Sei sulla pagina 1di 1

TRASFORMATORE PER SUB / MINISUB

TRANSFORMER FOR SUB / MINISUB


N1 PRESSACAVO PG16
N1 CABLE GLAND PG16

N1 PRESSACAVO PG11
N1 CABLE GLAND PG11

30 mm

92,5 mm

141mm

CARATTERISTICHE TECNICHE:
Trasformatore toroidale di sicurezza da 50VA (per MINISUB) o da 300VA (per SUB)
Con protezione termica
Conforme alle normative di settore
Contenitore in policarbonato
Con pressacavi preinstallati per l'ingresso/circuito primario (220/230/240V 50/60Hz) e per l'uscita/circuito secondario (12V)
Grado di protezione IP65
ISTRUZIONI DI MONTAGGIO:
Aprire il box ed effettuare il cablaggio elettrico utilizzando cavi di dimensione adeguata al pressacavo
PG11 (Dmin=6mm D max =8,5 mm) PG16 (Dmin=10mm D max =14 mm)
Bloccare i pressacavi
Richiudere il box in questa fase prestare molta attenzione al posizionamento della guarnizione interna al box
AVVERTENZE
Togliere tensione prima effettuare manutenzioni
L' installazione deve essere eseguita da personale qualificato secondo
le norme di settore
Il rispetto di queste norme molto importante per l'efficienza dell'apparecchio
e per la sicurezza delle persone, pertanto esse vanno conservate
TECHNICAL INFORMATION:
Safety toroidal transformer - 50VA (for MINISUB) or 300VA (for SUB)
With thermal protection
In compliance with the european standards
Box in policarbonate
With preinstalled cable glands for entry/primary circuit (220/230/240V 50/60Hz) and for output/secondary circuit (12V)
IP65 - protection
INSTALLATION INSTRUCTIONS:
Open the box and connect them to the terminal block using cable wires of the right dimension respect at the cable gland
PG11 (Dmin=6mm D max =8,5 mm) PG16 (Dmin=10mm D max =14 mm)
Close the cable gland.
Close the box, put carefully the gasket of the plastic box in the original position
RECOMMENDATIONS:
Disconnect the supply before effecting the maintenance
Installation should be carried out by a suitably qualified person in accordance
with good electrical practice and the appropiate national wiring regulations
Is very important to follow these instructions to, enable the fitting to be installed
correctly. Please retain for information.

ISTRTRASFSUB REV.4 03-06

Potrebbero piacerti anche