Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Figure 3
(If you need the Register Code, please refer to Steps 5~8.)
(If you have the Register Code, directly proceed to step 9.)
Figure 2
3. In Figure 2, type in the serial number, which is located on
the back of the Creader VII+ / Creader VIII.
4. After the serial number is entered, click Update to jump
to the registration page. Enter the following information
and click Submit (refer to Figure 3).
Figure 5
8. The register code shown in Figure 6 is the register code
for inputting in step 4.
Figure 6
(Return to step 4 and input the code and then proceed)
9. Install the TF card from the tool into the supplied USB TF
card adaptor and insert into the USB port of the computer.
10. Reopen the Creader VII+ / Creader VIII update tool, select
the updates you would like to perform or click Select
All, and then click Download to start downloading. See
Figure 7.
Figure 7
11. Once all steps are complete, reinsert the TF card into the
tool and power the tool via USB cable (one end to Creader
VII+ / Creader VIII and the other end to the computer) or
via OBD II cable (one end to OBD II connector of Creader
VII+ / Creader VIII and the other end to the vehicles DLC).
A dialog box prompting you to upgrade will pop up on the
screen (See Figure 8), select OK button to proceed.
Figure 8
12.The registration process is now complete!