Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
2013
ELECTRONICS AND COMMUNICATION ENGINEERING PACIFIC INSTITUTE OF TECHNOOGY
required for the station. Location of station on broad gauge main Hamirgarh Railway line.
INTRODUCTION
B.S.L-T.P.S is coal based power plant in Bhilwara. It is located ideally on the left bank of Kothari River near Bhilwara. Its has 2 units of capacity 10 MW and 6 MW, which were synchronized in 1999. It is one of the highest power generating plant in Bhilwara with installed capacity of 16 MW.
PLANT OVERVIEW
Bunkers
Crusher house
Conveyor
B.S.L- T.P.S
TURBINE
Turbine is a machine in which a shaft is rotated steadily by impact of steam it converts heat energy into mechanical energy.
STEAM TURBINE
BOILER & SUPERHEATER STEAM AT 545 C H P TURBINE
STEAM AT 535 C
REHEATER
M P TURBINE
STEAM AT 535 C
STEAM AT 545 C
L P TURBINE
TURBO GENERATOR
Designed for continuous operation at the rated output. Directly coupled with steam turbine, rotated at high speed of 3000 RPM. Two major parts:-
SWITCHYARD
The 220 KV Switch yard is the main part of the KTPS it has two buses arrangement with a bus coupled breaker. There are 11 feeders connected at 220 KV switchyard
CURRENT TRANSFORMER
POTENTIAL TRANSFORMER LIGHTNING ARRESTOR
CIRCUIT BREAKER
Circuit breaker is basically a mechanical device used to make or break an electrical circuit under normal & abnormal condition. A circuit breaker is switched on or off under load conditions an arc is produced in between the breaker contacts. This arc produced between the breaker contacts is quenching by some suitable medium.
Lightening Arresters are used in switchyard for preventing from Lightening phenomena and are installed at entrance of switchyard.
CURRENT TRANSFORMER
Current transformers are provided for measuring and protection. All Current Transformers at 220 KV switchyard are BHEL manufactured . Designed to provide a current in its secondary coil proportional to current flowing in its primary coil. Primary winding consists of very few turns. Secondary winding consists of large no. of turns Current to be measured is passes through primary winding.
POTENTIAL TRANSFORMER
Used for the measurement of high voltages. Primary winding is connected to voltage to be measured. Voltmeter is connected across the secondary winding.
SWITCHYARD LAYOUT
CONTROL PANEL
Turbine desk
Thank You !!