Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
1. The Malfunction Indicator Lamp (MIL) will come ON when the Ignition Switch is turned ON and the engine is not running. HINT: If the MIL does not come ON, proceed to troubleshoot the combination meter circuit. When the engine is started, the MIL should go OFF. If the lamp remains ON, the diagnosis system has detected a malfunction in the system.
2.
2.
Using a jumper wire or SST, connect terminals TE1 and E1 of the Data Link Connector (DLC) 1 or 2.
2. 3. 4.
5. 6. 7. 8.
9.
After completing the check, disconnect terminals TE1, TE2 and E1 and turn off the display. NOTES: When vehicle speed is 3 mph or below, DTC 42 (vehicle speed sensor signal) is output, but this is not abnormal. When the engine is not cranked, DTC 43 (starter signal) is output, but this is not abnormal. When the automatic transmission shift lever is in the "D", "2", "L" or "R" shift position, or when the air conditioner is ON or when the accelerator pedal is depressed, DTC 51 (switch condition signal) is output, but this is not abnormal.