0 valutazioniIl 0% ha trovato utile questo documento (0 voti)
33 visualizzazioni1 pagina
This document outlines a quality assurance protocol for inspecting tanks, including commonly inspected items such as welds, nozzles, dimensional checks, and surfaces. It specifies that independent inspection reports will be incorporated into the quality assurance manual. Hold points are designated for inspection stages including weld procedures, assembly steps, hydrostatic testing, and polishing. The protocol also requires maintaining records of drawing approvals in the quality assurance manual and getting client approval for new or modified drawings.
This document outlines a quality assurance protocol for inspecting tanks, including commonly inspected items such as welds, nozzles, dimensional checks, and surfaces. It specifies that independent inspection reports will be incorporated into the quality assurance manual. Hold points are designated for inspection stages including weld procedures, assembly steps, hydrostatic testing, and polishing. The protocol also requires maintaining records of drawing approvals in the quality assurance manual and getting client approval for new or modified drawings.
This document outlines a quality assurance protocol for inspecting tanks, including commonly inspected items such as welds, nozzles, dimensional checks, and surfaces. It specifies that independent inspection reports will be incorporated into the quality assurance manual. Hold points are designated for inspection stages including weld procedures, assembly steps, hydrostatic testing, and polishing. The protocol also requires maintaining records of drawing approvals in the quality assurance manual and getting client approval for new or modified drawings.
Inspection of completed welds Inspection of nozzle and flange fabrication Pre-polish inspection Nozzle preparation and set-up Dimensional check of tank and nozzles Inspection of probe pocket fabrication Grinding and polishing of internal welds Inspection of internal tank surfaces Passivation Witnessing of pressure testing Pressure gauge calibration certificate (if applicable) Final inspection of tank Tank documentation Pressure vessel certification Independent tank inspection reports will also be incorporated into the Quality Assurance manual. Hold Points The following designated production hold points shall be incorporated into the Inspection and Test Plan. The IET shall give client a minimum of 72 hours prior to reaching any hold point inspection stage: qualification of weld procedures/operators; assembly of jacket spirals to inner shell; (for jacketed vessels only) welding of stay to inner shell and dished heads; initial assembly of jacket shell to heads; (for jacketed vessels only) at completion of welding of pressure retaining components; hydrostatic test; Roughness testing for surface finish; and at completion of final polishing prior to packing. Will Client waive the right to the nominated inspection IET shall carry out internal checks and document the same for future verification by the client Drawing Approvals Records of new or modified drawings will be maintained as part of the quality assurance manual. All new drawings and modifications will be approved by Client prior to distribution or implementation