0%(1)Il 0% ha trovato utile questo documento (1 voto)
119 visualizzazioni1 pagina
The document lists various hardware events that can occur on DC3000/MC3000 systems including low system voltage, an overheated drive, a hardware/software mismatch between the drive and motor, the drive being deactivated during operation, a tool motor stall, and a high current offset at tightening start. Notes are provided for some events regarding further actions like part not ready (PNFR) or acknowledging (ACK) the event.
The document lists various hardware events that can occur on DC3000/MC3000 systems including low system voltage, an overheated drive, a hardware/software mismatch between the drive and motor, the drive being deactivated during operation, a tool motor stall, and a high current offset at tightening start. Notes are provided for some events regarding further actions like part not ready (PNFR) or acknowledging (ACK) the event.
The document lists various hardware events that can occur on DC3000/MC3000 systems including low system voltage, an overheated drive, a hardware/software mismatch between the drive and motor, the drive being deactivated during operation, a tool motor stall, and a high current offset at tightening start. Notes are provided for some events regarding further actions like part not ready (PNFR) or acknowledging (ACK) the event.
Event code Event name Information Note E601 System voltage low DC voltage too low PFNR TNR ACK E603 Drive overheated The DC drive is too hot, drive deactivated. TNR E618 Drive HW/SW mismatch Drive hardware and software mismatch. Check motor type in ToolsTalk DS/DL. ACK E619 Drive deactivated DC drive deactivated during operation. E620 Tool stall Tool motor stall. E621 High current offset High current offset at tightening start