Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
The Armature Bar is jammed down and touching the front coil. It cannot move up and down.
Good. At rest, teh armature bar is not touching the front coil. Room to go up and down. Armature Bar Setting Troubleshooting Answer # A132 Problem Machine does not run. Because Armature Bar is not in proper position. It is jammed down on coils. Check Armature Bar Spacing with machine off. 1. The armature bar should be above the coils, and not touching the coils. 2. Contact screw must be touching the front spring. Space must be left between the armature bar and the coils so that the armature bar can go up and down. The Contact Screw is turned too far down and pressing the entire Armature Bar Assembly down onto the coils. It cannot move up and down. Unscrew (Back-Off) the Contact Screw to provide clearance.
Why
Cause Remedy
Contact Screw Troubleshooting Answer # A133 Problem Machine does not run. Because Contact Screw is not touching the front spring. Check Why Cause The contact screw must be touching the front spring. Electricity will not flow unless a circuit is complete. The Contact Screw is turned too far up and is not touching the front spring.
Remedy Turn the Contact Screw down until it touches the front spring (or the contact point on the front spring).
Remedy Bend the solder lug out so that it no longer touches the frame.