
AB
AB
AA
AB
AB
AA
AA
AB
AA
AA
AA
AC
AB
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
23
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
VRK-CD1JJ680JY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF820JY
VRS-CZ1JF392FY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CH1JF103JY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF000JY
VRS-CZ1JF000JY
VRS-CZ1JF000JY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRS-CZ1JF103FY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF103FY
VRS-CZ1JF470JY
VRS-CZ1JF103FY
VRK-CD1JJ680JY
VRS-CH1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRK-CD1JJ220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRS-CZ1JF680JY
VRS-CZ1JF220JY
VRK-CD1JJ680JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRK-CD1JJ220JY
VRK-CD1JJ220JY
VRK-CD1JJ220JY
VRK-CD1JJ220JY
VRK-CD1JJ220JY
VRK-CD1JJ220JY
VRK-CD1JJ220JY
VRK-CD1JJ220JY
VRS-CZ1JF220JY
VRK-CD1JJ151JY
VRK-CD1JJ151JY
VRK-CD1JJ151JY
VRK-CD1JJ151JY
VRK-CD1JJ151JY
VRK-CD1JJ151JY
VRK-CD1JJ151JY
VRK-CD1JJ151JY
VRS-CZ1JF220JY
VRK-CD1JJ220JY
VRK-CD1JJ220JY
VRK-CD1JJ220JY
VRK-CD1JJ220JY
VRK-CD1JJ220JY
VRK-CD1JJ220JY
VRK-CD1JJ220JY
VRK-CD1JJ220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF151JY
VRS-CZ1JF151JY
VRS-CZ1JF151JY
VRS-CZ1JF151JY
VRS-CZ1JF151JY
VRS-CZ1JF151JY
VRS-CZ1JF151JY
VRS-CZ1JF151JY
AC
AA
AA
AA
AA
AB
AB
AA
AA
AB
AB
AA
AB
AB
AA
AA
AA
AA
AA
AB
AA
AA
AB
AA
AB
AC
AA
AA
AA
AA
AA
AC
AA
AA
AB
AB
AB
AB
AA
AC
AA
AA
AC
AC
AC
AC
AC
AC
AC
AC
AA
AC
AC
AC
AC
AC
AC
AC
AC
AA
AC
AC
AC
AC
AC
AC
AC
AC
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
24
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
VRS-CH1JF680JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF151JY
VRS-CZ1JF151JY
VRS-CZ1JF151JY
VRS-CZ1JF151JY
VRS-CZ1JF151JY
VRS-CZ1JF151JY
VRS-CZ1JF151JY
VRS-CZ1JF151JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF220JY
VRS-CZ1JF224JY
VRS-CZ1JF330JY
VRS-CZ1JF330JY
VRS-CZ1JF330JY
VRS-CZ1JF330JY
VRS-CZ1JF000JY
VRS-CZ1JF103FY
VRS-CZ1JF000JY
VRS-CZ1JF103FY
VRS-CZ1JF330JY
VRS-CZ1JF330JY
VRS-CZ1JF000JY
VRS-CZ1JF330JY
VRS-CZ1JF000JY
VRS-CZ1JF330JY
VRS-CZ1JF000JY
VRS-TV1JD222JY
VRS-CZ1JF473FY
VRS-CZ1JF103FY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRK-CD1JJ470JY
VRK-CD1JJ470JY
VRS-CZ1JF104FY
VRS-CZ1JF103FY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRS-CZ1JF472JY
VRS-CZ1JF222FY
VRS-CZ1JF000JY
VRS-CZ1JF562FY
VRS-CZ1JF621FY
VRS-CZ1JF121FY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF560DY
VRS-CZ1JF560DY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF560DY
VRS-CZ1JF560DY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF560DY
VRS-CZ1JF560DY
VRS-CZ1JF472JY
VRS-CZ1JF102FY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF560DY
VRS-CZ1JF560DY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AB
AA
AB
AA
AA
AA
AA
AA
AA
AA
AA
AA
AB
AA
AA
AC
AC
AB
AB
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AB
AB
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
25
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CH1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF470JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF123FY
VRS-CZ1JF102FY
VRS-CH1JF472JY
VRS-CH1JF472JY
VRS-CH1JF472JY
VRS-CH1JF472JY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRS-CZ1JF472JY
VRS-CZ1JF000JY
VRS-CZ1JF470JY
VRS-CH1JF472JY
VRS-CH1JF472JY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF4R7JY
VRS-CZ1JF102FY
VRS-CJ1JF472JY
VRS-CJ1JF470JY
VRS-CZ1JF4R7JY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF000JY
VRS-CZ1JF391JY
VRS-CZ1JF000JY
VRS-CZ1JF000JY
VRS-CZ1JF102FY
VRS-CZ1JF102FY
VRS-CZ1JF102FY
VRS-CZ1JF000JY
VRS-CZ1JF511JY
VRS-CZ1JF000JY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRS-CJ1JF472JY
VRS-CZ1JF472JY
VRS-CJ1JF472JY
VRS-CJ1JF472JY
VRS-CZ1JF000JY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF563JY
VRS-CZ1JF563JY
VRS-CH1JF563JY
VRS-CZ1JF102FY
VRS-CZ1JF103FY
VRS-CH1JF101JY
VRK-CD1JJ470JY
VRS-CH1JF470JY
VRS-CH1JF470JY
VRS-CZ1JF101FY
AB
AB
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AB
AB
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AB
AB
AA
AA
AA
AA
AA
AA
AB
AA
AC
AA
AA
AA
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
26
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF101FY
VRS-CZ1JF101FY
VRS-CZ1JF470JY
VRS-CZ1JF470JY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF560DY
VRS-CZ1JF512JY
VRS-CZ1JF103FY
VRS-CZ1JF101FY
VRS-CZ1JF000JY
VRS-CZ1JF000JY
VRS-CZ1JF000JY
VRS-CZ1JF102FY
VRS-CZ1JF822FY
VRS-CZ1JF272FY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF182FY
VRS-CZ1JF182FY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF103FY
VRS-CZ1JF272FY
VRS-CZ1JF103FY
VRS-CZ1JF104FY
VRS-CZ1JF124FY
VRS-CZ1JF000JY
VRS-CZ1JF000JY
VRS-CZ1JF102FY
VRS-CZ1JF102FY
VRS-CH1JF470JY
VRS-CZ1JF103FY
VRS-CH1JF470JY
VRS-CZ1JF102FY
VRS-CZ1JF470JY
VRK-CD1JJ470JY
VRS-CZ1JF103FY
VRS-CZ1JF470JY
VRS-CZ1JF102FY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CJ1JF103JY
VRK-CD1JJ103JY
VRK-CD1JJ103JY
VRK-CD1JJ103JY
VRK-CD1JJ103JY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AB
AA
AA
AA
AA
AB
AB
AA
AA
AB
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AB
AA
AB
AB
AA
AA
AA
AA
AA
AA
AB
AA
AA
AA
AC
AB
AA
AA
AA
AA
AA
AB
AB
AB
AA
AC
AC
AC
AC
AB
AB
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
27
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF472JY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF221JY
VRS-CZ1JF221JY
VRS-CZ1JF103FY
VRS-CZ1JF563JY
VRS-CZ1JF822FY
VRS-CZ1JF682FY
VRS-CZ1JF154JY
VRS-CZ1JF104FY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF153FY
VRS-CZ1JF273FY
VRS-CZ1JF101FY
VRS-CZ1JF101FY
VRS-CZ1JF101FY
VRS-CZ1JF101FY
VRS-CZ1JF103FY
VRS-CZ1JF273FY
VRS-CZ1JF154JY
VRS-CZ1JF103FY
VRS-CZ1JF392FY
VRS-CZ1JF105JY
VRS-CZ1JF682FY
VRS-CZ1JF103FY
VRS-CZ1JF101FY
VRS-CZ1JF682FY
VRS-CZ1JF100JY
VRS-CZ1JF473FY
VRS-CZ1JF224JY
VRS-CZ1JF103FY
VRS-CZ1JF682FY
VRS-CZ1JF823JY
VRS-CZ1JF682FY
VRS-CZ1JF101FY
VRS-CZ1JF103FY
VRS-CZ1JF153FY
VRS-CZ1JF100JY
VRS-CZ1JF123FY
VRS-CZ1JF100JY
VRS-CZ1JF101FY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-CZ1JF103FY
VRS-TW2ED750JY
VRS-CZ1JF273FY
VRS-CZ1JF473FY
VRS-CZ1JF473FY
VRS-CZ1JF223FY
VRS-CZ1JF102FY
VRS-CZ1JF273FY
VRS-CZ1JF103FY
VRS-CZ1JF183FY
VRS-CZ1JF333JY
QCNCWA251WJZZY
QCNCWA251WJZZY
QCNCWA251WJZZY
QSOCZA072WJZZQ
QSOCZA072WJZZQ
QSOCZA065WJZZ
QSOCZA050WJZZY
VHHM1103J03-1Y
RTUDAA004WJQZ
RH-VXA066WJZZY
RH-VXA066WJZZY
RH-VXA066WJZZY
RH-VXA066WJZZY
RH-VXA066WJZZY
RH-VXA066WJZZY
RH-VXA066WJZZY
RH-VXA066WJZZY
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AA
AB
AB
AB
AA
AA
AB
AA
AA
AA
AA
AB
AB
AB
AA
AA
AA
AA
AA
AA
AB
AA
AA
AB
AA
AA
AA
AB
AA
AA
AA
AA
AA
AB
AA
AA
AA
AA
AB
AA
AA
AA
AA
AA
AB
AB
AB
AB
AA
AA
AA
AA
AA
AA
AA
AB
AA
AA
AH
AH
AH
AH
AH
AH
AH
AC
BD
AC
AC
AC
AC
AC
AC
AC
AC
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
J
28
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
RCRSCA045WJZZY
RCRSCA090WJZZY
RCRSCA108WJZZY
RCRSC0170TAZZY
RCRSZA008WJZZY
RCRSCA071WJZZY
RCRSCA094WJZZY
AG
AG
AF
AG
AQ
AG
AG
J
J
J
J
J
J
J
Crystal, 12.288MHz
Crystal, 36.864MHz
Crystal, 28.322MHz
Crystal, 14.31818MHz
Crystal, 27MHz
Crystal, 24.576MHz
Crystal, 25.140MHz
RBLN-0036CEZZ
RBLN-0036CEZZ
QTANAA008WJZZ
QPLGNA056WJZZ
AB
AB
AD
AB
J
J
J
J
Ferrite core
Ferrite core
Jack
Plug, 2pin (SP-L)
RBLN-0036CEZZ
RBLN-0036CEZZ
QTANAA008WJZZ
QPLGNA056WJZZ
AB
AB
AD
AB
J
J
J
J
Ferrite core
Ferrite core
Jack
Plug, 2pin (SP-R)
29
LC-37D90U
26
1-4
4-4
67 73
12
67
73
73
25
73
25
67
67
3-2
3-3
15-1 15-2
3-4
67
26 39
15
10
13
51
67
74
73
65
74-1-6
74-1-5
74-1-1
73
74-2
74-1
74-1-2
65
74-1-3
1-5
74-1-4
1-6
74-1-3
1-1
1-5
1-2
73
61
63
18
1-3
40
69
18-3
40
18-4
16-1
14
17
67
67
17-1 17-2
16
32
47
9
48
67
38
72
29
41
67
5-1
4-1
67
67
44
42
43
60
32
68
54
67
66
5-2
45
50
5-3
67
49
56
34
30
49
37
64
20
67
55
27
2-4
35
28
35
33
67
62
34
31
2-4
18-2
53
67
2-3
2-1
18-2
62 46
16-2
36
2-2
18-1
69
17-3
17-4
75
23
63
71
57
72
74-1-6
73
11
58
1-6
34
67
3-1
52
59
39
41
24
19
22
4-2
70
4-3
4
4-5
47
4-3
6
21
30
4-5
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
CCABAB315WJ01
Not Available
GCOVAB501WJSA
Not Available
HDECCA010WJSA
PSPAHA416WJZZ
PSPAHA801WJZZ
CCABBA764WJ01
Not Available
HiNDPB700WJSA
LHLDWA131WJKZ
LHLDZA644WJZZ
CCOVAB497WJ01
Not Available
JBTN-A429WJKA
JBTN-A535WJKA
MSPRCA049WJFW
CDAi-A195WJKA
GDAi-A195WJKA
LANGKA443WJSA
PSPAZA476WJZZ
PSPAZA477WJZZ
PSPAZA617WJZZ
CHNG-A105WJSA
GDAi-A196WJSA
GDAi-A200WJF7
MHNG-A105WJSA
XCSSN50P25000
R1LK370D3LZ1AB
DKEYDD743FM21
DUNTKD643FM11
DUNTKD716FM06
DUNTKD641FM10
DUNTKD744WE01
DUNTKD745WE01
RDENCA169WJQZ
CANGKA702WJ01
Not Available
PSPAHA811WJZZ
CANGKA722WJ01
Not Available
PSHEPA454WJU0
CANGTA317WJ01
Not Available
LHLDWA123WJKZ
PSPAGA329WJ00
XBPS730P08WS0
CANGTA330WJ01
Not Available
LHLDWA092WJZZ
PSPAGA329WJ00
XBPS730P08WS0
GCOVAA678WJKA
GCOVAB166WJKB
GCOVAB582WJKA
HiNDPB695WJSA
HiNDPB670WJSA
LANGKA644WJFW
LANGKA701WJFW
LANGKA703WJFW
LANGKA720WJN1
LANGKA721WJN1
LANGKA749WJFW
LBSHZA005WJZZ
LCHSMA286WJFW
LHLDW1025TAZZ
LHLDW1141CEZZ
LHLDWA004WJZZ
LHLDWA043WJKZ
LHLDWA048WJKZ
LHLDWA092WJZZ
LHLDWA096WJKZ
LHLDWA145WJKZ
NFANR0126CEZZ
NSFTZ0134CEFW
PRDARA192WJFW
PRDARA204WJFW
PRDARA312WJFW
PRDARA338WJFW
PSLDMA910WJFW
PSPAZA635WJKZ
PSPAZA700WJKZ
PSPAZA917WJKZ
PSPAZB192WJKZ
QCNW-E386WJQZ
AC
AE
AD
AC
AC
AD
AD
AB
EZ
AH
AB
AH
AE
AP
AN
AB
AE
AD
AB
AB
AB
AD
AC
AT
AD
AE
AC
AD
AH
AF
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
31
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
QCNW-E439WJQZ
QCNW-E503WJQZ
QCNW-E513WJPZ
QCNW-E516WJQZ
QCNW-E517WJQZ
QCNW-E519WJQZ
QCNW-E520WJQZ
QCNW-E521WJQZ
QPWBHD838WJQZ
QEARPA221WJFW
XBBS740P06000
XBBS830P06000
XBBS940P08000
XBBS940P25000
XBBSN50P12JS0
XBPS730P06WS0
XBPS930P08000
XBPSN30P20JS0
XEBS930P08000
XEBS930P10000
XEBS940P16000
XEBSN30P10000
DSP-ZA140WE01
CPNLSA060WJ01
HPNC-A127WJSA
HPNLSA060WJKA
PCUSUA001WJZZ
PSPAHA807WJZZ
PSPAZB076WJSA
PSPAZB124WJZZ
RSP-ZA140WJN2
Not Available
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
-
AA
AA
AB
AB
AF
AA
AB
AA
AA
AB
AA
AD
Cable Clamp
X2
Cable Band
X5
Operation Manual
X6
X3
AC Cord
X4
X7
X8
X9
NO.
PARTS CODE
DESCRIPTION
X1
X2
X3
X4
X5
X6
X7
X8
X9
LHLDW0110CESD
LHLDWA083WJ00
QACCDA039WJPZ
RRMCGA468WJSA
TiNS-C310WJZZ
Not Available
SSAKAA032WJZZ
SSAKA0101GJZZ
TCADEA126WJZZ
AE
AD
AQ
AZ
AB
X
X
X
X
X
X
X
X
Cable Clamp
Cable Band
AC Cord
Remote Control Unit
Operation Manual
"AAA" Size Battery
Polyethylene Bag
Polyethylene Bag
Enquete Card
32
LC-37D90U
S5
S3
S4
S5
S6
S5
S2
S7
S1
NO.
PARTS CODE
DESCRIPTION
SPAKCC517WJZZ
SPAKFA977WJZZ
SPAKPA338WJZZ
SPAKPA487WJZZ
SPAKXB057WJZZ
SPAKXB058WJZZ
TLABKA009WJZZ
Packing Case
Stand Sheet
Wrapping Paper (Monitor)
Wrapping Paper (Stand)
Packing Add. (Top) (Bottom)
Packing Add. (Stand)
No. Label
33
LC-37D90U
NO.
PARTS CODE
DESCRIPTION
AW
QCNW-C799WJPZ
QCNW-E134WJPZ
QCNW-E580WJQZ
QCNW-E579WJQZ
QCNW-E581WJQZ
AG
BG
J
J
J
J
J
34
LC-37D90U
MEMO
LC-37D90U
COPYRIGHT
TQ0000-S
May. 2006 Printed in Japan
Design and Production Information
Design: Japan
Production: SMM
MI. KD
SHARP CORPORATION
AV Systems Group
CS Promotion Center
Yaita, Tochigi 329-2193, Japan