Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
UART 1 GPIO
MEGA_CAM_SCL_2.8V MEGA_CAM_SDA_2.8V
T-FL ASH
GPS interface
GPS reciever
26MHz
MIPI
ISP
8M
OSC control
MEMORY 16-BIT IF
ASM
MAGNETIC SENSOR LCD IF
VT_CAM_SCL_2.8V VT_CAM_SDA_2.8V
8. Level 3 Repair
TRANSCEIVER
VT CAMERA /PROXY sensor
PS_ALS_SCL_2.8V PS_ALS_SDA_2.8V TOUCH_SCL_2.8V TOUCH_SDA_2.8V
CP +CP PMIC
Digital RF interface
TOUCH KEY GYRO SENSOR
SENSE_SCL_2.8V SENSE_SDA_2.8V
Digital RF
GPIO
24MHz TCXO
CP_D+ CP_D-
2G/3G_RX
2G/3 G Tx
AUDIO ACC SENSOR UART I2S1 I2S2 USB SIM
3G_TX
2G/3 G Rx
2G/3G PAM
DUP/SAW BANK
MHL_DM/DP/ID
2G_TX_LB 2G_TX_HB
16G i/Movinand
WiFi 2.8V
PM_L PM_H
3G_LB 3G_HB
Charger IC USB_OTG
UART 3 AUDIO I2S1 I2S0 UART 0
BT_UART_RXD BT_UART_TXD BT_UART_CTS BT_UART_RTS
BT/Wifi Module
3G_TX
RX MHL
MHL_I2C/MSENSOR_MHL_I2C AP_FLM_RXD AP_FLM_TXD CP_RXD_1.8V CP_TXD_1.8V
Switch IC
USB_DP/DM PMIC_DP/DM
X-TAL 37.4MHz
MICRO USB
2-MIC Chip
SPEECH_PCM_IN/OUT_ CODEC
Sub mic_P/N
Main mic_P/N
VPS_P VPS_N
OVP
USB_VBUS_AP_5V
RTC
AP_PMIC_SCL AP_PMIC_SDA
MICBIAS LDO
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
USB_DP
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
AP_D+/PCM / I2S IF Port 2 PCM / I2S IF Port 1 PCM / I2S IF Port 3
USB_VBUS_CP_5V
32.76 8 KHz
Ear mic_P/N
8-1
JTAG FOG
JTAG_RXD JTAG_TXD USB_ID
A/ S 2
LV. SHIFTER
A/ S 1
AP_RXD AP_TXD
FM Radio
SPK_OUT_P SPK_OUT_N EAR_L EAR_R
AP PMIC
RESET IC 3.5 EAR
Audio Codec
RCV_OUT_P RCV_OUT_N
RCV AMP
LINE2 L/R
MIC1
MIC2
MIC3
LINE1 L/R
RADIO_L RADIO_R
FUEL GAUGE
FUEL_I2C
Level 3 Repair
C637
C638
C509
L614
C657
C533
LED500
C548
AP_PS_HOLD
L507
C538
R340
TH300 R322
R349
C707
R426
C334
C333
RESET_PWRDWN_N
C329
C332
C331
R344
TP320
C552
C764
C763
U300
TP317
C557 C708
8M_AP_2.8V_EN
L302
C504
VIBTONE_PWM
C360
C351
C556 C554
UCP300
C335
L303
C354
C353
U303
C547
R625
C358 C356
C311
TP705
SC109
AP_PMIC_EN
TP703
C431
C544
C312
R508
R511
C403
PHONE_ACTIVE
C542
TP_PDA_ACTIVE
TP305
TP310
L301
SC113
R353
U708
L706
C726
C562
C728
R354
L707
R225
R416
R720
SIM300
R611 R609 C407 C406 C609 C602 C608 C603 R619 C348
R719
U707
C242
C617
L601
C632 C633
C248
C621 C622
C748
C747
C256
C252
AP_JTAG_EXTRST
GND
C607
C258
C560
C249
TP612
C615
XTAL_400
C605
U711
R468
R310
C347
C349
C720
SC116
C655
TP715
R215
TP_U_RXD
C746
C656
R232
SC118
C219
C223
L206
U202
C210
C212 C202
L201
SC107
R482
BH300
C758
C742
R501
R721
D501
C565
U206
C209
TP_USB_OTG_EN
R525
C201 C203
8-2
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
ANT200
C261
ZD701
ZD700
R527
R526
BH301
C204
SC122
OSC200
C262
C266
C761
R413
R412
C760
L213
U503
GPS_nRST
TH401
R234
R228
TP214
U709
R214 R235
TP212 TP_IF
U609
TP716
R731
R730 R734
R728
R727
C723
C214
R481
R735
Q500
R201
C762
R229
TP_U_TXD
R104
R103
R106
R312
C600
U600
BH302
BH303
TA503
C346
L703
R305
R600
C756
R629
R469
Q200
L704
U718
C232
R223
C229
C257
C606
C629
CD300
ANT100
R227
C235
R217
C236
C243 C246
SC111
C245
C744
U710
C625
C628
R630
C623
SC110
TP611
C651
TP607
TA502
C105
C106
C104
C618
C428
C427
C739
C429
C601
C610
RFS100
R615
R410
R411
R732
R725
R713
C737
R605
C736
U601
C233
R417
C430
SC117
TP218
U502
TP303
U400
C415
R715
R729
R722 C416
TP713
TP700
F700
C234 C259 C239
TP_NFC_IRQ
TP702
TP701
C433
L300
RESET_ALL
SC115
TP_eMMC_EN
RESET_REQ_N
F704
C659
TP316
C405
R517
C558
R516
C546
C432
C551
R523
C527
C522
U610
U603
C532
C523
C413
C521
C524
C541
SC120
L502
L506
C328
HDC701
L501
SC121
C320
C526
F701
F707 F709
R427 C755
R330
TP319
L500
R331
U720
R514
R348
C706
R704
C553
C518
C516
C517
VR607
OSC500
C529
C534
C501
C539
HDC704
SC119
L504
U611
TA600
L606
L607
F705
C704
L702
R703
C222
C220
L207
ANT201
R212
PAM200
L204
C265
C215
C530
C505
R624 R622
C537
C525
HDC600
R602
C660
C508
L600
C540
C519
R702
L503
R626
C300
R339
SC101
RESET300
U501
C313
TP318
TP101
R309
R308
R338
C330
C323
C322
C321
C344
C341
C343
C315
C310
C309
R337
R350
TP315
R352 R351
TP306 TP321 TP322
C550
C355
OSC300
F702
C506
C531
SC100
C658
R623 C304
C510
C507
C502
R408
C535
C573
R515
R546
TP609 TP610
TP312
TP313
TP311 TP309
TP601
R328
R329
C327
C345
C324
C339
C359
C319
C336
C337
C727
C730
L705
C731
R479
R480
C733
C734
L708
U204
C604
C630
TP613
C627
TP614
C624
C626
C631
R219
C240
C251
U602
C227
R218
C753
C754
C725
C724
C757
C350
R311
C741
U203
U201
R210 R211
R233
C211
L205
SC114
R524
C213
L200 C759 C752
HDC702
L508
C564
HDC703
Level 3 Repair
8-2-2. Bottom
VR600
L608
R604
L609
R603
R634 C614
C612 C613
C640
F706
L602
VR604
C639
HDC700
R454
C712
U703
C709
C711
C253
TP706
U205
TP704
C238 R216
TP402
R422
C241
L212
MOTOR_P
R341
R478
C705
L211
TP602
C179
L121
R445
C445
C559
R323
C500
C308
R102
C715
TP301
TP302
TP308
C314
U104
L122 L119
TP_SW_ANT100
C572
R315
R313
R317
R314
RESET_N_RF
TP100
C123
C142
C139
C137 C442 C146 C113
UCP400
C151
C138
C143
C438
C409
C101
R432 R429
R431
TP707
TP712
SC104
R711
R710
L103
C132
C425
TP401
C131
C443
R433
C420
R406
C421
C422
C111
L110
L113
C440
C423
C419
C401
C404
L117
C167
C357
R447
R448
TP603
C643
C156
R460
R465
C155
C325
VK600
R741
C159 C162
R404
TP_PA_RAMP
SC103
TP206 TP207
TP217
L202
R207
TP200
C217
OSC201
C218 R467 R466
C641
C642
C646
U607
TP605 TP604
U102
C152 C153 R111
C566
R533 R531
R529
R532
R510
C567
R208
R230
TP211
8-3
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
L111
C116
C125
C160
C158
BTC500
C645
U606
L112 C163
C117
C164
C124
C318
R300
C402 C439
SC105
R303
L509
C417
C561
R418
C447
C166
PAM100
R302
R301
C157
OSC400
C418
C436
R304
L114
TP405
OSC202
TP500
L104
C408
D500
TA501
C511
C228
C230
C108
F100
C100
U101
L106 L105
L102
C175
U100
C180
C173
C107
L108
L101
L100
L127
U704
C448
SC102
L109
C178
C134
CP_ON
TP300
TP400
R473
R446
C435
R434
R443
C169
C122 C426
C109
C121
C112
C255
R477
C254
SC112
L209
TP709
TP711
L210
TP_TRST_N_CP
TP_TDO_CP
TP_GND
TP_VSD2_1.8V
TP_TDI_CP
TP_TMS_CP
TP_TCK_CP
TP_RTCK_CP
JTAG303
JTAG302
VR603 VR602 C619 C620 R633
PORON202
JTAG300
L120
FM_RST
L604
VR605
C611 C765
F703
R455
U702 U701
C710
C545
R472
TH400
C701
L700
L701
R402
TP708
R403
R420
R430
C161
R108
R474
R437
R435
R438
R436
C716
C644
U706
C713 R421
R709 R737
C714
U608
C719 R475
R712
R424
R423
C174
C172
C176
C170
C171
C135
C424
C446
C400
C410
C411
C444
R463
R464
C717
C718
R316
R318
R320
R325
R319
C145
C136
C144
OSC100
L116
R346
C114
TP307
UME300
L107
C102
C103
C130
C129
C133
C128
C120
C127
C126
C118
R428
R440
C302
C303
C307
C305
C306
C168
PK601
L118
R459 R450
R513
R449
R461
C412
C571
C301
R451 R405
C441
R425
C181
R442
R444
U103
BAT500
C206
R205 C208
MOD201
TP213
C647
R628
L115
C154
U504
D502
Level 3 Repair
Oscilloscope
Digital Multimeter
Power Supply
Soldering iron
8-4
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-3-1. Power On
Cell-phone can`t power on.
Charging the battery by TA. If its voltage level is extremely low(under 3.0V), Change the battery.
No
Power-on the phone and check the power-on sound or motor vibration. Sound or vibration is ok?
Yes
No SW re-download and re-booting No Try to power on with anyway jig. If booting is success with anyway jig,check the PK601 (soldering crack, open, etc)
Change the PK601(Power-key FPCB) And retry to the power-on operation. Test condition (Power supply 4.0V)
Abnormal
Check the U501 output voltage
(C535 > 2.0V, C418 or C554 > 1.2V)
No
If the output voltage is not satisfied with normal condition, Change the U501. Each voltage level has 10% margin.
Yes Check the U501 output signal (AP_PS_HOLD(TP) > 2.8V) Yes
Check the Clock OSC500(TP213)
No
If the output voltage is not satisfied with normal. condition, Change the UCP400. Each voltage level has 10% margin. Change the OSC500. If OSC400 does not still work, Change the U501 This problem is internal oscillator of U501.
No
Yes check the initial operation Yes END Test condition (Oscilloscope setting) : 20.0us.div (time division)
8-5
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-6
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
If Phone do not go download mode, boot code area of Movinand MCP is damaged. It need to change the UME300(Movinand MCP)
Download success
No
Yes
Check the OSC500, OSC400 and R418. (Crack, open etc.) Check the output clock waveforms and frequency. Test condition (Oscilloscope setting) : 20.0us.div (time division) @ 32.768Khz : 100ns.div (time divisioin) @ 24Mhz
32.768KHz : OSC500(TP213), 24Mhz : OSC400(C440) OSC400 is operating when phone is not in sleep mode
Abnormal
END
8-7
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-8
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-3-3. No Service
No service Yes Check memu setting Menu applications setting wireless and network mobile networks network mode setting is auto mode ?
Menu Phone Keypad *#1234# check Phone version PHONE : I9100XXXX or PHONE : unknown
PHONE : unknown
No
Yes
No
Abnormal
Yes END
8-9
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
ON1 ON2_N
H2 J2
CP_ON
CP_VSD1
D3 D1 E1
LQM2HPN3R3MGCL
CP_VSD2_1.8V
C2 A2 A3
L303
3.3uH
LQM2HPN3R3MGCL
U14 T13 T14
VSD1_GND
CLKOUT0 CLKOUT2
N8 P10
XTAL_26MHZ_CP
C354 18PF
0603
VSD2_GND
F32K
L17
UCP300 PMB9811-B
OSC32K
M17
T_OUT0 T_OUT1
N4 P3
OSC300 FC-135(0.032768MHz)
DMINUS DPLUS
T11 U11
C355
15pF
0603
HW_MON1 HW_MON2
R6 P7
HW_MON1 HW_MON2
R328 0ohm
0603 SHORT
DSP_AUDIO_IN1
B6
CP_DCP_D+
R330
TP317 TP318
R329 0ohm
0603 SHORT
DSP_AUDIO_IN1 IPC_HOST_WAKEUP
4.02K
1005
HSIC_DATA1 HSIC_STROBE1
0ohm
0603 SHORT
T1 U2 U3 T2 T3
R331
IPC_SLAVE_WAKEUP ACTIVE_STATE_HSIC
TP319 TP320
REF_CLK_EN SYSCLKEN SYS_CLK TRIG_B TRIG_IN RESET2_N RESET_BB_N RESET_PWRDWN_N ALERT_N TRST_N XRESET_N ANAMON FCDP_RBN FSS FWP TCK TDI TDO TMS TM_EN VREF VRTC
RESET_REQ_N CP_PMU_RST_OR For Modem and PMIC, RF Reset TRST_N_CP RESET_N_RF For RF Reset
VRTC_1.8V
VSS_PMU
VSS_RTC
VSS_SD1
VSS_SD2
VSS_USB
VSS_PLL
RESERVED
H8 RESET_ALL
0603
VSS
VSS
NC
NC
NC
NC
NC
NC
NC
0603
8-10
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
No
Yes
No
Change to the new SIM card. If it doesn`t still work SIM card after changeing the SIM card, Check the UCP300 (Crack etc)
Yes
END
8-11
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
TA / USB Insert
No
No
Yes No
Battery is Charging?
Yes END
8-12
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-13
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
Check main microphone function in voice call receiver mode or in Voice Recording mode Yes
Check Sub-PCB module where main MIC is placed for any damage (Tear in FPC, etc)
No
Yes
No
Yes
No
Yes END
8-14
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
VCC_1.8V_PDA
V_BAT
L601
C605
C606
C607
VCC_2.8V_PDA
J4 J2 E1 D2 D8 A7 J7
E2 G2 H1 E3 F3 F4
CLK1 SCL SDA GPIO DMICCLK DMICDAT BCLK0 BCLK0 LRCK0 SDIN0 SDOUT0 BCLK1 LRCK1 SDIN1 SDOUT1 BCLK2 LRCK2 SDIN2 SDOUT2 MBS1 MIN1 MIN1 MIG1 MBS2 MIN2 MIG2 MBS3 MIN3 MIG3
C615
H8 J9 H9 A9 B8 B9 G8 G9 C8 C9 C5 C6 B7 C7 B6 A6 R629 R630
SPK_OUT_N SPK_OUT_P
MM_I2S_CLK MM_I2S_SYNC MM_I2S_DO MM_I2S_DI SPEECH_PCM_CLK SPEECH_PCM_SYNC SPEECH_PCM_IN_CODEC SPEECH_PCM_OUT_CODEC BT_PCM_CLK BT_PCM_SYNC BT_PCM_OUT BT_PCM_IN
C621 C622 C624 C626
H2 J1 F2 F1 G1 G3 H3 G4 G5 H4 H5 J5 J6 C2 A1 B1 C1 B4 A3 B3 C3 A2 B2 B5 C4
U602
LOUT1R|LOUT1N LOUT1L|LOUT1P LOUT2R|LOUT2N LOUT2L|LOUT2P REFAN LDOA|AVDD CPP CPN REFCPP REFCPN VREF
C617 C618
C619 C620
LINEL|LINEP LINER|LINEN
SPGNDR A8 SPGNDL J8 CPGND F9
DGND AGND H7 AGND H6 AGND A5 DGND
V_BAT
NC 2 NC 1
MICBIAS_LDO_2.8V
C242
J3 D1
MICBIAS_EN
3 CE
GND
GND
5
U204
C617
C618
C655
SC111
C739
C656
C231
C604
C627
L601
C632
C621
R227
C748
C747
C248
C256
C252
R223
C607
C258
R630
C249
R469
C560
TP612
C615
XTAL_400
C605
U711
R468
Q200
C756
L704
BH303
L703
U718
C723
R727
C720
SC116
C232
C655
TP715
R215
C746
C656
8-15
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
U709
U609
TP716
R730
R728
R731
R735
C257
C622
C229
C235
C246
C633
C236
C243
C245
C744
U710
C629
C606
C625
C628
R629
C623
SC110
TP611
C651
C630
TP613
C624
TP614
C626
C631
R219
C240
C251
U602
C753
C754
C724
C725
C757
C741
R734
Level 3 Repair
Check Sub microphone function in voice call loudSPK mode or in camcording mode Yes
Check RCV-Earjack module where Sub MIC is placed for any damage (Tear in FPC, etc)
No
Yes
No
Yes
No
Yes END
8-16
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
V_BAT
SUB_MICBIAS_LDO_2.8V
SUB_MICBIAS_EN
3 CE
GND
GND
5
C657
C658
L606
C637
C638
C509
C508
VR607
LED500
R349
C552
C504
L302
C351
SC121
C526
C556
L303
C353
U303
R625
C356
C300
R517
C659
C405
R516
SC109
C558
C546
TP_eMMC_EN
RESET_REQ_N
AP_PMIC_EN
R508
L300
8-17
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
R511
C544
PHONE_ACTIVE
C522
C527
U610
U603
C304
C523
C413
C547
C358
R409
C521
C524
C541
C505
C525
C328
L506
C554
L500
R348
C530
C533
L504
C657
U611
TA600
R624 R622 C660
L607
C537
L614
HDC600
R602
L600
L503
C550
C414
C555
C658
R626
R623
R408
C535
C573
R515
R546
Level 3 Repair
VCC_1.8V_PDA
V_BAT
L601
C605
C606
C607
VCC_2.8V_PDA
J4 J2 E1 D2 D8 A7 J7
E2 G2 H1 E3 F3 F4
CLK1 SCL SDA GPIO DMICCLK DMICDAT BCLK0 BCLK0 LRCK0 SDIN0 SDOUT0 BCLK1 LRCK1 SDIN1 SDOUT1 BCLK2 LRCK2 SDIN2 SDOUT2 MBS1 MIN1 MIN1 MIG1 MBS2 MIN2 MIG2 MBS3 MIN3 MIG3
C615
H8 J9 H9 A9 B8 B9 G8 G9 C8 C9 C5 C6 B7 C7 B6 A6 R629 R630
SPK_OUT_N SPK_OUT_P
MM_I2S_CLK MM_I2S_SYNC MM_I2S_DO MM_I2S_DI SPEECH_PCM_CLK SPEECH_PCM_SYNC SPEECH_PCM_IN_CODEC SPEECH_PCM_OUT_CODEC BT_PCM_CLK BT_PCM_SYNC BT_PCM_OUT BT_PCM_IN
C621 C622 C624 C626
H2 J1 F2 F1 G1 G3 H3 G4 G5 H4 H5 J5 J6 C2 A1 B1 C1 B4 A3 B3 C3 A2 B2 B5 C4
U602
LOUT1R|LOUT1N LOUT1L|LOUT1P LOUT2R|LOUT2N LOUT2L|LOUT2P REFAN LDOA|AVDD CPP CPN REFCPP REFCPN VREF
C617 C618
C619 C620
LINEL|LINEP LINER|LINEN
SPGNDR A8 SPGNDL J8 CPGND F9
DGND AGND H7 AGND H6 AGND A5 DGND
NC 2 NC 1
C242
J3 D1
U204
C231
C604
C627
C617
C618
L601
C632
C621
R227
C748
C747
C248
C256
C252
R223
C607
C258
R630
C249
R469
C560
TP612
C615
XTAL_400
C605
U711
R468
Q200
C756
L704
BH303
L703
U718
C723
C720
SC116
C232
R727
C655
TP715
R215
C746
C656
8-18
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
U709
U609
TP716
R730
R728
R731
R735
C257
C622
C229
C235
R217
C246
C633
C236
C243
SC111
C245
C744
U710
C629
C606
C625
C628
R629
C623
SC110
TP611
C651
C630
TP613
C624
TP614
C626
C631
C739
R219
C240
C251
U602
C227
R218
R226
C753
C754
C724
C725
C757
C741
R734
Level 3 Repair
Check speaker function. Play MP3 with maximum volume level. Yes
No Reconnect HDC703
Yes
Yes
Yes END
8-19
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
HDC703 1 3 5 7 9 11 13 15 17 19 21 23 25 27 29 31 33 2 1 3 4 5 6 7 8 9 10 12 11 14 13 15 16 18 17 20 19 22 21 24 23 25 26 28 27 30 29 31 32 33 34 NC NC NC NC 35 36 37 38 2 4 6 8 10 12 14 16 18 20 22 24 26 28 30 32 34
MICBIAS_LDO_2.8V
D501
C565
R527
VDD_2V85_SUE2
R525
R526
ZD700
SW_ANT
VCC_1.8V_PDA
C242
C604 C627 C617 C618 C744
C739
L601
C632
C621
R227
C748
C747
C248
C607
R469
C560
TP612
C615
XTAL_400
C605
U711
R468
Q200
C756
C605
C606
C607
L704
VCC_2.8V_PDA
BH303
L703
E2 G2 H1 E3 F3 F4
CLK1 SCL SDA GPIO DMICCLK DMICDAT BCLK0 BCLK0 LRCK0 SDIN0 SDOUT0 BCLK1 LRCK1 SDIN1 SDOUT1 BCLK2 LRCK2 SDIN2 SDOUT2 MBS1 MIN1 MIN1 MIG1 MBS2 MIN2 MIG2 MBS3 MIN3 MIG3
C615
C720
H8 J9 H9 A9 B8 B9 G8 G9 C8 C9 C5 C6 B7 C7 B6 A6 R629 R630
SPK_OUT_N SPK_OUT_P
SC116
R727
G3 H3 G4 G5 H4 H5 J5 J6 C2 A1 B1 C1 B4 A3 B3 C3 A2 B2 B5 C4
LOUT1R|LOUT1N LOUT1L|LOUT1P LOUT2R|LOUT2N LOUT2L|LOUT2P REFAN LDOA|AVDD CPP CPN REFCPP REFCPN VREF
C617 C618
VPS_L VPS_R
R215
C619 C620
LINEL|LINEP LINER|LINEN
SPGNDR A8 SPGNDL J8 CPGND F9
DGND AGND H7 AGND H6 AGND A5 DGND
8-20
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
C746
HPOUTL HPOUTR
EAROUT_L EAROUT_R
C656
R735
TP614
U709
TP612 TP613
U602
RCOUTN RCOUTP
RCV_P RCV_N
U609
TP716
R730
R731
MM_I2S_CLK
TP611
H2 J1 F2 F1 G1
C655
TP715
C723
R728
R630
C625
V_BAT
C256
C252
R223
C258
C249
U718
C232
C257
C622
C229
C235
R217
C246
C633
C236
C243
SC111
C245
ZD701
U503
JTAG_USB_ID
HDC702
L508
C762
U710
C629
C606
C628
R629
C623
C762
C564
TP_USB_OTG_EN
R524
HDC703
U204
C231
C630
C624
C626
C631
R219
C240
C251
SC110
TP611
C651
L601
TP613
U602
TP614
C227
R218
R226
C753
C754
C724
C725
C757
C741
R734
Level 3 Repair
No Reconnect HDC600
Yes
Check RCV-Earjack module where RCV's placed for any damage (Tear in FPC, etc) Yes
Yes END
8-21
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-22
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
L606
C637
C638
C509
C508
VR607
LED500
R349
C552
C504
L302
C351
SC121
C526
C556
L303
C353
U303
R625
C358
C356
C300
R517
C659
C405
R516
SC109
C558
C546
TP_eMMC_EN
RESET_REQ_N
AP_PMIC_EN
L300
R508
VCC_1.8V_PDA
R511
C544
PHONE_ACTIVE
C242
C617
C618
L601
C632
C621
R227
C748
C747
C248
C256
C252
R223
C607
C258
R630
C249
R469
C560
TP612
VCC_2.8V_PDA
E2 G2 H1 E3 F3 F4
CLK1 SCL SDA GPIO DMICCLK DMICDAT BCLK0 BCLK0 LRCK0 SDIN0 SDOUT0 BCLK1 LRCK1 SDIN1 SDOUT1 BCLK2 LRCK2 SDIN2 SDOUT2 MBS1 MIN1 MIN1 MIG1 MBS2 MIN2 MIG2 MBS3 MIN3 MIG3
C615
H8 J9 H9 A9 B8 B9 G8 G9 C8 C9 C5 C6 B7 C7 B6 A6 R629
BH303
L703
SPK_OUT_N SPK_OUT_P
C720
MM_I2S_CLK MM_I2S_SYNC MM_I2S_DO MM_I2S_DI SPEECH_PCM_CLK SPEECH_PCM_SYNC SPEECH_PCM_IN_CODEC SPEECH_PCM_OUT_CODEC BT_PCM_CLK BT_PCM_SYNC BT_PCM_OUT BT_PCM_IN
C621 C622 C624 C626
R727
C2 A1 B1 C1 B4 A3 B3 C3 A2 B2 B5 C4
R215
LINEL|LINEP LINER|LINEN
SPGNDR A8 SPGNDL J8 CPGND F9
DGND AGND H7 AGND H6 AGND A5 DGND
8-23
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
C746
H4 H5 J5 J6
LOUT2R|LOUT2N LOUT2L|LOUT2P
C619 C620
C656
R735
LOUT1R|LOUT1N LOUT1L|LOUT1P
C618
U709
C617
VPS_L VPS_R
U609
TP716
R730
R731
G3 H3 G4 G5
R630
C655
TP715
HPOUTL HPOUTR
EAROUT_L EAROUT_R
R728
H2 J1 F2 F1 G1
SC116
U602
RCOUTN RCOUTP
RCV_P RCV_N
C723
C756
SC110
TP611
C605
C606
C607
C615
XTAL_400
C605
U711
R468
Q200
L704
U718
C232
C257
C622
C229
C235
R217
C246
V_BAT
C633
C236
C243
SC111
C245
C744
U710
C522
C527
C629
C606
C625
C628
R629
C623
C651
U610
U603
C304
C523
C413
C547
R409
C521
C524
C541
C505
C525
C328
L506
C554
L500
R348
C530
C533
L504
C657
U611
TA600
R624 R622 C660
L607
C537
L614
HDC600
R602
L600
L503
C550
C414
C555
C658
R626
R623
R408
C535
C573
R515
C604
R546
U204
C231
C627
C630
C624
C626
C631
C739
L601
R219
C240
C251
U602
TP614
C227
R218
R226
C753
C754
C724
C725
C757
TP613
C741
R734
Level 3 Repair
8-3-8. BT/WIFI
BT/WiFi is not working Yes Check BT or WiFi function ON Yes Check the Voltage on C208 = 2.8V Yes Check 37.4MHz Clock at R208 Yes Check the Voltage on L202 = 1.5V Yes Check the Status of C201, ANT200 Yes No No No No Check the U501(crack, open, damaged, etc.) No
Yes END
8-24
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
VCC_2.8V_PDA
ANT200
2 1
C201
2 1 C203
1005
R230
C206
C261
C204
V_BAT
VCC_2.8V_PDA
L202
14
47
48
42
C262
27
52
21
TCXO_VDD
VDD_FEM
VIO
ANT_FM_RX
HSIC_AVDD
ANT_2G|5G
ANT_DIVER_CTRL
R203
R204
R205
R206
R207
VDD_CORE
VIN_LDO
VIN_LDO
SR_VLX
SR_VLX
VBAT
VBAT
53
C208
23 24 25 26
55 56 59 58 54
TP200
BT_HOST_WAKE BT_WAKE BT_EN BT_nRST BT_UART_RTS BT_UART_CTS BT_UART_RXD BT_UART_TXD
57
36 35 33 34
BT_PCM_SYNC 43
TP206 61 TP207 62
28 30 29
MOD201
TCXO_IN
OSCIN BT_UART_CTS BT_UART_RTS BT_UART_TXD BT_UART_RXD HSIC_DATA HSIC_STROBE HSIC_PREF WL_UART_TXD WL_UART_RXD WL_GPIO6 WL_HOST_WAKE WL_REG_ON FM_AOUT1 FM_AOUT2 CLK_REQ SLEEP_CLK OSCOUT
44 45
XTAL_37_4M_IN XTAL_37_4M_OUT
51 49 50
TP211
31
38 39
7 17
WL_WAKE
37
TP213
WLAN_HOST_WAKE WLAN_EN
40
BT_WIFI_CLK32K
TP217
60
12 11
41
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
18
32
GND
46
GND
13
70
GND
71
72
73
19
74
75
76
15
16
63
64
65
66
68
67
20
OSC201
XTAL_37_4M_IN
XTAL_37_4M_OUT
R208 C217
2
3
1 4
C218
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
22
8-25
69
77
GND
GND
Level 3 Repair
L202
C201
C203
C217
OSC201
R208
R230
TP211
8-26
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
ANT200
C261
C204
C206
R204
R205
R203
R206
C208
R207
TP200
BH301
MOD201
TP213
Level 3 Repair
8-3-9. FM RADIO
Yes END
8-27
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
FM_INT
R216
VCC_2.8V_PDA VCC_2.8V_PDA
C238
L209
19 1817 16 15 14 13
RADIO_L_SI
LOUT
GND NC
NC NC
GPO
VA
L212
FM_RADIO_ANT
NC FMI
12
L210
ROUT
RADIO_R_SI
C241
U205
_SEN SCLK SDIO VIO
GND 11 VD 10 RCLK 9
3 RFGND 4 _RST
L211
FM_CLK32K
FM_RST
VCC_1.8V_PDA
V_BAT
C605
L601
C606
C607
VCC_2.8V_PDA
E2 G2 H1 E3 F3 F4
J7 A7 D8 D2 E1 J2 J4
CLK1 SCL SDA GPIO DMICCLK DMICDAT BCLK0 BCLK0 LRCK0 SDIN0 SDOUT0 BCLK1 LRCK1 SDIN1 SDOUT1 BCLK2 LRCK2 SDIN2 SDOUT2 MBS1 MIN1 MIN1 MIG1 MBS2 MIN2 MIG2 MBS3 MIN3 MIG3
C615
H8 J9 H9 A9 B8 B9 G8 G9 C8 C9 C5 C6 B7 C7 B6 A6 R629 R630
SPK_OUT_N SPK_OUT_P
MM_I2S_CLK MM_I2S_SYNC MM_I2S_DO MM_I2S_DI SPEECH_PCM_CLK SPEECH_PCM_SYNC SPEECH_PCM_IN_CODEC SPEECH_PCM_OUT_CODEC BT_PCM_CLK BT_PCM_SYNC BT_PCM_OUT BT_PCM_IN
C621 C622 C624 C626
H2 J1 F2 F1 G1 G3 H3 G4 G5 H4 H5 J5 J6 C2 A1 B1 C1 B4 A3 B3 C3 A2 B2 B5 C4
U602
LOUT1R|LOUT1N LOUT1L|LOUT1P LOUT2R|LOUT2N LOUT2L|LOUT2P REFAN LDOA|AVDD CPP CPN REFCPP REFCPN VREF
C617 C618
LINEL|LINEP LINER|LINEN
DGND DGND AGND AGND AGND
D1 J3 A5 H6 H7 F9 J8 A8
1 2
NC NC
8-28
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-29
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-3-10. LCD
LCD is still off after PWR ON Yes Check the connection of HDC 701 Yes No
No
Yes
Yes
8-30
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-31
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-32
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-3-11. TSP
Yes
Yes
No
Yes
No
Yes
No
Yes
Yes END
8-33
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-34
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-35
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-3-12. 8M CAM
"Camera" function does not work
Yes
No
Abnormal Resolder L503, C533 Check the C533 = C709 = C714 = C712 = C549 = C553 = C545 = voltage 1.2V, 1.2V 2.8V 1.5V 1.8V 1.8V 1.8V Resolder U701, C709, C710 Resolder U703, C713, C714 No Resolder U702, C711, C712 Resolder C549 Resolder C553 Resolder C545 Replace the PBA Yes Resolder R703 Replace the PBA.
No
No
Yes
No
8-36
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
VCC_SUB_2.0V
U702 4 VDD VOUT 1
VT_CORE_1.5V
VCC_SUB_2.0V
U701 4 VDD VOUT 1
CAM_SENSOR_CORE_1.2V
V_BAT
CAM_SENSOR_A2.8V
U703
F703 F706 I|O 1 I|O I|O 2 3 4 8M_CAM_D0_P_F 8M_CAM_D0_N_F 8M_CAM_CLK_P_F 8M_CAM_CLK_N_F 8M_CAM_D1_P_F 8M_CAM_D1_N_F 4 I|O 3 I|O 1 8M_CAM_D1_P 8M_CAM_D1_N
4 VDD
VOUT 1
8M_CAM_D0_P 8M_CAM_D0_N
GND
GND
C709
C710
C713
C714
C711
C712
N13
G3
G5
G4
E4
H4
H5
H6
D4
N1
E2
E3
F4
E1
F1
K3
K4
F2
L4
J4
J5
VCOIN
NC
NC
DCIN
DCIN
D2 D3
SAFEOUT1 SAFEOUT2
VCC_32CP
18RNC1
28T1
28TCOM1
28RCOM2
28RNO1
28TNO2
18T2
18TNC2
18R1
28R2
BATT
BATT
_DETBAT
18VLL
VBATTFG
NC
NC
INB01 INB01
G2
BC
INB02 INB03
C517 C519
D1
VL
INB04 INB05
F3
VICHG
INB06A INB06B
F6 E5 E6 F5 AP_PS_HOLD E7 F7 D7
CAM_ISP_CORE_1.2V
INB07
L503
L506
C4
32KHZ_CP
LX6 LX6
C1 C2
XIN XOUT
LX7
C3
BUCK1 32KHZ_AP BUCK2 BUCK3 _MR1 _MR2 _RSO BUCK4 BUCK5 BUCK6 BUCK6EN IN21 BUCK7 BUCK4_GND
D9 D8 D6
C533
K9
SET1 SET2 SET3 PWREN M13 L8 M11 N12 M9 N11 N9 M12 J13 L9 J11 J10 J9 K11 K12 K13 J12 K10 K8
LDO1
C536
GPIO0 GPIO1 GPIO2 GPIO3 GPIO4 GPIO5 GPIO6 GPIO7 GPIO8 GPIO9 GPIO10 GPIO11
U501
LDO2 LDO3 LDO4 LDO5 LDO6 LDO7 LDO8 LDO9 LDO10 LDO11 LDO12 LDO13 LDO14 LDO16
V_BAT
F8 G9 G8
D11 D10
IN_GPIO1 IN_GPIO2
A3 A2 C5
LDO21
LXF LXF
A5 B5
J1 K1 D5 L1
COMN1 COMP2 COMP UID INMOTOR MIC_USB MDP MDN DN1 DP2 MGAIN MPWM OUTF OUTF
A4 B4
10
GND
VT_CAM_1.5V_EN
3 CE
GND
GND
GND
8M_1.2V_EN
3 CE
GND
8M_CAM_CLK_N
I|O
I|O
C545
C549
CAM_IO_EN
3 CE
GND
8M_CAM_CLK_P
6 GND
GND
I|O
I|O
C553
K2
G1 H1
H3 J3
UT1 UR2
CB SNS AIN
G6 L7 J7 J6 J8 K5 K6 K7 L5
H2 J2
SL1 SR2
L2 L3 C6 C7
GPIO_GND
REFINPA
DGND1
DGND2
PGND1
GNDM
AGND
PGND6
GND
PGNDF
PGND5
PGND7
PGNDF
PGND1
PGND2
PGND3
PGND4
PGND6
PGND7
FGND
FGND
KVSS
G12
G13
H10
H12
H11
H13
C12
C13
A10
A13
M6
M1
N6
N5
B2
A7
B1
A6
B3
B6
B7
A1
L6
NC
NC
L606
C637
C638
C509
C657
C529
C534
C501
C533
C520
C549
C543
LED500
C548
R454
L507
C538
C707
C712
L500
C552
C764
C763
C557
U703
U720
C504
VIBTONE_PWM
C708
8M_AP_2.8V_EN
L501
HDC701
C526
C547
R422
R516
C558
C546
TP705
MOTOR_P
TP602
8-37
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
C705
TP402
C545
TH400
L701
R402
R403
C644
C532
C551
C522
C521
C527
C523
C524
C541
SC120
TP704
L700
L502
L506
C554
TP706
C556
F701
C709
C711
TP709
C701
R455
C553
C539
F705
C518
HDC700
TP711
TP710
C516
R514
C517
VR607
F706
U702 U701
C765 C710
C704
HDC704
C703 R701 C540 C519
L702
R703
PAM200
F703
R471
R470
C700
R414
R415
OSC500
SC119
L504
U611
TA600
C530 C505
R624 C660 R622
L204
C265
C215
L607
C537
C525
L614
C550 C414 C555
C508
L503
U501
C506 C510 C507
C502
C713 R421
C714
U608
F702
C531
C535
C573
R515
R423
R424
Level 3 Repair
8-3-13. 2M CAM
Yes
No
No
Resolder U703, C713, C714 Resolder U702, C711, C712 Resolder C549 Resolder C553
Yes
No
Check F705
Yes
Yes
END
8-38
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
VCC_SUB_2.0V
U702 4 VDD VOUT 1
VT_CORE_1.5V
VCC_SUB_2.0V
U701 4 VDD VOUT 1
CAM_SENSOR_CORE_1.2V
V_BAT
CAM_SENSOR_A2.8V
U703
F705
4 VDD
VOUT 1
VT_CAM_CLK_P VT_CAM_CLK_N
8 7 6 5
1 2 3 4
GND
VT_CAM_1.5V_EN
3 CE
GND
GND
GND
8M_1.2V_EN
3 CE
GND
CAM_IO_EN
3 CE
GND
VT_CAM_D0_N VT_CAM_D0_P
I|O
C709
C710
C713
C714
C711
C712
N13
G3
G5
G4
E4
H4
H5
H6
D4
N1
E2
E3
F4
E1
F1
K3
K4
F2
L4
J4
J5
VCOIN
NC
NC
DCIN
DCIN
D2 D3
SAFEOUT1 SAFEOUT2
VCC_32CP
18RNC1
28T1
28TCOM1
28RCOM2
28RNO1
28TNO2
18T2
18TNC2
18R1
28R2
BATT
BATT
_DETBAT
18VLL
VBATTFG
NC
NC
INB01 INB01
G2
BC
INB02 INB03
C517 C519
D1
VL
INB04 INB05
F3
VICHG
INB06A INB06B
F6 E5 E6 F5 AP_PS_HOLD E7 F7 D7
CAM_ISP_CORE_1.2V
INB07
L503
L506
C4
32KHZ_CP
LX6 LX6
C1 C2
XIN XOUT
LX7
C3
BUCK1 32KHZ_AP BUCK2 BUCK3 _MR1 _MR2 _RSO BUCK4 BUCK5 BUCK6 BUCK6EN IN21 BUCK7 BUCK4_GND
D9 D8 D6
C533
K9
SET1 SET2 SET3 PWREN M13 L8 M11 N12 M9 N11 N9 M12 J13 L9 J11 J10 J9 K11 K12 K13 J12 K10 K8
LDO1
C536
GPIO0 GPIO1 GPIO2 GPIO3 GPIO4 GPIO5 GPIO6 GPIO7 GPIO8 GPIO9 GPIO10 GPIO11
U501
LDO2 LDO3 LDO4 LDO5 LDO6 LDO7 LDO8 LDO9 LDO10 LDO11 LDO12 LDO13 LDO14 LDO16
V_BAT
F8 G9 G8
D11 D10
IN_GPIO1 IN_GPIO2
A3 A2 C5
LDO21
LXF LXF
A5 B5
J1 K1 D5 L1
COMN1 COMP2 COMP UID INMOTOR MIC_USB MDP MDN DN1 DP2 MGAIN MPWM OUTF OUTF
A4 B4
10
C545
C549
C553
K2
G1 H1
H3 J3
UT1 UR2
CB SNS AIN
G6 L7 J7 J6 J8 K5 K6 K7 L5
H2 J2
SL1 SR2
L2 L3 C6 C7
GPIO_GND
REFINPA
DGND1
DGND2
PGND1
GNDM
AGND
PGND6
GND
PGNDF
PGND5
PGND7
PGNDF
PGND1
PGND2
PGND3
PGND4
PGND6
PGND7
FGND
FGND
KVSS
G12
G13
H10
H12
H11
H13
C12
C13
A10
A13
M6
M1
N6
N5
B2
A7
B1
A6
B3
B6
B7
A1
L6
NC
NC
L606
C637
C638
C509
C657
C529
C534
C501
C533
C520
C549
C543
LED500
C548
R454
L507
C538
C707
C712
L500
C552
C764
C763
C557
U703
U720
C504
VIBTONE_PWM
C708
8M_AP_2.8V_EN
L501
HDC701
C526
C547
R422
R516
C558
C546
TP705
MOTOR_P
TP602
8-39
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
C705
TP402
C545
TH400
L701
R402
R403
C644
C532
C551
C522
C521
C527
C523
C524
C541
SC120
TP704
L700
L502
L506
C554
TP706
C556
F701
C709
C711
TP709
C701
R455
C553
C539
F705
C518
HDC700
TP711
TP710
C516
R514
C517
VR607
F706
U702 U701
C765 C710
C704
HDC704
C703 R701 C540 C519
L702
R703
PAM200
F703
R471
R470
C700
R414
R415
OSC500
SC119
L504
U611
TA600
C530 C505
R624 C660 R622
L204
C265
C215
L607
C537
C525
L614
C550 C414 C555
C508
L503
U501
C506 C510 C507
C502
C713 R421
C714
U608
F702
C531
C535
C573
R515
R423
R424
Level 3 Repair
8-3-12. GSM1800 RX
NORMAL CONDITION catch the channel? NO Check C107 -65dBm ? NO Check the Voltage at C102 = VBATT ? YES Check C101, L101 -65dBm ? YES Check component soldering status OK at F100 YES NO NO NO Resolder or change C101, L101 NO Resolder or change U101, C102 YES CHECK soldered RFS100, L107,C107,L108
Check the voltage at {C138 = VOUT_CHARGER ?} & {C169, C170, C171 = VOUT_CHARGER?} & {C137, C174 = 2.85V ?} & {C134, C176 = 2.65V ?} & {C136, C178 = 1.8V?} & {C135, C175, C173 = 1.2V?}
NO
YES NO
END
8-40
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-41
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
NORMAL CONDITION catch the channel? NO Check C107 -65dBm ? NO Check the Voltage at C102 = VBATT YES Check C108, L102 -65dBm ? YES Check component soldering status OK at F100 YES NO NO NO Resolder or change C108, L102 NO Resolder or change U101, C102
Check the voltage at {C138 = VOUT_CHARGER ?} & {C169, C170, C171 = VOUT_CHARGER?} & {C137, C174 = 2.85V ?} & {C134, C176 = 2.65V ?} & {C136, C178 = 1.8V?} & {C135, C175, C173 = 1.2V?}
NO
YES NO
END
8-42
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-43
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
NORMAL CONDITION catch the channel? NO Check C107 -65dBm ? NO Check the Voltage at C102 = VBATT ? YES Check L103, L106 -65dBm ? YES Check component soldering status OK at F100 YES NO NO NO Resolder or change L103, L106 NO Resolder or change U101, C102
Check the voltage at {C138 = VOUT_CHARGER ?} & {C169, C170, C171 = VOUT_CHARGER?} & {C137, C174 = 2.85V ?} & {C134, C176 = 2.65V ?} & {C136, C178 = 1.8V?} & {C135, C175, C173 = 1.2V?}
NO
YES NO
END
8-44
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-45
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
Check the voltage at {C138 = VOUT_CHARGER ?} & {C169, C170, C171 = VOUT_CHARGER?} & {C137, C174 = 2.85V ?} & {C134, C176 = 2.65V ?} & {C136, C178 = 1.8V?} & {C135, C175, C173 = 1.2V?}
NO
YES NO
END
8-46
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-47
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
NORMAL CONDITION catch the channel? NO Check C107 -65dBm ? NO Check the Voltage at C102 = VBATT ? YES Check L104, L105 -65dBm ? YES Check component soldering status OK at F100 YES NO NO NO Resolder or change L104, L105 NO Resolder or change U101, C102 YES CHECK soldered RFS100, L107,C107,L108
Check the voltage at {C138 = VOUT_CHARGER ?} & {C169, C170, C171 = VOUT_CHARGER?} & {C137, C174 = 2.85V ?} & {C134, C176 = 2.65V ?} & {C136, C178 = 1.8V?} & {C135, C175, C173 = 1.2V?}
NO
YES NO
END
8-48
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-49
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-3-17. GSM850/GSM900 TX
YES
CONTINOUS TX ON CONDITION TX POWER DAC:14500 CODE APPLIED GSM850 CH : 190 GSM900 CH : 62 RBW : 100KHz VBW : 100KHz SPAN : 10MHz REF LEV. : 10dBm ATT. : 20dB
Check the Voltage at C102 = VBATT ? YES Check C120, L110, L113 : About 30dBm ? NO Check the Voltage at R741,C117=VOUT_CHARGER? YES Check C125, L112 : About 0dBm ? YES
NO
YES
NO
YES
Check the voltage at {C138 = VOUT_CHARGER ?} & {C169, C170, C171 = VOUT_CHARGER?} & {C137, C174 = 2.85V ?} & {C134, C176 = 2.65V ?} & {C136, C178 = 1.8V?} & {C135, C175, C173 = 1.2V?}
NO
YES NO
END
8-50
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-51
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-3-18. DCS/PCS TX
YES
CONTINOUS TX ON CONDITION TX POWER DAC:14500 CODE APPLIED DCS CH : 685 PCS CH : 661 RBW : 100KHz VBW : 100KHz SPAN : 10MHz REF LEV. : 10dBm ATT. : 20dB
Check the Voltage at C102 = VBATT ? YES Check C111, C118 : About 27dBm ? NO
NO
YES
Check the Voltage at R741,C117=VOUT_CHARGER? YES Check C124, L111 : About -4dBm ? YES
NO
YES
Check the voltage at {C138 = VOUT_CHARGER ?} & {C169, C170, C171 = VOUT_CHARGER?} & {C137, C174 = 2.85V ?} & {C134, C176 = 2.65V ?} & {C136, C178 = 1.8V?} & {C135, C175, C173 = 1.2V?}
NO
YES NO
END
8-52
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-53
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
YES
CONTINOUS TX ON CONDITION TX POWER DAC:14500 CODE APPLIED WCDMA Band1 CH : 10700 RBW : 100KHz VBW : 100KHz SPAN : 10MHz REF LEV. : 10dBm ATT. : 20dB
Check the Voltage at C102 = VBATT ? YES Check C108, L102 : About 22dBm ? NO Check component soldering status OK at F100 YES Check C132, C126 : About 22dBm ? NO Check the Voltage at R741,C117=VOUT_CHARGER? YES Check C124, L111 About 0dBm ? YES
NO
YES
NO
YES
NO
YES
Check the voltage at {C138 = VOUT_CHARGER ?} & {C169, C170, C171 = VOUT_CHARGER?} & {C137, C174 = 2.85V ?} & {C134, C176 = 2.65V ?} & {C136, C178 = 1.8V?} & {C135, C175, C173 = 1.2V?}
NO
YES NO
YES
8-54
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
END
8-55
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-56
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
YES
CONTINOUS TX ON CONDITION TX POWER DAC:14500 CODE APPLIED WCDMA Band2 CH : 9880 RBW : 100KHz VBW : 100KHz SPAN : 10MHz REF LEV. : 10dBm ATT. : 20dB
Check the Voltage at C102 = VBATT ? YES Check L103, L106 : About 22dBm ? NO Check component soldering status OK at F100 YES Check C131, C127, L114 : About 22dBm ? NO Check the Voltage at R741,C117=VOUT_CHARGER? YES Check C124, L111 About 0dBm ? YES
NO
YES
NO
YES
NO
YES
Check the voltage at {C138 = VOUT_CHARGER ?} & {C169, C170, C171 = VOUT_CHARGER?} & {C137, C174 = 2.85V ?} & {C134, C176 = 2.65V ?} & {C136, C178 = 1.8V?} & {C135, C175, C173 = 1.2V?}
NO
YES NO
YES
8-57
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
END
8-58
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-59
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
YES
CONTINOUS TX ON CONDITION TX POWER DAC:14500 CODE APPLIED WCDMA Band5 CH : 4408 RBW : 100KHz VBW : 100KHz SPAN : 10MHz REF LEV. : 10dBm ATT. : 20dB
Check the Voltage at C102 = VBATT ? YES Check C100, L100 : About 22dBm ? NO Check component soldering status OK at F100 YES Check C128, C133 About 22dBm ? NO Check the Voltage at R741,C117=VOUT_CHARGER? YES Check C125, L112 : About 0dBm ? YES
NO
YES
NO
YES
NO
YES
Check the voltage at {C138 = VOUT_CHARGER ?} & {C169, C170, C171 = VOUT_CHARGER?} & {C137, C174 = 2.85V ?} & {C134, C176 = 2.65V ?} & {C136, C178 = 1.8V?} & {C135, C175, C173 = 1.2V?}
NO
YES NO
YES
8-60
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
END
8-61
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-62
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
YES
CONTINOUS TX ON CONDITION TX POWER DAC:14500 CODE APPLIED WCDMA Band2 CH : 3013 RBW : 100KHz VBW : 100KHz SPAN : 10MHz REF LEV. : 10dBm ATT. : 20dB
Check the Voltage at C102 = VBATT ? YES Check L104, L105 : About 22dBm ? NO Check component soldering status OK at F100 YES Check C129, C130 : About 22dBm ? NO Check the Voltage at R741,C117=VOUT_CHARGER? YES Check C125, L112 : About 0dBm ? YES
NO
YES
NO
YES
NO
YES
Check the voltage at {C138 = VOUT_CHARGER ?} & {C169, C170, C171 = VOUT_CHARGER?} & {C137, C174 = 2.85V ?} & {C134, C176 = 2.65V ?} & {C136, C178 = 1.8V?} & {C135, C175, C173 = 1.2V?}
NO
YES NO
YES
8-63
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
END
8-64
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-65
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-3-8. MHL
MHL Does not work Yes Check if MHL_SEL(TP716) goes High Yes No
No
Change U709
Yes
No
Yes
Replace U708
Yes
END
D:\PROJECT\P3\\\REAL\P7100_REV0.6\Untitled-2.eps
8-66
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-3-8. MHL
8-67
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-3-9. OTG
Yes
No
Yes
No
Yes
Replace U503(MAX8627)
Yes END
8-68
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-3-9. OTG
8-69
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
1 A VSS
2 VSS XEIN T_22 XEIN T_13 XEIN T_26 XEIN T_20 XEIN T_11 XEI NT_3 VDD Q_M 1 XOM_3
3 VDD 1_E XEIN T_24 XEIN T_31 XEIN T_18 XEIN T_29 XEIN T_16 XEI NT_9 VDD Q_M1 XOM _2
4 XEIN T_23 XEIN T_30 XEIN T_27 XEIN T_25 XEIN T_21 XEIN T_15 XEIN T_19 VDD Q_M 1 XOM_5
5 VSS XEIN T_17 XEIN T_12 XEIN T_14 XEI NT_4 XEIN T_10 XEI NT_7 VDD Q_M 1 XOM _4 XCL KOUT XM1 VREF XGNSS_ RF_RST N XGNSS _IM AG
6 VDD Q_E2 XEI NT_8 XEI NT_2 XEI NT_5 XEI NT_0 VDD Q_M 2 VDD Q_M 1 VDD Q_M 1 VDD Q_M 1 VDD Q_M 1 VDD Q_M 1 VDD Q_M 1 VDD Q_M 1 VDD Q_M 1 VDD _ARM VDD _ARM XM 1ZQ VDD11 _APLL VDD11 _M PLL VDD11 _VPLL VDD11 _EPLL
7 VDD Q_M2 VDD Q_M2 VDD Q_M2 VDD Q_M2 VDD Q_M2 VDD Q_M2
8 VDD Q_E2 XADC AIN_4 XADC AIN_5 XADC AIN_1 XEI NT_1 VDD Q_M 2
9 VSS XADC AIN_8 XADC AIN_0 XADC AIN_7 XADC AIN_6 VDD Q_M 2
10
11
12 VDD Q_E2
13 VSS
14
15
16
17
19 VDD Q_E2 XVV D_3 XVV D_6 XVV D_5 XVV D_20 VDDQ_ MODEM
20 VSS XVV D_14 XVV CLK XVV D_7 XVV D_17 XVV D_16
21 XVV D_10 XVV D_1 XVV D_4 XVV D_21 XVV D_11 XVV D_18
22 XVV DEN XVVSY NC_LDI XVV D_22 XVV D_8 VDDQ _EXT1 VDDQ _EXT2
23 XVV D_0 XVV SYNC XVV D_23 XVV D_19 XVV D_12 VDDQ _EXT0
24 XVSY S_OE XSPI CSN_1 XSPI CSN_0 XVH SYNC XVV D_2 XSPIM ISO_1
25 VDD Q_E2 XUT XD_2 XURT SN_2 XSPIM OSI_0 VDDQ _SBUS VDDQ _AUD0
26 VSS XUCT SN_2 XUR XD_0 XURT SN_0 XSBU SCLK XSBU SDATA
27 XUT XD_3 XSPI CLK_1 XSPI CLK_0 XPWMT OUT_2 XUT XD_0 XUT XD_1 XUCT SN_0 XUR XD_3 XHDM IREXT XI2S 1SDO XI2S 1LRCK XI2C 1SCL XI2C 1SDA POP_ ZQ_E1 XDA COUT XCID ATA_0 XCID ATA_3 XM IPIVR EG_0P4V XCIF IELD XCID ATA_7 XCID ATA_4 XCIV SYNC XM IPI2L V REG_0P4 XCID ATA_6
28 VDD 2_E XSPIM OSI_1 XSPIM ISO_0 XPWM T OUT_0 XPWM T OUT_3 XPWM T OUT_1 XUCT SN_1 XUR XD_2 XI2S2 CDCLK XI2S 1SCLK XI2S1 CDCLK XI2S 2SDI XI2S 2SCLK VDDC A_E1 VDD 1_E VSS POP_VR E F_CA_E2 POP_ ZQ_E2 VDD 2_E XCI PCLK XCI HREF VSS VDDC A_E2 VDD 1_E XCID ATA_1 XJTM S
29 VSS VDD 1_E XUR XD_1 XHDM IXTO XHDM ITX2P XHDM ITX1P XHDM ITX0P XHDM ITXCP POP_VR E F_CA_E1 XI2S 1SDI XI2S 2SDO XMIP IM DN0 XMIP IM DN1
30 VSS A
XM DM A XM DMA DDR_2 DDR_0 XADC AIN_3 XADC AIN_9 XADC AIN_2 XM 2 VREF VDD Q_M 2
XM DM D XMDMD XM DM D XM DM D ATA_0 ATA_6 ATA_8 ATA_14 POP_VR XM DM D XM DM D E ATA_15 ATA_11 F_DQ_E2 XM D M CSN XM D M WEN
VSS VDD 2_E XEI NT_6 VDD Q_E1 XEIN T_28 VDD Q_E1 VDD Q_M1 VSS VDD Q_E1 VSS
VSS XURT SN_1 XHDM IXTI XHDM ITX2N XHDM ITX1N XHDM ITX0N XHDM ITXCN VSS VDD 2_E VDDC A_E1 XM IP IM DP0 XM IP IM DP1
XM DMA XMDM A XM DM A XM DM D XMDMD XM DM D DDR_5 DDR_12 DDR_10 ATA_13 ATA_3 ATA_2 XM DMA XMDM A XM DM A XM DM D XMDMD ATA_1 ATA_10 DDR_4 DDR_9 DDR_1 XM DM IRQN
XM DMA XMDM A XM DM A XM DM D XMDMD XM DM D XM DM D DDR_3 DDR_8 DDR_11 ATA_7 ATA_9 ATA_4 ATA_12 VDD Q_M 2 VDD Q_M 2 VDD Q_M 2 VDD Q_M 2 VDD Q_M 2 XM 2ZQ VDD3 3_ADC
VDD33_H VSS_HD DMI_OS M I_OSC C VDD11_H DM I_PLL VSS VSS VDD _ARM VDD _ARM VSS VDD _ARM VDD _ARM VDD _ARM VDD _ARM VSS VDD _INT VDD _INT VSS VDD _INT VDD _INT VSS VDD _ARM VDD _ARM VSS VDD _ARM VDD _ARM VDD _ARM VDD _ARM VSS VDD _INT VDD _INT VSS VDD _INT VDD _INT VSS VDD _ARM VDD _ARM VDD _ARM VDD _ARM VDD _ARM VDD _ARM VDD _ARM VSS VDD _INT VDD _INT VSS VDD _INT VDD _INT VSS VDD _ARM VDD _ARM VDD _ARM VDD _ARM VDD _ARM VDD _ARM VDD _ARM VSS VDD _INT VDD _INT VSS VDD _INT VDD _INT VDD _INT VDD _INT VSS VDD _INT VDD _INT VDD _INT VDD _INT VSS VDD _INT VDD _INT VDD _INT VDD _INT VDD _INT VDD _INT VDD _INT VDD _INT VDD _INT VDD _INT VDD _INT VDD _INT VSS VDD _ARM VDD _ARM VSS VDD _ARM VSS VDD _ARM VDD _ARM VSS VDD _ARM VSS VDD _INT VDD _INT VDD _INT VDD _INT VDD _INT VSS VSS VDD _G3D VDD _G3D VSS VDD _G3D VDD _G3D VSS VDD _G3D VSS VDD _INT VDD _INT VSS VDD _INT VDD _INT VSS VDD _G3D VDD _G3D VDD _G3D VDD _G3D VDD _G3D VDD _G3D VDD _G3D VSS VDD _INT VDD _INT VSS VDD _INT VDD _INT VSS VDD _G3D VDD _G3D VSS VDD _G3D VDD _G3D VSS VDD _G3D VSS VDD _INT VDD _INT VSS VDD _INT VDD _INT VSS VDD _G3D VDD _G3D VSS VDD _G3D VDD _G3D VSS VDD _G3D VSS VDD11 _HDM I XI2C 0SCL XI2C 0SDA VDD3 3_DAC VDD3 3_ABB XDAC IREF XDAC COM P XCID ATA_5 VDD18 _MIPI VSS_ MIPI VSS_ MIPI VSS_ MIPI VDDQ _CAM VSS_M IPI2L VSS_M IPI2L VDD18_ M IPI2L VDDQ _SYS0 VDD11 _UOTG XM0AD DR_13 XRT CXTI XM0AD DR_11 XSAT ARX2P 7 VDD_ ALIVE VDDQ _KEY XM 0AD DR_15 XM 0AD DR_10 XM 0A DDR_8 XSAT ARX2M 8 VDDQ _SYS1 XM0A DDR_7 XM 0C SN_1 XM0A DDR_4 VCC _O XSAT ATX2M 9 VDDQ _AUD1 VDDQ _GPS0 XM0AD DR_12 XM 0A DDR_9 POP_ CEB_O XSAT ATX2P 10 VDD11 VDD33 D_SATA A_SATA VDD11 VDD11 T_SATA A_SATA XSATA REFRES XM 0A DDR_1 XM 0B EN_0 XSATA ATEST XM 0A DDR_5 XM 0A DDR_0 XM0A DDR_3 XM 0AD DR_14 XM0A DDR_6 XM 0B EN_1 XM 0C SN_2 VSS 13 VDD _INT VDD _INT VDD _INT VDD _INT VDD _INT VDD _INT 14 XM0F RNB_1 VDDQ _GPS1 XM0A DDR_2 XM0F RNB_0 XM 0W AITN VSS 15 XM 0 OEN XM 0F RNB_3 XM 0C SN_0 XM 0 WEN XM 0C SN_3 VCC Q_O 16 XM0D ATA_2 XM0D ATA_1 XM0D ATA_9 XM 0DA TA_11 XM 0DA TA_12 VCC _O 17 VDD Q_M 0 XM 0D ATA_7 XM 0D ATA_8 XM0DA TA_10 XM 0D ATA_4 VSS 18 VDD Q_M 0 XM0D ATA_6 XM 0DA TA_14 XM0D ATA_0 XM 0DA TA_RDN VCC Q_O 19 XMM C1 XMM C0 DATA_1 DATA_3 XMM C1 DATA_3 XM 0D ATA_3 XM0DA TA_15 XM 0D ATA_5 XM0DA TA_13 20 VDDQ_ MM C01 XMM C 1CM D XMM C1 DATA_0 XMM C 0CMD VDDQ _MM C3 XMM C 3CLK VDDQ _MM C2 VSS VDDQ _SYS0 XMM C 3CDN VSS_ HDM I VSS_ HDM I XI2S 2LRCK VDD33 A_DAC VSSA _DAC VSS _DAC XDAC VREF VDDQ _LCD XCID ATA_2 VDD11_ M IPI_PLL VDD11 _M IPI VDD11 _M IPI VDD11 _M IPI VDD11_ MI PI2L_PLL VDD11_ M IPI2L VDD11_ M IPI2L XCIC LKENB
VSS
VSS
VSS
VSS
VSS
VSS
XXTI VDD Q_E1 VSS VDD _ARM VDD _ARM VSS VDD 1_E VSS VDD 2_E
VSS
VSS
VSS
VSS
VSS
VSS VDD _G3D VSS VDD _G3D VSS VDD _INT VDD _INT VSS VDD _INT VDD _INT
XGNSS_ XGNSS_ XGNSS_ XGNSS RTC_OU GPIO_2 CLKREQ _ISIGN T VDD _ARM VDD _ARM XGNSS _QM AG VDD _ARM VDD _ARM XGNSS_ GPIO_4 VDD _ARM VDD _ARM XGNS S_SDA XGNSS_ GPIO_3 VDD _ARM VDD _ARM VDD3 3_ABB VSS_ APLL VSS_ M PLL VSS_ VPLL VSS_ EPLL
XM IPI XM IPI M DNCLK MDPCLK XMIP IM DN2 XMIP IM DN3 XMIP ISDN0 XMIP ISDN1 XM IP IM DP2 XM IP IM DP3 XM IP ISDP0 XM IP ISDP1
VSS
VSS
XGNSS_ XGNSS_ XGNSS_ GPIO_5 GPIO_6 GPIO_1 XGNSS_ XGNSS_ XVPLL GPIO_7 GPIO_0 FILTER XEPLL FILTER
VSS
VSS
XM IPI XM IPI SDNCLK SDPCLK XMIP ISDN2 XMIP ISDN3 XM IP ISDP2 XM IP ISDP3
VSS
VSS
XTSEXT XUHOS XGNSS AA _RES TDATA2 _QSIGN AB VDD Q_E1 XUHO STDP VSS VDD Q_E1 XUO TGDP VDD Q_E1 XUS BXTI VSS
VSS
VSS
AA
XUHOS XEFFSO VDD11H VSS12 VDD12 TDATA1 URCE_0 _UHOST _UHOST _UHOST XUHO STDM XUOT GVBUS XUOT GREXT XUO TGDM XI2S0 SDO_1 XUS BXTO VDD 2_E VSS 2 XUHOST STROBE 2 XUHOST STROBE 1 XUHOS TREXT XUO TGID XI2S0 SDO_0 XI2S 0SCLK XI2S 0LRCK VDD 1_E 3 VSSH_ UHOST VSSD_ UHOST VSSAC _UOTG VDD _RTC XRTC CLKO XI2S 0SDI XI2S0 CDCLK VDD Q_E1 4 VSSAC VDD33 _UHOST _UHOST VSSA_ UHOST VSSA _UOTG VSSD _UOTG VDDQ_ CKEM 1 XI2S0 SDO_2 XM0 FCLE XM 0 FALE 5 VDD11 _UHOST VDD33 _UOTG VDDQ _CKO VDDQ_ CKEM2 XRT CXTO XM 0F RNB_2 VSS 6
VSS
VSS
XM IPI XM IPI AB 2LM DN0 2LM DP0 XM IPI2 XM IPI2 LM DNCL LM DPCL AC K K XM IPI XM IPI AD 2LM DN1 2LM DP1 XM IPI 2LSDN0 XM IPI 2LSDP0 AE
AC
AD
AE
XUHOST XUHOS XJTDO OVERCU TPWREN R VDDQ _CAM XJTCK XJT RSTN XJTDI XMM C 2CDN XMM C 2CM D XMM C 2CLK 27
AF
AF
AG
XUOTGD XM IPI RVVBUS 2LSDN1 XJDB GSEL POP _TQ0 VDDC A_E2 28 POP _TQ1 VDD 1_E VSS 29
AG
AH
XMM C3 XMM C3 XMM C3 XMM C2 DATA_2 DATA_0 DATA_3 DATA_0 XMM C 0CLK VCC Q_O 23 XMM C 1CLK XMM C 3CM D 24 XMM C2 XMM C2 DATA_3 DATA_2 VSS 25 VCC _O 26
AH
AJ
AJ
AK
VSS 1
VSS 30
AK
8-70
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
UCP300
FBGA
1
VDD_VBA T_SD2
NC
MEM_A_8
MEM_BFC MEM_SDC MEM_BC0 MEM_A_0 MEM_A_1 MEM_A_2 MEM_A_3 MEM_A_4 LKO_1 LKO _n
VPLL
SD2_SW
SD2_SW
NC
MEM_A_9
FWP
VIO_12
VSS_SD2
MEM_A_1 MEM_A_2 0 2
xx
MEM_A_5
MEM_A_7
VDD_VSD VUSB_PD 2
SD2_FB
VDD_VBA T_SD1
MEM_A_1 MEM_A_2 1 1
VSS
VSS
MEM_AD_ 3
ANAMON
SD1_FB
SD1_SW
MEM_A_1 MEM_A_2 2 0
VSS
FSS
SD1_SW
VSS
MEM_AD_ 15
xx
MEM_AD_ 4
TRIG_B
VRTC
VSS_SD1
VSS
xxx
VPMU
VSIM
MEM_A_1 MEM_A_1 5 7
MEM_CS2 MEM_CS3 _n _n
M1
AGND
ON1
VUSB_IO
J K
VDD_IO18
VSS
VSS
M2
M3
M4
ON2_N
VREF
J K
VDDCORE
VSS
VDD_IO18
EINT3
VDDCORE VDD_IO18
ETM11_T RACECLK
ETM11_T RACEPKT 4
TM_EN
L M
F32K
VSS
VSS
MIPI_HSI _ RX_RDY
MIPI_HSI _ TX_FLG
VSS
MMCI1_C MD
L M
OSC32K
VSS
xx
EINT1
EINT2
ETM11_T MMCI1_D MMCI1_D MMCI1_D MMCI1_C MMCI1_D RACEPKT AT_3 AT_0 AT_2 LK AT_1 0 MMCI1_C D I2S2_CLK I2S2_CLK 1 0
VDD_RTC
USB_ID
VPP
CLKOUT0
T_OUT0
USB_TEST
VBUS
VSS
HW_MON 2
xx
T_OUT1
I2S2_TX
I2S2_RX
xx
VDD_PLL
VSS
VDDCORE
HW_MON RESET2_N 1
NC
I2S2_WA1 I2S2_WA0
CC_RST
CC_IO
VDD_SIM
DMINUS
VDD_DIG RF
XRESET_ N
TCK
TRIG_IN
TRST_n
NC
VSS
VDD_IO12 CC_CLK
DPLUS
ALERT_N
TMS
TDI
TDO
NC
17
16
15
14
13
12
11
10
765432
8-71
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
U501
1 A
NC
2
FLE D 2
3
FLE D 1 D GND2 32kHz AP SAF E OUT2 DET BAT \ VICH G 18T NC2
4
OUTF
5
LXF
6
PG N DF
PGN D F
7
PG N D6 PG N D6 REF INPA
8
LX 6
9
INB 06A INB 06B BUCK 6
10
GND M
11
IN _ M O T O R
12
INB 02 BUCK 2 PG N D2 BUCK 3 INB 03 BUCK 7 PG N D 7 A GND LDO 17 LDO 16 INL 2 LDO 8 LDO 4
13
NC
FG ND
FG ND
OUTF
LXF
LX 6
MD N
MDP
LX2
XIN
XOU T
FLE D _EN
GSMB
BUCK 6EN
M PWM IN_
GPIO2
M GAIN IN_
GPIO 1
PG N D3
VL
SAF E OUT1
COMP
RSO\
IRQ1 \
MR2 \
MR 1\
LX3
BA TT
BATT
JIG ON
SCL
GP IO 7 GP IO 9 GP IO 11
GPIO 1 GPIO 3 GPIO 5 GPIO _GND LDO 12 LDO 18 INL 4 INL 6 INL 5
INB 07
DC IN
DC IN
ONO\
SDA
LX7 PG N D 7 GND
DN1
BC
28T1
CB
SET 3
DP2
SL1
UT 1
28T NO2
28R NO 1
SET 2
SET 1
COM N1 COM P2
SR2
UR2
18R1
VBA T TFG
THRM
AIN
VTT
MIC_ USB
18T2
28R
COM2
ALR T
VBFG
SCA FG
UID PG N D 5 NC
IDB
BOOT
28R2
SDA FG BUCK 1 PG N D 4
KVS S PG N D 1 PG N D 1
SNS
BU CK 5
INB 05 INB 04
BUCK 4
LX 1
LX5
LX4
LX 1
NC
TOP VIEW
8-72
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
UME300
3. PIN CONFIGURATION
A B C D E F G H J K L M N P R T U V W Y AA AB AC AD AE AF AG AH 1 DNU DNU NC VSSd A5d A12d VDDd CKEd VDDQd NC BA1d BA0d VSSd NC DNU DNU 2 DNU NC DAT3m VDDIm A6d A11d NC /CSd /RASd /CASd VSSd A0d VDDd VSSQm NC DNU 3 DAT0m DAT4m A4d A7d A8d A9d NC /WEd NC A10d A1d A2d A3d VDDQm 4567 DNU ------------------DAT1m DAT5m VSSQm NC ---VDDQm VDDQm VSSQm ------------------DNU DNU CMDm VSSQm VDDQm CLKm VSSQd VSSQm NC NC NC DAT2m DAT6m NC --NC VDDm VSSm NC NC RSTm VDDm ----NC NC VSSm NC DAT7m VDDQm NC NC NC DNU 8 VDDQd NC NC NC VSSm NC NC VDDQd 9 DNU -----------------VSSQd NC NC -NC VDDm -NC NC VSSQd -----------------DNU DNU NC NC NC NC NC NC VSSm VDDm NC VSSd NC NC VDDd NC NC NC NC VDDd VSSQd DQ15d DQ14d DQ11d DQ10d UDQSd CKd /CKd LDQSd DQ5d DQ3d DQ1d DQ0d VSSQd 10 11 DNU 12 13 DNU NC VDDQd DQ13d DQ12d DQ9d UDMd VDDQd VDDQd LDMd DQ6d DQ4d DQ2d VDDQd NC DNU 14 DNU DNU NC VDDQd VSSQd DQ8d VSSQd VDDd VSSd VSSQd DQ7d VSSQd VDDQd NC DNU DNU -
8-73
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
U100
1
NC
2
PM_H
3
GN D
4
PM_L
5
GPO3
7
MI1
9
VDDBA T
10
CEXT_D CXO XO
11
12
XOX
13
NC
A
VDDBA T_TXRF VDD_TX RF NB NB GPO2
A
XO_SUP XO_EXT VDD1V8 _SCU
NB
NB
MI2
D2B_OU AFC_DA T C
PA_RF
C
PA_PO W_DET
CEXT_T XMS
G ND
VDD1V8 _DIG
G ND
G ND
DI3_TX_ DAT
DI3_RX_ DAT
VDD1V8 _FBR
SPI_CL K
SPI_DR W
NB
NB
CEXT_T XPLL
GND
VDD2V5 _FSYS
NB
DI3_TX_ DATX
DI3_RX_ DATX
G ND
RX_L1
VSPI
SPI_SS
GND
G ND
GPO1
E
RX_L2 RX_L1X VDD1V8 _RCBB GND GND GND VDD1V8 _RCMS
VDD1V8 _TXMS
VDD_TE ST
NB
NB
VDDIO
REF_CL K_EN
GND
F
RX_L2X RX_M1
NB
SYS_CL K_EN
SYS_CL K
GND
GND
G
RX_M2 RX_M1X GND GND
VDD1V8 _RCLO
GND
GND
GND
GND
GND
NB
FSYS1
FSYS1_ EN
GND
G ND
NB
NB
H
RX_M2X RX_H1 GND VDD2V5 _RCBB VDD2V5 _RCRF G ND GND VDD2V5 _RXDC O NB
CEXT_R XPLL
GND
NB
FSYS2_ EN
FSYS2
H
FSYS3_ EN
GND
GND
GPO8
FSYS3
J
RX_H2 RX_H1X NB
NB
GND
GND
NB
K
RX_H2X VDD1V8 _RCRF G ND RD_L1 RD_L1X RD_H RD_HX G ND
VDD1V8 _RXPLL
G ND
GPO7
RESET_ N
CLK_O N
L
NC
VDD2V5 _RFC
GN D
G ND
VDD1V8 _RFC
GND
RD_L2
RD_L2X
RD_M
RD_MX
GND
GPO4
GPO6
M 1 2 3 4 5 6 7 8 9 10
PA_BIA S
PA_RA MP
NC
M 13
11
12
Figure 2
8-74
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
U103
Pin Out
A1 VSNS_ 2V85 A2 OUT 3B
A3 AGND
A4 VANA
B1 LX3A
B2 VDD_IO
B3 CLK_ ON
B4 SPI_SS
C1 VPWR
C2 VSNS_ 1V8
C3 VSNS_ 1V2
C4 SPI_ DRW
D1 LX2
D2 PGND
D3 LX1
D4 SPI_ CLK
Bumps Down
U104
Pin Out
A1 VSNS_ 2V85 A2 OUT 3B
A3 AGND
A4 VANA
B1 LX3A
B2 VDD_IO
B3 CLK_ ON
B4 SPI_SS
C1 VPWR
C2 VSNS_ 1V8
C3 VSNS_ 1V2
C4 SPI_ DRW
D1 LX2
D2 PGND
D3 LX1
D4 SPI_ CLK
Bumps Down
8-75
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
U708
8-76
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
U601
8-77
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
U602
8-78
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
U202
8-79
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.