Sei sulla pagina 1di 2

[Pangalengan] help exit quit config display current-config display saved-config display version reset display e1 status display

eth status display gfp status display ppp status display statistics [Pangalengan] [Pangalengan] [Pangalengan]display current-config <--System current configuration <--Running Time : 0 hours,10 minutes,14 seconds sysname Pangalengan password root <--Network Configuration ip-address 30.30.3.7 255.255.255.0 gateway 30.30.3.1 <--SNMP Community Configuration snmp-agent community 1 read public snmp-agent community 2 write private <--SNMP Trap Configuration <--Global Configuration e1 work-mode gfp-1e1 vlan enable qinq disable admin vlan 401 eth isolation enable e1 clock-source line gfp tx-scram payload gfp rx-scram payload gfp lcas enable gfp fcs disable gfp ext-header null-header <--VLAN Configuration vlan 1 vlan-id 401 member 2-5 vlan 2 vlan-id 406 member 1,5 <--E1 Configuration e1 port-mode vlan-trunk e1 vlan-pvid 401 e1 loop-detect 1 enable e1 loop-detect 2 enable <--Ethernet Configuration eth 1 admin up eth 1 duplex auto eth 1 port-mode vlan-access eth 1 rate-limit egress 0 eth 1 rate-limit ingress 0 eth 1 vlan-pvid 406 eth 2 admin up eth 2 duplex auto eth 2 port-mode vlan-access eth 2 rate-limit egress 0 eth 2 rate-limit ingress 0

eth 2 vlan-pvid 401 eth 3 admin up eth 3 duplex auto eth 3 port-mode vlan-access eth 3 rate-limit egress 0 eth 3 rate-limit ingress 0 eth 3 vlan-pvid 401 eth 4 admin up eth 4 duplex auto eth 4 port-mode vlan-access eth 4 rate-limit egress 0 eth 4 rate-limit ingress 0 eth 4 vlan-pvid 401 [Pangalengan]

Potrebbero piacerti anche