Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
The protection circuit for the RRU uses a single sided PCB that is 1.6mm thick. The Ericsson P/N for the PCB assembly is 128 2311/1 R1C and the board is called the Combined SPD. There are two 6-pin connectors [Component ID 5] for the input and output of the circuit. The connector on the left in the diagram is the input while the connector on the right is the output. There are five 90V surge arrestors [Component ID 4] from EPCOS AG and three rectifiers [Component ID 3] from Fairchild Semiconductor that form the basis of the over voltage protection circuit.