Sei sulla pagina 1di 1
Send Rucon) Peete Rs Important Instructions Subject No. 735P3 Brake Pad Kit f Use With Topload Washers Install brake pads so the countersunk holes are up against the weldment anid bearing assembly. See illustration, IMPORTANT: When installing brake assembly, we recomend replacing three brake pads. DO NOT replace worn pads only. Apply a small amount of 26594P Silicone Lubricant to both sides of each brake pad ‘where it will contact the brake assembly. DO NOT OVER LUBRICATE! Excess lubricant can be thrown into the pivot dome area during normal washer operation. Any lubricant on the pivot dome, base or frietion ring will affect washer operation. This condition will persist until lubricant is removed. WELDMENT ANE BEARING ASSEMBLY eg eo ‘COUNTERSUNK HOLES ‘COUNTERSUNK HOLES RSP.C. P.O. Box 990 Form No, 5-99-44 Ripon, WI 54971-0990 Paget oft June 1999

Potrebbero piacerti anche