Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
www.huawei.com
Objectives
Describe the concepts of the LTE UE connections Describe the procedure of random access Describe the procedure of RRC setup Describe the procedure of S1 signaling setup Describe the procedure of E-RAB setup Describe the structure of QoS in EPS Describe the QoS mapping in EPS
Page1
Contents
1. Connection Management Overview 2. Random Access 3. Signaling Connection Management 4. Dedicated Radio Bearer Management
5. QoS in EPS
Page2
UE Connections
Connection between the UE and eNodeB Connection between the UE and MME
Page3
Page4
Page5
UE
PDN-GW
TFT
TFT
Each Dedicated EPS Bearers has an associated TFT (Traffic Flow Template)
Page6
Page7
Contents
1. Connection Management Overview 2. Random Access 3. Signaling Connection Management 4. Dedicated Radio Bearer Management
5. QoS in EPS
Page8
Obtain the uplink synchronization signals from the network Request dedicated resources for data transmission
Page9
initial RRC connection establishment RRC connection reestablishment Handover UE is noticed downlink data arrival UE detects Uplink data arrival
Page10
Contention-based RA
Contention-based RA
initial RRC connection establishment RRC connection reestablishment UE detects uplink data arrival
Page11
Page12
CP TCP
Guard Period
Page13
Burst
TCP
TSEQ
0 1 2 3 4
1.4 km < R 14.5 km 29 km < R 77.3 km 14 km < R 29.5 km 77 km < R 100 km R 1.4 km
Page14
Preamble Sequence
Page15
Preamble
PreambleFmt
RootSequenceIdx
Page16
E Sub Header A Sub Header B Sub Header n MAC RAR A MAC RAR B MAC RAR n R
T RAPID or BI
RAPID
Oct 1
Page17
Page18
Contention Resolution
Page19
Page20
RA Backoff Control
Page21
Contents
1. Connection Management Overview 2. Random Access 3. Signaling Connection Management Procedure 4. Dedicated Radio Bearer Management Procedure
5. QoS in EPS
Page22
Page23
RRC States
PLMN Selection Broadcast of System Information Cell Selection
RRC Connection (SRB) RRC Context in eNB UE Known in a Cell Send and/or Receive Data to/from UE Network Controlled Mobility Measurement Control UE Monitors Scheduling Control Channel UE Reports Channel Quality UE can send Feedback Information DRX can be Configured
DRX configured by NAS Broadcast of System Information Paging Cell Reselection Mobility GUTI Allocated Located in Tracking Area(s) No RRC Context Stored in the eNB
LTE Detached
Page24
UE
eNB
RRC Connection Setup Radio Resource Config Dedicated - srb-ToAddModList - drb-ToAddModList - drb-ToReleaseList - MAC Main Config - SPS Config - Physical Config Dedicated
RRC Connection Setup Complete Selected PLMN-Identity Registered MME Dedicated Info NAS
Page25
Handover failure RRC reconfiguration failure Radio link failure Integrity check failure
Page27
Page28
Page29
S1 Initial UE Message
Initial UE M essage eNB UE S1AP ID NAS-PDU TAI E-UTRAN CGI S-TMSI (O) CSG Identity (O) RRC Establishment cause GUMMEI (O) eNB Initial UE Message MME
Page31
MME
Page32
Page33
eNB
MME
Page34
Contents
1. Connection Management Overview 2. Random Access 3. Signaling Connection Management 4. Dedicated Radio Bearer Management
5. QoS in EPS
Page35
Page36
Page37
eNB
MME
Page38
MME
E-RAB Setup Response MME UE S1AP ID eNB UE S1AP ID E-RAB Setup List - E-RAB ID - Transport Layer Address - GTP-TEID E-RAB Failed to Setup List (O) Criticality Diagnostics (O)
Page39
Page40
Page41
Contents
1. Connection Management Overview 2. Random Access 3. Signaling Connection Management 4. Dedicated Radio Bearer Management
5. QoS in EPS
Page42
UE: User Equipment S-GWServing Gateway eNodeB: evolved NodeB P-GW: Packet Data Network Gateway
Page44
ARP (Allocation and Retention Priority), is used define the priority of EPS resource allocation and retention, defined in
EPC
ARP only take effect during admission process, not for scheduling. Once the bearer is setup, the ARP doesnt any
Drop
MRB
Pass
Internet
APN2
APN-AMBR UE-AMBR
Intranet
Page47
Page48
QoS Management
QoS Parameters delivery
EPC
Radio QoS
Transport QoS
QoS mapping (DSCP) TRM: Admission control Load control Flow control
Page49
Thank you
www.huawei.com