Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
1. To return a LiteOn drive to stock you need your Dummy.bin (from your drive dump) and Stock FW for your relevant drive and the latest Jungleflasher.
7. Click Spoof Source to Target button (Check that DVD Keys are the same in the Source and Target sections). 8. You may Save to File your new Stock firmware. 9. Right-click over the Source firmware section again. Select Verify Key.
10.Now check the Running log for this! Its Verified against drive
14. As soon as Drive returned Status 0xD0, Power cycle the drive i.e. Switch Power OFF then ON in quick succession ONCE. 15. Hopefully expected result of Serial flash found with Status 0x72 will return, showing drive now in Vendor Mode under Drive Properties.
DONT PANIC IF IT DOESNT ENTER VENDOR MODE FIRST TIME OR IF YOUR DRIVE IS NOW NOT SHOWING UP AND WILL NO LONGER EJECT SIMPLY PRESS INTRO AND CYCLE DRIVE POWER IF STILL NOT IN VENDOR MODE, TRY ERASING AGAIN!
16. Click the Write button to write Target Buffer to the drive. Expect to see: Sending Chip Erase to Port 0xFE20 Erasing: Writing target buffer to flash Writing Bank 0: ................ Writing Bank 1: ................ Writing Bank 2: ................ Writing Bank 3: ................ Flash Verification Test ! Reading Bank 0: ................ Reading Bank 1: ................ Reading Bank 2: ................ Reading Bank 3: ................ Write verified OK ! NOTE: Port 0xFE20 is the port that the drive is connected to. 17. Write Verified OK! in Running Log signals good write. 18. Send an Outro to the drive by Clicking on the Outro / ATA Reset button. 19. All done Drive now in Stock Mode. MADE USING JUNGLEFLASHER TUTORIAL AS BASE.