Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
SS-MS525/V521
SERVICE MANUAL
US Model
Canadian Model
AEP Model
UK Model
E Model
Australian Model
Ver.1.0 2001.2
SS-MS525
SS-V521
SA-WMS525
SPECIFICATION
SS-MS525 (front,center, and rear speakers)
SS-V521
Speaker system
Speaker units
Enclosure type
Rated impedance
Power handling capacity
Maximum input power:
Sensitivity level
Frequency range
Dimensions (w/h/d)
Mass
Full range x 2,
magnetically shielded
5 cm (2 in.), balance drive
type
Bassreflex
8 ohms
120 watts
87 dB (1 W, 1 m)
120 Hz - 20,000 Hz
When attached speaker
grille:
Approx. 89 x 144 x 130
mm (3 5/ 8 x 5 3/ 4 x 5 1/ 8
in.)
When attached supplied
speaker stand:
Approx. 89 x 128 x 143
mm (3 5/ 8 x 5 1/ 8 x 5 3/ 4
in.) (pointed upwards)
Approx. 89 x 122 x 143
mm (3 5/ 8 x 4 7/ 8 x 5 3/ 4
in.) (pointed downwards)
When attached speaker
grille:
Approx. 750 g (1 lb 10 oz)
When attached supplied
speaker stand:
Approx. 850 g (1 lb 14 oz)
SA-WMS525 (subwoofer)
Speaker system
Active subwoofer,
magnetically shielded
Speaker unit
Woofer: 20 cm (8 in.),
cone type
Enclosure type
Advanced SAW type
Reproduction frequency range
26 Hz - 250 Hz
Amplifier section
Rated Power Output
120 W (8 ohms 20 Hz - 20
kHz, THD 0.8%)
Inputs
Outputs
LINE OUT (output pin jack)
SPEAKER OUT (output terminals)
General
Power requirements
USA and Canada:
Europe and Australia:
E:
Power consumptions
120 V AC, 60 Hz
220 - 230 V AC, 50/60 Hz
110-120V/220-240V AC, 50/60Hz
90 W
1 W (standby mode)
Approx. 230 x 392 x
464 mm (9 1/ 8 x 15 1/ 2 x
18 3/ 8 in.), including front
grille
Approx. 13.2 kg
(29 lb 2 oz)
Dimensions (w/h/d)
Mass
Supplied accessories
SA-VE525
Foot pads (16)
Center speaker stand (1)
Screw (for the center speaker stand) (1)
Washer (for the center speaker stand) (1)
Audio connecting cord (1)
Speaker connecting cords, 10 m (32 ft 9 3/ 4 in.) (2)
Speaker connecting cords, 3.5 m (11 ft 6 in.) (3)
Speaker connecting cords, 2.5 m (8 ft 2 1/ 2 in.) (2)
SA-VE522
Foot pads (8)
Audio connecting cord (1)
Speaker connecting cords, 3.5 m (11 ft 6 in.) (2)
Speaker connecting cords, 2.5 m (8 ft 2 1/ 2 in.) (2)
SS-V521
Foot pads (4)
Speaker connecting cords, 10m (32 ft 9 3/ 4 in.) (1)
Design and specifications are subject to change without
notice.
ACTIVE SUBWOOFER
9-873-807-11
Sony Corporation
2001B0900-1
2001. 2
SA-VE522/VE525/WM525/SS-MS525/V521
SAFETY CHECK-OUT
TABLE OF CONTENTS
(US model)
1. GENERAL .......................................................................... 3
LEAKAGE
2. DIAGRAMS
2-1. Circuit Boards Location ........................................................ 3
2-2. Schematic Diagram ............................................................... 4
2-3. Printed Wiring Board ............................................................ 5
3. EXPLODED VIEW
The AC leakage from any exposed metal part to earth ground and
from all exposed metal parts to any exposed metal part having a
return to chassis, must not exceed 0.5 mA (500 microamperes).
Leakage current can be measured by any one of three methods.
1.
2.
3.
To Exposed Metal
Parts on Set
0.15F
1.5k
AC
voltmeter
(0.75V)
Earth Ground
SA-VE522/VE525/WM525/SS-MS525/V521
SECTION 2
DIAGRAMS
SECTION 1
GENERAL
Location of controls
Note:
X : parts extracted from the component side.
Y : parts extracted from the conductor side.
b : Pattern from the side which enables seeing.
Note:
All capacitors are in F unless otherwise noted. pF: F
50 WV or less are not indicated except for electrolytics
and tantalums.
All resistors are in and 1/4 W or less unless otherwise
specified.
C : panel designation.
Note:
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part
number specified.
Note:
Les composants identifis par
une marque 0 sont critiques
pour la scurit.
Ne les remplacer que par une
pice por tant le numro
spcifi.
: B+ Line.
: B Line.
Voltages are dc with respect to ground under no-signal conditions.
no mark : Power on
: Impossible to measure
Voltages are taken with a VOM (Input impedance 10M).
Voltage variations may be noted due to normal preduction
tolerances.
Signal path.
K : AUDIO
1 POWER button
2 ON/STANDBY indicator
3 LEVEL dial
4 MODE dial
Abbreviation
CND : Canadian model
SP : Singapore model
MX : Mexican model
POWER board
AUTO POWER board
LED board
MAIN board
CONTROLboard
SA-VE522/VE525/WM525/SS-MS525/V521
2-3. SCHEMATIC DIAGRAM
SA-VE522/VE525/WM525/SS-MS525/V521
MAIN BOARD
There are a few cases that the part isnt mounted in
model is printed on diagram.
J101
IN
LINE
OUT
CONTROL BOARD
TM101
Semiconductor
Location
Ref. No.
SP
SPEAKER
11
OUT
IN
(11)
1-680-785-
Location
D101
D102
D103
D104
D303
D304
D305
D306
D501
D502
D503
D505
D506
D507
D701
D702
D703
D704
B-5
B-5
B-6
B-6
B-4
B-4
C-4
E-4
E-4
E-4
E-4
E-4
D-4
D-4
C-5
C-5
C-5
C-5
IC101
IC102
IC104
A-6
A-5
C-4
Ref. No.
Location
Q101
Q301
Q302
Q303
Q304
Q305
Q306
Q307
Q308
Q309
Q310
Q311
Q501
Q502
Q701
Q702
Q703
Q704
Q705
A-5
B-4
A-4
A-4
A-5
A-5
B-4
B-5
D-4
D-4
C-4
D-4
D-4
D-4
C-6
C-5
D-6
D-4
D-4
S701
AUTO POWER
SAVE
POWER BOARD
SP
AC
IN
11
(11)
1-680-786-
SP
SP
LED
BOARD
POWER SW BOARD
11
11
(11)
(11)
1-680-784-
11
(11)
1-680-788-
11
EXCEPT SP
(11)
1-680-789-
1-680-787-
SA-VE522/VE525/WM525/SS-MS525/V521
SECTION 3
EXPLODED VIEWS
NOTE:
-XX and -X mean standardized parts, so they
may have some difference from the original
one.
Color Indication of Appearance Parts
Example:
KNOB, BALANCE (WHITE) . . . (RED)
56
#5
54
#3
not supplied
#5
#5
T601
55
not
supplied
#5
SP901
#5
#5
#5
#5
#5
not
supplied
#4
#5
#4
53
60
#3
#1
T501
#1
5
4
Supplied with
RV201 and S201
57
58
8
3
7
#2
not supplied
9
52
#2
Part No.
Description
X-4953-330-1
X-4953-555-1
3-703-564-21
4-227-298-01
4-999-482-31
FRAMEASSY, GRILLE
PANELASSY, FRONT
SCREW,TAPPING
SHEET
KNOB(VOL)
51
10
Ref. No.
1
2
3
4
5
59
52
Ref. No.
#5
#5
Remark
Ref. No.
Part No.
Description
6
7
8
9
10
4-231-866-01
1-680-787-11
4-973-938-51
1-680-788-11
1-680-785-11
PACKING
POWER SWITCH BOARD
KNOB(A), PUSH
LED BOARD
CONTROL BOARD
SP901
Remark
Part No.
Description
51
52
53
54
55
A-4412-638-A
4-981-864-01
1-680-789-11
1-680-786-11
3-905-609-01
56
56
56
56
57
4-232-739-11
4-232-739-21
4-232-739-31
4-232-739-41
1-777-071-21
Remark
Ref. No.
57
* 58
59
* 60
0 T501
Part No.
1-783-820-11
3-703-244-00
A-4476-543-A
3-703-044-26
1-435-999-11
Description
Remark
CORD,POWER (US,CND,MX)
BUSHING (2104), CORD
MAINMOUNTED PC BOARD
LABEL, CAUTION (US,CND,MX)
TRANSFORMER, POWER (US,CND,MX)
0 T501
0 T501
0 T601
0 T601
0 T601
1-437-219-11
1-437-246-11
1-435-993-11
1-435-994-11
1-435-995-11
SA-VE522/VE525/WM525/SS-MS525/V521
SP
105
106
104
104
104
102
103
SP
102
101
Ref. No.
101
102
103
104
105
Part No.
Description
X-4953-331-1
4-231-872-01
4-231-867-01
4-986-971-11
X-4953-556-1
Remark
Ref. No.
106
SP
Part No.
Description
1-694-516-21 TERMINAL, SPEAKER
1-529-977-11 SPEAKER (5CM)
Remark
SA-VE522/VE525/WM525/SS-MS525/V521
SECTION 4
AUTO POWER CONTROL ELECTRICAL PARTS LIST
NOTE:
Ref. No.
Part No.
Description
Due to standardization, replacements in the
parts list may be different from the parts
specified in the diagrams or the components
used on the set.
-XX, -X mean standardized parts, so they
may have some difference from the original
one.
Items marked * are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when
ordering these items.
CAPACITORS:
uF: F
RESISTORS
All resistors are in ohms.
METAL: metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F: nonflammable
Ref. No.
Part No.
Part No.
Description
Remarks
Ref. No.
R602
Description
Remarks
Part No.
Description
1-247-843-11 CARBON
Remarks
3.3K
5%
1/4W
HOLDER, FUSE
RY601
RY602
1-113-925-11 CERAMIC
1-113-925-11 CERAMIC
0 C4
1-113-925-11 CERAMIC
0 C5
C601
1-113-924-11 CERAMIC
1-104-666-11 ELECT
20.00% 250V
20.00% 250V
(CND,AEP,UK,US,MX)
0.01uF
20.00% 250V
(SP)
0.0047uF 20.00%250V
220uF
20.00% 25V
1-104-666-11
1-126-964-11
1-126-964-11
1-126-964-11
1-126-964-11
220uF
10uF
10uF
10uF
10uF
C602
C603
C604
C605
C606
ELECT
ELECT
ELECT
ELECT
ELECT
1-564-505-11
1-564-505-11
1-564-104-00
1-564-507-11
20.00%
20.00%
20.00%
20.00%
20.00%
25V
50V
50V
50V
50V
PLUG, CONNECTOR 2P
PLUG, CONNECTOR 2P
PIN, CONNECTOR (B3P-VH) 3P
PLUG, CONNECTOR 4P
< DIODE >
DIODE
DIODE
DIODE
DIODE
DIODE
0.01uF
0.01uF
D601
D602
D603
D604
D605
8-719-974-59
8-719-974-59
8-719-974-59
8-719-974-59
8-719-921-88
1SR139-100
1SR139-100
1SR139-100
1SR139-100
MTZJ-13B
D606
D607
D608
0 S601
1-136-165-00
1-136-169-00
1-136-169-00
1-136-169-00
1-136-169-00
MYLAR
MYLAR
MYLAR
MYLAR
MYLAR
0.1uF
0.22uF
0.22uF
0.22uF
0.22uF
5.00%
5.00%
5.00%
5.00%
5.00%
50V
50V
50V
50V
50V
C206
C207
C208
C209
C210
1-136-169-00
1-136-169-00
1-136-169-00
1-136-169-00
1-136-169-00
MYLAR
MYLAR
MYLAR
MYLAR
MYLAR
0.22uF
0.22uF
0.22uF
0.22uF
0.22uF
5.00%
5.00%
5.00%
5.00%
5.00%
50V
50V
50V
50V
50V
C211
C212
C213
C214
1-126-964-11
1-126-964-11
1-136-165-00
1-136-165-00
ELECT
ELECT
MYLAR
MYLAR
10uF
10uF
0.1uF
0.1uF
20.00%
20.00%
5.00%
5.00%
50V
50V
50V
50V
5%
5%
1/4W
1/4W
<FUSE>
0 F601
0 F601
0 F601
0 F602
1-532-744-11
1-532-463-11
1-532-215-00
1-532-259-00
D201
D202
< IC >
IC201
IC202
IC203
IC204
8-759-145-58
8-759-145-58
8-759-145-58
8-759-145-58
IC
IC
IC
IC
BA4558
BA4558
BA4558
BA4558
1-247-843-11 CARBON
3.3K
5%
1/4W
R201
R202
1-247-831-91 CARBON
1-247-855-91 CARBON
1K
10K
SA-VE522/VE525/WM525/SS-MS525/V521
CONTROL
Ref. No.
Part No.
Description
Remarks
R203
R204
R205
1-247-843-11 CARBON
1-247-873-91 CARBON
1-247-855-91 CARBON
3.3K
56K
10K
5%
5%
5%
1/4W
1/4W
1/4W
R206
R207
R208
R209
R210
1-247-851-91
1-247-871-91
1-247-855-91
1-247-855-91
1-247-859-91
CARBON
CARBON
CARBON
CARBON
CARBON
6.8K
47K
10K
10K
15K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R211
R212
R213
R214
R215
1-247-839-91
1-247-807-31
1-247-855-91
1-247-845-91
1-247-845-91
CARBON
CARBON
CARBON
CARBON
CARBON
2.2K
100
10K
3.9K
3.9K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R216
R217
R218
R219
R220
1-247-855-91
1-247-855-91
1-247-855-91
1-247-853-91
1-247-853-91
CARBON
CARBON
CARBON
CARBON
CARBON
10K
10K
10K
8.2K
8.2K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R221
1-247-807-31 CARBON
100
5%
1/4W
Ref. No.
MAIN
Part No.
Description
C501
C502
C503
C504
C505
1-130-955-00
1-130-955-00
1-135-782-11
1-135-782-11
1-104-666-11
FILM
FILM
ELECT CHIP
ELECT CHIP
ELECT
0.01uF
0.01uF
10000uF
10000uF
220uF
5%
5%
20%
20%
20.00%
100V
100V
80V
80V
25V
Remarks
C506
C507
C508
C509
C510
1-104-666-11
1-126-964-11
1-126-964-11
1-104-664-11
1-104-664-11
ELECT
ELECT
ELECT
ELECT
ELECT
220uF
10uF
10uF
47uF
47uF
20.00%
20.00%
20.00%
20.00%
20.00%
25V
50V
50V
25V
25V
C511
C512
C513
C514
C515
1-164-159-21
1-164-159-21
1-126-964-11
1-126-964-11
1-164-159-21
CERAMIC
CERAMIC
ELECT
ELECT
CERAMIC
0.1uF
0.1uF
10uF
10uF
0.1uF
50V
50V
20.00% 50V
20.00% 50V
50V
C516
C701
1-164-159-21 CERAMIC
1-104-661-91 ELECT
0.1uF
330uF
50V
20.00% 16V
CN101
CN301
CN302
CN501
CN502
1-564-508-11
1-564-243-11
1-565-792-11
1-564-687-11
1-564-507-11
PLUG, CONNECTOR 5P
PIN, CONNECTOR 6P
PIN, CONNECTOR 2P
PIN, CONNECTOR 3P
PLUG, CONNECTOR 4P
CN701
1-162-286-31
1-162-286-31
1-162-286-31
1-162-286-21
1-126-964-11
CERAMIC
CERAMIC
CERAMIC
CERAMIC
ELECT
220PF
220PF
220PF
220PF
10uF
10%
10%
10%
10.00%
20.00%
50V
50V
50V
50V
50V
C106
C107
C108
C109
C110
1-162-215-31
1-162-215-31
1-136-163-00
1-136-164-00
1-136-174-00
CERAMIC
CERAMIC
MYLAR
MYLAR
MYLAR
47PF
47PF
0.068uF
0.082uF
0.56uF
5%
5%
5.00%
5.00%
5.00%
50V
50V
50V
50V
50V
C111
C116
C117
C118
C301
1-136-163-00
1-136-153-00
1-136-153-00
1-126-964-11
1-136-153-00
MYLAR
FILM
FILM
ELECT
FILM
0.068uF
0.01uF
0.01uF
10uF
0.01uF
5.00%
5%
5%
20.00%
5%
50V
50V
50V
50V
50V
C303
C304
C305
0 C306
0 C307
1-126-964-11
1-162-282-31
1-102-121-00
1-101-804-00
1-101-810-00
ELECT
CERAMIC
CERAMIC
CERAMIC
CERAMIC
10uF
100PF
2200PF
10PF
100PF
20.00%
10%
10%
5%
5%
50V
50V
50V
500V
500V
C308
C309
C310
C311
C312
1-126-934-11
1-128-560-11
1-128-560-11
1-130-313-11
1-136-165-00
ELECT
ELECT
ELECT
FILM
MYLAR
220uF
22uF
22uF
0.047uF
0.1uF
20.00%
20.00%
20.00%
5.00%
5.00%
10V
100V
100V
100V
50V
C313
C314
C315
C316
C317
1-130-471-00
1-136-161-00
1-126-934-11
1-126-964-11
1-126-948-11
MYLAR
MYLAR
ELECT
ELECT
ELECT
0.001uF
0.047uF
220uF
10uF
100uF
5%
5.00%
20.00%
20.00%
20.00%
50V
50V
10V
50V
35V
8-719-991-33
8-719-991-33
8-719-991-33
8-719-991-33
8-719-991-33
DIODE
DIODE
DIODE
DIODE
DIODE
1SS133T-77
1SS133T-77
1SS133T-77
1SS133T-77
1SS133T-77
D304
D305
D306
D501
D502
8-719-991-33
8-719-991-33
8-719-991-33
8-719-302-37
8-719-974-59
DIODE
DIODE
DIODE
DIODE
DIODE
1SS133T-77
1SS133T-77
1SS133T-77
RBV-602
1SR139-100
D503
D504
D505
D506
D507
8-719-974-59
8-719-974-59
8-719-974-59
8-719-921-88
8-719-921-88
DIODE
DIODE
DIODE
DIODE
DIODE
1SR139-100
1SR139-100
1SR139-100
MTZJ-13B
MTZJ-13B
D701
D702
D703
D704
8-719-991-33
8-719-991-33
8-719-991-33
8-719-991-33
DIODE
DIODE
DIODE
DIODE
1SS133T-77
1SS133T-77
1SS133T-77
1SS133T-77
< IC >
IC101
IC102
IC104
IC301
IC701
8-759-145-58
8-759-145-58
8-759-145-58
8-759-145-58
8-759-145-58
IC
IC
IC
IC
IC
BA4558
BA4558
BA4558
BA4558
BA4558
Q101
Q301
Q302
SA-VE522/VE525/WM525/SS-MS525/V521
MAIN
Ref. No.
Part No.
Description
Remarks
Q303
Q304
Q305
Q306
Q307
Q308
Q309
8-729-119-78
8-729-214-51
8-729-270-51
8-729-119-78
8-729-178-41
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2785-HFE
2SA1145-O
2SC2705-O
2SC2785-HFE
2SC2784-P
Q310
Q311
Q501
Q502
Q701
8-729-119-78
8-729-029-86
1-800-937-11
1-800-938-11
8-729-029-86
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2785-HFE
DTC124ESA
2SC2003
2SA954
DTC124ESA
Q702
Q703
Q704
Q705
8-729-119-77
8-729-029-86
8-729-029-40
8-729-029-40
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1175-FEK
DTC124ESA
DTA124ESA
DTA124ESA
1-260-107-11
1-260-107-11
1-247-871-91
1-247-871-91
1-247-855-91
CARBON
CARBON
CARBON
CARBON
CARBON
4.7K
4.7K
47K
47K
10K
5%
5%
5%
5%
5%
1/2W
1/2W
1/4W
1/4W
1/4W
R106
R107
R108
R109
R110
1-247-855-91
1-247-855-91
1-247-855-91
1-247-839-91
1-247-839-91
CARBON
CARBON
CARBON
CARBON
CARBON
10K
10K
10K
2.2K
2.2K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R111
R112
R113
R114
R115
1-247-855-91
1-247-831-91
1-247-831-91
1-247-879-91
1-247-879-91
CARBON
CARBON
CARBON
CARBON
CARBON
10K
1K
1K
100K
100K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R116
R117
R118
R119
R120
1-247-855-91
1-247-843-11
1-247-855-91
1-247-837-91
1-247-839-91
CARBON
CARBON
CARBON
CARBON
CARBON
10K
3.3K
10K
1.8K
2.2K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R121
R122
R123
R124
R125
1-247-869-81
1-247-831-91
1-247-867-81
1-247-845-91
1-247-845-91
CARBON
CARBON
CARBON
CARBON
CARBON
39K
1K
33K
3.9K
3.9K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R126
R136
R137
R138
R139
1-247-807-31
1-247-859-91
1-247-863-91
1-247-867-81
1-247-839-91
CARBON
CARBON
CARBON
CARBON
CARBON
100
15K
22K
33K
2.2K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R140
R141
R301
R302
R303
1-247-839-91
1-247-887-00
1-247-855-91
1-247-855-91
1-247-855-91
CARBON
CARBON
CARBON
CARBON
CARBON
2.2K
220K
10K
10K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R304
R305
R306
R307
R308
1-247-863-91
1-247-873-91
1-247-819-81
1-247-859-91
1-249-408-91
CARBON
CARBON
CARBON
CARBON
CARBON
22K
56K
330
15K
180
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
Ref. No.
Part No.
Description
0 R309
0 R310
R311
R312
0 R313
1-247-813-91
1-249-408-91
1-247-855-91
1-247-863-91
1-249-407-11
CARBON
CARBON
CARBON
CARBON
CARBON
180
180
10K
22K
150
5%
5%
5%
5%
5%
Remarks
1/4W F
1/4W F
1/4W
1/4W
1/4W F
0 R314
R315
R316
0 R317
0 R318
1-249-401-11
1-247-873-91
1-247-835-91
1-249-393-11
1-249-393-11
CARBON
CARBON
CARBON
CARBON
CARBON
47
56K
1.5K
10
10
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1/4W F
1/4W F
0 R319
R320
R321
R322
R323
1-249-393-11
1-217-156-00
1-215-868-00
1-247-855-91
1-247-827-91
CARBON
METAL
METAL OXIDE
CARBON
CARBON
10
0.22
680
10K
680
5%
10%
5%
5%
5%
1/4W F
5W
1W
1/4W
1/4W
R324
R325
R326
R327
R328
1-247-831-91
1-247-831-91
1-247-831-91
1-247-855-91
1-247-857-91
CARBON
CARBON
CARBON
CARBON
CARBON
1K
1K
1K
10K
12K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R329
R330
R331
R332
R333
1-247-839-91
1-215-868-00
1-247-831-91
1-247-859-91
1-247-837-91
CARBON
METAL OXIDE
CARBON
CARBON
CARBON
2.2K
680
1K
15K
1.8K
5%
5%
5%
5%
5%
1/4W
1W
1/4W
1/4W
1/4W
R335
R336
R337
R338
R339
1-247-863-91
1-247-857-91
1-247-873-91
1-247-879-91
1-247-879-91
CARBON
CARBON
CARBON
CARBON
CARBON
22K
12K
56K
100K
100K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R340
R341
0 R501
0 R502
R503
1-247-863-91
1-215-868-00
1-249-393-11
1-249-393-11
1-247-839-91
CARBON
METAL OXIDE
CARBON
CARBON
CARBON
22K
680
10
10
2.2K
5%
5%
5%
5%
5%
1/4W
1W
1/4W F
1/4W F
1/4W
R504
R701
R702
R703
R704
1-247-839-91
1-247-879-91
1-247-831-91
1-247-857-91
1-247-855-91
CARBON
CARBON
CARBON
CARBON
CARBON
2.2K
100K
1K
12K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R705
R706
R707
R708
R709
1-247-855-91
1-247-879-91
1-247-903-00
1-247-831-91
1-247-839-91
CARBON
CARBON
CARBON
CARBON
CARBON
10K
100K
1M
1K
2.2K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R710
R711
1-247-839-91 CARBON
1-247-855-91 CARBON
2.2K
10K
5%
5%
1/4W
1/4W
10
SA-VE522/VE525/WM525/SS-MS525/V521
LED
Ref. No.
Part No.
Description
Remarks
Ref. No.
POWER
Part No.
1-790-503-21
1-790-503-31
3-701-443-21
4-233-674-11
*********************************************************************
1-680-786-11 POWER BOARD
*************
< CAPACITOR >
C401
1-104-664-11 ELECT
Remarks
Description
POWER SWITCH
47uF
20.00% 25V
Q401
Q402
Q403
Q404
8-729-141-30
8-729-119-76
8-749-010-25
8-749-010-26
TRANSISTOR 2SC3623A-LK
TRANSISTOR 2SA1175-HFE
IC MN2488-OPY-M
IC MP1620-OPY-M
< RESISTOR >
R401
1-247-871-91 CARBON
47K
5%
1/4W
R402
1-247-839-91 CARBON
2.2K
5%
1/4W
0 R403
1-249-414-11 CARBON
560
5%
1/4W F
0 R404
1-249-408-11 CARBON
180
5%
1/4W F
0 R405
1-249-408-11 CARBON
180
5%
1/4W F
0 R406
1-217-151-00 METAL
0.22
10%
2W
0 R407
1-217-151-00 METAL
0.22
10%
2W
*********************************************************************
1-113-924-11 CERAMIC
**********
HARDWARE LIST
**********
SP901
0 T501
0 T501
0 T501
0 T601
1-529-296-11
1-435-999-11
1-437-219-11
1-437-246-11
1-435-993-11
MISCELLANEOUS
*************
SPEAKER (20CM)
TRANSFORMER, POWER (US,CND,MX)
TRANSFORMER, POWER (SP)
TRANSFORMER, POWER (AEP,UK)
TRANSFORMER, POWER (US,CND,MX)
#1
#2
#3
#4
#5
7-685-664-79
7-685-646-79
7-685-662-79
7-685-660-19
7-685-647-79
0 T601
1-435-994-11 TRANSFORMER, POWER (AEP,UK)
0 T601
1-435-995-11 TRANSFORMER, POWER (SP)
**************************************************************
The components identified by mark 0 or
dotted line with mark 0 are critical for
safety.
Replace only with part number specified.
11
SA-VE522/VE525/WM525/SS-MS525/V521
Ref. No.
PartHISTORY
No.
Description
REVISION
Remarks
Ref. No.
Part No.
Description
12
Ver.
Date
1.0
2001.01
Description of Revision
New
Remarks